-
Hearth and Home Technologies 21M-ACC - page 1
R www .quadrare.com 7039-131F September 1, 2008 O-T L T ested and Listed by Portland Oregon USA OMNI-T est Laboratories, Inc. C US DO NOT DISCARD THIS MANUAL NOTICE • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation. • Read, understand and follow these instructions ...
-
Hearth and Home Technologies 21M-ACC - page 2
Page 2 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) Hearth & Home T echnologies welcomes you to our tradi - tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durabil - ity , and performance. This commitment begins with our research of the market, including ‘V oice of t ...
-
Hearth and Home Technologies 21M-ACC - page 3
September 1, 2008 7039-131F Page 2100 Millennium Wood Stove (ACC) R Section 1: Listing and Code Approvals A. Appliance Certications ...................... 4 B. Mobile Home Approved ...................... 4 C. Glass Specications ............................ 4 D. BTU & Efciency Specications .......... 4 Section 2: Getting Started ...
-
Hearth and Home Technologies 21M-ACC - page 4
Page 4 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) 1 Listing and Code Approvals The Quadra-Fire 2100 Millennium Wood Stove (ACC) meets the U.S. Environmenta l Protec tion Agency’ s 1990 particu late emission standards. A. Appliance Certication C. Glass Specications D. BTU & Efciency Specications This stove is eq ...
-
Hearth and Home Technologies 21M-ACC - page 5
September 1, 2008 7039-131F Page 5 2100 Millennium Wood Stove (ACC) R 2 Getting Started A . Design, Installation & Location Consider ations Consideration must be given to: • Safety • Convenience • T rafc ow • Chimney and chimney connector required It is a good idea to plan your instal latio n on pap er , us ing exact measurements ...
-
Hearth and Home Technologies 21M-ACC - page 6
Page 6 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) Marginal Location: • Below peak Location NOT recommended: • Not the highest point of the roof • Wind loading possible Multi-level Roofs Windward Leeward Recommended: Outside Air Intake on windward side NOT recommended: Outside Air Intake on leeward side Recommended Location ...
-
Hearth and Home Technologies 21M-ACC - page 7
September 1, 2008 7039-131F Page 7 2100 Millennium Wood Stove (ACC) R Exterior conditions such as roof line, surrounding trees, prevailing winds and nearby hills can influence stove pe rf orm anc e. Y our loc al deal er is the expe rt in yo ur geo grap hic area and can usually make suggestions or discover solutions that will easily correct your ...
-
Hearth and Home Technologies 21M-ACC - page 8
Page 8 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) Floor Protector Chimney Co nn ec tor Insulated " T " Flashing Lis te d T e rm in ati on C ap T r im C o lla r on Ins id e Wall Listed Chimney Storm Collar Wall S up po r t Roof Brace (if required) Thimble Floor Protector Thimble, 12" (305mm) Of Brick Ceiling Joist ...
-
Hearth and Home Technologies 21M-ACC - page 9
September 1, 2008 7039-131F Page 9 2100 Millennium Wood Stove (ACC) R 3 Dimensions and Clearances 26-7/16 in. (671mm) 24-5/16 in. (618mm) 6-1 1/16 in. (170mm) 16 in. (406mm) 1 1-1/2 in. (292mm) 20-3/4 in. (527mm) C L C L 4-1/2 in (108mm) Outside Air Connection A. Appliance Dimensions Figure 9.1 Front View Figure 9.2 Side View NOTE: Flue Collar size ...
-
Hearth and Home Technologies 21M-ACC - page 10
Page 10 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) B. Clearances to Combustibles (UL and ULC) BACKW ALL / SIDEW ALL A B C D E F E F CORNER INST ALLA TION STOVE T O CEIL ING CLEARA NCE C D ALCOVE TOP VIEW G A B ALCOVE SIDE VIEW NOTE: Clearances may only be reduced by means approved by the regulatory authority having jurisdiction ...
-
Hearth and Home Technologies 21M-ACC - page 11
September 1, 2008 7039-131F Page 1 1 2100 Millennium Wood Stove (ACC) R A. Hearth Protection Requirements FLOOR PROTECTION: Floor protector must be non-com - bustible material, extending beneath heater and to the front, sides and rear as indicated. The oor must be non-com - bustible or otherwise adequately protected from radiant heat given off b ...
-
Hearth and Home Technologies 21M-ACC - page 12
Page 12 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) B. Outside Air Kit Installation 1. Remove all materials from packing box. 2. Using a #2 Phillips screw driver attach the ex adapter to the stove using 4 screws. Figure 12.1. . Remove circular “knock-out” in the base of the pedestal. 4. Floor & Rear Installation: Cu ...
-
Hearth and Home Technologies 21M-ACC - page 13
September 1, 2008 7039-131F Page 1 2100 Millennium Wood Stove (ACC) R C. Blower (Optional) 1. Remove the bolts (1/4”-20 Phillips head) on the outer skin at the bottom rear of appliance. 2. Align holes in mounting ange of blower with bolt holes in appliance. Blower should be positioned at bottom of rear outer skin as shown in Figure 13.1 ...
-
Hearth and Home Technologies 21M-ACC - page 14
Page 14 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) NOTE: I n Canada when using a factory-built chimney it must be safety listed, Type UL103 HT (2100 o F) CLASS “A” or conforming to CAN/ULC-S629M, STANDARD FOR 650 o C FACTORY-BUILT CHIMNEYS. 5 Chimney Requirements Floor Protector Chimney C on ne ct or Insulated " T " ...
-
Hearth and Home Technologies 21M-ACC - page 15
September 1, 2008 7039-131F Page 15 2100 Millennium Wood Stove (ACC) R Thimble Site constructed for masonry chimney installation: Components • A minimum length of 12 inches [05mm] (longer for thicker walls) of solid insulated factory-built chimney length constructed to UL 10 T ype HT 6 inch (152mm) inside diameter . Chimney needs to extend ...
-
Hearth and Home Technologies 21M-ACC - page 16
Page 16 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) Chimney Height / Rise and Run Th is prod uct was de sign ed for an d test ed on a 6 in ch (15 2mm) chimney , 14 to 16 feet (420-480cm) high, (includes stove heig ht) measu red fr om th e base of th e appl ianc e. The further your stack height or diameter varies from this cong ...
-
Hearth and Home Technologies 21M-ACC - page 17
September 1, 2008 7039-131F Page 17 2100 Millennium Wood Stove (ACC) R D. Chimney T ermination Requirements Follow manufacturer ’s instructions for clearance, securing ashing and terminating the chimney . • Must have an approved and listed cap • Must not be located where it will become plugged by snow or other material • Must terminate a ...
-
Hearth and Home Technologies 21M-ACC - page 18
Page 18 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) 6 Mobile Home Installation 10 . Burn wood only . Other types of fuels may generate poisonous gases (e.g., carbon monoxide). 1 1. If unit burns poorly while an exhaust blower is on in home, (i.e., range hood), increase combustion air . 12. Inst alla tion sh all be in a cco rdan c ...
-
Hearth and Home Technologies 21M-ACC - page 19
September 1, 2008 7039-131F Page 19 2100 Millennium Wood Stove (ACC) R N OTE: When the speed control is turned clockwise, it will click on to high speed. Continue to turn the speed control clockwise to dec rease the spee d. At full clockwise, the blower should blow gently , but should not stop. 1. With the appliance plugged in, turn the speed contr ...
-
Hearth and Home Technologies 21M-ACC - page 20
Page 20 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) 8 Operating Instructions B. Wood Selection & Storage Burn only dry seasoned wood. Store wood under cover , out of the rain and snow . Dry and well-seasoned wood will not only minimize the chance of creosote formation, but will give you the most efcient re. Even dry woo ...
-
Hearth and Home Technologies 21M-ACC - page 21
September 1, 2008 7039-131F Page 21 2100 Millennium Wood Stove (ACC) R 2. Second Stage The next stage of burning, the secondary stage, is the period when the wood gives off ammable gases which burn above the fuel with bright ames. During this stage of burning it is very important that the ames be maintained and not allowed to go out. This ...
-
Hearth and Home Technologies 21M-ACC - page 22
Page 22 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) F . Burn Rates and Operating Efciency For maximum operating efciency 1. This appliance has a timer system (ACC) that operates the stove at its maximum efciency removing any guess work for the homeowner . Follow the instructions below for each burn rate for the Start-Up ...
-
Hearth and Home Technologies 21M-ACC - page 23
September 1, 2008 7039-131F Page 2 2100 Millennium Wood Stove (ACC) R G. Building A Fire Before lighting your rst re in the stove: 1. Conrm the bafe is correctly positioned. It should be even with the front tube and resting on all tubes. Figure 23.1. 2. Remove all labels from glass. There are many ways to build a re. The basic pri ...
-
Hearth and Home Technologies 21M-ACC - page 24
Page 24 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) CORRECT POSITION INCORRECT POSITIONS Firebox damage due to improper bafe place - ment is not covered by warranty . Operate the wood burning appliance with the bafe in the correct position only . Not doing so could result in: • Reduced efciency • Overheating the chim ...
-
Hearth and Home Technologies 21M-ACC - page 25
September 1, 2008 7039-131F Page 25 2100 Millennium Wood Stove (ACC) R J. Opacity (Smoke) This is the measure of how cleanly your appliance is burn - ing. Opacity is measured in percent; 100% opacity is when an object is totally obscured by the smoke column from a chimney , and 0% opacity means that no smoke column can be seen. As you become famili ...
-
Hearth and Home Technologies 21M-ACC - page 26
Page 26 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) K. Frequently Asked Questions ISSUES SOLUTIONS Odor from appliance When rst operated, this appliance may release an odor for the rst several hours. This is caused by the curing of the paint and the burning off of any oils remaining from manufacturing. Metallic noise Noise ...
-
Hearth and Home Technologies 21M-ACC - page 27
September 1, 2008 7039-131F Page 27 2100 Millennium Wood Stove (ACC) R 9 Maintaining & Servicing Y our Appliance A. General Maintenance Inspe ction : Inspect th e sy stem at the ap plian ce connectio n and at the chimney top. Cooler surfaces tend to build creosote deposits quicker , so it is important to check the chimney from the top as well a ...
-
Hearth and Home Technologies 21M-ACC - page 28
Page 28 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) B. Glass Replacement 1 . Ensure that the re is out and the appliance is cool to the touch. 2. Protect a table or counter top with padding or towels. Protect your hands and wear gloves to prevent injury . . Remove the door with the broken glass by lifting the door up and of ...
-
Hearth and Home Technologies 21M-ACC - page 29
September 1, 2008 7039-131F Page 29 2100 Millennium Wood Stove (ACC) R Replace the rebrick if they become crumbly and/or if there is a 1/4 inch (6.5mm) gap between the bricks. Inspect the rebrick after each ash removal. The rebox is lin ed with hig h quality rebrick, which has exceptional insulating properties. There is no need to us ...
-
Hearth and Home Technologies 21M-ACC - page 30
Page 0 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) D. Bafe Removal 1. Remove all ash from the rebox, and extinguish all hot embers before disposal into a metal container . 2. The bafe board has 2 pieces. With the ceramic blanket still in place, slide one bafe piece over the top of other one and pull out top piece t ...
-
Hearth and Home Technologies 21M-ACC - page 31
September 1, 2008 7039-131F Page 1 2100 Millennium Wood Stove (ACC) R F . T ube Channel Assembly Replacement Removing Tube Channel Assembly 1. Remove the right side shield by removing 2 screws in the back using a Phillips head screw driver. 2. Remove 4 screws from channel access cover and remove cover. . Locate 2 channel nuts inside of chambe ...
-
Hearth and Home Technologies 21M-ACC - page 32
Page 2 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) 10 T roubleshooting With proper installation, operation, and maintenance your woodstove will provide years of trouble-free service. If you do experience a prob - lem, this troubleshooting guide will assist a qualied service person in the diagnosis of a problem and the corre ...
-
Hearth and Home Technologies 21M-ACC - page 33
September 1, 2008 7039-131F Page 2100 Millennium Wood Stove (ACC) R 1 1 Reference Materials Figure 33.1 - Door , Glass And Door Handle Assembly A. Exploded Drawings Figure 33.2 - Burn Rate Air & Start-Up Air Controls 32 33 34 35 42 36 37 38 39 40 41 4 6 7 9 10 12 13 14 5 49 Glass Size: 14-1/8” wide x 9-1/16” high Item Description ...
-
Hearth and Home Technologies 21M-ACC - page 34
Page 4 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) 30 1 13 2 3 4 5 6 7 9 10 12 14 16 17 18 19 20 21 22 23 24 25 26 27 28 29 31 43 SIZES (#0) Bafe Board: 8-1/8” w x 1” h, each (#29) Ceramic Blanket: 19” w x 1-/4” h, 1/2” thick Item Description Item Description 1 Oak Strip for Pedestal 18 Panel Assembly, ...
-
Hearth and Home Technologies 21M-ACC - page 35
September 1, 2008 7039-131F Page 5 2100 Millennium Wood Stove (ACC) R B. Service Parts & Accessories ITEM # ACCESSORIES PART NO. Blower Assembly BK-ACC 31 Door Assembly, Black SRV709-008 Outside Air Kit, Floor & Rear (termination cap, wire ties, ex adapter, fasteners) OAK-ACC see page 12 Outside Air Back Cover Plate & Sealing R ...
-
Hearth and Home Technologies 21M-ACC - page 36
Page 6 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) 39 Nut, Locking (Door Handle) 82-1060 see page 12 Outside Air Cover Plate & Sealing Rope, 1 inch x 4 ft SRV70-041 Paint, Touch-Up, Matte Black 7000-304 25 Panel Assembly, Side, Left SRV709-00 18 Panel Assembly, Side, Right SRV709-002 2 Pedestal Base 7033- ...
-
Hearth and Home Technologies 21M-ACC - page 37
September 1, 2008 7039-131F Page 7 2100 Millennium Wood Stove (ACC) R Date of Service Performed By Description of Service C. Service And Maintenance Log ...
-
Hearth and Home Technologies 21M-ACC - page 38
Page 8 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) Date of Service Performed By Description of Service C. Service And Maintenance Log (Cont’d) ...
-
Hearth and Home Technologies 21M-ACC - page 39
September 1, 2008 7039-131F Page 9 2100 Millennium Wood Stove (ACC) R D. Homeowner ’ s Notes ...
-
Hearth and Home Technologies 21M-ACC - page 40
Page 40 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) D. Homeowner ’ s Notes (Cont’d) ...
-
Hearth and Home Technologies 21M-ACC - page 41
September 1, 2008 7039-131F Page 41 2100 Millennium Wood Stove (ACC) R E. W arranty Policy Hearth & Home Technologies LIMITED WARRANTY Hearth & Home Technologies (“HHT”) and its respective brands extends the following warranty for HHT gas, wood, pellet and electric appliances purchased from an authorized HHT dealer and installed in the ...
-
Hearth and Home Technologies 21M-ACC - page 42
Page 42 7039-131F September 1, 2008 R 2100 Millennium Wood Stove (ACC) Hearth & Home Technologies LIMITED WARRANTY (Cont’d) HHT’s obligation under this warranty does not extend to damages resulting from: (1) installation, operation or maintenance of the appliance not in accordance with the installation instructions; operating instruc ...
-
Hearth and Home Technologies 21M-ACC - page 43
September 1, 2008 7039-131F Page 4 2100 Millennium Wood Stove (ACC) R This page is left blank intentionally ...
-
Hearth and Home Technologies 21M-ACC - page 44
R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI INDUSTRIES 7039-131F September 1, 2008 Page 44 CONT ACT INFORMA TION : Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer , visit our web site at www .quadrare.com This product may be cov ...
Haben Sie eine Frage bezüglich Hearth and Home Technologies 21M-ACC?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Hearth and Home Technologies 21M-ACC nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Hearth and Home Technologies 21M-ACC hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.