Manuel d’utilisation Hearth and Home Technologies 42

44 pages 4.62 mb
Télécharger

Aller à la page of 44

Summary
  • Hearth and Home Technologies 42 - page 1

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 1 Owner ’ s Manual Installation and Operation Models: Montana-36 Montana-42 Woodburning Fireplace DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible ...

  • Hearth and Home Technologies 42 - page 2

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 2 Read this manual before installing or operating this replace. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Outdoor Lifestyles wood burning replace. The Outdoor Lifestyles replace you have se ...

  • Hearth and Home Technologies 42 - page 3

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certication . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started A. Design and Installation Considerations . . . . . . . . . . . . 5 B. T ypical Fireplace Syste ...

  • Hearth and Home Technologies 42 - page 4

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 4 1 Listing and C od e Appro vals A. Appliance Certication This replace system has been tested and listed in accor- dance with UL 127 and CAN/ULC-S610-M87 standards by Underwriters Laboratories Inc. for installation and operation in the Unit ...

  • Hearth and Home Technologies 42 - page 5

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 5 2 Get ting Star t ed A. Design and Installation Considerations Draft is the pressure difference needed to vent replaces successfully . Considerations for successful draft include: • Location of replace and chimney Check building code ...

  • Hearth and Home Technologies 42 - page 6

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 6 Before beginning the installation be sure the following tools and building supplies are available: Reciprocating saw Framing material Pliers High temp caulking material Hammer Gloves Phillips screwdriver Framing square Flat blade screwdriver Ele ...

  • Hearth and Home Technologies 42 - page 7

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 7 3 F raming and Clearances A. Selecting Fireplace Location This outdoor replace will shed moderate amounts of water , but is not waterproof. W ater and condensing water vapor may enter the chase under certain conditions. The replace wil ...

  • Hearth and Home Technologies 42 - page 8

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 8 B A H F Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. C D G G C D H G F J I E Figure 3.1 Fireplace Locations FREEST ANDING INST ALLA TION (Combustible Structure) (Encl ...

  • Hearth and Home Technologies 42 - page 9

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 9 0 in. 0 in. to level of standoffs Combustible Object 36 in. (914 mm) 1-1/2 in. (38 mm) Drywall 0 in. 1/2 in. (13 mm) 1-1/2 in. (38 mm) B. Clearances Figure 3.3 Clearances to Combustible Materials Fire Risk • Comply with all minimum clearan ...

  • Hearth and Home Technologies 42 - page 10

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 10 2 in./51 mm minimum air space clearance to the enclosure. Use only noncombustible material below the top of the top standoffs. 28-3/8 in. 721 cm 74-1/2 in. 1892 cm 53- 7/8 in. 1368 cm C. Sidewalls/Surrounds Adjacent combustible side walls must ...

  • Hearth and Home Technologies 42 - page 11

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 1 1 E. Chimney Requirements When planning your replace location, the chimney construc- tion and necessary clearances must be considered. The re- place system and chimney components have been tested to provide exibility in construction ...

  • Hearth and Home Technologies 42 - page 12

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 12 72 in./183 cm min. TR1 1/TR444 T ermination Cap A. Install the Dual Cooling Air Kit The cooling air kit is supplied as a standard feature with this replace and is required for safe operation. Installation must be done at the time of initial ...

  • Hearth and Home Technologies 42 - page 13

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 13 B. Secure the Fireplace • Position the Fireplace This replace may be placed on either a combustible or noncombustible continuous at surface. Follow the in- structions for framing in Section 3.D. Slide the replace into position. B ...

  • Hearth and Home Technologies 42 - page 14

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 14 A. Chimney Requirements V ertical distances are measured from the base of the re- place. • Minimum overall straight height is 6 ft 4 in. if the replace is fre est andi ng and a min imu m of 10 ft fro m a comb ust ibl e structure. See Fi ...

  • Hearth and Home Technologies 42 - page 15

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 15 B. Using Offsets/Returns T o bypass any overhead obstructions, the chimney may be offset using an of fset/return. An offset and return may be attached together or a chimney section(s) may be used between an offset and return. Perform the fo ...

  • Hearth and Home Technologies 42 - page 16

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 16 C. Assemble the Chimney Sections Attach either a straight chimney section or an offset to the top of the replace (depending on your installation require- ment). Chimney sections are locked together by pushing downward until the top section m ...

  • Hearth and Home Technologies 42 - page 17

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 17 E. Install the Attic Insulation Shield An insulation shield must be installed when there is a pos- sibility of insulation coming into contact with the factory built chimney system. • Be nd the tab s at the to p of the att ic ins ula tio n ...

  • Hearth and Home Technologies 42 - page 18

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 18 6 Complete the Enclosure Figure 6.1 Multiple Chimneys A. Chimney T ermination Chimney T ermination Requirements (See Figure 6.1) • Must have a cap approved and listed for this replace system • Must not be located where it will become plu ...

  • Hearth and Home Technologies 42 - page 19

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 19 T ermination Cap Storm Collar Slope Downward T urn-down Drip Edge Chase (Chimney) 2 in. (51 mm) Collar on Chase T op Caulk .018 (26 ga) min. Galvanized Chase T op Figure 6.3 Chase T op Construction B. Chase T op A metal chase top is require ...

  • Hearth and Home Technologies 42 - page 20

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 20 Not e : T o protect against the ef fect of cor rosio n on t hose par ts exposed to the weather , t he ter mination cap can be painted with a r ust-resist ant paint. Fire Risk • The minimum overlap of cap to pipe MUST be met or chimney may sep ...

  • Hearth and Home Technologies 42 - page 21

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 21 • TCT1 175 T erra Cotta Cap Chimney Pipe Chase T op T ermination Cap Chase Collar 2 in. (51 mm) Minimum Height Remove 2 screws from front & back to lift the top off T ermination cap pipe and chimney section must overlap 1-1/2 in. (38 ...

  • Hearth and Home Technologies 42 - page 22

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 22 A. Gas Log/Lighter Provisions A certied gas log lighter or decorative gas log set can be installed in this replace. This replace was not tested and listed for use with an un- vented gas log heater . Do not install an unvented gas log h ...

  • Hearth and Home Technologies 42 - page 23

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 23 8 F inishing A. Hearth Extension A hearth extension must be installed with all replaces to protect the combustible oor in front of the replace from both radiant heat and sparks. See Figures 8.1 -8.3. 2 in. (51 mm) required Continuo ...

  • Hearth and Home Technologies 42 - page 24

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 24 B. Finishing Material • Combustible Material Material which is made of or surfaced with wood, compressed paper , plant bers, plastics, or any material capable of igniting and burning, whether ame proofed or not, plastered or not plaster ...

  • Hearth and Home Technologies 42 - page 25

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 25 9 Operat ing Instruct ions A. General Information Fireplaces, as well as other woodburning appliances, have been used safely for many years. It has been our experience that most problems are caused by improper installation and operation of ...

  • Hearth and Home Technologies 42 - page 26

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 26 D. Flue Damper The  ue damper must be in full open position, and is oper- ated by moving the handle up toward the top of the  replace. Before lighting the  re, verify this by looking up from the in- side of the  replace. Always oper ...

  • Hearth and Home Technologies 42 - page 27

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 27 G. Grate The factory installed integral grate must be used to hold the logs from falling out of an open replace and to allow air to pass between the burning logs. It is important to keep the re off the hearth and to allow the ashes to ...

  • Hearth and Home Technologies 42 - page 28

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 28 I. Starting a Fire Check the ue damper to be certain it is in the full open po- sition. Place crumpled or twisted paper under the replace grate. Loosely arrange kindling or small pieces of wood to form a layer above the paper . The res ...

  • Hearth and Home Technologies 42 - page 29

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 29 Diagnostics and Problem Solving 1 0 T roubleshooting I can’t get a good re going. What am I doing wrong? Diagnostic Questions Possible Causes of Condition Solutions Is the damper open? • No draft Open damper . Is there enough paper/s ...

  • Hearth and Home Technologies 42 - page 30

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 30 A. Disposal of Ashes Ashes should be placed in a metal container with a tight-t- ting lid. The closed container of ashes should be placed on a noncombustible oor or on the ground, well away from all combustible materials, pending nal d ...

  • Hearth and Home Technologies 42 - page 31

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 31 Fire Risk • Do not use chimney cleaners or ame colorants in your replace. Will corrode chimney . W ARNING D. Maintenance T ask List Asphyxiation Risk Fire Risk Annual inspection by qualified technician recommended. Check: • Condit ...

  • Hearth and Home Technologies 42 - page 32

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 32 1 2 Reference Materials A. Fireplace Dimensions C 23 in. [597 mm] D B 9-1/2 in. [241 mm] E Gas Log Knockout (both sides) F 2-3/8 in. [60 mm] Outside Air (both sides) Gas Knockout for Optional Integrated Burner (both sides) Model A B C D E F MON ...

  • Hearth and Home Technologies 42 - page 33

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 33 B. Fireplace Components Bi-fold Glass Doors Herringbone Pattern Refractory T raditional Brick Pattern Refractory 20 in. (508 mm) 66 in. (1676 mm) 1/2 in. (13 mm) HX4 Hearth Extension 16 in. (406 mm) 52 in. (1321 mm) 1/2 in. (13 mm) HX3 Hear ...

  • Hearth and Home Technologies 42 - page 34

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 34 C. Chimney Components The following pictures show only those chimney components which may be safely used with this replace. 13 in. (330 mm) 14 in. (356 mm) 14 in. (356 mm) 5-1/4 in. (133 mm) 4 in. (102 mm) CAK5A Chimney Air Kit ID4 Insulated ...

  • Hearth and Home Technologies 42 - page 35

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 35 A B 17 in. (432 mm) Ceiling Firestop Assembled Diameter: 17 in./432 mm Height: 24 in./610 mm AS10 Straight Attic Insulation Shield 2 in. (51 mm) 13 in. (330 mm) JB577 Chimney Joint Band 13 in. (330 mm) CB576 Chimney Joint Band 39-7/8 in. (1 ...

  • Hearth and Home Technologies 42 - page 36

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 36 72 in. (1829 mm) 36 in. (914 mm) 2 in. (51 mm) 13-3/8 in. (340 mm) CT56 Chase T op A B C D LDS33/LDS46 Decorative Shroud TR1 1/TR444 Round T ermination Cap 15-3/4 in. (400 mm) TR1 1T/TR442 Round T elescoping T ermination Cap 32-3/8 in. (822 mm) ...

  • Hearth and Home Technologies 42 - page 37

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 37 Woodburning T ermination Cap Shroud TS345/T445 (T op V ent) TR342/TR344 TR442/TR444 TV342 TR342/TR344* TR442/TR444* (* with TR-TVK installed) TR1 1/TR1 1T TV1 1/TV1 1T TR1 1/TR1 1T* (* with TR-TVK installed) OPEN TOP with solid sides and 3 ...

  • Hearth and Home Technologies 42 - page 38

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 38 D. Service Parts Service Parts 06/1 1 36” Outdoor Woodburning Fireplace 2 1 3 4 5 6 8 9 10 1 1 12 13 14 15 16 17 7 Part number list on following page. MONT ANA-36, MONT ANA-36H Beginning Manufacturing Date: Sept 2003 Ending Manufacturing Date ...

  • Hearth and Home Technologies 42 - page 39

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 39 D. Service Parts (continued) Service Parts 06/1 1 42” Outdoor Woodburning Fireplace 2 1 3 4 5 6 8 9 10 1 1 12 13 14 15 16 17 7 MONT ANA-42, MONT ANA-42H Part number list on following page. Beginning Manufacturing Date: Sept 2003 Ending Ma ...

  • Hearth and Home Technologies 42 - page 40

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 40 This page intentionally left blank. ...

  • Hearth and Home Technologies 42 - page 41

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 41 This page intentionally left blank. ...

  • Hearth and Home Technologies 42 - page 42

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 42 E. Limited W arranty Outdoor Lifestyles by Hearth & Home T echnologies, Inc.™ Limited W arranty Hearth & Home T echnologies, Inc. (“HHT”) extends the following warranty for all Outdoor Lifestyles by HHT™ brand products (“Produ ...

  • Hearth and Home Technologies 42 - page 43

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K • 7/1 1 43 Limited W arranty (continued) • Damages resulting from: (1) failure to install, operate, or maintain the Product in accordance with the installation instructions, operating instructions, and listing agent identification label furnished wi ...

  • Hearth and Home Technologies 42 - page 44

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • Montana US-CAN • 4039-156 Rev K 7/1 1 44 – NOTES – F . Contact Information DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation. • Read, understand and follow these in ...

Fabricant Hearth and Home Technologies Catégorie Outdoor Fireplace

Les documents que nous recevons du fabricant de l'appareilHearth and Home Technologies 42 peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Hearth and Home Technologies
- manuels d’utilisations 42
- fiches produit Hearth and Home Technologies
- dépliants
- ou étiquettes-énergie Hearth and Home Technologies 42
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Hearth and Home Technologies 42.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Hearth and Home Technologies 42, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Hearth and Home Technologies 42. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Hearth and Home Technologies 42.

Manuel d’utilisation complet de l’appareil Hearth and Home Technologies 42, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Hearth and Home Technologies 42 par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Hearth and Home Technologies 42.

Le manuel d’utilisation complet Hearth and Home Technologies, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Hearth and Home Technologies 42 - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Hearth and Home Technologies 42, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lHearth and Home Technologies 42 qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Hearth and Home Technologies 42 - qui devraient nous aider dans les premières étapes lors de l'utilisation Hearth and Home Technologies 42
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Hearth and Home Technologies 42
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Hearth and Home Technologies 42 dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Hearth and Home Technologies 42?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Hearth and Home Technologies 42, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Hearth and Home Technologies 42 il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Commentaires (0)