-
Cub Cadet 1451 - page 1
1450digser vice REV 12/6/0 5 SER VICE MANU AL (DOMESTIC ) IMPING ER CONVEYOR OVE NS MODEL 1450,1451 WITH PUSH BUT TON C ONTROLS Lincoln Foo dservice Products, Inc. 1111 North Hadley Road P.O. Box 1229 Fort W ayne, Indiana 46801-1229 Phone : (800) 374 -3004 • Fax: (260) 436 -0735 Technical Service Hot Line (800) 678-9 511 www.lincolnfp. com ...
-
Cub Cadet 1451 - page 2
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 2 SEQUENCE OF OPERATION IMPINGER ADVANTAGE SERIAL NUMBER N2865 4 AND A BOVE (OVENS WITH P USH BUTTON CONTROLS) MODEL 14 50 120VAC 60 HZ. NAT. GAS MODEL 14 51 120VAC 60 HZ. LP GAS POW ER SUPPLY Electrical po wer is supp lied to th e oven b y a three c onductor c ordset. Vo ltage from the black ...
-
Cub Cadet 1451 - page 3
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 3 SCHEMATIC DI AGRAM MODEL 1450, 1451 SERIAL NUMBER N2865 4 AND A BOVE ...
-
Cub Cadet 1451 - page 4
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 4 TROUBLESHOOTING GUIDE IMPINGER ADVANTAGE GAS OVENS SERIAL NUMBER N2865 4 AND A BOVE (OVENS WITH P USH BUTTON CONTROLS) SYMPTO M POSSIBLE CAUSE EVALUATION Oven fan wi ll not run Incom ing power supply Check circuit break er, reset if required. Check power plug to be sure it is f irm ly in re ...
-
Cub Cadet 1451 - page 5
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 5 not running, ch eck for opens, shor ts or gr ounds. W ITH POW ER OFF: Turn m otor to check for lock ed rotor. Replace burner blower m otor as ne eded. Burner trans form er Check for 120VAC su pplied to pr imar y of burner transform er. If no voltage is prese nt, trace wiring bac k to centri ...
-
Cub Cadet 1451 - page 6
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 6 the displa y, replace oven contr ol. If there is a read-out on the contro l, set the control to max imum tem perature (see Installat ion operat ions m anual for temper ature adjustm ent). W ith the control set at m aximum temper ature, check for 120VAC at the tem peratur e regulation valve. ...
-
Cub Cadet 1451 - page 7
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 7 Control transf orm er Check for 120VAC suppl y to the pr imar y of the control transform er. If no voltage is prese nt, trace wiring bac k to the oven power s witch. If vo ltage is pres ent, chec k foe 24VAC at the transf orm er sec ondary. If there is primar y voltage, but n o secondar y v ...
-
Cub Cadet 1451 - page 8
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 8 REMOVAL, INSTALLATION & ADJUST MENTS IMPINGER A DVANTAGE SERIES CAUTION! BEFORE R EMOVING O R INST ALLING AN Y COM PONENT IN T HE IMPINGER OVEN BE SU RE TO DISCONNECT ELECT RICAL PO W ER AND GAS S UPPLY MOTO R, MAIN FAN - R EPLAC EMENT 1. Shut off power at m ain break er. 2. Rem ove lou ...
-
Cub Cadet 1451 - page 9
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 9 THERMOST AT , COOLING F AN - REPLAC EMENT 1. Shut off power at m ain break er. 2. Rem ove control pane l top and f ront cover. 3. Rem ove lead wires a nd mark for reassem bly. 4. Rem ove two (2) scre ws and rem ove therm os tat. 5. Reassem ble in rever se order. BURNER BLOW ER MOTO R - REPL ...
-
Cub Cadet 1451 - page 10
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 10 6. Rem ove incoming nip ple. 7. Rem ove pilot tube ass embly from control valve. 8. Disconnect pipe union j ust abo ve solenoi d valve. 9. Disconnect wiring fr om c ontrol valve m aking note of wire num bers and location. Rem ove p iping fr om old valve for insta llation o n new val ve. 10 ...
-
Cub Cadet 1451 - page 11
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 11 BURNER IGNIT OR - REPLACE MENT 1. Shut off power at m ain break er. 2. Rem ove control pane l top and f ront cover. 3. Rem ove burner assem bl y. (SEE "BURN ER ASS Y.") 4. Rem ove pilot shield and pilot s hield extens ion. 5. Rem ove burner ignitor . 6. Reassem ble in rever se or ...
-
Cub Cadet 1451 - page 12
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 12 REVERSING C ONVE YOR DIRECT ION All ovens le aving our plant are wired to op erate co nveyors f rom lef t to right. T o reverse co nveyor dir ection, use the follow ing proced ure. 1. Shut off power at oven s witch. 2. Set conve yor revers ing switch in the other position. 3. Turn oven “ ...
-
Cub Cadet 1451 - page 13
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 13 This page in tentionally left blank. ...
-
Cub Cadet 1451 - page 14
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 14 GENERAL VIEW ADVANTAGE SERIES LETT ER PART NUMBE R D ESCRIPTIO N A 369003 Door hinge B 369110 Access wind ow assem bly C 369337 Retainer (o ld st yle) 369929 Retainer (n ew style) D 369828 Handle spac er E 369209 Latch & strik e F 369310 Screw, 6-3 2 x 3/16” G 369308 Bottom, acces s ...
-
Cub Cadet 1451 - page 15
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 15 ...
-
Cub Cadet 1451 - page 16
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 16 CONTROL BOX – 1450, 1451 S/N N28654 and ABOVE LETT ER PART # DESCRIPT ION A 369263 Gas Valve B 369344 Pilot Shut Of f Valve C 369398 Solenoid Valve Nat/L P D 370059 Manifold, Burner E 369072 Main Orific e, Nat. 369099 Main Orific e, L.P. F 369144 Pilot Shie ld Extension G 369202 Pilot Sh ...
-
Cub Cadet 1451 - page 17
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 17 ...
-
Cub Cadet 1451 - page 18
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 18 OVEN BA CK ADVANTAGE SERIES GAS AND ELE CTRIC LETT ER PART NUM BER DESCRIPT ION A 3698 08 C over, m otor (gas ove ns) 370140 Cover, m otor (electric ovens) B 3698 00 Motor , main f an (60 H z.) 369214 Motor, m ain fan (50 H z.) C 369033 Motor clam p D 369215 Motor suppor t assem bl y E 369 ...
-
Cub Cadet 1451 - page 19
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 19 ...
-
Cub Cadet 1451 - page 20
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 20 CONVEYOR 1450 SE RIES LETT ER PART NUM BER DESCRIPT ION 369830 Com plete conve yor assembl y A 369816 Conve yor belt 370092 Conve yor belt, 1 foot sec tion B 369825 Retaining r ing C 369813 Conveyor bearing b lock D 369314 Roll, conveyor, notch ed E 369812 Conve yor idler shaf t F 369160 C ...
-
Cub Cadet 1451 - page 21
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 21 ...
-
Cub Cadet 1451 - page 22
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 22 ...
-
Cub Cadet 1451 - page 23
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 23 ...
-
Cub Cadet 1451 - page 24
Impinger I – 1450 Ser ies Ser vice Manua l - Dom estic 24 ...
Cub Cadet 1451についてご質問がありますか?
次のフォームを使用してください
見つけた説明書を読んでもCub Cadet 1451の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがCub Cadet 1451で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。