日本語 dropdown-ico

Hearth and Home Technologies BH 105の取扱説明書

49ページ 4.71 mb
ダウンロード

ページに移動 of 49

Summary
  • Hearth and Home Technologies BH 105 - page 1

                                                 ? ...

  • Hearth and Home Technologies BH 105 - page 2

    ...

  • Hearth and Home Technologies BH 105 - page 3

     H opper Li d L at c h es H opper C on tr o l B oard Co v er C on tr o l B oard C om b u s t i o n B l o w er C om b u s t i o n B l o w er Co v e r T e m p er a t u re / Press ure G a uge Pre ss u re R e l i e f V a l ve A quast a t We l l 1- 1/ 4” F MP T Su pp ly 1- 1/ 4” F MP T R e t u r n A s h D oor Fi re bo x D oo r A ccess C o v er T ...

  • Hearth and Home Technologies BH 105 - page 4

          ? ...

  • Hearth and Home Technologies BH 105 - page 5

       ECO-CHOICE™ LIMITED W ARRANTY Hearth & Home T echnologies Inc., on behalf of its Heatilator® brand (”HHT”), extends the following warranty for all ECO-CHOICE™ furnace and boiler products (“Products”) that are purchased from an HHT authorized dealer . W arranty Coverage: Subject to the conditions, exclu ...

  • Hearth and Home Technologies BH 105 - page 6

      Boiler Kit Materials: (Refer to page 2) List of items contained within the boiler kit shipped with the unit. 1 - Control board cover 1 - Access cover (Hopper Swing Plate Knob) 5 - Spring Handles 1 - 1/2” Boiler Drain 1 - 3/4” Safety Relief V alve 1 - 1/2” Aquastat W ell 1 - 1/2” Dual T emperature/Pressure Gauge ...

  • Hearth and Home Technologies BH 105 - page 7

     Design: The rst thing that needs to be done is deciding where and how the boiler will be installed. Things that need to be taken into consideration are the intended use of the boiler for example, is the boiler going to be used as your primary heating system or is it going to be used as a secondary or backup heating system. If it is to be use ...

  • Hearth and Home Technologies BH 105 - page 8

      NOTE: All installation clearances and restrictions must be adhered to. INST ALLA TION IS TO BE PERFORMED BY A QUALIFIED INST ALLER. NOTE:Use only 4” diameter type “L” or “PL” venting system. Be sure to inspect and clean exhaust venting system frequently . ...

  • Hearth and Home Technologies BH 105 - page 9

     Requirements for T erminating the V enting W ARNING: V enting termi nals must not be recesse d into a wall or siding. NOTE: Only PL vent pipe wall pass-throughs and re stops should be used when venting through combustible materials. NOTE: Always take into consideration the effect the prevailing wind direction or other wind currents will caus ...

  • Hearth and Home Technologies BH 105 - page 10

       Fig. 3 A voiding Smoke and Odors - Negative Pressure, Shut-down and Electrical Power Failure. T o reduce the pr obability of back-drafting or burn back in the pellet boiler during a power failure, it must be able to draft naturally without exhaust blower operation. Negative pressure in the house will resist this natura ...

  • Hearth and Home Technologies BH 105 - page 11

      V enting   4” T ype “L” or “PL” V ent pipe This is the minimum venting conguration. Fig. 5 - Fig. 4 + The minimum vent conguration is a 90 o or T ee on a starter collar and a 24” length horizontal through an exterior wall. A cap on the end should direct the ue gasses down and away from the structure ...

  • Hearth and Home Technologies BH 105 - page 12

       Chimneys taller than 20’ above the connection will require a draft test to determine if the draft is too high. Note: The high burn draft should not exceed .85 IWC. Some form of a restrictor plate may be required at the top of high chimneys to reduce the draft. See page 21 for th ...

  • Hearth and Home Technologies BH 105 - page 13

     Outside Air T o install outside air , use 2 3/4” I.D.galvanized steel ex pipe, part # 2-00-08 544 ( 12’ 6” length ) or part # 2-00-08545 ( 25’ length) See Fig. 6. There is a break- away hole on the rear panel which must be removed before connecting the ex pipe. See Fig. 7. When the appliance is side wall vented: The air intake ...

  • Hearth and Home Technologies BH 105 - page 14

      T o install power to the boiler , rst remove the cover on the 4” X 4” junction box located on the back of the unit. There are several knockout holes provided for the incoming main power wires. Also, a knockout hole can be used for the auxiliary output overheat zo ...

  • Hearth and Home Technologies BH 105 - page 15

     Installing Duct   ? ...

  • Hearth and Home Technologies BH 105 - page 16

     Installing Duct/Air Conditioning  Boilers intended to be connected to an existing boiler or boiler system shall: 1. Be capable of being installed without interfering with the normal delivery of heated water from the original boiler to the radiation system. 2. Be capable of being installed to operate as int ...

  • Hearth and Home Technologies BH 105 - page 17

     NOTE: AL W A YS REFER TO THE INDIVIDU AL COMPONENTS RECOMMENDED INST ALLA TION INSTRUCTIONS FOR THE PROPER MOUNTING POSITION AND LOCA TION WITHIN THE PIPING SYSTEM. HIGHER TEMPERA TURE W A TER (IF NEEDED) NO TE: T YPICALL Y , AS LONG AS THE W A TER TEMPERA TURE NEEDED IS NOT MORE THAN 120 F , THE MIXING V AL VE SHOWN ABOVE (EXAMPLE 2) IS NO ...

  • Hearth and Home Technologies BH 105 - page 18

      * PRESSURE RELIEF V ALVE * TEMPERA TURE/PRESSURE GAUGE AIR VENT T YPICAL BOILER HOT WA TER PIPING SHOWING AIR REMOV AL SYSTEM, PROVISIONS FOR THE EXP ANSION OF W A TER AND THE AUT OMA TIC COLD W A TER SUPPL Y . ALSO SHOWN IS THE A UTOMA TIC MIXING V AL VE. THIS COULD ALSO BE DONE BY (2) CL OSEL Y SP ACED ...

  • Hearth and Home Technologies BH 105 - page 19

       ? ...

  • Hearth and Home Technologies BH 105 - page 20

       MINIMUM OF 72" OF 3/4" FINNED BASEBOARD (HIGH TEMPERA TURE) BASEBOARD HEA T SYSTEM RETURN SHUT-OFF V ALVE NOTE: AL W A YS REFER TO THE INDIVIDU AL COMPONENTS RECOMMENDED INST ALLA TION INSTRUCTIONS FOR THE PROPER MOUNTING POSITION AND LOCA TION WITHIN THE PIPING ...

  • Hearth and Home Technologies BH 105 - page 21

      D ra ft B o lt L oc at io n Vi e wing W i ndow Ai r was h S l o t Fi r ebox Door Fig. 9 “T est” Low Draft Adjustment Pot Fig. 10 Fig. 1 1 Covered Un-Covered Air W ash Slot Draft T est Procedure After the venting is completed, the rebox low draft will need to be checked and possibly adjusted. After ...

  • Hearth and Home Technologies BH 105 - page 22

     Fuel and Fuel Storage Pellet fuel quality can uctuate from manufacturer to manufacturer , and even from bag to bag. Hearth & Home T echnologies recommends using only fuel that is certied by the Pellet Fuels Institute (PFI). Fuel Material • Made from sawdust and/or other wood by-products • Source material typically determines as ...

  • Hearth and Home Technologies BH 105 - page 23

      Power Light Indicates power to the contr ol boar d. Status Light W ill be lit anytime ther e is a call for heat. Combustion Blower Light Indicates Power to combustion blower Feed Motor Ligh t Indica tes Power to the feed motor . Max T emp dial The “Max T emp Dial” is used to set the desir ed maximum operating ...

  • Hearth and Home Technologies BH 105 - page 24

      Contr ol Board Operation Aquastat Sensor - This sensor is located in the aqua- stat well on the top of the water jacket. This sensor along with the outdoor air sensor is what the control board uses to regulate the feed rate based on these two observed conditions. (Boiler T emp. & Outdoor Air T emperature) Outd ...

  • Hearth and Home Technologies BH 105 - page 25

          ? ...

  • Hearth and Home Technologies BH 105 - page 26

     1. T urn Mode Selector to “OFF”. This resets the control in addition to turning it off. Starting A Fire Automatically  3. Fill Hopper with pellets. When lling the hopper check for excessive nes in the bottom of the hopper . Fines are small pieces of br oke n pell et s (s awd us t) . Fi ne s do not ow e ...

  • Hearth and Home Technologies BH 105 - page 27

     4. If Starting After an Empty Hopper , T urn Feed Adjuster to “TEST” (for one 60 second cycle). This will feed pellets into the auger tube and also allow you to check the motors for operat ion. NOTE: The auger motor will not operate with any of the doors open. 7. T u r n t he M A X . T E M P . D ia l on the control board to the desired t ...

  • Hearth and Home Technologies BH 105 - page 28

     8. T urn the MIN. TEMP . Dial on the control board to the desired Minimum temperature. This will start the lighting process if the temperature at the aquastat sensor is approximately 5° F . less than the set temperature on the MAX TEMP . dial. T h i s i s m o r e t h a n j u s t a n a u t o m a t i c i g n i t i o n p e l l e t boiler . The ...

  • Hearth and Home Technologies BH 105 - page 29

      NOTE: Stirrin g the starti ng gel into the pellet s usually allows the r e to become established quicker . CAUTION: A vapor ash could occur if too much time is allowed to pass before lighting the starting gel. CAUTION: Care must be taken not to get starting gel on your hands or clothing. Serious burns could ...

  • Hearth and Home Technologies BH 105 - page 30

     Fig. 18 Burnpot Cleaning: The burnpot should be cleaned no less than once a week. For best operation the burnpot should be cleaned every time the hopper is lled with pellets. The re does not have to be out to scrape the burnpot although it is recommended the boiler be on minimum burn at the time of cleaning. Note: Scraping can be done ...

  • Hearth and Home Technologies BH 105 - page 31

      Fig. 21 A s h Door Handl e A s h Door A s h P a n A s h P a n Handl e Ash Removal It is recomme nded to remove the ashe s when the boile r is not in oper ation . This lessen s the chance s of coming in contact with hot surfaces. Ashes can be removed while in operation but, extra care must be taken. Open Ash ...

  • Hearth and Home Technologies BH 105 - page 32

      Cleaning This cleaning should be done after each ton of pellets used. The frequency of this cleaning w ill be directly related to the quality and the ash content of the pel- lets being used. Keep in mind that the cleaner the heat exchanger surface is kept, the higher the heat transfer efciency will be. Du ...

  • Hearth and Home Technologies BH 105 - page 33

      The boiler MUST be OFF and COOL before you should attempt to clean the combustion blower . The wire to the combustion blower doesn’ t need to be disconnected during the cleaning process. Loosen the three (3) thumb screws about 4 turns each. See Fig. 23. Hold the motor head with one hand and the blower plat ...

  • Hearth and Home Technologies BH 105 - page 34

          ...

  • Hearth and Home Technologies BH 105 - page 35

       ...

  • Hearth and Home Technologies BH 105 - page 36

             ...

  • Hearth and Home Technologies BH 105 - page 37

             ? ...

  • Hearth and Home Technologies BH 105 - page 38

             ...

  • Hearth and Home Technologies BH 105 - page 39

             ...

  • Hearth and Home Technologies BH 105 - page 40

             ? ...

  • Hearth and Home Technologies BH 105 - page 41

             ? ...

  • Hearth and Home Technologies BH 105 - page 42

      BTU Input Range= 0, and 9350 to 1 13,900* 0 BTU if system is satised. Min. Burn = 1.1 pound per hour Max. Burn = 13.4 pounds per hour * 8500 BTU per pound gures Electrical 120 V AC 60 Hz Combustion blower 1.4 AMP Auger motor .7 AMP Igniter element 3.6 AMP Control board .05 AMP Approximate operati ...

  • Hearth and Home Technologies BH 105 - page 43

      GREEN/YELL OW DARK BL UE PELLET BOILER WIRING DIAGRAM 4" SQUARE JUNCTION BO X BLACK GREEN/YELLOW WHITE RED RED WHITE GREEN 3/8"FLEX CONDUIT BROWN WHITE WHITE WHITE RED DARK BLUE AUX. OUTPUT (OVERHEA T ZONE) 120 V AC 60 HZ MAIN POWER (SUPPLIED BY OTHERS) WHITE GREEN BLACK RED WHITE BROWN 3/ ...

  • Hearth and Home Technologies BH 105 - page 44

       “105 Series” PELLET BOILER WHITE GREEN Relay enclosure box - GRAINGER # 1EGH7 RED RED WHITE GREEN DPDT RELA Y flange mtd. - GRAINGER # 2XC O2 2 4 6 3 1 5 1/2" CONDUIT 8 7 16-3 A WG PVC CORD These cord tails can be made from an inexpensive 16/3 e ...

  • Hearth and Home Technologies BH 105 - page 45

       W ood Hearth & Home T echnologies, Inc. W ARNING: R isk of fire - Do not operate with the flue draft ex ceeding -.9 in W ater Column / -224P a. A T TENTION: Risque de feu - Ne fonctionnez pas avec l'ébauche deconduite de cheminée excédan t -.9 " colonne de l'eau / -224Pa. BH105 B ...

  • Hearth and Home Technologies BH 105 - page 46

      Date Of Service Performed By Description Of Service ...

  • Hearth and Home Technologies BH 105 - page 47

     Proudly P rinted On 100% Recycled P aper ...

  • Hearth and Home Technologies BH 105 - page 48

    1 T urn Mode Selector to OFF . 2 Use heat exchanger cleanout r ods to clean the heat exchanger tubes.** 3 Scrape the air holes in the burnpot.** 4 Fill the hopper with pellets. 5 T urn Feed Adjuster to “T est”.* 6 Check the Combustion Blower and Feeder Motor for operation.* 7 T urn Feed Adjuster back to the #4 setting. 8 T urn the MAX TEMP dial ...

  • Hearth and Home Technologies BH 105 - page 49

    At Harman, we build each pr oduct to a standard, not a price. This pow erful heating appliance boasts uncompr omising attention to detail and helps preserve our planet by using envir onmentally responsible fuels. (Signatur e of Box er) Y our pr emium quality hear th product designed and assembled by the experienced and skilled members at Harman in ...

メーカー Hearth and Home Technologies カテゴリー Egg Cooker

Hearth and Home Technologies BH 105のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- BH 105の取扱説明書
- Hearth and Home Technologiesの製品カード
- パンフレット
- またはHearth and Home Technologies BH 105の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Hearth and Home Technologies BH 105の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Hearth and Home Technologies BH 105の取り付け説明書、サービスマニュアル、簡易説明書、またはHearth and Home Technologies BH 105のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Hearth and Home Technologies BH 105の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Hearth and Home Technologies BH 105デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがHearth and Home Technologies BH 105を使用するのを助ける技術的文書のことです。説明書は通常、全てのHearth and Home Technologies BH 105ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Hearth and Home Technologiesの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Hearth and Home Technologies BH 105の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははHearth and Home Technologies BH 105の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Hearth and Home Technologies BH 105に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Hearth and Home Technologies BH 105デバイスの基本機能を使うにあたってのヒント。 Hearth and Home Technologies BH 105のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Hearth and Home Technologies BH 105に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるHearth and Home Technologies BH 105のメーカー/サービスへの連絡先に関する情報。

Hearth and Home Technologies BH 105についてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもHearth and Home Technologies BH 105の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがHearth and Home Technologies BH 105で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)