AT&T D-10,000の取扱説明書

13ページ 0.48 mb
ダウンロード

ページに移動 of 13

Summary
  • AT&T D-10,000 - page 1

    107 W. Main Street Worthington, PA 16262 Phone: 724.297.3416 Fax: 724.297.5189 h t t p :/ / www.a ir ta k. c o m OPERATING INSTRUCTIONS Refrigerated Air Dryers Models D-320 through D-10,000 4-2002 ...

  • AT&T D-10,000 - page 2

    2 Contents A. INTRODUCTION B. RECEIVING C. LOCATION D. FOUNDATION E. PIPING F. ELECTRICAL G. COMPRESSED AIR CIRCUIT 1. Air to Air Heat Exchanger 2. Air to Refrigerant Heat Exchanger (Evaporator) 3. Drain Traps H. REFRIGERANT CIRCUIT 1. Refrigerant Compressor 2. Air-C ooled Condenser and Condenser Fan Cycling Control (Low Ambient) 3. Air to Refriger ...

  • AT&T D-10,000 - page 3

    3 A. INTRODUCTION AIR/TAK Refrigerated Compressed Air Dryers are of the hi gh-efficiency type, designed to effectively remove moisture from compressed air by means of a refrigerat ion process. The compressed air pressure dewpoint is reduced to 38°F and then reheated to prevent in-plant air lines from sweating. The 38°F dewpoint can be maintained ...

  • AT&T D-10,000 - page 4

    4 In keeping with good compressed air piping design, the air dryer should be installed on the downstream side of the air receiver and aftercooler. An AIR/TAK prefilter(s) for oil and dirt removal in stalled at the inlet of the dryer is recommended. Contamination can be present in a compress ed air system and can reduce the ability of the dryer heat ...

  • AT&T D-10,000 - page 5

    5 G. COMPRESSED AIR CIRCUIT 1. Air-to-Air Heat Exchanger: This unique high-efficiency heat exchanger is of a finned shell and tube design. The tubes are of high quality copper and are enhanced by outer fins of corrugated aluminum . The air is first directed into the shell of the heat exchanger and is baffled back and forth across the finned t ubes ...

  • AT&T D-10,000 - page 6

    6 The circuiting within the evaporator is serpent ined in such a manner as to guarantee a completely flooded evaporator. Each evaporator is designed to insure adequat e refrigerant velocity to eliminate the problem of oil return to the crankcase. 4. Expansion Valves: The thermostatic expansion valve (TXV) is used on Model D-320-A, and larger. This ...

  • AT&T D-10,000 - page 7

    7 10. Oil Sightglass: The oil sightglass is found on the side of the cr ankcase on accessible scroll compressors to provide a visual means of checking the oil level. The oil must be checked only while the compressor is in operation. During compressor operation the oil sight glass should be approximately 1/2 full. 11. Refrigerant Liquid Line Filter- ...

  • AT&T D-10,000 - page 8

    8 I. START-UP After the installation of your air dryer at a su itable location, the following checks should be made: a) Bypass piping installed and valves set to bypass the dryer. b) Before start-up, the refrigerant analyzer gauge should indicate a dryer shutdown pressure of 125-175 PSIG for R-22 or 74-108 PSIG fo r R-134a for Models D-320-A throug ...

  • AT&T D-10,000 - page 9

    9 J. DESIGN CONDITIONS Each dryer is shipped complete and ready for installation. Every dryer is tested and preset at the factory for optimum service at the design conditions. The following ar e the standard design conditions for a refrigerated dryer operating at 60 HZ: 38°F (3.3°C) Pressure Dew Point 100° F (37.8°C) Inlet Temperature (Compress ...

  • AT&T D-10,000 - page 10

    10 Cooling Water Requirements MODEL # HEAT TO COOLING WATER KW INPUT (4) COOLING WATER AMBIENT (1) GPM (2) GPM (3) D-400-W 23682 1780 4.7 1.9 1.95 D-500-W 33894 2550 6.8 2.7 2.6 D-600-W 37250 3650 7.5 3.0 2.92 D-800-W 52859 3980 10.6 4.3 4.22 D-1000-W 66150 5360 13.2 5.3 4.8 D-1600-W 90845 7366 18 7.3 6.82 D-2000-W 128646 10431 26 10.3 9.4 D-2500-W ...

  • AT&T D-10,000 - page 11

    11 SYMPTOMS PROBABLE CAUSE REMEDY Dryer not running. a. Disconnect open. a. Close disconnect. High temperature light off, analyzer gauge normal. b. Fuse blown. b. Replace fuse. c. Wiring, improper or broken. c. Check wiring diagram or repair. d. Control transformer d. Replace. defective. e. Unit not turned on. e. Turn unit on. Dryer not running. a. ...

  • AT&T D-10,000 - page 12

    12 SYMPTOMS PROBABLE CAUSE REMEDY g. Defective refrigerant g. Repair or replace compressor valves. compressor. h. Suction pressure too high. h. Adjust hot gas bypass valve. Dryer running. a. Leaky refrigerant circuitry. a. Locate and repair. High temperature light on, analyzer gauge pressure low. b. Suction pressure too low b. Adjust hot gas Check ...

  • AT&T D-10,000 - page 13

    13 High pressure drop across a. Excess flow. a. Dryer undersized. dryer inlet and outlet. Replace with larger dryer. b. Low air pressure. b. Dryer undersized. Replace with larger dryer. c. Partially frozen. c. Shut dryer off until ice melts. Power light “ON” but dryer a. No cooling water supply to a. Check cooling water supply. not running drye ...

メーカー AT&T カテゴリー Clothes Dryer

AT&T D-10,000のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- D-10,000の取扱説明書
- AT&Tの製品カード
- パンフレット
- またはAT&T D-10,000の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、AT&T D-10,000の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、AT&T D-10,000の取り付け説明書、サービスマニュアル、簡易説明書、またはAT&T D-10,000のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、AT&T D-10,000の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

AT&T D-10,000デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがAT&T D-10,000を使用するのを助ける技術的文書のことです。説明書は通常、全てのAT&T D-10,000ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

AT&Tの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. AT&T D-10,000の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははAT&T D-10,000の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。AT&T D-10,000に関してこのドキュメントで見つけることができる全てのヒントの目次
3. AT&T D-10,000デバイスの基本機能を使うにあたってのヒント。 AT&T D-10,000のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。AT&T D-10,000に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるAT&T D-10,000のメーカー/サービスへの連絡先に関する情報。

AT&T D-10,000についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもAT&T D-10,000の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがAT&T D-10,000で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)