Campbell Hausfeld Welder / Generator GW4500の取扱説明書

20ページ 6.93 mb
ダウンロード

ページに移動 of 20

Summary
  • Campbell Hausfeld Welder / Generator GW4500 - page 1

    W elder / Generator T able of Contents Description . . . . . . . . . . . . . . . . . . . . . . 1 Unpacking . . . . . . . . . . . . . . . . . . . . . . . 1 Safety Guidelines . . . . . . . . . . . . . . . . . 1 Specifications. . . . . . . . . . . . . . . . . . . . . 1 General Safety Information . . . . . . 2 - 4 Glossary of T erms . . . . . . . . . . ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 2

    2 www .chpower .com Operating Instructions and Parts Manual General Safety Information CALIFORNIA PROPOSITION 65 The cables on this product may contain chemicals, including lead, known to the State of California to cause cancer and birth defects or other repr oductive harm. W ash hands after handling. The engine exhaust from this pr oduct contains ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 3

    3 www .chpower .com GW4500 General Safety Information (Continued) Always keep a fire extinguisher accessible while performing arc welding operations. • All installation, maintenance, repair and operation of this equipment should be performed by qualified persons only in accordance with national, state, and local codes. Improper use of electric ar ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 4

    4 www .chpower .com Operating Instructions and Parts Manual General Safety Information (Continued) Fire hazard! Do not weld on containers or pipes that contain or have contained flammable materials or gaseous or liquid combustibles. Arc welding closed cylinders or containers such as tanks or drums can cause explosion if not properly vented! V erify ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 5

    5 www .chpower .com GW4500 Getting T o Know Y our Welder / Generator Glossary of T erms AC or Alternating Current - electric current that reverses direction periodically . Sixty cycle current travels in both directions sixty times per second. Arc Length - the distance from the end of the electrode to the point where the arc makes contact with the w ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 6

    6 www .chpower .com Operating Instructions and Parts Manual GROUNDING 1. Use the ground terminal and wing nut on the welder / generator frame to connect the unit to a suitable ground source. Securely fasten the end terminal of the ground wire to the ground terminal on the welder / generators frame. Tighten the washer and wing nut on top of the grou ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 7

    7 www .chpower .com GW4500 combination of 240 volt loads and also with 120 volt loads through the 120 volt receptacles. The 120/240 volt twist lock receptacle , found on some welder / generators, is rated for 20 amps and may be used in any combination of 120 volt and 240 volt loads. 4. Individual receptacles should not be loaded beyond the amperage ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 8

    8 www .chpower .com Operating Instructions and Parts Manual Generator Operation (Continued) INST ALLA TION FOR ST AND-BY USE Precautions must be taken to prevent electrical back feeding into utility systems. This requires isolation of the electrical system. T o isolate the electrical system, perform the following procedures: 1. T urn off the main e ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 9

    9 www .chpower .com GW4500 Welder Operation (Continued) 5. T ighten the set screw , securing the cable in place. 6. Slide the insulated handle onto the electrode holder and tighten the phillips head screw . Do not overtighten the phillips head screw . Overtightening will damage the insulated handle. DINSE PLUGS (SEE FIGURE 3) 1. Strip 1/2 inch of i ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 10

    10 www .chpower .com Operating Instructions and Parts Manual Welding Guidelines GENERAL This line of welding machines utilizes a process known as Shielded Metal-Arc W elding (SMAW). This process is used to bond metals by heating them with an electric arc created between the electrode and the work piece. Electrodes used for shielded metal arc weldin ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 11

    11 www .chpower .com GW4500 Welding Guidelines (Continued) W ork angle is the angle from horizontal, measured at right angles to the line of welding. For most applications, a 45º travel angle and 45º work angle is sufficient. For specific applications, consult an arc welding handbook. NOTE: Right handed welders should weld from left to right. Lef ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 12

    12 www .chpower .com Operating Instructions and Parts Manual Welding Guidelines (Continued) SLAG REMOV AL Wear ANSI approved safety glasses (ANSI Standard Z87.1) and pr otective clothing when removing slag. Hot, flying debris can cause personal injury to anyone in the area. After completing the weld, wait for the welded sections to cool. A protecti ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 13

    13 www .chpower .com GW4500 T roubleshooting Chart - General Symptom Possible Cause(s) Corrective Action Engine will not start 1. Engine switch is set to "OFF". 2. Fuel valve is turned to "CLOSE". 3. Choke is open. 4. Engine is out of gas. 5. Engine is filled with contaminated or old gas 6. Spark plug is dirty . 7. Spark plug is ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 14

    14 www .chpower .com Operating Instructions and Parts Manual T roubleshooting Chart - W elder Symptom Possible Cause(s) Corrective Action Welder runs but does not weld 1. Inadequate current at electrode 2. Poor connections at welder 3. Front panel switch set incorrectly 4. Open, shorted, or incorrect wiring 5. Faulty capacitor 6. Open or shorted fi ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 15

    15 www .chpower .com GW4500 Welding Impedance Gen. Weld. Rotor Red White Brown Battery Charger 12V AC Blue Brown Grey Red Black White Y ellow Green Main Winding Brown Red White Green Generator/Welder Power Switch 2 4 6 8 10 12 14 16 18 20 22 24 13 5 7 9 1 1 1 3 1 5 1 7 1 9 2 1 2 3 Capacitor Thermal T rip (Fitted Inside the Windings) Violet Black Bl ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 16

    16 www .chpower .com Operating Instructions and Parts Manual 1 2 7 3 4 5 6 8 9 10 11 12 13 14 15 16 17 18 19 20 11 11 11 21 22 Figure 12 Welder / Generator Assembly ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 17

    17 www .chpower .com GW4500 For r eplacement parts or technical assistance, call 1-800-543-6400 1 Engine - Honda GX270 PM004264A V 1 2 W elded Frame Assembly GW004000AD 1 3 T ie Bracket GN004399AD 1 4 Isomount - Angle (short) GN004405A V 1 5 Isomount - Angle (extended) GN004406A V 1 6 Isomount GN004401A V 1 7 Hat Bracket GW004050AD 1 8 Hex head Scr ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 18

    18 www .chpower .com Operating Instructions and Parts Manual 1 2 3 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 4 10 28 Figure 13 Alternator Assembly ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 19

    19 www .chpower .com GW4500 For r eplacement parts or technical assistance, call 1-800-543-6400 1 Alternator - 4kW , 140A AC (includes items 2 through 22) GW001000A V 1 2 Engine Adapter GN002301SV 1 3 Rotor T ie Rod GN002304SV 1 4 Nyloc Nut - M8-1.25 ▲ 5 5 Diode, Suppressor , Capacitor Kit (2 each) GN002337SJ 1 6 Air Outlet Guard GN002310SV 2 7 R ...

  • Campbell Hausfeld Welder / Generator GW4500 - page 20

    20 www .chpower .com Operating Instructions and Parts Manual Limited W arranty 1. DURA TION: The manufacturer warrants that it will repair , at no charge for parts or labor , the welder , welding gun, or cables, proven defective in material or workmanship, during the following time period(s) after date of original retail purchase: For 5 Y ears: The ...

メーカー Campbell Hausfeld カテゴリー Welding System

Campbell Hausfeld Welder / Generator GW4500のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- Welder / Generator GW4500の取扱説明書
- Campbell Hausfeldの製品カード
- パンフレット
- またはCampbell Hausfeld Welder / Generator GW4500の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Campbell Hausfeld Welder / Generator GW4500の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Campbell Hausfeld Welder / Generator GW4500の取り付け説明書、サービスマニュアル、簡易説明書、またはCampbell Hausfeld Welder / Generator GW4500のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Campbell Hausfeld Welder / Generator GW4500の製品を使用するにあたって最も人気のある説明書を閲覧できます。

Campbell Hausfeld Welder / Generator GW4500デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがCampbell Hausfeld Welder / Generator GW4500を使用するのを助ける技術的文書のことです。説明書は通常、全てのCampbell Hausfeld Welder / Generator GW4500ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Campbell Hausfeldの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Campbell Hausfeld Welder / Generator GW4500の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははCampbell Hausfeld Welder / Generator GW4500の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Campbell Hausfeld Welder / Generator GW4500に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Campbell Hausfeld Welder / Generator GW4500デバイスの基本機能を使うにあたってのヒント。 Campbell Hausfeld Welder / Generator GW4500のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Campbell Hausfeld Welder / Generator GW4500に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるCampbell Hausfeld Welder / Generator GW4500のメーカー/サービスへの連絡先に関する情報。

Campbell Hausfeld Welder / Generator GW4500についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもCampbell Hausfeld Welder / Generator GW4500の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがCampbell Hausfeld Welder / Generator GW4500で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)