English dropdown-ico

Manual Bosch GWH 425 EF

26 pages 13.7 mb
Download

Go to site of 26

Summary
  • Bosch GWH 425 EF - page 1

    Water heat ers for u se with Natural an d L.P.G. GWH 425 EF Flow Modulat ed wit h Elec t ronic Ignit ion and Power V ent ing Suit able for heat ing pot able w ater only - Not a pproved fo r spac e heat ing purpose s (Intend ed for vari able flow a pplicatio ns with stea dy cold wa ter inlet t emperatu res) GWH- 425-EF -N GWH- 425-EF -L 6 720 607 01 ...

  • Bosch GWH 425 EF - page 2

    2 6 720 607 017 WARNING : Improper installation, adjustment , alteration , service or maintenance can c ause injury or property damage. Refer to this manual. For assistance or additional information consult a qualified installer, service agency or the gas supplier . Upon completion of the installation, these instructions should be handed to the use ...

  • Bosch GWH 425 EF - page 3

    3 6 720 607 017 425 EF LP and 425 EF NG Specifications W ater C onnection 1 /2” Thread fitting N PT H x W x D 29 3/ 4” x 1 8 1 / 4” x 8 3/ 4" V ent 4” Gas C onnection 1 /2” N PT thread Min. W ater Pressure 1 8 Psi Max. W ater Pressure 1 50 Psi Shipping W eight 50.6 LB Net W eight 44 LB 2.3 G P M at 90 ° rise 4.6 G P M at 45 ° rise ...

  • Bosch GWH 425 EF - page 4

    4 6 720 607 017 M I N I M U M I N S T ALLA TIO N C LE AR AN C E S F R O M C O M B U STI B LE AN D N O N CO M B U STI B LE MA TE R IAL S F O R AL C OVE O R C L O SET I N ST ALLA TI O N S FR O NT VI EW S I D E VI EW MO DE L 425 E F * On a combustible wall surface the unit should be mounted away from the wall to provide adequate clearance of the vent ...

  • Bosch GWH 425 EF - page 5

    5 6 720 607 017 G E N E R AL R U LE S T O FOLL O W FOR SAF E OP E R A TION 1. Y ou should follow these instructions when you inst all your heater . In the United St ates : The installation must conform with local codes or, in the absence of local codes , the National Fuel Gas Code AN S I Z223. 1 / N F P A 54. In Canada: The Installation should conf ...

  • Bosch GWH 425 EF - page 6

    6 6 720 607 017 COMBUSTION AIR REQUIREMENTS The 425 E F water heater holds cold water in its copper heat exchanger and brass water valve when not in use. Because of this, any cold air that comes in through the unit’s vent pipe is capable of freezing these components. This Installation Manual specifies the vent length requirements and the amount o ...

  • Bosch GWH 425 EF - page 7

    7 6 720 607 017 Fig. 3 - Incandescent Part icle T ray Illust ration The incandescent particle tray (shipped loose in the carton with the water heater) must be attached at the bottom of the water heater front cover at the time of installation. Use the screws provided. See figure 3. SCREWS INCANDESCENT P ARTICLE TRA Y Fig. 2 - Mounting the Heater WAL ...

  • Bosch GWH 425 EF - page 8

    8 6 720 607 017 VENTING WARNING: Do not reduce the vent pipe size and do not common vent with any other vented appliance or stove. This appliance must be vented horizontally to the outside with a sealed 4” single wall vent pipe. The appliance’s flue gasses are under positive pressure and must travel through a single wall 4” pipe that is seale ...

  • Bosch GWH 425 EF - page 9

    9 6 720 607 017 Fig 4: S ome V enting Guide Suggest ions An approved side wall vent terminal must be used when the water heater is vented through a side wall. Locate in accordance with AN SI Z223. 1 and local applicable codes. See Fig 5 for restrictions in location of vent terminal in relation to opening doors and windows, grade, and forced air inl ...

  • Bosch GWH 425 EF - page 10

    10 6 720 607 017 Fig 5: Side wall exit locations for mechanical draft vent terminals SOFFIT VENT HOOD 7’ MINIMUM ABOVE PUBLIC WALKW AY ONE FOOT ABOVE GRADE 3’ ABOVE ANY FORCED AIR INLET WITHIN 10’ 4’ MIN 1’ MIN 4’ MIN 4’ MIN 4’ MIN 1’ MIN VENT HOOD MUST BE MOUNTED FOUR FEET AW AY FROM DOORS AND WINDOWS VENT HOOD MUST BE MOUNTED FO ...

  • Bosch GWH 425 EF - page 11

    11 6 720 607 017 Fig. 6 - Appliance pressure regulator (with directional arrow on reverse side pointing up) GAS LINE SIZING The pressure regulator provided with the heater is adjusted to deliver the proper gas pressure (as indicated on the rating plate and in the manual for altitude up to 2000 feet (660 meters) above sea level. On appliances being ...

  • Bosch GWH 425 EF - page 12

    12 6 720 607 017 GAS PIPING, CONNECTIONS Before connecting the gas supply, chec k the rating plate on the right side of the front cover to be sure that the heater is rated for the same gas to which it will be connected. In the United States : The installation must conform with local codes or , in the absence of local codes , the National Fuel Gas C ...

  • Bosch GWH 425 EF - page 13

    13 6 720 607 017 Fig.7 - Water valve and water connectors, top view W A T ER C O NNEC T IO NS Install the heater centrally in the building if possible and make hot water piping runs as short as possible When facing the heater , the cold water inlet will be on the right and the hot water outlet on the left.. Although water piping throughout your str ...

  • Bosch GWH 425 EF - page 14

    14 6 720 607 017 ELECTRICAL CONNECTIONS WARNING: For safety reasons, disconnect the power supply to the heater before any service or testing is performed. WARNING: This heater must be electrically grounded in accordance with the most recent edition of the National Electrical Code , NF P A 7 0. In Canada , all electrical wiring to the heater should ...

  • Bosch GWH 425 EF - page 15

    15 6 720 607 017 OPER A T ING INST RUC T IO NS Before operating the heater , make sure that the system is filled with water . Open the cold water inlet supply to the heater fully . Open a hot water faucet to permit the water to fill the heater and the piping and to eliminate the air trapped in the system Close the hot water faucet after the water f ...

  • Bosch GWH 425 EF - page 16

    16 6 720 607 017 Fig. 1 2 - Charact eristic Pilot Flame Flame sensor Piezo Electrode W at e r V alve (Part # 87 07 002802): The water valve on this heater should be ser viced periodically . Lubricate component #36 on page 22 with a small amount of silicon, faucet or lithium grease every two years to keep its o rings fresh and pushrod sliding smooth ...

  • Bosch GWH 425 EF - page 17

    17 6 720 607 017 3. Water flow is not sufficient to activate heater . W ater flow rate at faucet is below minimum flow needed to activate heater . When temperature adjustment knob is turned all the way clockwise, the model 425 EF requires 1 /2 gallon per minute flow to activate the heater. As a reference , this is a flow which would fill a quart ja ...

  • Bosch GWH 425 EF - page 18

    18 6 720 607 017 Mineral deposits can eventually (3-5 years in hard water areas) corrode the water valve parts to a point where they will need replacing. Any sign of moisture at the bleed hole is a sign that the water valve needs to be replaced immediately. 1 0. Poor circuit connect ions at t he EC O ( overheat sensor ) or the flue gas safety devic ...

  • Bosch GWH 425 EF - page 19

    19 6 720 607 017 WA T E R I S T OO HOT 1 . T emperat ure Select ion t oo high T urn the temperature adjustment knob counter-clockwise (to the left) to lower the maximum water temperature. Note: This will increase the activation flow rate. 2. Inlet water temperature is very warm (60°-75°F) Reduce inlet gas supply to lower the heaters degree rise. ...

  • Bosch GWH 425 EF - page 20

    20 6 720 607 017 ...

  • Bosch GWH 425 EF - page 21

    21 6 720 607 017 Fig . 1 5 - Diagram of 425 E F 1 . Heat exchanger 2. Pilot assembly 3. Burner manifold gas pressure test nipple 4. Main gas burner 5. Pilot gas tubing 6. Gas valve 7 . electric control box 8. Power cord 9. on/off switch 1 0. T emperature adjustment selector 1 1 . Microswitch 1 2. Gas inlet gas pressure test nipple 1 3. Exhaust Fan ...

  • Bosch GWH 425 EF - page 22

    22 6 720 607 017 Fig. 1 6 - I NTE R IOR COM PO N E NTS D IAGR AM AN D P ARTS LI ST ...

  • Bosch GWH 425 EF - page 23

    23 6 720 607 017 Fig. 1 6 INTERIOR COMPONENTS DIAGRAM AN D P ARTS LIST 425 E F 1 Cover 8 705 421 775 2 Temperature a djustment knob 8 702 000 111 3 Temperature adjustment collar 8 700 403 008 4 Draft diverter 8 705 505 451 5 Heat excha nger 8 705 406 235 6 Overheat sensor (ECO) 8 707 206 040 7 Main burner 8 708 120 298 NG 7 Main burner 8 708 120 29 ...

  • Bosch GWH 425 EF - page 24

    24 6 720 607 017 Fig. 1 7 - Flow chart of 425 EF ...

  • Bosch GWH 425 EF - page 25

    25 6 720 607 017 Fift een Y ear Limit ed Warranty General B O SC H P R O water heaters are warranted by the Manufacturer ( B O SC H ) through C ontrolled Energy C orp. C ontrolled Energy Corp . ( C E C ) will furnish a replacement heat exchanger and will furnish a replacement of any other part which fails in normal use and service within the applic ...

  • Bosch GWH 425 EF - page 26

    VU L C AN O T ermodomésticos S.A . Estrada de Cacia 380 1 - 8 56 Aveiro - P O RTUGAL Recycled paper © 20 04 C ontrolled Energy Corporation , W aitsfield , V T all rights reserved Replacement Parts available from North American Distributor CONTROLL E D E NE R G Y C OR P . 340 Mad River Park Waitsfield, Vermont 0 567 3 Phone 86 6-33 0-27 30 Fax (80 ...

Manufacturer Bosch Category Water Heater

Documents that we receive from a manufacturer of a Bosch GWH 425 EF can be divided into several groups. They are, among others:
- Bosch technical drawings
- GWH 425 EF manuals
- Bosch product data sheets
- information booklets
- or energy labels Bosch GWH 425 EF
All of them are important, but the most important information from the point of view of use of the device are in the user manual Bosch GWH 425 EF.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Bosch GWH 425 EF, service manual, brief instructions and user manuals Bosch GWH 425 EF. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Bosch GWH 425 EF.

Similar manuals

A complete manual for the device Bosch GWH 425 EF, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Bosch GWH 425 EF by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Bosch GWH 425 EF.

A complete Bosch manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Bosch GWH 425 EF - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Bosch GWH 425 EF, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Bosch GWH 425 EF, that we can find in the current document
3. Tips how to use the basic functions of the device Bosch GWH 425 EF - which should help us in our first steps of using Bosch GWH 425 EF
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Bosch GWH 425 EF
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Bosch GWH 425 EF in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Bosch GWH 425 EF?

Use the form below

If you did not solve your problem by using a manual Bosch GWH 425 EF, ask a question using the form below. If a user had a similar problem with Bosch GWH 425 EF it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)