English dropdown-ico

Manual Poulan PR185H42STG

48 pages 1.72 mb
Download

Go to site of 48

Summary
  • Poulan PR185H42STG - page 1

    OWNER'S MANUAL MODEL: PR185H42STG LAWN TRACTOR A L W A Y S WEAR EYE PROTECTION DURING OPERATION WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. IMPORTANT MANUAL Do Not Throw Away 183113 Rev. 1 3.19.02 RD Printed in U.S.A. 02478 ...

  • Poulan PR185H42STG - page 2

    2 Safe Operation Practices for Ride-On Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. SAFETY RULES I. GENERAL OPERATION • Read, understand, and follow all instructions in the manual and on the machine ...

  • Poulan PR185H42STG - page 3

    3 Safe Operation Practices for Ride-On Mowers SAFETY RULES • Be sure the area is clear of other people before mowing. Stop machine if anyone enters the area. • Never carry passengers or children even with the blades off. • Do not mow in reverse unless absolutely necessary. Al- ways look down and behind before and while backing. • Never carr ...

  • Poulan PR185H42STG - page 4

    4 GASOLINE CAPACITY 2.0 GALLONS AND TYPE: UNLEADED REGULAR OIL TYPE (API-SF-SJ): SAE 30 (above 32°F) SAE 5W-30 (below 32°F) OIL CAPACITY: W/ FILTER 4.0 PINTS W/O FILTER 3.75 PINTS SPARK PLUG: CHAMPION RC12YC (GAP: .040") GROUND SPEED (MPH): Forward: 0-5.5 Reverse 0-2.4 TIRE PRESSURE: FRONT: 14 P SI REAR: 10 PSI CHARGING SYSTEM: 3 AMPS BATTER ...

  • Poulan PR185H42STG - page 5

    5 UNASSEMBLED PARTS (1) Large Flat Washer Steering Wheel Insert Steering Sleeve Steering Wheel (1) Knob (1) Washer 17/32 x 1-3/16 x 12 Gauge Seat (2) Mulch Blades (2) Keys Slope Sheet Steering Extension Shaft Steering Adapter (1) Oil Drain Tube (1) Hex Bolt 1/4-28 x 1-1/4 (1) Locknut 1/4-28 (1) Locknut 1/2-20 ...

  • Poulan PR185H42STG - page 6

    6 ASSEMBL Y T OOLS REQUIRED FOR ASSEMBL Y A socket wrench set will make assembly easier. Standard wrench sizes are listed. Utility knife Pliers (1) 3/4" wrenches Tire pressure gauge (2) 7/16" wrenches When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). T ...

  • Poulan PR185H42STG - page 7

    7 ASSEMBL Y TO ROLL TRACTOR OFF SKID (See Operation section, page 10, for location and function of controls) • Press lift lever plunger and raise attachment lift lever to its highest position. • Release parking brake by depressing clutch/brake pedal. • Place freewheel control in freewheeling position to disengage transmission (See “TO TRANS ...

  • Poulan PR185H42STG - page 8

    8 ASSEMBL Y CHECKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton. ✓ Battery is properly prepared and charged. (Mi ...

  • Poulan PR185H42STG - page 9

    9 OPERA TION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED REVERSE NEUTRAL HIGH LOW ATTACHMENT CLUTCH ENGAGED MOWER LIFT DAN ...

  • Poulan PR185H42STG - page 10

    10 OPERA TION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Our tractors conform to the safety standards of the American National Standard ...

  • Poulan PR185H42STG - page 11

    11 OPERA TION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses. • Never use choke ...

  • Poulan PR185H42STG - page 12

    12 OPERA TION TO OPERATE ON HILLS CAUTION: Do not drive up or down hills with slopes greater than 15° and do not drive across any slope. • Choose the slowest speed before starting up or down hills. • Avoid stopping or changing speed on hills. • If slowing is necessary, move throttle control lever to slower position. • If stopping is absolu ...

  • Poulan PR185H42STG - page 13

    13 OPERA TION TO START ENGINE (See Fig. 5) When starting the engine for the first time or if the engine has run out of fuel, it will take extra cranking time to move fuel from the tank to the engine. • Be sure freewheel control is in the transmission engaged position. • Sit on seat in operating position, depress clutch/brake pedal and set parki ...

  • Poulan PR185H42STG - page 14

    14 FIG. 10 MOWING TIPS • Mower should be properly leveled for best mowing performance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustments section of this manual. • The left hand side of mower should be used for trimming. • Drive so that clippings are discharged onto the area that has been cut. Have the cut area to the right of th ...

  • Poulan PR185H42STG - page 15

    15 MULCHING MOWING TIPS IMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE. • The special mulching blade will recut the grass clippings many times and reduce them in size so that as they fall onto the lawn they will disperse into the grass and not be noticed. Also, the mulched grass will bio ...

  • Poulan PR185H42STG - page 16

    16 CUST OMER RESPONSIBILITIES B E F O R E E A C H U S E T R A C T 0 R Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil (with oil filter) Replace Air Filter Paper Cartridge Replace Spark Plug Check Battery Level Check Tire Pressure Clean Battery and Terminals FILL IN DATES AS YOU COMPLETE REGU ...

  • Poulan PR185H42STG - page 17

    17 CUST OMER RESPONSIBILITIES BLADE REMOVAL (See Fig. 12) • Raise mower to highest position to allow access to blades. • Remove blade bolt, lock washer and flat washer secur- ing blade. • Install new or resharpened blade with trailing edge up towards deck as shown. IMPORTANT: TO ENSURE PROPER ASSEMBLY, CENTER HOLE IN BLADE MUST ALIGN WITH STA ...

  • Poulan PR185H42STG - page 18

    18 CUST OMER RESPONSIBILITIES V-BELTS Check V-belts for deterioration and wear after 100 hours of operation and replace if necessary. The belts are not adjustable. Replace belts if they begin to slip from wear. TRANSAXLE COOLING The transmission fan and cooling fins should be kept clean to assure proper cooling. Do not attempt to clean fan or trans ...

  • Poulan PR185H42STG - page 19

    19 CUST OMER RESPONSIBILITIES MUFFLER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or damage. SPARK PLUGS Replace spark plugs at the beginning of each mowing season or after every 100 hours of operation, whichever occurs first. Spark plug type and gap setting are shown in “PRODUCT SPEC ...

  • Poulan PR185H42STG - page 20

    20 SER VICE AND ADJUSTMENTS TRACT OR TO REMOVE MOWER (See Fig. 18) Mower will be easier to remove from the right side of tractor. • Place attachment clutch in “DISENGAGED” position. • Move attachment lift lever forward to lower mower to its lowest position. • Roll belt off engine pulley. • Remove small retainer spring, and lift clutch s ...

  • Poulan PR185H42STG - page 21

    21 SER VICE AND ADJUSTMENTS NUT "E" "D" "D" MANDREL FIG. 21 NUT "F" FRONT LINKS FIG. 22 FRONT-TO-BACK ADJUSTMENT (See Figs. 21 and 22) IMPORTANT: DECK MUST BE LEVEL SIDE-TO-SIDE. IF THE FOLLOWING FRONT-TO-BACK ADJUSTMENT IS NECESSARY, BE SURE TO ADJUST BOTH FRONT LINKS EQUALLY SO MOWER WILL STAY LEVEL SIDE-TO ...

  • Poulan PR185H42STG - page 22

    22 SER VICE AND ADJUSTMENTS TO ADJUST BRAKE (See Fig. 24) Your tractor is equipped with an adjustable brake system which is mounted on the side of the transaxle. If tractor requires more than six (6) feet stopping distance at high speed in highest gear on a level dry concrete or paved surface, then brake must be adjusted. • Depress clutch/brake p ...

  • Poulan PR185H42STG - page 23

    23 SER VICE AND ADJUSTMENTS TO REMOVE WHEEL FOR REPAIRS (See Fig. 27) • Block up axle securely. • Remove axle cover, retaining ring and washers to allow wheel removal (rear wheel contains a square key - Do not lose). • Repair tire and reassemble. • On rear wheels only: align grooves in rear wheel hub and axle. Insert square key. • Replace ...

  • Poulan PR185H42STG - page 24

    24 SER VICE AND ADJUSTMENTS FIG. 29 FIG. 30 TO REPLACE HEADLIGHT BULB • Raise hood. • Pull bulb holder out of the hole in the backside of the grill. • Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill. • Close hood. REPLACING BATTERY (See Figs. 29 and 30) CAUTION: Do not short battery termi ...

  • Poulan PR185H42STG - page 25

    25 ENGINE TO ADJUST THROTTLE CONTROL CABLE (See Fig. 32) The throttle control has been preset at the factory and adjustment should not be necessary. Check adjustment as described below before loosening cable. If adjustment is necessary, proceed as follows: • With engine not running, move throttle control lever to fast position. • Check that swi ...

  • Poulan PR185H42STG - page 26

    26 ST ORAGE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. CAUTION: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure. TRACT OR Remove mower from trac ...

  • Poulan PR185H42STG - page 27

    27 PROBLEM CAUSE CORRECTION TROUBLESHOOTING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly. 2. See “TO START ENGINE” in Operation section. 3. Engine flooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air filter. 5. Clean/replace air filter ...

  • Poulan PR185H42STG - page 28

    28 PROBLEM CAUSE CORRECTION TROUBLESHOOTING POINTS Engine continues to run 1. Faulty operator-safety presence control system. 1. Check wiring, switches and connections. If not when operator leaves seat corrected, contact an authorized service center/ with attachment clutch department. engaged Poor cut - uneven 1. Worn, bent or loose blade. 1. Repla ...

  • Poulan PR185H42STG - page 29

    29 BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RED BLACK ORANGE BLACK BROWN BLACK BLACK BLACK STARTER M SEAT SWITCH (NOT OCCUPIED) GROUNDING CONNECTOR ATT'MENT CLUTCH (CLUTCH OFF) CLUTCH / BRAKE (PEDAL UP) SOLENOID BLACK LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 ...

  • Poulan PR185H42STG - page 30

    30 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 ELECTRICAL 28 29 26 24 42 43 27 27 25 41 27 27 40 33 90 30 8 2 1 27 D . C . A M P E R E S 45 16 16 22 21 52 ...

  • Poulan PR185H42STG - page 31

    31 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 ELECTRICAL KEY P ART N O . N O . DESCRIPTION 1 144927 Battery 2 74760412 B o l t Hex Hd 1/4-20unc X 3/4 8 176689 B o x B attery Fender 1 6 176138 S w i t ch I nt er l oc k 2 1 175685 H arness Socket Light 2 2 4152J Bu l b , L i g ht # 1156 2 4 4799J Cable Battery 2 5 146147 Cable Batt ...

  • Poulan PR185H42STG - page 32

    32 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 CHASSIS 26 25 58 219 20 219 23 64 208 13 208 11 1 3 2 9 208 208 5 5 207 3 3 3 142 3 3 3 142 17 29 28 12 51 57 53 52 54 55 145 37 3 37 24 26 25 3 31 24 30 35 3 26 33 10 26 34 35 18 14 38 14 206 212 159 ...

  • Poulan PR185H42STG - page 33

    33 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 CHASSIS KEY P ART N O . N O . DESCRIPTION 1 174619 C hassis 2 176554 Drawbar 3 17060612 S crew 3/8-16 X .75 5 155272 B um per Hood/Dash 9 168337X012 Dash P/L 1 0 72140608 B o l t C a rriage 3/8-16 x 1 1 1 174996 Panel Dash Lh 1 2 145660 C l i p Ti nnerman 1 3 172106 Panel Dash Rh 1 4 ...

  • Poulan PR185H42STG - page 34

    34 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 DRIVE 66 29 28 32 30 52 32 59 38 61 41 53 35 55 36 62 35 36 22 39 34 16 1 77 77 30 52 56 64 65 212 63 116 70 57 96 26 25 19 24 26 26 76 78 75 74 27 26 15 37 51 27 51 48 151 202 49 47 50 120 81 156 166 165 82 168 163 14 164 21 8 10 83 159 161 198 158 162 169 150 84 16 199 16 250 71 200 ...

  • Poulan PR185H42STG - page 35

    35 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 DRIVE KEY P ART N O . N O . DESCRIPTION KEY P ART N O . N O . DESCRIPTION 1 - - - - - - Transaxle Hydro Gear 314-0510 (Order Parts From Transaxle Manufacturer) 8 165619 Rod Shift Hydro LT 1 0 76020416 P i n C ot t e r 1 / 8 x 1 C A D 1 4 10040400 Washer Lock Hvy Helical 1 5 74490544 B ...

  • Poulan PR185H42STG - page 36

    36 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 STEERING ASSEMBLY 5 5 4 3 43 6 43 8 10 40 32 11 8 6 87 46 46 8 6 87 29 88 71 17 43 91 2 1 41 42 37 36 37 38 12 39 44 51 54 33 35 34 68 67 67 67 13 65 68 15 15 15 29 29 82 ...

  • Poulan PR185H42STG - page 37

    37 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 STEERING ASSEMBLY KEY P AR T N O . N O . DESCRIPTION 1 180656 W heel Steering 2 172393 A x l e Asm Cast Iron LT 3 169840 S pindle Asm LH 4 169839 S pindle Asm RH 5 6266H B earing Race Thrust Harden 6 121748X W asher 25/32 X 1-5/8 X 16 Ga 8 12000029 R ing Klip #t5304-75 1 0 175121 Link ...

  • Poulan PR185H42STG - page 38

    38 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 SEAT ASSEMBLY 1 171683 Seat 2 140551 Bracket Pivot Seat 8 720 3 71110616 B o l t Fi n Hex 3/8-16unc X 1 4 19131610 W asher 13/32 X 1 X 10 Ga 5 145006 C lip Push-In 6 73800600 N u t H ex w / In s . 3/ 8 - 16 U n c 7 124181X S pring Seat Cprsn 2 250 Blk Zi 8 17000616 S c r e w 3 / 8 -1 ...

  • Poulan PR185H42STG - page 39

    39 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 DECALS NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm KE Y PART NO. N O. DESCRIPTION 6 2 1 5,8 4,10 3,9 11 7 WHEELS AND TIRES KEY P ART N O . N O . DESCRIPTION KEY P ART N O . N O . DESCRIPTION 10 3 16 9 1 59192 C a p V alve Tire 2 65139 S t e m Va l ve 3 170455 ...

  • Poulan PR185H42STG - page 40

    40 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 ENGINE 14 38 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 10 62 6 5 72 13 26 25 4 8 17 16 17 3 81 23 45 44 46 32 31 33 37 33 41 112 40 ...

  • Poulan PR185H42STG - page 41

    41 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 ENGINE KEY P AR T N O . N O . DESCRIPTION NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm 1 170771 Control, Throttle 2 17720408 S c r e w Hex Thd Cut 1/4-20 x 1/2 3 - - - - - - - Engine Briggs Model 407777 (Order Parts from Engine Mfg.) 4 149723 M u ffler, Asm. Tw ...

  • Poulan PR185H42STG - page 42

    42 15 14 13 11 10 9 8 16 68 37 30 31 32 33 146 148 145 150 45 144 147 147 142 149 142 49 50 51 54 52 53 55 56 34 1 46 44 21 24 25 26 27 2 28 29 23 21 21 21 18 18 20 2 48 59 19 4 3 5 6 21 40 143 36 40 37 40 159 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 MOWER DECK 152 151 153 154 157 158 67 153 156 155 113 117 116 118 119 114 115 ...

  • Poulan PR185H42STG - page 43

    43 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 MOWER DECK KEY P ART N O . N O . DESCRIPTION KEY P ART N O . NO. DESCRIPTION 1 165892X421 M o w e r D eck Assembly, 42" 2 72140506 B o l t 3 138017 Bracket Asm Fr. Sway Bar 3/42 4 165460X B r acket Asm Deck 42" Sway Bar 5 4939M R e t ai n e r S p ri n g 6 178024 B a r Sway D ...

  • Poulan PR185H42STG - page 44

    44 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 MOWER LIFT 36 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 23 24 25 27 28 29 30 50 26 37 41 40 38 12 11 31 32 31 32 19 19 13 13 13 13 49 ...

  • Poulan PR185H42STG - page 45

    45 TRACTOR - - MODEL NUMBER PR185H42STG PRODUCT NO. 954 56 67-82 MOWER LIFT 1 159460 W i r e Asm Inner/Sprg W/plunger LT 2 159471 Shaft Asm Lift RH w/Inf 3 105767X P i n G roove 1 500 Zinc 4 12000002 E R i n g #5133-62 5 19211621 W asher 21/32 X 1 X 21 Ga 6 120183X Bearing Nylon Blk 629 Id 7 125631X G ri p Handle 8 170770 Button Plunger 1 1 139865 ...

  • Poulan PR185H42STG - page 46

    46 LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materials and workmanship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, without charge for parts or labor incurred in replacin ...

  • Poulan PR185H42STG - page 47

    47 15 DEGREES MAX. FOLD ALONG DOTTED LINE THIS IS A 15 DEGREE SLOPE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees. Make turns gradually to preven ...

  • Poulan PR185H42STG - page 48

    Your POULAN PRO product has been expertly engineered and carefully manufactured to rigid quality standards. As with all mechanical products, some adjustments or part replacement may be necessary during the life of your unit. FOR SERVICE OR REPLACEMENT PARTS: 1. Consult your dealer/place of purchase. 2. Consult the yellow pages of your phone directo ...

Manufacturer Poulan Category Lawn Mower

Documents that we receive from a manufacturer of a Poulan PR185H42STG can be divided into several groups. They are, among others:
- Poulan technical drawings
- PR185H42STG manuals
- Poulan product data sheets
- information booklets
- or energy labels Poulan PR185H42STG
All of them are important, but the most important information from the point of view of use of the device are in the user manual Poulan PR185H42STG.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Poulan PR185H42STG, service manual, brief instructions and user manuals Poulan PR185H42STG. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Poulan PR185H42STG.

Similar manuals

A complete manual for the device Poulan PR185H42STG, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Poulan PR185H42STG by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Poulan PR185H42STG.

A complete Poulan manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Poulan PR185H42STG - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Poulan PR185H42STG, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Poulan PR185H42STG, that we can find in the current document
3. Tips how to use the basic functions of the device Poulan PR185H42STG - which should help us in our first steps of using Poulan PR185H42STG
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Poulan PR185H42STG
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Poulan PR185H42STG in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Poulan PR185H42STG?

Use the form below

If you did not solve your problem by using a manual Poulan PR185H42STG, ask a question using the form below. If a user had a similar problem with Poulan PR185H42STG it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)