English dropdown-ico

Manual Intel SC5000

56 pages 3.83 mb
Download

Go to site of 56

Summary
  • Intel SC5000 - page 1

    SC5000 Rack Kit Installation Guide Order Number: 7 49354-002 ...

  • Intel SC5000 - page 2

    Disclaimer Intel Corpora tion (Intel) m akes no warr anty of any kind with reg ard to this material, inc luding, but not limited to, the implied warranties of m erchantab ility and f itness for a particular purpose. Int el assum es no responsibi lity for any errors that may ap pear in this document. Int el makes no commitm ent to update nor to keep ...

  • Intel SC5000 - page 3

    iii Contents Safety Guidelines Server Prec auti ons ............................................................................................................... 5 Equi pment R ack P reca ution s ............................................................................................... 6 Rack Installat ion Procedures Kit C onten ts ......... ...

  • Intel SC5000 - page 4

    iv SC5000 Rack Kit Installa tion Guide ...

  • Intel SC5000 - page 5

    5 Safety Guidelines Before you re move a serve r cover, observe the se safety g uidelines : • Only technically qualified person nel should inte grate the server . • Turn off a ll periph eral devic es connected to the ser ver. • Turn off the server u sing the push-butt on on/off powe r switch on the fron t panel of t he serv er, and unplug the ...

  • Intel SC5000 - page 6

    6 SC5000 Rack Kit Installa tion Guide CAUTIONS E LECTROSTATIC DISCHARGE (ESD) AND ESD PROTECTION : ESD can damage disk d rives, add- in board s, and other components. This serve r can withstand nor mal leve ls of environm ental ESD whil e hot-sw apping SCSI hard disk dr ives. However, we r ecommend d oing all p rocedures i n this manual o nly at an ...

  • Intel SC5000 - page 7

    Safety Guide lines 7 O VERCURRENT PROTECTION : The server is de signed for an A C line voltage so urce with up to 2 0 ampere s of overcurrent p rotection. If the power syste m for the equ ipment rack is installed on a branch ci rcuit with more than 20 ampere s of protect ion, you mu st provide supplemental prot ection for the server. I f more than ...

  • Intel SC5000 - page 8

    8 SC5000 Rack Kit Installa tion Guide ...

  • Intel SC5000 - page 9

    9 Rack Installation Procedur es This manu al descri bes the proc edure to conv ert an SC5000 ch assis fro m the p edestal co nfigurat ion to the rack c onfigu ration. It supp lemen ts the Intel ® SC5000 Server Chassis Subassembly Pr oduct Guide (744708-003). In the fo llowing proc edures, chas sis direc tions (to p, botto m, left, right) re fer to ...

  • Intel SC5000 - page 10

    10 SC5000 Rack Kit Installa tion Guide Remove Feet 1. Place th e chassis on a workb ench so the feet han g over the s ide. 2. Remove th e four screw s (Figur e 1, A) that a ttach the rea r foot to the chassis and remove the foot. 3. Remove th e four screw s that ho ld the front foo t to the cha ssis and re move th e foot. OM09378 A Figure 1. Remo v ...

  • Intel SC5000 - page 11

    Rack Ins tallation Proced ures 11 Remove Top Cover 1. Loosen the two t humbscrews that atta ch the top co ver to the c hassis. 2. Slide th e cover backwa rd a short d istance, un til it s tops. 3. Pull the ent ire cover o utward, s traight awa y from th e chassis, to disengage the rows o f tabs from th e notches i n the to p and botto m edges o f t ...

  • Intel SC5000 - page 12

    12 SC5000 Rack Kit Installa tion Guide Remove 5 ¼-Inch Devices 1. Disconnec t the data a nd power cable s from th e device. 2. Remove and save the two screw s that hold the slide ra ils to the chassis. OM09381 A B C Figure 3 . Removing a 5 ¼ -inch Devi ce A. Power cable B. Data cable C. Slide rail ...

  • Intel SC5000 - page 13

    Rack Ins tallation Proced ures 13 3. Remove and save the two screw s that attach the slide rai ls to the device. OM09383 Figure 4. Removing Slide Rails ...

  • Intel SC5000 - page 14

    14 SC5000 Rack Kit Installa tion Guide Remove Door 1. Move the chas sis so the d oor hangs over the edg e of your workb ench. 2. Open the door. 3. Press th e plastic cl ip (Figu re 5, A) in tow ards the chassis. 4. Pull the hing e pin (F igure 5, B) out with one hand wh ile suppor ting the doo r with th e other. 5. Slide the door to the left to rem ...

  • Intel SC5000 - page 15

    Rack Ins tallation Proced ures 15 7. Remove and save the fou r screws at taching the hinge p late to the chassis. 8. Remove th e hinge p late. OM09380 Figure 6. Removing the Hinge Plate ...

  • Intel SC5000 - page 16

    16 SC5000 Rack Kit Installa tion Guide Remove Bezel 1. Press th e tab up (Figu re 7, A). 2. Slide the beze l to the right. 3. Remove th e bezel from the c hassis . OM09382 A Figure 7. Removing the Bezel A. Tab ...

  • Intel SC5000 - page 17

    Rack Ins tallation Proced ures 17 Remove EMI Covers 1. Remove and save the two screws that at tach the EMI covers to the chassis . 2. Remove all o f the EMI cove rs. There wi ll be one th in cover and up to three w ider cov ers. Do not remove a ny of the ha rd drive ca rriers. OM09376 A Figure 8. Remo ving t he EMI Co vers A. EMI covers ...

  • Intel SC5000 - page 18

    18 SC5000 Rack Kit Installa tion Guide Remove Right Side Cover 1. Remove and save the sc rew at the rear of the c hassis (Fi gure 9, A). 2. Pull up on the black c lip (Figure 9, B). 3. Remove and save the bla ck clip (F igure 9, C). 4. Slide th e cover backwa rds and rem ove it (Fig ure 9, D). OM09390 A C B D Figure 9. Removing the Right Side Cover ...

  • Intel SC5000 - page 19

    Rack Ins tallation Proced ures 19 Install Right Side Cover 1. Slide th e new cover in to position (Figur e 10, A). 2. Insert the black c lip (F igure 10, B). 3. Press the cl ip down (F igure 10, C ). 4. Insert and tighten the screw you removed ea rlier (F igure 10, D ). OM09391 D A B C Figure 10. Installing the Right Side Cover A. Slide the cov er ...

  • Intel SC5000 - page 20

    20 SC5000 Rack Kit Installa tion Guide Install 5 ¼ -Inch Devices into the Reorientation Bracket 1. Remove th e two screws th at hold the EMI shiel d in plac e. 2. Remove th e EMI sh ield. 3. Slide th e device into the b racket. 4. Insert and tigh ten the four screws removed when you removed the sl ide rails. OM09392 C A B D Figure 11. Installing 5 ...

  • Intel SC5000 - page 21

    Rack Ins tallation Proced ures 21 Install the 5 ¼ -Inch Reorientation Bracket 1. Slide th e bracket i nto the cha ssis. 2. Insert and tigh ten five screws. 3. Connect data an d power cable s to the dev ices. OM09393 A C B Figure 12. In stallin g the 5 ¼ -Inch Reorientation Bracket A. Screw B. Data cable C. Power cab le ...

  • Intel SC5000 - page 22

    22 SC5000 Rack Kit Installa tion Guide Install Bezel 1. Position the chassis i ntrusion sw itch lo ck. 2. Using a Ph ilips sc rewdriv er, rot ate the sw itch loc k ½ turn clo ckwise. OM09385 D A B C Figure 13. In stalling the Ch assis Int rusion Lock A. Philips s crewdriver B. Cha ssis i ntru sio n swit ch lock C. Direction of rotation D. Chassi s ...

  • Intel SC5000 - page 23

    Rack Ins tallation Proced ures 23 3. Position the bezel. Mak e sure a ll of the p lastic tabs are al igned with t heir holes. 4. Slide i t to the le ft. OM09384 A Figure 14. Installing t he Bezel A. Tab ...

  • Intel SC5000 - page 24

    24 SC5000 Rack Kit Installa tion Guide Install Screw Plate 1. Position the Screw Plate. 2. Insert and tighten the four screws you re moved when you re moved the doo r hinge p late. OM09394 A Figure 1 5. Installin g the S crew P late A. Screw ...

  • Intel SC5000 - page 25

    Rack Ins tallation Proced ures 25 Install Front Cover 1. For each 5 ¼ -i nch periphe ral, remov e the co rresponding plastic c over. 2. If you hav e a hot swap bay i nstalle d, remove t hat plastic cover. 3. Position the bezel b y sliding the tabs on t he top und er the beze l. 4. Tighten the thum bscrews. OM09395 Figure 16. Installing the Front C ...

  • Intel SC5000 - page 26

    26 SC5000 Rack Kit Installa tion Guide Install Top Cover 1. Place th e cover so th e tabs go in to the s lots on the server. The cover should b e flush aga inst the chassis. 2. Slid the cove r forwa rd until i t stops. 3. Tighten the tw o cap tive screw s into t he rear of the chassi s. OM09170 Figure 17. Installing the Top Cover ...

  • Intel SC5000 - page 27

    Rack Ins tallation Proced ures 27 Install Rails 1. Using two screws for each handle, attach the handles to the chassi s. OM09375 Figure 18. Installing the Handles 2. Fully extend the ra ils. 3. Remove th e smalle st rai l. 4. Position the rail 5. Insert and tigh ten four screws. B B B B A OM09377 Figure 19. At taching t he Rail to the Ch assis A. R ...

  • Intel SC5000 - page 28

    28 SC5000 Rack Kit Installa tion Guide OM09388 Figure 20. Rails Installed in a Rack ✏ NOTE Your rack may v ary fr om the il lustration. Re fer to your rack docum entation for informat ion specific to your rack 7. Hold the ch assis so th e rails on the chassis en gage the rails in your rack. You wi ll need someone to he lp you a t this po int. 8. ...

  • Intel SC5000 - page 29

    SC5000  b ] c Û + ...

  • Intel SC5000 - page 30

    Intel (Intel) Intel Inte l Intel Inte l ® 2000 Year 2000 Capable † Copyright  2 000, Intel C orporation. ...

  • Intel SC5000 - page 31

    iii   ] <í .................................................................................................................... 5 ................................................................................................................. 6  ] c ' N ........................................................................ ...

  • Intel SC5000 - page 32

    iv SC5000 ...

  • Intel SC5000 - page 33

    5 ] <í • • • • I/O • (ESD) á u < ¼ ã _ M :  38 85 45 100 ...

  • Intel SC5000 - page 34

    6 SC5000 ¼ ã (ESD ) ESD ESD SCSI ESD ESD — ESD ESD CMOS  Û  ¼ ã _ M :  113 250 ...

  • Intel SC5000 - page 35

    7 20 20 350 1+1 12 ¼ ã 5 ° C (41 ° F) 35 ° C (95 ° F) 2000 Btu ...

  • Intel SC5000 - page 36

    8 SC5000 ...

  • Intel SC5000 - page 37

    9  ] c ' N SC5000 Int e l ® SC5000 (744708- 003) ESD ¹ K Ù Y  • • • • • • • 5 ¼ ...

  • Intel SC5000 - page 38

    10 SC5000  & î { 1. 2. 1 A 3. OM09378 A 1. A. ...

  • Intel SC5000 - page 39

    11  & J ª 1. 2. 3. OM09379 2. ...

  • Intel SC5000 - page 40

    12 SC5000  & 5 ¼ Å Ì  Û 1. 2. OM09381 A B C 3. 5 ¼ A. B. C. ...

  • Intel SC5000 - page 41

    13 3. OM09383 4. ...

  • Intel SC5000 - page 42

    14 SC5000  & ! ª 1. 2. 3. 5 A 4. 5 B 5. 6. OM09389 B A 5. A. B. ...

  • Intel SC5000 - page 43

    15 7. 8. OM09380 6. ...

  • Intel SC5000 - page 44

    16 SC5000  & õ 5 1. 7 A 2. 3. OM09382 A 7. A. ...

  • Intel SC5000 - page 45

    17  & EMI õ S 1. EMI 2. EMI OM09376 A 8. EMI A. EMI ...

  • Intel SC5000 - page 46

    18 SC5000  & Ç { ª 1. 9 A 2. 9 B 3. 9 C 4. 9 D OM09390 A C B D 9. A. B. C. D. ...

  • Intel SC5000 - page 47

    19 ] c Ç { ª 1. 10 A 2. 10 B 3. 10 C 4. 10 D OM09391 D A B C 10. A. B. C. D. ...

  • Intel SC5000 - page 48

    20 SC5000 Ú 5 ¼ Å Ì  Û c 9a n !   1. EMI 2. EMI 3. 4. OM09392 C A B D 11. 5 ¼ A. 5 ¼ B. C. EMI D. EMI ...

  • Intel SC5000 - page 49

    21 ] c 5 ¼ Å Ì a n !   1. 2. 3. OM09393 A C B 12. 5 ¼ A. B. C. ...

  • Intel SC5000 - page 50

    22 SC5000 ] c õ 5 1. 2. OM09385 D A B C 13. A. B. C. D. ...

  • Intel SC5000 - page 51

    23 3. 4. OM09384 A 14. A. ...

  • Intel SC5000 - page 52

    24 SC5000 ] c S - 1. 2. OM09394 A 15. A. ...

  • Intel SC5000 - page 53

    25 ] c ! ª 1. 5 ¼ 2. 3. 4. OM09395 16. ...

  • Intel SC5000 - page 54

    26 SC5000 ] c J ª 1. 2. 3. OM09170 17. ...

  • Intel SC5000 - page 55

    27 ] c Ð < 1. OM09375 18. 2. 3. 4. 5. B B B B A OM09377 19. A. B. 6. ...

  • Intel SC5000 - page 56

    28 SC5000 OM09388 20. ✏ ¼  7. 8. A OM09374 21. ...

Manufacturer Intel Category Recording Equipment

Documents that we receive from a manufacturer of a Intel SC5000 can be divided into several groups. They are, among others:
- Intel technical drawings
- SC5000 manuals
- Intel product data sheets
- information booklets
- or energy labels Intel SC5000
All of them are important, but the most important information from the point of view of use of the device are in the user manual Intel SC5000.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Intel SC5000, service manual, brief instructions and user manuals Intel SC5000. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Intel SC5000.

Similar manuals

A complete manual for the device Intel SC5000, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Intel SC5000 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Intel SC5000.

A complete Intel manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Intel SC5000 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Intel SC5000, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Intel SC5000, that we can find in the current document
3. Tips how to use the basic functions of the device Intel SC5000 - which should help us in our first steps of using Intel SC5000
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Intel SC5000
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Intel SC5000 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Intel SC5000?

Use the form below

If you did not solve your problem by using a manual Intel SC5000, ask a question using the form below. If a user had a similar problem with Intel SC5000 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)