English dropdown-ico

Manual Raypak 5100

13 pages 0.24 mb
Download

Go to site of 13

Summary
  • Raypak 5100 - page 1

    Raypak ® Swimming Pool Heat Pump OWNER’S MANUAL This manual should be maint ained in legible condition and kep t adjacent to the heat pump or in a safe p lace for future use. For additional information call: (800) 260-2758 Manual Effective Da te: 1 1/15/2004 De ve lop ed an d p ri nt ed i n U .S .A . Part No. 00-0 2104A 5100 Models 6100 The inst ...

  • Raypak 5100 - page 2

    i PRODUCT SAFETY SIGNS AND LABE LS This manual, as well as the pool/spa heat pum p itself, contains ANSI-approved product safety signs and labels. Please read these signs and labe ls, as they convey important safety information about hazards that may be potentially present in and around the heat pump. They are classified according to relative serio ...

  • Raypak 5100 - page 3

    ii Swimming Pool Heat Pump OWNER’S MANUAL - Models 5100 and 6100 CONTENTS Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 I. Installation Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 II. Electr ...

  • Raypak 5100 - page 4

    1 Intr oduction This pool heat pump is an electromec hanical machine that incorporates a pressurized refrigerant gas in a sealed sys tem. ONL Y trained and qualified service personnel are authorized to install or service this eq uipment. Without proper training a nd knowledge of such equipment, any attempt to inst all or service the unit could resu ...

  • Raypak 5100 - page 5

    2 Situate the pool heat pump caref ully to minimize installati on costs while providing maximum efficiency of operation, and to allow adequate service access, as follows: • For unrestricted air intake and service access, pos ition each side of the un it at least 1 ft from walls, pipes and other obstructions. • The unit is designed for outdoor i ...

  • Raypak 5100 - page 6

    3 III. W ater Connections The heat pump inlet and outlet connection s are NOT interchangeable. They must be connected as inst ructed below . 1. Connect the heat pump in the return water line between the filter and the pool. See page 10, Plumbing Diag rams. 2. Connect the filter outlet to the fitting marked WA T E R I N at the bottom side of the uni ...

  • Raypak 5100 - page 7

    4 NOTE: The heat pump will not run whe n the Remote position is selected and there is no remote co ntrol system attached. Defrost Switch : Prevents heat pump operation if am bient air temperature falls below a predetermined safe minimum (appr oximately 42-48° F , based on hum idity). The compressor will shut OFF but the fan will continue to run. D ...

  • Raypak 5100 - page 8

    5 NOTE: The heat pump wi ll be OFF when the Remote position is selected on th e P ool/Sp a selector switch and there is no remote con trol system att ached. 4. Allow the heat pump to operate for a few minutes to stabilize operating pressure s and to allow various component temperatures to normalize. 5. V erify that the discharge air temperature is ...

  • Raypak 5100 - page 9

    6 VII. Fr eeze Protection If the heat pump is installed in a location subjec t to freezing conditions, it is important to protect the water circuit from fr eezing, just as should be done for the pump and filter . System Drain-Down 1. T urn the heat pump circuit break er or disconnect switch to OFF . 2. From the control panel, tu rn the contr ol swi ...

  • Raypak 5100 - page 10

    7 C. Unplug Condensation Drain Holes - The heat pump extracts humidity from the air as it passes through the coil, similar to the way a cold drink outside “sweats” on a hot day . This con- densation drains from the bottom of the unit. 1. Routinely check to be sure the condensation dr ain holes in the base of the unit are not plugged with dirt o ...

  • Raypak 5100 - page 11

    8 B. UNIT IS NOT RUNNING • Is the control panel Power lamp ON? If not, the cir cuit brea ker may be shut OFF or tripped. Reset the breaker by switching it OFF , then back ON. V erify that the br eaker is set and operating pr operly befor e calling for service. • Are the thermostat setting and the Pool/Spa se tting correct? V erify th at the tem ...

  • Raypak 5100 - page 12

    9 Plumbing Diagrams For systems with p umps of less than 2 HP (under 80 gpm), no external bypass is required. Connections ar e 2-inch unio ns. Plumb the h eat pump after the filter and before any chlorinators. Wa t er I n (from pool) Wa t er O ut (to pool) Filter For systems with pum ps of 2 HP or greate r (ove r 80 gpm ) , an ex te rn al bypass mu ...

  • Raypak 5100 - page 13

    10 ...

Manufacturer Raypak Category Heat Pump

Documents that we receive from a manufacturer of a Raypak 5100 can be divided into several groups. They are, among others:
- Raypak technical drawings
- 5100 manuals
- Raypak product data sheets
- information booklets
- or energy labels Raypak 5100
All of them are important, but the most important information from the point of view of use of the device are in the user manual Raypak 5100.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Raypak 5100, service manual, brief instructions and user manuals Raypak 5100. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Raypak 5100.

Similar manuals

A complete manual for the device Raypak 5100, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Raypak 5100 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Raypak 5100.

A complete Raypak manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Raypak 5100 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Raypak 5100, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Raypak 5100, that we can find in the current document
3. Tips how to use the basic functions of the device Raypak 5100 - which should help us in our first steps of using Raypak 5100
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Raypak 5100
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Raypak 5100 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Raypak 5100?

Use the form below

If you did not solve your problem by using a manual Raypak 5100, ask a question using the form below. If a user had a similar problem with Raypak 5100 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)