English dropdown-ico

Manual Hearth and Home Technologies Dakota 42H

36 pages 2.38 mb
Download

Go to site of 36

Summary
  • Hearth and Home Technologies Dakota 42H - page 1

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 1 Owner ’ s Manual Installation and Operation Models: Dakota 42 Dakota 42H DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation. • Read, understand ...

  • Hearth and Home Technologies Dakota 42H - page 2

    2 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 Read this manual before installing or operating this appliance. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Heat-N-Glo LifeStyle Collection gas appliance—an elegant and clean alternative to wood burning appliances ...

  • Hearth and Home Technologies Dakota 42H - page 3

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certifi cation . . . . . . . . . . . . . . . . . . . . . . . . . 4 B. Glass Specifi cations . . . . . . . . . . . . . . . . . . . . . . . . . . 4 C. BTU Specifi cations . . . . . . . . . . . . . . . ...

  • Hearth and Home Technologies Dakota 42H - page 4

    4 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 1 Listing and Code Appro vals A. Appliance Certifi cation This product is listed to ANSI standards for “V ented Gas Fireplaces” and applicable sections of “Gas Burning Heating Appliances for Manufactured Homes and Recreational V ehi- cles”, and “Gas F ...

  • Hearth and Home Technologies Dakota 42H - page 5

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 5 A. Design and Installation Considerations Check building codes prior to installation. • Installation MUST comply with local, regional, state and national codes and regulations. • Consult insurance carrier , local building, fire offi cials or authorities hav ...

  • Hearth and Home Technologies Dakota 42H - page 6

    6 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 C D F F B A G E Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. Note: • Illustrations refl ect typical installations and are FOR DESIGN PURPOSES ONL Y . • Illustrations/diagrams are ...

  • Hearth and Home Technologies Dakota 42H - page 7

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 7 Free Standing Installation COMBUSTIBLE STRUCTURE Minimum Clearance * * This appliance can be installed a minimum of 6 in. (152 mm) from a combustible structure unless the structure is vinyl which requires a minimum clearance of 48 in. (1219 mm) 84 in. (2134 mm) ...

  • Hearth and Home Technologies Dakota 42H - page 8

    8 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 FP = FIREPLACE OPENING X = AIR SUPP L Y INLE T = AREA WHERE FIREPLACE IS NOT PERMITTED O N P R Q FP (See Note 2) ___________________________________________________________________________ _________________________________________________________________________ ...

  • Hearth and Home Technologies Dakota 42H - page 9

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 9 5 Appliance Pre paration Sharp Edges • Wear protective gloves and safety glasses during installation. CAUTION A. Remove Logs, Ember Bed and Shipping Cover Open the doors by sliding the handles toward the outside edges of the doors (see Figure 5.1) Remove the e ...

  • Hearth and Home Technologies Dakota 42H - page 10

    10 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 A. Fuel Conversion Before making gas connections ensure appliance being in- stalled is compatible with the available gas type. Any natural or propane gas conversions necessary to meet the appliance and locality needs must be made by a quali- fi ed technician u ...

  • Hearth and Home Technologies Dakota 42H - page 11

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 1 1 W ARNING Fire Risk Explosion Risk • Gas build-up during line purge may ignite. • Purge should be performed by qualifi ed technician. • Ensure adequate ventilation. • Ensure there are no ignition sources such as sparks or open fl ames. W ARNING CHECK ...

  • Hearth and Home Technologies Dakota 42H - page 12

    12 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 E. V alve Access Figure 6.1 Loosen Refractory Retaining Strip Figure 6.2 Lift Out Doors Figure 6.3 Remove V alve Access Panel Figure 6.4 Remove Exterior V alve Access Panel Figure 6.5 Connect Manometer • The gas valve can be accessed behind the cement refract ...

  • Hearth and Home Technologies Dakota 42H - page 13

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 13 Batter y polarity must be c or rect or module damage will occur . CAUTION Note: This applianc e must be elect ric ally wired and g r o u n d e d i n a c c o r d a n c e w i t h l o c a l c o d e s o r, i n t h e a b s e n c e of local codes, with National Elect ...

  • Hearth and Home Technologies Dakota 42H - page 14

    14 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 Fire Risk Do NOT obstruct air inlet or outlet grilles. Do NOT modify grilles. • Modifying or covering grilles could cause temperature rise and fi re hazard. Finishing materials must not interfere with: • Air fl ow through grilles or louvers. • Operation ...

  • Hearth and Home Technologies Dakota 42H - page 15

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 15 A. Remove the Shipping Materials Remove shipping materials from inside or underneath the fi rebox. B. Clean the Appliance Clean/vacuum any sawdust that may have accumulated in- side the fi rebox or underneath in the control cavity . C. Accessories Install app ...

  • Hearth and Home Technologies Dakota 42H - page 16

    16 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 Figure 9.3 Rear Log Figure 9.4 Front Right Log Figure 9.6 Left Center Log Figure 9.5 Front Left Log Figure 9.7 Right Center Log E. Positioning the Logs • Place rear log on the grate against the appliance back wall. • Place front right log on the grate again ...

  • Hearth and Home Technologies Dakota 42H - page 17

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 17 Handle glass with care. • Inspect the gasket to ensure it is undamaged. • Inspect the glass for cracks, chips or scratches. • Do NOT strike, slam or scratch glass. • Do NOT operate appliance with glass door removed, cracked, broken or scratched. • Rep ...

  • Hearth and Home Technologies Dakota 42H - page 18

    18 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 Fire Risk Burn Risk HOT! DO NOT TOUCH. SEVERE BURNS MA Y RESUL T . CLOTHING IGNITION MA Y RESUL T Glass and other surfaces are hot during operation and cool down. W ARNING • Keep children away . • CAREFULL Y SUPER VISE children in same room as appliance. ? ...

  • Hearth and Home Technologies Dakota 42H - page 19

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 19 B. Lighting the Appliance Intellifi re Ignition Final Inspection by _________________________________ 1. T urn off wall switch. 2. This appliance is equipped with an igni- tion device which automatically lights the burner . Do not try to light the burner by ha ...

  • Hearth and Home Technologies Dakota 42H - page 20

    20 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 Note: This appliance should be r un three to four hours on the initial star t-up. T ur n it of f and let it cool c ompletely . Remov e and clean t he glass. Replace the glas s and run t h e a p p l i a n c e f o r a n a d d i t i o n a l 12 h o u r s . T h i s ...

  • Hearth and Home Technologies Dakota 42H - page 21

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 21 With proper installation, operation and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualifi ed service person in the diagnosis of a problem and the correcti ...

  • Hearth and Home Technologies Dakota 42H - page 22

    22 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 Although the frequency of appliance servicing and maintenance will depend on use and the type of installation, a qualifi ed service technician should perform an appliance check-up at the beginning of each heating season. Fire Risk Explosion Risk Inspect extern ...

  • Hearth and Home Technologies Dakota 42H - page 23

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 23 A. V alve Service and Replacement Figure 12.2 Loosen Refractory Retaining Strip Retaining Strip Figure 12.3 Lift Out Doors Figure 12.4 Remove V alve Access Panel Figure 12.56 Remove Exterior Valve Access Panel Figure 12.6 T urn off Gas V alve Figure 12.1 T ools ...

  • Hearth and Home Technologies Dakota 42H - page 24

    24 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 Figure 12.7 Remove V alve from V alve Bracket Orifice T ube Pilot T ube Figure 12.8 Disconnect Pilot and Orifi ce T ubes • Remove the two screws securing the valve to the valve bracket. • Disconnect the pilot and orifi ce tubes using a 7/16 in. and a 5/8 ...

  • Hearth and Home Technologies Dakota 42H - page 25

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 25 Inspect Maintenance T asks Doors, surrounds and fronts 1. Access condition of screen and replace as necessary . Recommend addition of screen if one is not present. 2. Inspect for scratches, dents or other damage and repair as necessary . 3. V erify no obstructi ...

  • Hearth and Home Technologies Dakota 42H - page 26

    26 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 A. Appliance Dimension Diagram Dimensions are actual appliance dimensions. Use for reference only . For framing dimensions and clearances refer to Sec- tion 3. Figure 13.1 Appliance Dimensions 1 3 13 Refe re nc e M a te ri al s 48 in. (1219 mm) 42 in. (1067 mm) ...

  • Hearth and Home Technologies Dakota 42H - page 27

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 27 This page intentionally left blank. ...

  • Hearth and Home Technologies Dakota 42H - page 28

    28 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 B. Service Parts List Exploded Parts Diagram DAKOT A42 Service Parts DAKOT A Beginning Manufacturing Date: 1/19/04 Ending Manufacturing Date: Active 27 23 25 29 31 18 19 20 6 5 4 17 16 7 1 11 15 14 29 11 13 11 12 12 26 22 24 28 30 30 32 33 9 (Left) & 8 (Rig ...

  • Hearth and Home Technologies Dakota 42H - page 29

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 29 Service Parts List DAKOT A42 Service Parts DAKOT A Beginning Manufacturing Date: 1/19/04 Ending Manufacturing Date: Active # Description of Part DAKOT A42 DAKOT A42H DAKOT A42L DAKOT A42LH Qty . 1 Door Stop - Bottom 4036-109 4036-109 4036-109 4036-109 1 2 Door ...

  • Hearth and Home Technologies Dakota 42H - page 30

    30 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 Exploded Parts Diagram DAKOT A42 Service Parts DAKOT A Beginning Manufacturing Date: 1/19/04 Ending Manufacturing Date: Active 3 6 4 13 15 12 16 14 1 7 9 11 8 10 5 2 (#22) 60 in. Flex Line Assembly 24 23 25 ...

  • Hearth and Home Technologies Dakota 42H - page 31

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 31 Service Parts List DAKOT A42 Service Parts DAKOT A Beginning Manufacturing Date: 1/19/04 Ending Manufacturing Date: Active # Description of Part DAKOT A42 DAKOT A42H DAKOT A42L DAKOT A42LH Qty . V alve Assembly 4036-01 1 4036-01 1 4036-012 4036-012 1 ON/OFF V a ...

  • Hearth and Home Technologies Dakota 42H - page 32

    32 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 This page intentionally left blank. ...

  • Hearth and Home Technologies Dakota 42H - page 33

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 33 This page intentionally left blank. ...

  • Hearth and Home Technologies Dakota 42H - page 34

    34 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 This page intentionally left blank. ...

  • Hearth and Home Technologies Dakota 42H - page 35

    Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 35 Hearth & Home T echnologies Inc. 20802 Kensington Blvd. Lakeville, MN 55044 www .fireplaces.com C. W arranty W ARRANTY FOR HEA T -N-GLO FIREPLACES The limited warranty will not become effective until you have mailed the completed warranty card to: Hearth &a ...

  • Hearth and Home Technologies Dakota 42H - page 36

    36 Heat-N-Glo Lifestyle Collection • Dakota 42/Dakota 42H • 4036-905 Rev I • 10/05 D. Contact Information Hearth & Home T echnologies Inc. 20802 Kensington Blvd. Lakeville, MN 55044 www .fireplaces.com Please contact your Heat-N-Glo LifeStyle Collection dealer with any questions or concerns. For the number of your nearest Heat-N-Glo LifeS ...

Manufacturer Hearth and Home Technologies Category Indoor Fireplace

Documents that we receive from a manufacturer of a Hearth and Home Technologies Dakota 42H can be divided into several groups. They are, among others:
- Hearth and Home Technologies technical drawings
- Dakota 42H manuals
- Hearth and Home Technologies product data sheets
- information booklets
- or energy labels Hearth and Home Technologies Dakota 42H
All of them are important, but the most important information from the point of view of use of the device are in the user manual Hearth and Home Technologies Dakota 42H.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Hearth and Home Technologies Dakota 42H, service manual, brief instructions and user manuals Hearth and Home Technologies Dakota 42H. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Hearth and Home Technologies Dakota 42H.

Similar manuals

A complete manual for the device Hearth and Home Technologies Dakota 42H, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Hearth and Home Technologies Dakota 42H by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Hearth and Home Technologies Dakota 42H.

A complete Hearth and Home Technologies manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Hearth and Home Technologies Dakota 42H - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Hearth and Home Technologies Dakota 42H, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Hearth and Home Technologies Dakota 42H, that we can find in the current document
3. Tips how to use the basic functions of the device Hearth and Home Technologies Dakota 42H - which should help us in our first steps of using Hearth and Home Technologies Dakota 42H
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Hearth and Home Technologies Dakota 42H
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Hearth and Home Technologies Dakota 42H in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Hearth and Home Technologies Dakota 42H?

Use the form below

If you did not solve your problem by using a manual Hearth and Home Technologies Dakota 42H, ask a question using the form below. If a user had a similar problem with Hearth and Home Technologies Dakota 42H it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)