English dropdown-ico

Manual Poulan 196692

30 pages 0.82 mb
Download

Go to site of 30

Summary
  • Poulan 196692 - page 1

    OPERA T OR'S MANU AL MODEL: XT24H42YT LA WN TRA CT OR AL W A YS WEAR EYE PR O TECTION DURING OPERA TION Visit our website: www .poulan-pro.com W ARNING: Read this Man u al and f ollow all W arnings and Saf ety Instructions. F ail ure to do so can re sult in serious in ju ry . IMPOR T ANT MANU AL Do Not Thr ow A wa y 196692 01.26.05 TR Printed ...

  • Poulan 196692 - page 2

    2 I. GENERAL OPERA TION • Read, understand, and f ollow all instructions on the machine and in the manual bef ore star ting. • Do not put hands or f eet near rotating par ts or under the machine. K eep clear of the discharge opening at all times. • Only allow responsib le adults, who are f amiliar with the in str uc tions, to oper ate the mac ...

  • Poulan 196692 - page 3

    3 • Be sure the area is clear of bystanders bef ore operat- ing. Stop machine if anyone enters the area. • Ne v er carry passengers. • Do not mow in re v erse unless absolutely necessary . Al ways look do wn and behind bef ore and while bac k- ing. • Ne ver carr y children, e v en with the blades shut off . They ma y f all off and be seriou ...

  • Poulan 196692 - page 4

    4 PR ODUCT SPECIFICA TIONS Gasoline Capacity 3.5 Gallons and T ype: Unleaded Regular Oil T ype (API-SG-SL): SAE 30 (abov e 32°F) SAE 5W-30 (belo w 32°F) Oil Capacity: W/Filter : 4.0 Pints W/o Filter: 3.75 Pints Spark Plug: Champion QC12YC (Gap: .040") Ground Speed (MPH): F orward: 5.5 Rev erse: 2.4 Tire Pressure: Front: 14 PSI Rear : 10 PSI ...

  • Poulan 196692 - page 5

    5 UNASSEMBLED P AR TS Steering Wheel Steering Wheel Insert (1) Large Flat Washer Steering Wheel Adapter Seat (2) Keys Slope Sheet Key (1) Oil Drain Tube (1) Knob (1) Washer 17/32 x 1-3/16 x 12 Gauge Steering Sleeve (1) Hex Bolt 1/4-28 x 1-1/4 (1) Hex nut 1/2-20 ...

  • Poulan 196692 - page 6

    6 ASSEMBL Y T OOLS REQUIRED FOR ASSEMBL Y A sock et wrench set will mak e assemb ly easier . Stan dard wrench sizes are listed. (1) 3/4" wrench Pliers (1) 9/16" wrench Tire pressure gauge Utility knif e When right or left hand is mentioned in this man ual, it means when you are in the oper ating po si tion (seated be hind the steer ing wh ...

  • Poulan 196692 - page 7

    7 ASSEMBL Y NO TE: Y ou ma y no w roll or drive y our tractor off the skid. F ollow the ap pro pri ate instruction below to remo v e the tractor from the skid . T O ROLL TRA CT OR OFF SKID (See Op- er a tion section for location and function of con tr ols) • Press lift lev er plunger and r aise attachment lift le v er to its highest po si tion. ? ...

  • Poulan 196692 - page 8

    8 CHECK TIRE PRESSURE The tires on your tr actor were o v erinfl ated at the f actory f or shipping pur poses. Correct tire pressure is impor tant f or best cutting perf ormance. • Reduce tire pressure to PSI shown in “PR ODUCT SPEC I FI CA TIONS” section of this manual. CHECK DECK LEVELNESS F or best cutting results, mo wer housing should b ...

  • Poulan 196692 - page 9

    9 OPERA TION These symbols ma y appear on your tr actor or in literature supplied with the product. Learn and understand their mean- ing. DANGER, KEEP HANDS AND FEET AWAY FREE WHEEL (Automatic Models only) OVER TEMP LIGHT KEEP AREA CLEAR SLOPE HAZARDS 15 15 (SEE SAFETY RULES SECTION) BATTERY REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSU ...

  • Poulan 196692 - page 10

    10 02884 OPERA TION KNO W Y OUR TRA CT OR READ THIS O WNER'S MANU AL AND SAFETY R ULES BEFORE OPERA TING Y OUR TRA CT OR Compare the illustrations with y our tractor to f amiliarize y ourself with the locations of v arious controls and ad just ments . Sav e this man ual f or future ref erence . Our tractors conf orm to the safety standards of ...

  • Poulan 196692 - page 11

    11 OPERA TION The operation of any tractor can result in f oreign objects thr own into the e yes, which can result in severe e ye dam age. Al wa ys wear safety glass es or eye shields while op- erating your tractor or per fo r m ing any adjustments or repair s. W e rec om mend a wide vision safety mask o ver spectacles or stan dard saf ety glasses. ...

  • Poulan 196692 - page 12

    12 OPERA TION T O OPERA TE ON HILLS W ARNING: Do not drive up or down hills with slopes greater than 15° and do not drive across an y slope. • Choose the slowest speed bef ore star ting up or down hills. 0 2806 A TT A CHMENT LIFT LEVER HIGH PO SI TION LO W POSITION DEFLECT OR SHIELD FIG. 7 FIG. 6 REVERSE OPERA TION SYSTEM (R OS) Y our tractor is ...

  • Poulan 196692 - page 13

    13 ADD GASOLINE • Fill fuel tank to bottom of fi ller neck. Do not ov erfi ll. Use fresh, clean, regular un lead ed gasoline with a minimum of 87 octane. (Use of leaded gasoline will increase carbon and lead o xide deposits and reduce valv e life). Do not mix oil with gasoline. Purchase fuel in quan ti ties that can be used within 30 da ys to a ...

  • Poulan 196692 - page 14

    14 FIG. 9 MO WING TIPS • Mow er should be proper ly lev eled f or best mowing per- f ormance. See “T O LEVEL MOWER HOUSING” in the Ser vice and Adjustments section of this manual. • The left hand side of mower should be used f or trim- ming. • Drive so that clippings are discharged onto the area that has been cut. Hav e the cut area to th ...

  • Poulan 196692 - page 15

    15 MAINTENANCE LUBRICA TION CHART ➀ FRONT WHEEL BEARING ZERK ➀ FRONT WHEEL BEARING ZERK ➁ ENGINE ➀ SPINDLE ZERK ➀ SPINDLE ZERK ➀ GENERAL PURPOSE GREASE ➁ REFER T O MAINTENANCE “ENGINE” SECTION IMPORT ANT: DO NO T OIL OR GREASE THE PIVO T POINTS WHICH HA VE SPECIAL NYLON BEARINGS. VISCOUS LU BRI CANTS WILL A TTRACT DUST AND DIR T T ...

  • Poulan 196692 - page 16

    16 MAINTENANCE BLADE REMO V AL (See Fig. 10) • Raise mower to highest position to allow access to blades . • Remov e blade bolt, lock washer and fl at washer se cur ing blade . • Install new or resharpened blade with trailing edge up tow ards deck as sho wn. IMPORT ANT : T O ENSURE PROPER ASSEMBL Y , CENTER HOLE IN BLADE MUST ALIGN WITH ST A ...

  • Poulan 196692 - page 17

    17 MAINTENANCE V- B E LT S Check V -belts f or deterioration and wear after 100 hours of operation and replace if necessary . The belts are not ad just able . Re place belts if the y begin to slip from wear . TRANSAXLE COOLING The transmission f an and cooling fi ns should be kept clean to assure proper cooling. Do not attempt to clean f an or tra ...

  • Poulan 196692 - page 18

    18 MAINTENANCE MUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could create a fi re hazard and/or dam- age. SP ARK PLUGS Replace spark plugs at the beginning of each mowing season or after e v er y 100 hours of operation, whiche v er occurs fi rst. Spark plug type and gap setting are shown in “PROD UCT SPEC ...

  • Poulan 196692 - page 19

    19 SER VICE AND ADJUSTMENTS FIG. 15 TRA CT OR W ARNING: T O A V OID SERIOUS INJUR Y , BEFORE PERFORMING ANY SER VICE OR AD JUST - MENTS: • Depress c lutch/brake pedal full y and set parking brake. • Place motion contr ol lever in neutral (N) position. • Place attachment c lutch in “DISENGA GED” position. • T urn ignition key to “STOP? ...

  • Poulan 196692 - page 20

    20 FIG. 20 T O REPLACE MO WER BLADE DRIVE BEL T (See Fig. 20) The mow er blade driv e belt ma y be replaced without tools. P ark the tractor on le v el surf ace . Engage parking brake . BEL T REMO V AL - • Remove mo wer from tractor (See “T O REMO VE MO W ER” in this section of this man ual). • W ork belt off both mandrel pulleys and idler ...

  • Poulan 196692 - page 21

    21 SER VICE AND ADJUSTMENTS FIG. 21 FIG. 22 01513 WITH P ARKING BRAKE “ENGAGED” JAM NUT DO NO T TOUCH THIS NUT . IF FURTHER BRAKE AD JUST MENT IS NECESSAR Y CON- T A CT Y OUR NEAREST AUTHORIZED SER VICE CENTER/DEP ARTMENT OPERA TING ARM NUT “A” T O CHECK AND ADJUST BRAKE (See Fig. 21) Y our tractor is equipped with an ad just ab le brak e s ...

  • Poulan 196692 - page 22

    22 SER VICE AND ADJUSTMENTS T O REMO VE WHEEL FOR REP AIRS (See Fig. 24) • Block up axle securely . • Remove axle co v er , retaining r ing and washers to allow wheel remov al (rear wheel contains a square k e y - Do not lose). • Repair tire and reassemble . • On rear wheels only: align groo v es in rear wheel hub and axle. Inser t square k ...

  • Poulan 196692 - page 23

    23 SER VICE AND ADJUSTMENTS FIG. 26 T O REMO VE HOOD AND GRILL ASSEMBL Y (See Fig. 27) • Raise hood. • Unsnap headlight wire connector . • Stand in front of tractor . Gr asp hood at sides, tilt to ward engine and lift off of tractor . • T o replace, re v erse abov e procedure . T O REPLACE HEADLIGHT B ULB • Raise hood. • Pull bulb holde ...

  • Poulan 196692 - page 24

    24 ST ORA GE Immediately prepare your tr actor f or storage at the end of the season or if the tractor will not be used f or 30 da ys or more. W ARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reac h an open fl ame or spark. Allo w the engine to cool before storing in any en clo sure . TRA CT OR Remov ...

  • Poulan 196692 - page 25

    25 TR OUBLESHOO TING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly . 2. See “T O ST ART ENGINE” in Operation section. 3. Engine fl ooded. 3. Wait se v eral min utes bef ore attempting to star t. 4. Bad spark plug. 4. Replace spark plug. 5. Dir ty air fi lter . 5. Clean/replace air fi lter . 6. D ...

  • Poulan 196692 - page 26

    26 TR OUBLESHOO TING POINTS Engine dies when 1. Rev erse operation system 1. T ur n ignition key to tractor is shifted (ROS) is not "ON" while ROS "ON" position. into reverse mow er or other attachment See Operation section. is engaged. Engine continues to run 1. F aulty operator-saf ety presence control system. 1. Check wiring, ...

  • Poulan 196692 - page 27

    27 LIMITED W ARRANTY The Manuf acturer warr ants to the original consumer purchaser that this product as manuf actured is free from def ects in materi- als and work man ship. For a period of two (2) y ears from date of purchase b y the original consumer purchaser , we will repair or replace, at our option, without charge f or parts or labor incurre ...

  • Poulan 196692 - page 28

    28 SER VICE NO TES ...

  • Poulan 196692 - page 29

    29 15 DEGREES MAX. FOLD ALONG DO TTED LINE THIS IS A 15 DEGREE SLOPE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees. Make turns gradually to preve ...

  • Poulan 196692 - page 30

    This product has been exper tly en gi neered and carefully manu fa c tured to rigid quality stan dards. As with all mechanical products, some adjustments or par t replacement ma y be necessary dur ing the life of y our unit. F or P arts and ser vice , contact our authorized distributor: call 1-800-849-1297 • F or replacement par ts, ha v e av ail ...

Manufacturer Poulan Category Lawn Mower

Documents that we receive from a manufacturer of a Poulan 196692 can be divided into several groups. They are, among others:
- Poulan technical drawings
- 196692 manuals
- Poulan product data sheets
- information booklets
- or energy labels Poulan 196692
All of them are important, but the most important information from the point of view of use of the device are in the user manual Poulan 196692.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Poulan 196692, service manual, brief instructions and user manuals Poulan 196692. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Poulan 196692.

Similar manuals

A complete manual for the device Poulan 196692, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Poulan 196692 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Poulan 196692.

A complete Poulan manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Poulan 196692 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Poulan 196692, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Poulan 196692, that we can find in the current document
3. Tips how to use the basic functions of the device Poulan 196692 - which should help us in our first steps of using Poulan 196692
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Poulan 196692
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Poulan 196692 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Poulan 196692?

Use the form below

If you did not solve your problem by using a manual Poulan 196692, ask a question using the form below. If a user had a similar problem with Poulan 196692 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)