Manual Zenoah HEZ2601F

56 pages 1.05 mb
Download

Go to site of 56

Summary
  • Zenoah HEZ2601F - page 1

    O WNER / OPERA T OR MANU AL MODE D’EMPLOI MANU AL DE INSTR UCCIONES STICK EDGERS COUPE-BORDURES COR T A CÉSPEDES 848-A45-93A1 (705) APPLICABLE SERIAL NUMBERS : DRIVE UNIT 60100101 and up ENGINE UNIT 60100101 and up NUMEROS DE SERIE APPLICABLES : BOITE DE COMMANDES 60100101 et au-delà MOTEUR 60100101 et au-delà NÚMEROS DE SERIE APLICABLES: UNI ...

  • Zenoah HEZ2601F - page 2

    2 SAFETY FIRST Instructions contained in warnings within this manual marked with a symbol concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail. ■ WARNINGS IN THE MANUAL This mark indicates ...

  • Zenoah HEZ2601F - page 3

    3 SECURITE Les instructions contenues dans les mises en garde de ce mode d’emploi portant le symbole concernent les points critiques qui doivent être pris en considération pour éviter les blessures corporelles graves, c’est pourquoi ces précautions doivent être rigoureusement suivies. ■ DIFFERENTS TYPES D’AVERTISSEMENT DE CE MODE D’E ...

  • Zenoah HEZ2601F - page 4

    4 1. P ar ts location English English ■ HEZ2601F/HEZ2601F-CA Overall size(LxWxH) ··············································································· 72.8 (1850)x11.0 (280)x12.0 (305) in (mm) Dry weight w/o acc. ······················· ...

  • Zenoah HEZ2601F - page 5

    5 1. Emplacement des pieces 1. Situación de las piezas Français Español 1. Poignée 2. Bouton d’allumage 3. Câble d’accélérateur 4. Levier d’accélération 5. Manette des gaz 6. Garde-lame 7. Lame 8. Roues 9. Pare-étincelles du silencieux 10. Poignée de démarrage 11. Réservoir de carburant 12. Pompe d’amorçage 13. Levier de start ...

  • Zenoah HEZ2601F - page 6

    3. W arning labels on the machine 6 English (1) Read owner's manual before operating this machine. (2) Wear head, eye and ear protection. (3) Warning! Danger of kickback. (4) Beware of thrown objects. (5) Warning/Attention (6) Keep all children, bystanders and helpers 15 meters away from the stick edgers. If warning label peel off or become so ...

  • Zenoah HEZ2601F - page 7

    3. Etiqueta de advertencia en la máquina 3. Etiquettes d’avertissement sur la machine 7 Français Español (1) Lire le mode d’emploi avant d’utiliser cette machine. (2) Porter un casque de sécurité, des lunettes de sécurité et un casque antibruit. (3) Avertissement! Phénomène de rebond dangereux. (4) Attention aux objets qui volent ou ...

  • Zenoah HEZ2601F - page 8

    8 1. Read this manual carefully until you completely understand and follow all safety and operating instructions. 2. Keep this manual handy so that you may refer to it later whenever any questions arise. Also note, if you have any questions which cannot be answered herein, contact the dealer from whom you purchased the product. 3. Always be sure to ...

  • Zenoah HEZ2601F - page 9

    9 1. Lea detenidamente este manual hasta comprender cabalmente todas las instrucciones de seguridad y uso. 2. Mantenga este manual a mano para que pueda consultarlo cuando tenga alguna duda. Si tiene cualquier duda que no esté cubierta en este manual, consulte en la tienda donde adquirió el producto. 3. Asegúrese de incluir siempre este manual a ...

  • Zenoah HEZ2601F - page 10

    10 it unsafe to use the product. ■ WORKING PLAN 1. You should never use the product when under the influence of alcohol, when suffering from exhaustion or lack of sleep, when suffering from drowsiness as a result of having taken cold medicine or at any other time when a possibility exists that your judgment might be impaired or that you might not ...

  • Zenoah HEZ2601F - page 11

    grands vents ou toute autre condition climatique rendant l’utilisation de la machine dangereuse. ■ PLAN DE TRAVAIL 1. Ne jamais utiliser la machine sous l’influence de l’alcool ou en état de faiblesse due à la fatigue, au manque de sommeil, à la prise de médicament ou à tout autre moment où l’on n’est pas réellement capable de l? ...

  • Zenoah HEZ2601F - page 12

    12 Remove any obstacle before beginning work. 3. Inspect the entire unit for loose fasteners and fuel leakage. Make sure that the cutting attachment is properly installed and securely fastened. 4. Be sure the debris guard is firmly attached in place. 5. If the cutting head is the metal blade, change the guard and handle, and attach the shoulder str ...

  • Zenoah HEZ2601F - page 13

    13 Retirer tout obstacle avant de commencer le travail. 3. Vérifier que la machine ne comporte aucun élément desserré ou de fuite de carburant. S’assurer que l’outil de coupe est monté correctement et bien serré. 4. S'assurer que le cache de protection anti-débris est fermement attaché. 5. Si la tête de coupe est la lame en métal ...

  • Zenoah HEZ2601F - page 14

    14 1. Grip the handles firmly with both hands using your whole hand. Place your feet slightly apart (slightly further apart than the width of your shoulders) so that your weight is distributed evenly across both legs, and always be sure to maintain a steady, even posture while working. 2. Keep cutting attachment below waist level. 3. Maintain the s ...

  • Zenoah HEZ2601F - page 15

    15 deux mains. Ecarter légèrement les jambes (pour que les pieds reposent sur une largeur un peu plus importante que celle des épaules) et avoir une posture de travail stable et répartir le poids du corps également sur chaque jambe. 2. Maintenir l’outil de coupe toujours plus bas que le niveau de la taille. 3. Faire tourner le moteur à la v ...

  • Zenoah HEZ2601F - page 16

    16 manual must be performed, please contact a representative from the store nearest RedMax authorized servicing dealer for assistance. 5. Do not use any accessory or attachment other than those bearing the RedMax mark and recommended for the unit. 6. Under no circumstances should you ever take apart the product or alter it in any way. Doing so migh ...

  • Zenoah HEZ2601F - page 17

    17 5. Ne pas utiliser d’accessoires ou d’outils de marque autres que RedMax ou non agréés. 6. Ne jamais démonter ou modifier la machine, quelles que soient les circonstances. Dans le cas contraire, la machine risque d’être endommagée en cours d’utilisation ou de ne pas fonctionner correctement. ■ MANIPULATION DU CARBURANT 1. Le moteu ...

  • Zenoah HEZ2601F - page 18

    18 6. Set up English ■ MOUNTING OTHER PARTS 1. Insert the driveshaft into the clutch drum, then attach the gearbox to the shaft tube as aligning the positioning holes and fasten the screw (A). Fasten the clamp bolt (B) firmly. (SE1) (A) Screw (B) Clamp bolt (B) Tightning Torque: 52~69in-lbs (6~8N.m.) 2. Install the handle to the shaft tube and cl ...

  • Zenoah HEZ2601F - page 19

    19 6. Assemblage 6. Montaje Français Español ■ MONTAGE D’AUTRES PIECES 1. Insérez l’arbre d’entraînement dans le tambour d’embrayage, puis fixez la boîte d’engrenage au tube d’arbre en alignant les trous de positionnement et serrez la vis (A). Serrez le boulon d’ablocage (B) fermement. (SE1) (A) Vis (B) Boulon d’ablocage (B) ...

  • Zenoah HEZ2601F - page 20

    20 7. Fuel English • Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 3m (10ft) away from the fueling point before starting the engine. • The RedMax engines are lubricated by oil ...

  • Zenoah HEZ2601F - page 21

    • La gasolina es muy inflamable. Evite fumar o producir cualquier llama o chispa cerca del combustible. Asegúrese de detener el motor y dejar que se enfríe antes de repostar la unidad. Seleccione un terreno al aire libre para el reabastecimiento y aleje la unidad una distancia de por lo menos 3 metros (10 pies) del punto de abastecimiento antes ...

  • Zenoah HEZ2601F - page 22

    22 ■ HOW TO MIX FUEL Agitate carefully. 1. Measure out the quantities of gasoline and oil to be mixed. 2. Put some of the gasoline into a clean, approved fuel container. 3. Pour in all of the oil and agitate well. 4. Pour In the rest of gasoline and agitate again for at least one minute. As some oils may be difficult to agitate depending on oil i ...

  • Zenoah HEZ2601F - page 23

    23 participer ainsi à la protection de l’environnement et de votre santé. • De l’essence ou de l’huile de basse qualité risque d’endommager les joints, les conduites d’essence ou le réservoir d’essence du moteur. ■ COMMENT OBTENIR UN BON MELANGE Agiter avec précautions. 1. Mesurez les volumes d’essence et d’huile à mélang ...

  • Zenoah HEZ2601F - page 24

    24 cause severe damage to the internal engine parts very quickly. 2. GASOHOL – It can cause deterioration of rubber and/or plastic parts and disruption of engine lubrication. 3. OIL FOR 4-CYCLE ENGINE USE – It can cause spark plug fouling, exhaust port blocking, or piston ring sticking. 4. Mixed fuels which have been left unused for a period of ...

  • Zenoah HEZ2601F - page 25

    25 1. ESSENCE SANS HUILE (ESSENCE PURE) – L’essence pure est capable d’endommager très rapidement les pièces du moteur. 2. ESSENCE-ALCOOL – Ce mélange risque de très rapidement détruire les pièces en caoutchouc et/ou en plastique et d’empêcher la lubrification du moteur. 3. HUILE POUR MOTEURS 4 TEMPS – Elles risquent d’encrasse ...

  • Zenoah HEZ2601F - page 26

    26 8. Operation English The RedMax stick edgers are designed for edging lawn in gardens, parks, roadsides and so on. Before starting the engine, take the operating position and adjust the handle position and the wheel height as necessary. ■ ADJUSTING WHEEL HEIGHT 1. Loosen the wing nut and change the wheel height to obtain desired cutting depth. ...

  • Zenoah HEZ2601F - page 27

    27 8. Fonctionnement 8. Uso Français Español Les coupe-bordures RedMax sont conçus pour couper les bordures des pelouses de jardins, parcs, bordures de route, etc. Avant de démarrer le moteur, mettez-vous en position d’utilisation et réglez la position de la poignée et la hauteur de la roue comme requis. ■ REGLAGE DE LA HAUTEUR DE LA ROUE ...

  • Zenoah HEZ2601F - page 28

    28 8. Operation English 6. Move the choke lever downward to open the choke. And restart engine. (OP3) 7. Allow the engine to warm up for several minutes before starting operation. 1. When restarting the engine immediately after stopping it, leave the choke open. 2. Overchoking can make the engine hard to start due to excess fuel. When the engine fa ...

  • Zenoah HEZ2601F - page 29

    29 8. Fonctionnement 8. Uso Français Español • Eviter de tirer à fond sur la corde de démarrage ou de relâcher brutalement la poignée. Ces opérations risquent d’endommager le système de démarrage. 6. Ramener le levier du starter vers le bas pour le remettre en position ouverte. Et redémarrer le moteur (OP3). 7. Laisser le moteur chauf ...

  • Zenoah HEZ2601F - page 30

    30 8. Operation English ■ HOW TO USE 1. Always wear eye protection such as safety goggles. Never lean over the rotating cutting head. Rocks or other debris could be thrown into eyes and face and cause serious personal injury. 2. Keep the blade guard and the mad guard attached in place at all times when the unit is operated. 3. Before starting a j ...

  • Zenoah HEZ2601F - page 31

    31 8. Fonctionnement 8. Uso Français Español • Caliente el motor antes de ajustar la velocidad de marcha en vacío. ■ COMO USAR 1. Utilizar siempre protección para los ojos tales como gafas. No se apoye nunca sobre el cabezal de corte giratorio. Piedras u otros desechos podrían salir despedidos hacia sus ojos y cara y causarle serios daños ...

  • Zenoah HEZ2601F - page 32

    32 Maintenance, replacement, or repair of the emission control device and systems may be performed by any non-road engine repair establishment or individual. •A lways be sure to stop the engine before inspecting the stick edger for problems or performing maintenance. •N ever alter the stick edger or take the engine apart. •W hen replacing par ...

  • Zenoah HEZ2601F - page 33

    Elément à vérifier Action 33 L’entretien, le remplacement ou la réparation du dispositif et des systèmes de lutte contre les émissions peuvent être effectués par toute société ou individu spécialisé dans la réparation des moteurs hors-route. • Assurez-vous de toujours arrêter le moteur avant d’inspecter le coupe-bordures ou d’ ...

  • Zenoah HEZ2601F - page 34

    34 every every every 25 50 100 system/compornent procedure before hours hours hours note use after after after fuel leaks, fuel spillage wipe out ✔ fuel tank, air filter, fuel filter inspect/clean ✔✔ replace, if necessary see ■ ADJUSTING replace carburetor idle adjusting screw ✔ IDLING SPEED (p.28) if necessary clean and readjust GAP: .02 ...

  • Zenoah HEZ2601F - page 35

    35 9. Entretien 9. Mantenimiento Français Español Toutes les Toutes les Toutes les 25 50 100 Système/Composant Procédure Avant heures heures heures Remarque utilisation suivantes suivantes suivantes fuites ou éclaboussures de carburant essuyer ✔ réservoir de carburant, filtre à air, filtre à carburant vérifier/nettoyer ✔✔ remplacer s ...

  • Zenoah HEZ2601F - page 36

    36 9. Maintenance English • Make sure that the engine has stopped and is cool before performing any service to the machine. Contact with moving cutting head or hot muffler may result in a personal injury. ■ AIR FILTER • The air filter, if clogged, will reduce the engine performance. Check and clean the filter element in warm, soapy water as r ...

  • Zenoah HEZ2601F - page 37

    37 9. Entretien 9. Mantenimiento Français Español Assurez-vous que le moteur est arrêté et refroidi avant de commencer toute maintenance sur l'appareil. Un contact avec la lame tournante ou avec le silencieux encore chaud pourraient provoquer des blessures. ■ FILTRE A AIR • Si le filtre à air est colmaté, la performance du moteur en ...

  • Zenoah HEZ2601F - page 38

    38 9. Maintenance English ■ MUFFLER • Inspect periodically, the muffler for loose fasteners, any damage or corrosion. If any sign of exhaust leakage is found, stop using the machine and have it repaired immediately. • Note that failing to do so may result in the engine catching on fire. ■ SPARK ARRESTER • The muffler is equipped with a sp ...

  • Zenoah HEZ2601F - page 39

    39 9. Entretien 9. Mantenimiento Français Español ■ SILENCIEUX • Vérifier régulièrement l’état du silencieux : dommages, corrosion et fixation. Si le silencieux fuit, arrêter d’utiliser la machine et la faire réparer immédiatement. •S i l’on continue d’utiliser la machine dans cette condition, le moteur risque de prendre feu. ...

  • Zenoah HEZ2601F - page 40

    40 9. Maintenance English ■ BLADE (MA7) • Place the blade between holders (A) and (B) while locking the gear shaft by putting the bar, through the key holes on the holder(A) and the gearcase. Use the socket and the screwdriver to tighten the blade mounting bolt. (1) Blade mounting nut (Left-handed) Tightning Torque: 130~150in-lbs(15~20N.m.) (2) ...

  • Zenoah HEZ2601F - page 41

    41 9. Entretien 9. Mantenimiento Français Español ■ LAME (MA7) • Placez la lame entre les supports (A) et (B) tout en verrouillant l’arbre de transmission en plaçant la barre à travers les boutonnières sur le support (A) et le carter d’engrenage. Utilisez la douille et le tournevis pour serrer le boulon de montage de la lame. (1) Ecrou ...

  • Zenoah HEZ2601F - page 42

    42 9. Maintenance English ■ PROTECTOR • When you replace protector, use new bolt (T3207- 24130). (MA9) Tightning Torque: 35~52in-lbs(4.0~6.0N.m.) ■ PROCEDURES TO BE PERFORMED AFTER EVERY 100 HOURS OF USE 1. Remove the muffler, insert a screwdriver into the vent, and wipe away any carbon buildup. Wipe away any carbon buildup on the muffler exh ...

  • Zenoah HEZ2601F - page 43

    43 9. Entretien 9. Mantenimiento Français Español ■ PROTECTEUR • Lorsque vous remettez le protecteur en place, utilisez un boulon neuf (T3207-24130). (MA9) Couple de serrage : 35~52in-lbs (4.0~6.0N.m.) ■ PROCEDURE A EFFECTUER TOUTES LES 100 HEURES D’UTILISATION 1. Démonter le silencieux et insérer un tournevis dans la fente pour retirer ...

  • Zenoah HEZ2601F - page 44

    44 Case 1. Starting failure CHECK PROBABLE CAUSES ACTION fuel tank ➞ incorrect fuel ➞ drain it and with correct fuel fuel filter ➞ fuel filter is clogged ➞ clean carburetor adjustment screw ➞ out of normal range ➞ adjust to normal range sparking (no spark) ➞ spark plug is fouled/wet ➞ clean/dry ➞ plug gap is incorrect ➞ correct ...

  • Zenoah HEZ2601F - page 45

    45 13. P ar ts list 13. Liste des pièces 13. Lista de piezas NOTE : 1. Use RedMax/ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. RedMax/ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company. 3. When placing parts orders for repair and/o ...

  • Zenoah HEZ2601F - page 46

    46 13. P ar ts list Fig.1 DRIVE UNIT HEZ2601F/HEZ2601F-CA (S/N 60100101 and up) ...

  • Zenoah HEZ2601F - page 47

    47 Fig.1 DRIVE UNIT HEZ2601F/HEZ2601F-CA (S/N 60100101 and up) Key# Description Part Number Q'ty 1P IPE COMP. T3207-12100 1 2 SHAFT COMP. T3207-12200 1 3 GEARCASE ASSY T3207-13000 1 4• GEARCASE T3207-13110 1 5• HOLDER-B 6129-13250 1 6• HOLDER-A 6129-13240 1 7• SHAFT 6129-13211 1 8• PINION T3207-13310 1 9• GEAR 6129-13220 1 10 • B ...

  • Zenoah HEZ2601F - page 48

    48 Fig.2 ENGINE UNIT HEZ2601F/HEZ2601F-CA (S/N 60100101 and up) 13. P ar ts list ...

  • Zenoah HEZ2601F - page 49

    Key# Description Part Number Q'ty 1 CYLINDER 848-F3R-12A2 1 2 GASKET, base 848-F3R-12B0 1 3 BOLT, M5x22 4820-12130 2 4 INSULATOR 848-F3R-14A0 1 5 GASKET, insulator 4810-13120 1 6 GASKET, carburetor 4810-13130 1 7 BOLT, M5x20 4820-13180 2 8 REEDVALVE (S) ASSY 848-F3R-1600 1 10 • REEDVALVE 848-F3R-16C0 1 11 • STOPPER 4810-16130 1 12 • SCRE ...

  • Zenoah HEZ2601F - page 50

    The California Air Resources Board and ZENOAH AMERICA, INC. are pleased to explain the emission control system warranty on your 2007 and later small off-road engine. In California, new small off-road engines must be designed, built and equipped to meet the state’s stringent anti-smog standards. ZENOAH AMERICA, INC. must warrant the emission contr ...

  • Zenoah HEZ2601F - page 51

    La Commission des ressources en air de Californie et ZENOAH AMERICA, INC. sont heureux d'expliquer la garantie du système de contrôle des émissions de votre petit moteur hors route de 2007 et ultérieur. En Californie, les nouveaux petits moteurs hors route doivent être conçus, construits et équipés pour respecter les normes anti-pollut ...

  • Zenoah HEZ2601F - page 52

    La Comisión de Recursos del Aire de California y ZENOAH AMERICA, INC. tienen el agrado de explicar la garantía del sistema de control de emisiones para motores “todo terreno” modelo 2007 y posteriores . En California, los nuevos motores “todo terreno” deben ser diseñados, construidos y equipados para cumplir con las estrictas normas anti ...

  • Zenoah HEZ2601F - page 53

    EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE UNIT, RedMax / ZENOAH AMERICA, INC., THROUGH ANY RedMax DEALER, WILL REPAIR OR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL AND EACH SUBSEQUENT PURCHASER, ANY PART OR PARTS FOUND TO BE DEFECTIVE IN MATERIAL AND/OR WORKMANSHIP. EMISSION-RELATED PARTS ARE: THE CARBURETOR ...

  • Zenoah HEZ2601F - page 54

    Pièces en rapport avec les émissions de gaz d'échappement : RedMax / ZENOAH AMERICA, INC., par l'intermédiaire de n'importe quel revendeur RedMax, réparera gratuitement ou remplacera gratuitement pour l'acheteur initial et chaque acheteur successif toute(s) pièce(s) se révélant de constitution et/ou de montage défectueu ...

  • Zenoah HEZ2601F - page 55

    PIEZAS REALACIONADAS CON LAS EMISIONES, POR DOS (2) AÑOS A CONTAR DE LA FECHA DE ENTREGA ORIGINAL DEL UNIDAD, RedMax / ZENOAH AMERICA, INC., A TRAVÉS DE CUALQUIER DISTRIBUIDOR RedMax, REPARARÁ O REEMPLAZARÁ, GRATUITAMENTE, PARA EL COMPRADOR ORIGINAL Y CUALQUIER COMPRADOR POSTERIOR, CUALQUIER PIEZA O PIEZAS QUE PRESENTEN DEFECTOS EN SUS MATERIAL ...

  • Zenoah HEZ2601F - page 56

    Printed in U.S.A. ZENOAH AMERICA, INC. 1100 Laval Blvd. Suite 110 Lawrenceville, Georgia 30043 HEZ2601F *1: The year will be changed every year of manufacturing. *2: The initial number will be changed every year of manufacturing. *3: SP : Sealed tank made of HDPE or PE. IMPORT ANT ENGINE INFORMA TION COMPLIANCE PERIOD : CA TEGOR Y A ENGINE F AMIL Y ...

Manufacturer Zenoah Category Edger

Documents that we receive from a manufacturer of a Zenoah HEZ2601F can be divided into several groups. They are, among others:
- Zenoah technical drawings
- HEZ2601F manuals
- Zenoah product data sheets
- information booklets
- or energy labels Zenoah HEZ2601F
All of them are important, but the most important information from the point of view of use of the device are in the user manual Zenoah HEZ2601F.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Zenoah HEZ2601F, service manual, brief instructions and user manuals Zenoah HEZ2601F. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Zenoah HEZ2601F.

Similar manuals

A complete manual for the device Zenoah HEZ2601F, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Zenoah HEZ2601F by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Zenoah HEZ2601F.

A complete Zenoah manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Zenoah HEZ2601F - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Zenoah HEZ2601F, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Zenoah HEZ2601F, that we can find in the current document
3. Tips how to use the basic functions of the device Zenoah HEZ2601F - which should help us in our first steps of using Zenoah HEZ2601F
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Zenoah HEZ2601F
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Zenoah HEZ2601F in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Zenoah HEZ2601F?

Use the form below

If you did not solve your problem by using a manual Zenoah HEZ2601F, ask a question using the form below. If a user had a similar problem with Zenoah HEZ2601F it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)