English dropdown-ico

Manual Aiwa CDC-Z107

36 pages 4.67 mb
Download

Go to site of 36

Summary
  • Aiwa CDC-Z107 - page 1

    SER VICE MANUAL DA T A STEREO CAR CD RECEIVER CDC-Z107 YU S/M Code No. 09-002-422-4R1 REVISION • This Service Manual is the “Revision Publishing” and replaces “Simple Manual” of CDC-Z107<YU>, (S/M Code No. 09-99B-422-4T1). BASIC CD MECHANISM : TN-CCD1001-113J ...

  • Aiwa CDC-Z107 - page 2

    SPECIFICATIONS RADIO SECTION (FM) Frequency Range 87.5 MHz – 108 MHz (100-kHz steps) 87.5 MHz – 108 MHz (50-kHz steps) Usable Sensitivity 12.7 dBf 50 dB Quieting Sensitivity 17.2 dBf IF Rejection 80 dB Frequency Response 30 Hz – 15,000 Hz S/N Ratio 63 dB Stereo Separation 35 dB at 1 kHz Alternate Channel Selectivity 70 dB Capture Ratio 3 dB ( ...

  • Aiwa CDC-Z107 - page 3

    Precaution to replace Optical block (OPTIMA-720AIE) Body or clothes electrostatic potential could ruin laser diode in the optical block. Be sure ground body and workbench, and use care the clothes do not touch the diode. 1) After the connection, remove solder shown in right figure. - 3 - CLASS 1 LASER PRODUCT KLASSE 1 LASER PRODUKT LUOKAN 1 LASER L ...

  • Aiwa CDC-Z107 - page 4

    KANRI NO. REF. NO. DESCRIPTION PART NO. KANRI NO. REF. NO. DESCRIPTION PART NO. - 4 - IC 87-A20-446-010 C-IC,LA9241ML 87-A21-319-010 C-IC,LC78622NE 87-A21-488-040 C-IC,LA6556 8Z-KT1-622-010 C-IC,LC75374E 87-A21-562-010 IC,LA4743B 88-KT1-606-080 IC,PST994D 87-A21-535-030 C-IC,LC72358N-9910 87-A21-489-030 C-IC,LC75853NW TRANSISTOR 89-324-122-080 TR,2 ...

  • Aiwa CDC-Z107 - page 5

    KANRI NO. REF. NO. DESCRIPTION PART NO. KANRI NO. REF. NO. DESCRIPTION PART NO. - 5 - C316 87-010-498-040 CAP,E 10-16 GAS C321 87-010-196-080 CHIP CAPACITOR,0.1-25 C322 87-010-555-040 CAP,E 100-10 M 5L SRE C323 87-010-196-080 CHIP CAPACITOR,0.1-25 C324 87-010-498-040 CAP,E 10-16 GAS C351 87-010-494-040 CAP,E 1-50 GAS C352 87-010-494-040 CAP,E 1-50 ...

  • Aiwa CDC-Z107 - page 6

    88 A Resistor Code Chip Resistor Part Coding Figure V alue of resistor Chip resistor W attage T ype T olerance 1/16W 1/10W 1/8W 1608 2125 3216 5% 5% 5% CJ CJ CJ Form LW t 1.6 0.8 0.45 2 1.25 0.45 3.2 1.6 108 11 8 128 : A : A CHIP RESISTOR P AR T CODE 0.55 Resistor Code Dimensions (mm) Symbol 1/16W 1005 5% CJ 1.0 0.5 0.35 104 L t W TRANSIST OR ILLUS ...

  • Aiwa CDC-Z107 - page 7

    WIRING - 1 (MAIN: 1 / 2) - 7 - 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 A B C D E F G H I J K L M N O P Q R S T U 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 ...

  • Aiwa CDC-Z107 - page 8

    - 8 - WIRING - 1 (MAIN: 1 / 2) 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 A B C D E F G H I J K L M N O P Q R S T U 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 ...

  • Aiwa CDC-Z107 - page 9

    SCHEM ATIC DIAGRAM - 1 (MAIN: 1 / 2) - 9 - ...

  • Aiwa CDC-Z107 - page 10

    SCHEM ATIC DIAGRAM - 2 (MAIN: 2 / 2) - 10 - ...

  • Aiwa CDC-Z107 - page 11

    WIRING - 2 (FRONT) - 11 - 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 A B C D E F G H I J K L M N O P Q R S T U 1 2 3 4 5 6 7 8 9 25 26 27 28 29 30 31 32 ...

  • Aiwa CDC-Z107 - page 12

    SCHEMATIC DIAGRAM - 3 (FRONT) - 12 - ...

  • Aiwa CDC-Z107 - page 13

    IC BLOCK DIAGRAM IC,LA4743B IC,LA6556 - 13 - ...

  • Aiwa CDC-Z107 - page 14

    LCD DIAGRAM - 14 - ...

  • Aiwa CDC-Z107 - page 15

    IC, LC72358N-9910 VOLTAGE CHART PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 1 2.45 2.47 2.35 2.35 2.42 2.28 2 ~ 6 0 0 0 0 0 0 7 4.87 4.91 4.85 4.84 4.90 4.87 8 0 0 0.05 0.05 0.15 0.03 9 0.10 0.10 0.20 0.21 0.70 0.21 10 0.10 0.10 0.22 0.21 0.75 0.24 1 1 0 0 0 0 0.03 0 1 2 00 0000 13 0 0 0 0 4.83 0 14 0 0 4.57 4.54 0 0 15 ~ 16 0 0 0 0 0 0 1 ...

  • Aiwa CDC-Z107 - page 16

    PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 68 4.94 4.95 4.76 4.76 4.87 4.79 69 0 0 0.58 0.57 0 0.59 70 0 0 2.51 2.51 0 2.52 71 ~ 72 0 0 0 0 0 0 73 4.98 4.97 4.80 4.80 4.91 4.84 74 0 0 0 2.34 0 2.31 75 0 0 2.45 0.01 0 0.03 7 6 00 0000 77 0 0 0.08 0.08 0 0 78 0 0 1.04 1.04 1.05 0 7 9 00 0000 80 2.53 2.52 2.45 2.46 2.50 2.47 PIN NO. BU (V) ...

  • Aiwa CDC-Z107 - page 17

    PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 1 ~ 2 0 0 0 0 2.50 0 3 0 0 0 0 2.53 0 4 0 0 0 0 2.49 0 5 ~ 7 0 0 0 0 2.51 0 8 0 0 0 0 2.52 0 9 ~ 12 0 0 0 0 2.51 0 13 0 0 0 0 2.50 0 14 0 0 0 0 2.51 0 15 0 0 0 0 2.50 0 16 0 0 0 0 2.61 0 17 0 0 0 0 2.52 0 18 0 0 0 0 2.42 0 19 0 0 0 0 2.52 0 20 0 0 0 0 2.53 0 21 0 0 0 0 2.51 0 22 ~ 23 0 0 0 0 0 0 ...

  • Aiwa CDC-Z107 - page 18

    PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 6 0 00 0000 61 0 0 0 0 2.22 0 62 0 0 0 0 3.71 0 63 0 0 0 0 0.19 0 64 0 0 0 0 4.91 0 PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 1 ~ 2 0 0 0 0 0 0 3 0 0 0 0 8.44 0 4 ~ 5 0 0 0 0 0 0 6 0 0 0 0 3.70 0 7 0 0 0 0 4.06 0 8 0 0 0 0 3.76 0 9 0 0 0 0 4.05 0 10 0 0 0 0 3.86 0 1 1 0 0 0 0 3.88 0 ...

  • Aiwa CDC-Z107 - page 19

    PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 1 0 0 0 0 0.05 0 2000000 3 0 0 0 0 1.55 0 4000000 5 0 0 0 0 1.77 0 6 0 0 0 0 4.69 0 7 0 0 0 0 0.33 0 8000000 9 0 0 0 0 2.49 0 10 0 0 0 0 2.39 0 1 1 000000 12 0 0 0 0 0.50 0 13 ~ 17 0 0 0 0 0 0 18 0 0 0 0 4.92 0 19 ~ 20 0 0 0 0 0 0 21 0 0 0 0 2.35 0 22 ~ 23 0 0 0 0 4.93 0 24 ~ 30 0 0 0 0 0 0 31 0 ...

  • Aiwa CDC-Z107 - page 20

    PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 5 9 00 0000 60 0 0 0 0 1.93 0 61 0 0 0 0 2.34 0 62 ~ 64 0 0 0 0 0 0 PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 1 ~ 2 0 0 0 0 0 0 3 0 0 0 0.02 0 0 4 0 0 6.89 0 6.93 0 5000000 6 0 0 3.42 3.42 3.42 3.42 7 ~ 8 0 0 0 0 0 0 9 0 0 0 7.95 0 7.85 10 ~ 1 1 0 0 0 0 0 0 12 0 0 7.27 0 7.31 0 13 0 ...

  • Aiwa CDC-Z107 - page 21

    PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 1 0 0 3.94 3.93 3.96 3.96 2 0 0 3.98 3.98 4.00 4.01 3 0 0 4.00 4.00 4.02 4.01 4 ~ 6 0 0 4.00 4.00 4.02 4.02 7 0 0 3.99 3.99 4.01 3.99 8 ~ 9 0 0 0 0 0 0 10 0 0 3.98 3.98 4.00 3.99 1 1 0 0 4.01 4.01 4.03 4.01 12 0 0 3.99 3.99 4.01 3.99 13 0 0 4.02 4.01 4.04 4.01 14 0 0 4.01 4.01 4.03 4.01 15 ~ 18 ...

  • Aiwa CDC-Z107 - page 22

    PIN NO. BU (V) BU+ACC (V) FM (V) AM(V) CD (V) AUX (V) 1 0 0 4.84 4.83 4.86 4.85 2000000 3 2.50 2.50 2.47 2.47 2.48 2.48 4 2.50 2.50 2.47 2.47 2.48 2.47 5 2.50 2.50 2.47 2.47 2.48 2.48 6 2.50 2.50 2.47 2.47 2.48 2.47 7 ~ 10 2.50 2.50 2.47 2.46 2.47 2.47 1 1 ~ 12 2.50 2.50 2.47 2.47 2.47 2.47 13 2.50 2.50 2.47 2.46 2.47 2.47 14 2.50 2.50 2.47 2.47 2. ...

  • Aiwa CDC-Z107 - page 23

    IC DESCRIPTION IC, LC72358N-9910 Pin No. Pin Name I/O Description 1 XIN I System clock oscillator input. 2 ~ 3 NC - Not connected. 4 E-VOL DO O Data output for electric volume. 5 E-VOL CLO O Clock output for electric volume. 6 E-VOL CE O CE output for electric volume. 7 LCD DI I LCD driver data signal input. 8 LCD DO O LCD driver data signal output ...

  • Aiwa CDC-Z107 - page 24

    Pin No. Pin Name I/O Description 48 RWC O Read / write control output terminal. 49 CD RES O DSP reset output terminal. 50 SW3 I Disc detection / chuck or release disc detection. 51 SW2 I 12 cm disc detection / 12 cm disc ejection end detection. 52 SW1 I Leading motor start detection. 53 R-ENCOD2 I Rotary encoder input 2. 54 R-ENCOD1 I Rotary encode ...

  • Aiwa CDC-Z107 - page 25

    IC, LA9241ML Pin No. Pin Name I/O Description 1 FIN2 O For the connection of the pickup photodiode. Addition to the FIN1 pin creates an RF signal and subtraction from it create an EF signal. 2 FIN1 O For the connection of the pickup photodiode. 3E O For the connection of the pickup photodiode. Subtraction from the F pin creates a TE signal. 4 F O F ...

  • Aiwa CDC-Z107 - page 26

    Pin No. Pin Name I/O Description 37 HFL O The HFL (high frequency level) signal is used to judge whether the main beam is positioned on the pit or on the mirror. 38 SLOF I Sled servo off control input. 39 CV- I CLV error signal input from the DSP. 40 CV+ 41 RFSM O RF output. 42 RFS- O Sets the RF gain and the EFM singal's 3T compensation const ...

  • Aiwa CDC-Z107 - page 27

    Pin No. Pin Name I/O Description 1 DEFI I Defect detection signal (DEF) input. (Must be connected to 0V when unused.) 2 TAI I For PLL/Test input. A pull-down resistor is built-in. (Must be connected to 0V.) 3 PDO O External VCO control phase comparator output. 4 VVSS - Intetnal VCO ground. (Must be connected to 0V.) 5 ISET I PDO output current adju ...

  • Aiwa CDC-Z107 - page 28

    Pin No. Pin Name I/O Description 39 RVSS - Right channel ground. (Must be connected to 0V.) 40 RCHO O Right channel output. 41 RVDD - Right channe power supply. 42 MUTER/CONT8 O Right channel mute output./ General purpose input/ output. 43 XVDD - Crystal oscillator power supply. 44 XOUT O Connections for a 16.9344 MHz crystal oscillator element. 45 ...

  • Aiwa CDC-Z107 - page 29

    1 RVRIN I 4dB volume control input. Must be driven at a low impedance. 2 RCOM – 1dB volume control common pin. For the connection of capacitors that compensate for bass and treble in the tone control 3 ~ 5 RT1 ~ RT3 – circuits. A high-frequency compensation capacitors must be connected between T1 and T2. A low-frequency compensation capacitors ...

  • Aiwa CDC-Z107 - page 30

    40 TP(R) 41 TUN(R) I Signal input pins. 42 CD(R) 43 AUX(R) 44 RSELO O Input selector output pin. Pin No. Pin Name I/O Description Pin No. Pin Name I/O Description 1 ~ 40 S1 ~ S40 O LCD segment output. 41 ~ 43 COM1~ COM3 O LCD command driver outputs. 44 ~ 49 KS1 ~ KS6 O Key scan outputs. 50 ~ 54 KI1 ~ KI5 I Key scan inputs. These pins have build-in ...

  • Aiwa CDC-Z107 - page 31

    1-1 How to Activate CD T est Mode 1) Connect 62 pin (test) of IC701 (LC72358N-9910) on MAIN C.B to the 31 pin (VDD) by cable. 2) Connect wire of ACC (red) and BACKUP (yellow) of power supply/speaker connector to DC+12V , then connect Ground (black) to -. When CD test mode is started, all displays will be lighted as shown in the following figure. 1- ...

  • Aiwa CDC-Z107 - page 32

    MECHANICAL EXPLODED VIEW 1 / 1 - 32 - 1 2 6 3 5 4 17 13 14 10 G 11 G 7 18 19 20 16 21 C C CHAS,FRONT -AC17 P .C.B B C 32 C 31 C C C 15 12 9 8 29 30 22 23 25 26 26 A A P .C.B 27 28 B 33 TN-CCD1001 -1 13J P ANEL, HT -SINK H2-AC 34 C 35 C C E D C 36 HT -SINK P .C.B C 37 38 B C F C 24 ...

  • Aiwa CDC-Z107 - page 33

    KANRI NO. REF. NO. DESCRIPTION PART NO. KANRI NO. REF. NO. DESCRIPTION PART NO. MECHANICAL PARTS LIST 1 / 1 Basic color symbol Color Basic color symbol Color Basic color symbol Color B Black C Cream D Orange G Green H Gray L Blue LT Transparent Blue N Gold P Pink R Red S Silver ST Titan Silver T Brown V Violet W White WT Transparent White Y Yellow ...

  • Aiwa CDC-Z107 - page 34

    CD MECHANISM EXPLODED VIEW 1 / 1 1 2 3 4 5 9 5 6 7 17 C C C B B A A F B 17 A A A A A A A A A A D D I H H G E E B I B C 16 15 14 13 11 25 26 28 20 19 12 24 18 27 20 21 22 23 10 62 63 2 8 31 32 33 30 35 34 29 2 37 41 38 50 59 38 39 40 45 44 42 55 56 57 68 40 36 67 54 67 53 58 52 51 61 P .C.B 60 64 65 66 43 46 49 47 48 - 34 - ...

  • Aiwa CDC-Z107 - page 35

    KANRI NO. REF. NO. DESCRIPTION PART NO. KANRI NO. REF. NO. DESCRIPTION PART NO. CD MECHANISM PARTS LIST 1 / 1 1 S3-031-010-010 FRAME 2 S3-031-050-240 DAMPER(J) 3 S3-031-010-260 REAR OAMPER BKT(J) 4 S3-031-010-270 FPC GUIDE 5 S3-031-010-290 HUNG UP SP(R) 6 S3-031-010-140 TRIG PL 7 S3-031-010-160 TRIG ARM 8 S3-031-010-120 TRIG LVR 9 S3-031-010-150 TR ...

  • Aiwa CDC-Z107 - page 36

    2 – 1 1, IKENOHA T A 1 – CHOME, T AITO-KU, TOKYO 1 10, JAP AN TEL:03 (3827) 31 1 1 Printed in Singapore 9820572 0251431 ...

Manufacturer Aiwa Category Car Stereo System

Documents that we receive from a manufacturer of a Aiwa CDC-Z107 can be divided into several groups. They are, among others:
- Aiwa technical drawings
- CDC-Z107 manuals
- Aiwa product data sheets
- information booklets
- or energy labels Aiwa CDC-Z107
All of them are important, but the most important information from the point of view of use of the device are in the user manual Aiwa CDC-Z107.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Aiwa CDC-Z107, service manual, brief instructions and user manuals Aiwa CDC-Z107. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Aiwa CDC-Z107.

Similar manuals

A complete manual for the device Aiwa CDC-Z107, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Aiwa CDC-Z107 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Aiwa CDC-Z107.

A complete Aiwa manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Aiwa CDC-Z107 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Aiwa CDC-Z107, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Aiwa CDC-Z107, that we can find in the current document
3. Tips how to use the basic functions of the device Aiwa CDC-Z107 - which should help us in our first steps of using Aiwa CDC-Z107
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Aiwa CDC-Z107
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Aiwa CDC-Z107 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Aiwa CDC-Z107?

Use the form below

If you did not solve your problem by using a manual Aiwa CDC-Z107, ask a question using the form below. If a user had a similar problem with Aiwa CDC-Z107 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)