English dropdown-ico

Manual Poulan 178219

48 pages 1.56 mb
Download

Go to site of 48

Summary
  • Poulan 178219 - page 1

    OWNER'S MANUAL MODEL: PR17H42STC LAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION 178219 1.29.01 JH Printed in U.S.A. WARNING: Read this Owner's Manual and follow all Warnings and Safety Instructions. Failure to do so can result in serious injury. IMPORTANT MANUAL DO NOT THROW AWAY ...

  • Poulan 178219 - page 2

    2 I . GENERAL OPERATION • Read, understand, and follow all instructions in the manual and on the machine before starting. • Only allow responsible adults, who are familiar with the instructions, to operate the machine. • Clear the area of objects such as rocks, toys, wire, etc., which could be picked up and thrown by the blade. • Be sure th ...

  • Poulan 178219 - page 3

    3 Look for this symbol to point out important safety precautions. It means CAUTION!!! BECOME ALERT!!! YOUR SAFETY IS IN- VOLVED. CAUTION: In order to prevent acciden- tal starting when setting up, transport- ing, adjusting or making repairs, always disconnect spark plug wire and place wire where it cannot contact spark plug. W ARNING Engine exhaust ...

  • Poulan 178219 - page 4

    4 PRODUCT SPECIFICA TIONS GASOLINE CAPACITY 2.0 GALLONS AND TYPE: UNLEADED REGULAR OIL TYPE (API-SF-SJ): SAE 30 (above 32 ° F) SAE 5W-30 (below 32 ° F) OIL CAPACITY: W/FILTER: 3.5 PINTS W/O FILTER: 3.0 PINTS SPARK PLUG: CHAMPION RC12YC (GAP: .030") GROUND SPEED (MPH): Forward: 0-5.5 Reverse 0-2.4 TIRE PRESSURE: FRONT: 14 P SI REAR: 10 PSI CH ...

  • Poulan 178219 - page 5

    5 UNASSEMBLED PAR TS (1) Large Flat Washer (1) Locknut 5/16-18 (1) Hex Bolt 5/16-18 x 1-1/4 (1) Hex Bolt 3/8-16 x 1 (1) Lock washer 3/8 Steering Wheel Insert Steering Sleeve Steering Wheel (1) Knob (1) Washer 17/32 x 1-3/16 x 12 Gauge Seat (2) Mulch Blades (2) Keys Slope Sheet Steering Extension Shaft Steering Adapter (1) Oil Drain Tube ...

  • Poulan 178219 - page 6

    6 ASSEMBL Y T OOLS REQUIRED FOR ASSEMBL Y A socket wrench set will make assembly easier. Standard wrench sizes are listed. (2) 1/2" wrenches Utility knife (1) 9/16" wrenches Tire pressure gauge Pliers When right or left hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel). T ...

  • Poulan 178219 - page 7

    7 ASSEMBL Y FIG. 3 NOTE: You may now roll or drive your tractor off the skid. Follow the appropriate instruction below to remove the tractor from the skid. TO ROLL TRACTOR OFF SKID (See Operation section, page 10, for location and function of controls) • Press lift lever plunger and raise attachment lift lever to its highest position. • Release ...

  • Poulan 178219 - page 8

    8 ASSEMBL Y CHECKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM THIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: All assembly instructions have been completed. No remaining loose parts in carton. Battery is properly prepared and charged. (Minimum 1 hour ...

  • Poulan 178219 - page 9

    9 OPERA TION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE LIGHTS ON FUEL CHOKE MOWER HEIGHT PARKING BRAKE LOCKED UNLOCKED REVERSE NEUTRAL HIGH LOW ATTACHMENT CLUTCH ENGAGED MOWER LIFT DAN ...

  • Poulan 178219 - page 10

    10 OPERA TION KNO W Y OUR TRA CT OR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Our tractors conform to the safety standards of the American National Stan ...

  • Poulan 178219 - page 11

    11 OPERA TION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses. IMPORTANT: LEAVING T ...

  • Poulan 178219 - page 12

    12 OPERA TION TO OPERATE ON HILLS CAUTION: Do not drive up or down hills with slopes greater than 15 ° and do not drive across any slope. • Choose the slowest speed before starting up or down hills. • Avoid stopping or changing speed on hills. • If slowing is necessary, move throttle control lever to slower position. • If stopping is absol ...

  • Poulan 178219 - page 13

    13 OPERA TION TO START ENGINE (See Fig. 5) When starting the engine for the first time or if the engine has run out of fuel, it will take extra cranking time to move fuel from the tank to the engine. • Be sure freewheel control is in the transmission engaged position. • Sit on seat in operating position, depress clutch/brake pedal and set parki ...

  • Poulan 178219 - page 14

    14 FIG. 10 MULCHING MOWING TIPS IMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE. • The special mulching blade will recut the grass clippings many times and reduce them in size so that as they fall onto the lawn they will disperse into the grass and not be noticed. Also, the mulched grass ...

  • Poulan 178219 - page 15

    15 CUST OMER RESPONSIBILITIES BEFORE EACH USE T R A C T 0 R Adjust Motion Drive Belt(s) Tension Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil Replace Air Filter Paper Cartridge Replace Spark Plug Check Battery Level Check Tire Pressure Clean Battery and Terminals FILL IN DATES AS YOU COMPL ...

  • Poulan 178219 - page 16

    16 BATTERY Your tractor has a battery charging system which is suffi- cient for normal use. However, periodic charging of the battery with an automotive charger will extend its life. • Keep battery and terminals clean. • Keep battery bolts tight. • Keep small vent holes open. • Recharge at 6-10 amperes for 1 hour. CUST OMER RESPONSIBILITIES ...

  • Poulan 178219 - page 17

    17 CUST OMER RESPONSIBILITIES ENGINE LUBRICATION Only use high quality detergent oil rated with API service classification SF-SJ. Select the oil ’ s SAE viscosity grade according to your expected operating temperature. TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE SAE VISCOSITY GRADES -20 ° 0 ° 30 ° 40 ° 80 ° 100 ° -30 ° -20 ° 0 ° ...

  • Poulan 178219 - page 18

    18 CUST OMER RESPONSIBILITIES AIR FILTER (See Fig. 17) Your engine will not run properly using a dirty air filter. Clean the foam pre-cleaner after every 25 hours of operation or every season. Service paper cartridge every 100 hours of operation or every season, whichever occurs first. Service air cleaner more often under dusty conditions. • Remo ...

  • Poulan 178219 - page 19

    19 SER VICE AND ADJUSTMENTS TRA CTOR TO REMOVE MOWER (See Fig. 19) Mower will be easier to remove from the right side of tractor. • Place attachment clutch in “ DISENGAGED ” position. • Move attachment lift lever forward to lower mower to its lowest position. • Roll belt off engine pulley. • Remove small retainer spring, and lift clutch ...

  • Poulan 178219 - page 20

    20 IDLER PULLEYS MANDREL PULLEYS FIG. 24 TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 24) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL - • Remove mower from tractor (See “ TO REMOVE MOWER ” in this section of this manual). • Work belt off both mandrel pulleys ...

  • Poulan 178219 - page 21

    21 SER VICE AND ADJUSTMENTS TO ADJUST BRAKE (See Fig. 25) Your tractor is equipped with an adjustable brake system which is mounted on the side of the transaxle. If tractor requires more than six (6) feet stopping distance at high speed in highest gear on a level dry concrete or paved surface, then brake must be adjusted. • Depress clutch/brake p ...

  • Poulan 178219 - page 22

    22 TO START ENGINE WITH A WEAK BATTERY (See Fig. 29) CAUTION: Lead-acid batteries generate explosive gases. Keep sparks, flame and smoking materials away from bat- teries. Always wear eye protection when around batteries. FIG. 29 TO ADJUST STEERING WHEEL ALIGNMENT If steering wheel crossbars are not horizontal (left to right) when wheels are positi ...

  • Poulan 178219 - page 23

    23 SER VICE AND ADJUSTMENTS HOOD TO REPLACE HEADLIGHT BULB • Raise hood. • Pull bulb holder out of the hole in the backside of the grill. • Replace bulb in holder and push bulb holder securely back into the hole in the backside of the grill. • Close hood. INTERLOCKS AND RELAYS Loose or damaged wiring may cause your tractor to run poorly, st ...

  • Poulan 178219 - page 24

    24 ST ORA GE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. CAUTION: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure. TRA CT OR Remove mower from tr ...

  • Poulan 178219 - page 25

    25 Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “ CHOKED ” properly. 2. See “ TO START ENGINE ” in Operation section. 3. Engine flooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air filter. 5. Clean/replace air filter. 6. Dirty fuel filter. 6. Replace fuel filt ...

  • Poulan 178219 - page 26

    26 PROBLEM CAUSE CORRECTION Engine continues to run 1. Faulty operator-safety presence control system. 1. Check wiring, switches and connections. If not when operator leaves corrected, contact an authorized service center/ seat with attachment department. clutch engaged Poor cut - uneven 1. Worn, bent or loose blade. 1. Replace blade. Tighten blade ...

  • Poulan 178219 - page 27

    27 BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RED BLACK ORANGE BLACK BROWN BLACK BLACK BLACK STARTER M SEAT SWITCH (NOT OCCUPIED) GROUNDING CONNECTOR ATT'MENT CLUTCH (CLUTCH OFF) CLUTCH / BRAKE (PEDAL UP) SOLENOID BLACK LIGHTING SYSTEM OUTPUT 5 AMP AC @ 3600 ...

  • Poulan 178219 - page 28

    28 TRA CT OR - - MODEL NUMBER PR17H42STC ELECTRICAL 28 29 26 24 42 43 27 27 25 41 27 27 40 33 30 8 2 1 27 D .C . A M P E R E S 45 16 16 22 21 52 ...

  • Poulan 178219 - page 29

    29 TRA CT OR - - MODEL NUMBER PR17H42STC ELECTRICAL KEY P ART N O . NO . DESCRIPTION 1 144925 Battery 2 74760412 B o l t H e x H d 1 / 4 - 20unc X 3/4 8 156417 Case Battery Mech Hinge 1 6 153664 Switch Interlock Push-In 2 1 166181 Harness Socket Light 2 2 4152J Bulb, Light # 1156 2 4 4799J Cable Battery 2 5 146147 Cable Battery 6 Ga Red w/16 wire 2 ...

  • Poulan 178219 - page 30

    30 TRA CT OR - - MODEL NUMBER PR17H42STC CHASSIS 26 25 58 207 20 207 23 64 208 13 208 11 1 3 2 9 208 208 5 5 207 3 3 3 142 3 3 3 142 17 29 28 12 51 57 53 52 54 55 145 37 3 37 24 26 25 3 31 24 30 35 3 26 33 10 26 34 35 18 14 38 14 206 212 159 ...

  • Poulan 178219 - page 31

    31 TRA CT OR - - MODEL NUMBER PR17H42STC CHASSIS KEY P ART N O . NO . DESCRIPTION 1 174619 Chassis 2 176554 Drawbar 3 17060612 Screw 3/8-16 X .75 5 155272 Bumper Hood/Dash 9 168337X012 Dash P/L 1 0 72140608 B olt Carriage 3/8-16 x 1 1 1 155927 Panel Dash Lh 1 2 145660 C lip Tinnerman 1 3 172108 Panel Dash Rh 1 4 17490608 Screw Thdrol 3/8-16 x1/2 1 ...

  • Poulan 178219 - page 32

    32 TRA CT OR - - MODEL NUMBER PR17H42STC DRIVE 66 29 28 32 30 52 32 59 38 61 41 40 53 35 55 36 42 62 35 36 22 39 34 16 1 77 77 30 52 56 64 65 212 63 116 70 57 96 26 25 19 24 26 26 76 78 75 74 27 26 15 37 51 27 51 48 151 202 49 47 50 120 81 156 166 165 82 168 163 14 164 21 8 10 83 159 161 198 158 162 169 150 84 16 199 16 61 71 200 73 16 61 197 95 89 ...

  • Poulan 178219 - page 33

    33 TRA CT OR - - MODEL NUMBER PR17H42STC DRIVE KEY P ART N O . NO . DESCRIPTION KEY P ART N O . NO . DESCRIPTION 1 - - - - - - Transaxle Hydro Gear 314-0510 (Order Parts From Transaxle Manufacturer) 8 165619 Rod Shift Hydro LT 1 0 76020416 Pi n C otter 1/8 x 1 CAD 1 4 10040400 W asher Lock Hvy Helical 1 5 74490544 Bolt, Hex FLGHD 5/16-18 Gr. 5 1 6 ...

  • Poulan 178219 - page 34

    34 TRA CT OR - - MODEL NUMBER PR17H42STC STEERING ASSEMBLY 5 5 4 3 43 6 43 8 10 40 32 11 8 6 87 46 46 8 6 87 29 88 71 29 17 43 91 2 1 41 42 37 36 37 38 63 11 39 44 51 54 33 35 34 68 67 67 67 13 65 68 15 15 15 29 29 82 ...

  • Poulan 178219 - page 35

    35 TRA CT OR - - MODEL NUMBER PR17H42STC STEERING ASSEMBLY KEY P AR T N O . NO . DESCRIPTION 1 159944X428 Wheel Steering 2 172393 A x l e Asm Cast Iron LT 3 169840 S p i n d l e Asm LH 4 169839 S p i n d l e Asm RH 5 6266H Bearing Race Thrust Harden 6 121748X Washer 25/32 X 1-5/8 X 16 Ga 8 12000029 Ring Klip #t5304-75 10 175121 Link Drag 1 1 100406 ...

  • Poulan 178219 - page 36

    36 TRA CT OR - - MODEL NUMBER PR17H42STC SEAT ASSEMBLY 1 171683 Seat 2 140551 Bracket Pivot Seat 8 720 3 71110616 Bolt Fin Hex 3/8-16unc X 1 4 19131610 W asher 13/32 X 1 X 10 Ga 5 145006 Clip Push-In 6 73800600 N u t Hex w/Ins. 3/8-16 Unc 7 124181X Spring Seat Cprsn 2 250 Blk Zi 8 17000616 Screw 3/8-16 x 1.5 Smgml 9 19131614 W a s h e r 1 3 / 3 2 X ...

  • Poulan 178219 - page 37

    37 TRA CT OR - - MODEL NUMBER PR17H42STC DECALS NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm KE Y PART NO. N O. DESCRIPTION 6 2 1 5,8 4,10 3,9 11 7 WHEELS AND TIRES KEY P AR T N O . NO . DESCRIPTION KEY P AR T N O . NO . DESCRIPTION 10 3 16 9 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 170455 Tire F T 15 X 6 0 - 6 Service 4 ...

  • Poulan 178219 - page 38

    38 TRA CT OR - - MODEL NUMBER PR17H42STC ENGINE 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 44 46 32 31 33 37 33 40 62 13 4 72 78 81 3 16 78 23 45 14 38 ...

  • Poulan 178219 - page 39

    39 TRA CT OR - - MODEL NUMBER PR17H42STC ENGINE 1 170551 Control Th/ch Flag 2 17720410 Screw Hex Thd Cut 1/4-20x5/8 T 3 - - - - - - - - Engine, Briggs Model 311777 (Order Parts From Engine Manufacturer) 4 137352 M uffler 1 3 165291 Gasket Eng 1 4 148456 Tube Drain Oil Easy 1 6 11050600 Washer Lock Ext Tooth 3/8 2 3 169837 Shield Brn/Dbr Guard 2 9 1 ...

  • Poulan 178219 - page 40

    40 TRA CT OR - - MODEL NUMBER PR17H42STC MOWER DECK 15 14 13 11 10 9 8 16 68 37 30 31 32 33 146 148 145 150 45 144 147 147 142 149 142 49 50 51 54 52 53 55 56 34 1 46 44 21 22 24 25 26 27 2 28 29 23 21 21 21 18 18 20 2 48 59 19 4 3 5 6 21 40 143 36 40 37 40 159 152 151 153 154 157 158 67 153 156 155 113 117 116 118 119 114 115 112 121 114 117 119 1 ...

  • Poulan 178219 - page 41

    41 TRA CT OR - - MODEL NUMBER PR17H42STC MOWER DECK KEY P ART N O . NO . DESCRIPTION KEY P ART N O . NO . DESCRIPTION 1 165892 Mower Deck Assembly, 42" 2 72140506 Bolt 3 138017 Bracket Asm Fr. Sway Bar 3/42 4 165460X421 B racket Asm Deck 42" Sway Bar 5 4939M R etainer Spring 6 130832 A r m , S u s pension, Rear 8 850857 Bolt 3/8-24 x 25 G ...

  • Poulan 178219 - page 42

    42 TRA CT OR - - MODEL NUMBER PR17H42STC MOWER LIFT 36 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 23 24 25 27 28 29 30 50 26 37 41 40 38 12 11 31 32 31 32 19 19 13 13 13 13 49 ...

  • Poulan 178219 - page 43

    43 TRA CT OR - - MODEL NUMBER PR17H42STC MOWER LIFT 1 159460 W ire Asm Inner/Sprg W/plunger LT 2 159471 Shaft Asm Lift RH w/Inf 3 105767X Pin Groove 1 500 Zinc 4 12000002 E Ring #5133-62 5 19211621 W asher 21/32 X 1 X 21 Ga 6 120183X Bearing Nylon Blk 629 Id 7 125631X Grip Handle 8 170770 Button Plunger 1 1 139865 Link Lift LH Fixed Length 1 2 1398 ...

  • Poulan 178219 - page 44

    44 SER VICE NO TES ...

  • Poulan 178219 - page 45

    45 SER VICE NO TES ...

  • Poulan 178219 - page 46

    46 LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materials and workmanship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, without charge for parts or labor incurred in replacin ...

  • Poulan 178219 - page 47

    47 15 ° MAX. SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. CUT OUT ON DOTTED LINES THIS IS A 15 ° SLOPE SIGHTING GUIDE ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION Operate your Tractor up and down the face of slopes (not greater than 15 ° ), never across the face. Make turns gradu- ally to ...

  • Poulan 178219 - page 48

    Your POULAN PRO product has been expertly engineered and carefully manufactured to rigid quality standards. As with all mechanical products, some adjustments or part replacement may be necessary during the life of your unit. FOR SERVICE OR REPLACEMENT PARTS: 1. Consult your dealer/place of purchase. 2. Consult the yellow pages of your phone directo ...

Manufacturer Poulan Category Lawn Mower

Documents that we receive from a manufacturer of a Poulan 178219 can be divided into several groups. They are, among others:
- Poulan technical drawings
- 178219 manuals
- Poulan product data sheets
- information booklets
- or energy labels Poulan 178219
All of them are important, but the most important information from the point of view of use of the device are in the user manual Poulan 178219.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Poulan 178219, service manual, brief instructions and user manuals Poulan 178219. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Poulan 178219.

Similar manuals

A complete manual for the device Poulan 178219, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Poulan 178219 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Poulan 178219.

A complete Poulan manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Poulan 178219 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Poulan 178219, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Poulan 178219, that we can find in the current document
3. Tips how to use the basic functions of the device Poulan 178219 - which should help us in our first steps of using Poulan 178219
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Poulan 178219
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Poulan 178219 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Poulan 178219?

Use the form below

If you did not solve your problem by using a manual Poulan 178219, ask a question using the form below. If a user had a similar problem with Poulan 178219 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)