Manual LG Electronics LA120HPO

76 pages 13 mb
Download

Go to site of 76

Summary
  • LG Electronics LA120HPO - page 1

    LG Room Air Conditioner SERVICE MANUAL LG MODELS: LAN091CNP (ASNC091F2G0) LAU091CNP (ASUC091FUG0) LAN121CNP (ASNC121F2G0) LAU121CNP (ASUC121FUG0) LAN091HNP (ASNH091F2G0) LAU091HNP (ASUH091FUG0) LAN121HNP (ASNH121F2G0) LAU121HNP (ASUH121FUG0) LA090CPI (ASNC091F2G0) LA090CPO (ASUC091FUG0) LA120CPI (ASNC091F2G0) LA120CPO (ASUC091FUG0) LA090HPI (ASNH09 ...

  • LG Electronics LA120HPO - page 2

    2 Room Air Conditioner Air Conditioner Ser vice Manual T ABLE OF CONTENTS Safety Precautions ........................................................................................................................................................... 3 Dimensions ........................................................................................ ...

  • LG Electronics LA120HPO - page 3

    Ser vice Manual 3 Saf ety Precautions Safety Precautions T o pre v ent injur y to the user or other people and proper ty damage, the f ollowing instructions must be f ollow ed. ■ Incorrect operation due to ignoring instruction will cause har m or damage. The seriousness is classified by the f ollo wing indications. ■ Meanings of symbols used in ...

  • LG Electronics LA120HPO - page 4

    4 Room Air Conditioner Saf ety Precautions ■ Operation Be cautious when unpacking and installing the product. • Sharp edges could cause injur y . Be especially careful of the case edges and the fins on the con- denser and e vapor ator . For installation, alwa ys contact the dealer or an A uthorized Service Center . • There is risk of fire, el ...

  • LG Electronics LA120HPO - page 5

    Ser vice Manual 5 Saf ety Precautions Use a dedicated outlet for this appliance. • There is risk of fire or electr ical shock. Grasp the plug to remove the cord fr om the outlet. Do not touch it with wet hands. • There is risk of fire or electr ical shock. Do not place a heater or other appliances near the power cab le . • There is risk of fi ...

  • LG Electronics LA120HPO - page 6

    6 Room Air Conditioner Saf ety Precautions ■ Installation Do not open the inlet grill of the product during operation. (Do not touch the electr ostatic filter , if the unit is so equipped.) • There is risk of physical injury , electric shock, or product f ailure. When the product is soaked (flooded or submerged), contact an A uthorized Ser vice ...

  • LG Electronics LA120HPO - page 7

    Ser vice Manual 7 Saf ety Precautions ■ Operation Do not install the product where the noise or hot air from the out- door unit could damage the neighborhoods. • It ma y cause a problem f or your neighbors. Use two or more people to lift and transport the air conditioner . • A void personal injury . Do not install the product where it will be ...

  • LG Electronics LA120HPO - page 8

    8 Room Air Conditioner Alwa ys insert the filter securely . Clean the filter every tw o weeks or more often if necessary . • A dir ty filter reduces the efficiency of the air conditioner and could cause product malfunction or dam- age. Do not insert hands or other objects through the air inlet or outlet while the air conditioner is plugged in. ? ...

  • LG Electronics LA120HPO - page 9

    Ser vice Manual 9 Dimensions Dimensions Indoor Unit This symbol aler ts y ou to the risk of electric shock. This symbol aler ts y ou to hazards that could cause harm to the air conditioner . This symbol indicates special notes. NOTICE Symbols Used in this Manual Pipe Hole Fix Hole Hanger Hole H W D W mm(inch) 600(23.6) H mm(inch) 600(23.6) D mm(inc ...

  • LG Electronics LA120HPO - page 10

    10 Room Air Conditioner Dimensions Outdoor Unit W L2 L3 L1 D H L4 L5 Gas side (3-way valve) Liquid side (2-way valve) MODEL 9k, 12k Models DIM unit W mm 770(30.3) H mm 540(21.3) D mm 245(9.6) L1 mm 285(11.2) L2 mm 64(2.5) L3 mm 518(20.4) L4 mm 10(0.4) L5 mm 100(3.9) ...

  • LG Electronics LA120HPO - page 11

    Ser vice Manual 11 Product Specifications Pr oduct Specifications Models Cooling Capacity kW (Min~Rating~Max) Btu/h Heating Capacity kW (Min~Rating~Max) Btu/h Power Input Cooling/Heating W Running Current Cooling/Heating A Starting Current Cooling/Heating A EER W/W Btu/h.W COP W/W Power Supply Ø / V / Hz Power Factor % Air Flow Rate Indoor,Max m 3 ...

  • LG Electronics LA120HPO - page 12

    12 Room Air Conditioner Installation Installation Installation P ar ts Installation T ools Read carefully, and then follow step by step. Type "A" screw and plastic anchor Type "B" screw Remote control holder Installation guide map Figure Figure Name Screw driver Electric drill Measuring tape, Knife Hole core drill Spanner Torque ...

  • LG Electronics LA120HPO - page 13

    Ser vice Manual 13 Installation Map Installation parts you should purchase. NOTICE (Left and right are identical) More than 28"(70cm) More than 23.6"(60cm) Sleeve Bushing-Sleeve Putty(Gum Type Sealer) Vinyl tape (Wide) • To carry out the drainage test, remove the air filter and pour water into the heat exchanger. • Apply after carryin ...

  • LG Electronics LA120HPO - page 14

    14 Room Air Conditioner 1. Check the quality label on the indoor and outdoor unit. 2. Make certain that the refr igerant is R-410A. THIS PRODUCT CONT AINS R-410A REFRIGERANT 1) Diff erent compressor oil - R-410A(P olyol ester) / R-22(Mineral). - Do not mix the e xisting mineral oil. - Do not apply used pipe, tools and gauges co vered with the e xis ...

  • LG Electronics LA120HPO - page 15

    Ser vice Manual 15 Indoor unit 1. Do not hav e any heat or steam near the unit. 2. Select a place where there are no obstacles in front of the unit. 3. Make sure that condensation dr ainage can be conv e- niently routed aw a y . 4. Do not install near a doorwa y . 5. Ensure that the inter v al between a wall and the left (or right) of the unit is m ...

  • LG Electronics LA120HPO - page 16

    16 Room Air Conditioner Piping Length and Elev ation Outdoor unit Indoor unit A B Outdoor unit Indoor unit A B A Oil trap Outdoor unit Indoor unit B If piping length is more than 16.4ft(5m) CA UTION: Capacity is based on standard length and maxim um allowance length is on the basis of reliability . Oil trap should be installed every 16.4~23feets (5 ...

  • LG Electronics LA120HPO - page 17

    Ser vice Manual 17 Installation Preparing W ork f or Installation Open panel front 1. Pull the upper par t of the front panel. 2. Lift up the panel. 3. T o detach the front panel, remov e the two scre ws at the lower par t. 4. Detach the front panel from the body . 5. T o detach the panel, disconnect the connector at the upper par t. Cover pipe and ...

  • LG Electronics LA120HPO - page 18

    18 Room Air Conditioner Installation Fixing Indoor Unit • Drill the piping hole with a ø 50mm hole core drill. Drill the piping hole at either the r ight or the left with the hole slightly slanted to the outdoor side. Drill a Hole in the W all 5-7mm (0.2~0.3") Indoor WALL Outdoor Plastic anchors INST ALLA TION GUIDE MAP 10mm INST ALLA TION ...

  • LG Electronics LA120HPO - page 19

    Ser vice Manual 19 Flaring work and connection of piping Flaring w ork and connection of piping Flaring W ork Main cause f or gas leakage is due to def ect in flaring wor k. Carr y out correct flaring work in the follo wing procedure. Cutting the pipes and the cable. 1. Use the piping kit accessor y or the pipes purchased locally . 2. Measure the d ...

  • LG Electronics LA120HPO - page 20

    20 Room Air Conditioner Flaring work and connection of piping Check 1. Compare the flared work with the figure by . 2. If a flared section is def ective , cut it off and do flaring work again. Indoor Preparing the indoor unit's piping and drain hose f or installation through the wall. CA UTION: If the drain hose is routed inside the r oom, ins ...

  • LG Electronics LA120HPO - page 21

    Ser vice Manual 21 Connecting the piping with the indoor unit and drain hose with drain pipe 1. Align the center of the pipings and sufficiently tighten the flare nut b y hand. 2. Tighten the flare nut with a wrench. 3. When e xtending the drain hose at the indoor unit, install the drain pipe . Wrap the insulation material around the connecting por ...

  • LG Electronics LA120HPO - page 22

    22 Room Air Conditioner Flaring work and connection of piping CA UTION: Installation Information For right piping. Follow the instruction belo w . Good case • Press on the upper side of clamp and unf old the tubing to downward slo wly . Bad case • F ollowing bending type from left to right may cause damage to the turbing. ...

  • LG Electronics LA120HPO - page 23

    Ser vice Manual 23 Flaring work and connection of piping Put a couple drops of refrigerant oil on the f ace of the flare bef ore assembling taking care not to add any contaminants . Align the center of the pipings and sufficiently tighten the flare nut b y hand. Finally , tighten the flare nut with torque wrench until the wrench clicks . • When t ...

  • LG Electronics LA120HPO - page 24

    24 Room Air Conditioner Connecting the cable betw een indoor unit and outdoor unit Connecting the cable between indoor unit and outdoor unit Connecting the Cables 1. Remov e the cover control from the unit b y loosening the screw . 2. Dismount caps on the conduit panel. 3. T emporarily mount the conduit tubes on the conduit panel. 4. Properly conne ...

  • LG Electronics LA120HPO - page 25

    Ser vice Manual 25 Connecting the cable betw een indoor unit and outdoor unit Connection method of the connecting cable(Example) 1. Dismount two-caps on the conduit panel. 2. Make a hole appropriate f or the passage of connec- tion cable through on cap b y tool. (for lo w voltage line) 3. P ass the connecting cable through the hole. 4. Properly con ...

  • LG Electronics LA120HPO - page 26

    26 Room Air Conditioner Connecting the cable betw een indoor unit and outdoor unit After the confirmation of the above conditions, prepare the wiring as follows: 1) Never fail to have an individual power circuit specifically for the air conditioner. As for the method of wiring, be guided by the circuit diagram posted on the inside of control cover. ...

  • LG Electronics LA120HPO - page 27

    Ser vice Manual 27 Checking the dr ainage and f or ming the pipings Chec king the drainage and f orming the pipings Chec king the Drainage T o chec k the drainage . 1. P our a glass of water on the e v aporator . 2. Ensure the water flo ws through the drain hose of the indoor unit without any leakage and goes out the drain e xit. Drain piping 1. Th ...

  • LG Electronics LA120HPO - page 28

    28 Room Air Conditioner Checking the dr ainage and f or ming the pipings Forming the Piping Form the piping by wrapping the connect- ing portion of the indoor unit with insula- tion material and secure it with two kinds of vinyl tapes. • If y ou want to connect an additional drain hose , the end of the drain outlet should be routed abo ve the gro ...

  • LG Electronics LA120HPO - page 29

    Ser vice Manual 29 Air purgingd AIR PURGING Air Purging Air purging The air and moisture remaining in the refrigerant system hav e undesirable eff ects as indicated below . 1. Pressure in the system rises. 2. Operating current rises. 3. Cooling(or heating) efficiency drops. 4. Moisture in the refrigerant circuit ma y freeze and b lock capillary tub ...

  • LG Electronics LA120HPO - page 30

    30 Room Air Conditioner Air purgingd Soap water method 1. Remov e the caps from the 2-wa y and 3-w ay v alv es. 2. Remov e the ser vice-por t cap from the 3-wa y valv e. 3. T o open the 2-wa y v alve turn the valv e stem counterclock- wise appro ximately 90 ° , wait f or about 2~3 sec, and close it. 4. Apply a soap water or a liquid neutr al deter ...

  • LG Electronics LA120HPO - page 31

    Ser vice Manual 31 Air purgingd Charging ■ Each outdoor unit is factory charged (nameplate charge) for the evaporator as well as a 7.5m(25ft) line set. Any time a line set is used either shorter or longer then the nominal 7.5m(25ft) line set length the refrigerant charge has to be adjusted. ■ Whether the line set is made shorter or longer you m ...

  • LG Electronics LA120HPO - page 32

    32 Room Air Conditioner Air purgingd 1. Fir st, Check the side co ver assembl y exactl y , and fix the power cor d in the bottom groo ve of cover side left. 2. Assemble connecting lead wire with controller , fix the upper par t of panel front, and matc h the lower part of panel front. 3. Scre w up panel front, and suspend the hook of panel front in ...

  • LG Electronics LA120HPO - page 33

    Ser vice Manual 33 T est running TEST R UNNING R-410A 95 ° F(35 ° C) 8.5~9.5kg/cm 2 G(120~135 P.S.I.G.) Outside ambient TEMP. Refrigerant The pressure of the gas side service valve. 1. Check that all tubing and wiring are properly connected. 2. Check that the gas and liquid side service valv es are fully open. Prepare remote controller 1. Remov e ...

  • LG Electronics LA120HPO - page 34

    34 Room Air Conditioner T est running If the actual pressure is higher than shown, the system is most lik ely ov er-charged, and charge should be remov ed. If the actual pressure are lower than shown, the system is most lik ely undercharged, and charge should be added. NOTICE PUMP DO WN This is performed when the unit is relocated or the refrigeran ...

  • LG Electronics LA120HPO - page 35

    Ser vice Manual 35 Ho w to replace picture & photograph How to replace picture & photog raph 1 . T ur n off power and then open the upper par t of front panel. 2 . Pull out the both links of low er par t of front panel, as described in the below picture. 3 . Push and close the top par t of the front panel and then pull the bottom par t of t ...

  • LG Electronics LA120HPO - page 36

    36 Room Air Conditioner Operation Operation Indoor Unit Operation ON/OFF by Remote controller Sensing the Room Temperature Room temperature control Starting Current Control Time Delay Safety Control Indoor Fan Speed Control Operation indication Lamps (LED) Healthy Dehumidification Mode Sleep Mode Auto Control Auto Air Control by the unit electronic ...

  • LG Electronics LA120HPO - page 37

    Ser vice Manual 37 The function of main contr ol INTAKE AIR TEMP. SETTING TEMP. +1 ° F (Compressor ON) SETTING TEMP. -1 ° F (Compressor OFF) Setting fan speed Setting fan speed More than 3 minutes More than 3 minutes Setting fan speed COMPRESSOR ON OFF ON OFF ON INDOOR FAN SPEED Low Low ■ Protection of the indoor heat exchanger from frosting ? ...

  • LG Electronics LA120HPO - page 38

    38 Room Air Conditioner . A uto Operation (Electronic contr ol mode) • The operation procedure is shown below. (Cooling & Heating Model) ❋ If initial mode is decided, that mode is continued without the room temperature changing. ■ Auto Operation for Cooling Press Start/Stop Button Select Auto Operation Mode Check the Room temperature Oper ...

  • LG Electronics LA120HPO - page 39

    Ser vice Manual 39 Operation ■ Auto Operation for Dehumidification(only Heating Model) • The Setting temperature will be same that of the auto operation for cooling. - Compressor ON temperature; Setting temperature +2 ° F - Compressor OFF temperature; Setting temperture -1 ° F ■ Auto Operation for Heating(only Heating Model) - Compressor ON ...

  • LG Electronics LA120HPO - page 40

    40 Room Air Conditioner Operation 6. Heating Operation Mode(only Heating Model) The unit will operate according to the setting conditions by the remote controller. The operation diagram is shown below. INTAKE AIR TEMP. SETTING TEMP. + 6 ° F (Compressor OFF) SETTING TEMP. (Compressor ON) Selecting fan speed Selecting fan speed A B A minimum 10sec. ...

  • LG Electronics LA120HPO - page 41

    Ser vice Manual 41 7. Cooling or Heating Mode with Sleep Mode A uto Control • When selecting the Cooling( ) or the Heating( ) combined with the Sleep Mode Auto Control( ), the operation diagram is as following. ■ Cooling Mode with the Sleep Mode • The setting temperature will be automatically raised by 2 ° F 30 minutes later and by 4 ° F 1 ...

  • LG Electronics LA120HPO - page 42

    42 Room Air Conditioner 8. Forced Operation Operation procedures when the remote control can't be used. The operation will be started if the power button is pressed. If you want to stop operation, re-press the button. Operation 9. A uto restar t In case the power comes on again after a power failure, Auto Restarting Operation is the function t ...

  • LG Electronics LA120HPO - page 43

    Ser vice Manual 43 Operation Displa y Function Self-diagnosis Function Signal Receptor Receives the signals from the remote control.(Signal receiving sound: two short beeps or one long beep.) Operation Indication Lamps On/Off : Lights up during the system operation. 3sec 3sec 3sec (once) 3sec 3sec (twice) 3sec (5times) Error Code 1 2 5 Error LED (I ...

  • LG Electronics LA120HPO - page 44

    44 Room Air Conditioner Operation Controls ON OFF CANCEL SET ° C/ ° F AUT O CLEAN 1 3 5 4 9 10 12 18 16 7 2 8 13 15 11 6 Cooling Operation Auto Operation or Auto Changeover Healthy Dehumidification Operation Flip-up door (opened) Heating Operation Signal transmitter • Cooling Model( ), Heat Pump Model( ) 17 Operation Mode 14 The controls will l ...

  • LG Electronics LA120HPO - page 45

    Ser vice Manual 45 Disassembl y Disassembly Indoor Unit W ARNING: Disconnect the unit from power suppl y before making an y chec ks. Be sure the power s witch is set to "OFF" 1. To remove the Grille from the Chassis. - Pull the grille bottom, the remove 2 securing screws. - Lift the both lower parts of panel front. - After pull down this ...

  • LG Electronics LA120HPO - page 46

    46 Room Air Conditioner Disassembly 3. To remove the Evaporator. - Remove hole tubing holde. - Remove 2 screws securing the evaporator. - Pull the evaporator out from the chassis carefully. 4. Before removing the Turbo Fan. - Remove the securing screws from the chassis. - Pull the pipe, top cover and the air guide. 5. To remove the Motor. - Remove ...

  • LG Electronics LA120HPO - page 47

    Ser vice Manual 47 Schematic Diagram Schematic Dia gram Heat Pump/Cooling Only Series(Indoor Unit) ...

  • LG Electronics LA120HPO - page 48

    48 Room Air Conditioner Schematic Diagram Heat Pump Series/ Cooling Only Series (Outdoor Unit) ...

  • LG Electronics LA120HPO - page 49

    Ser vice Manual 49 Schematic Diagram INDOOR UNIT P .W .B. ASSEMBL Y • P/No.: 6871A20999A (PCB ASSEMBL Y , MAIN) T op Vie w Bottom View ...

  • LG Electronics LA120HPO - page 50

    50 Room Air Conditioner Schematic Diagram • P/No.: 6871A20901C (PCB ASSEMBL Y , MAIN) OUTDOOR UNIT P .W .B. ASSEMBL Y T op Vie w Bottom View ...

  • LG Electronics LA120HPO - page 51

    Ser vice Manual 51 Schematic Diagram DISPLA Y P .W .B. ASM • P/No.: 6871A20921A (PCB ASSEMBL Y) ...

  • LG Electronics LA120HPO - page 52

    52 Room Air Conditioner Schematic Diagram Wiring Diagram (1) Indoor Unit (Cooling Only Models, & Heating Models) ...

  • LG Electronics LA120HPO - page 53

    Ser vice Manual 53 Schematic Diagram (2) Outdoor Unit(Cooling Only Models, & Heating Models) ...

  • LG Electronics LA120HPO - page 54

    54 Room Air Conditioner T roubleshooting Guide T r oubleshooting Guide Refrigeration Cycle Dia gram INDOOR UNIT OUTDOOR UNIT INDOOR UNIT OUTDOOR UNIT HEAT EXCHANGE (EVAPORATOR) HEAT EXCHANGE (EVAPORATOR) HEAT EXCHANGE (CONDENSER) HEAT EXCHANGE (CONDENSER) COMPRESSOR COMPRESSOR GAS SIDE GAS SIDE LIQUID SIDE LIQUID SIDE CAPILLARY TUBE CAPILLARY TUBE ...

  • LG Electronics LA120HPO - page 55

    Ser vice Manual 55 T roubleshooting Guide Piping Length and Elev ation Outdoor unit Indoor unit A B Outdoor unit Indoor unit A B A Oil trap Outdoor unit Indoor unit B If piping length is more than 16.4ft(5m) CA UTION: Capacity is based on standard length and maxim um allowance length is on the basis of reliability . Oil trap should be installed eve ...

  • LG Electronics LA120HPO - page 56

    56 Room Air Conditioner T roubleshooting Guide Pumping Down 3-wa y V alve • Procedure (1) Confirm that both liquid side and gas side valves are set to the open position. – Remove the valve stem caps and confirm that the valve stems are in the raised position. – Be sure to use a hexagonal wrench to operate the valve stems. (2) Operate the unit ...

  • LG Electronics LA120HPO - page 57

    Ser vice Manual 57 T roubleshooting Guide 1) Re-air purging (Re-installation) • Procedure (1) Confirm that both the liquid side valve and the gas side valve are set to the closed position. (2) Connect the charge set and a gas cylinder to the service port of the Gas side valve. – Leave the valve on the gas cylinder closed. (3) Air purging. – O ...

  • LG Electronics LA120HPO - page 58

    58 Room Air Conditioner T roubleshooting Guide 2) Balance refrigerant of the 3-way v alve (Gas leakage) • Procedure (1) Confirm that both the liquid side and gas side valves are set to the back seat. (2) Connect the charge set to the 3-way valve ’ s port. – Leave the valve on the charge set closed. – Connect the charge hose to the service p ...

  • LG Electronics LA120HPO - page 59

    Ser vice Manual 59 T roubleshooting Guide 2. Ev acuation (All amount of refrigerant leaked) • Procedure (1) Connect the vacuum pump to the center hose of charge set center hose (2) Evacuation for approximately one hour. – Confirm that the gauge needle has moved toward -76 cmHg (vacuum of 4 mmHg or less). (3) Close the valve (Lo side) on the cha ...

  • LG Electronics LA120HPO - page 60

    60 Room Air Conditioner T roubleshooting Guide 3. Gas Charging (After Evacuation) • Procedure (1) Connect the charge hose to the charging cylinder. – Connect the charge hose which you dis-con- nected from the vacuum pump to the valve at the bottom of the cylinder. – If you are using a gas cylinder, also use a scale and reverse the cylinder so ...

  • LG Electronics LA120HPO - page 61

    Ser vice Manual 61 T roubleshooting Guide Additional gas c harging (Gas leakage) • When refrigerant is insufficient by leakage, recharge the unit with the refrigerant up to normal operating suc- tion pressure. • Use the graph or the equation below to get operating suction pressure according to indoor and outdoor tem- perature. Suction pressure ...

  • LG Electronics LA120HPO - page 62

    62 Room Air Conditioner T roubleshooting Guide Cyc le P ar ts T roub le analysis 1. Check temperature difference between intake and discharge air and operating current. Temp. Difference Temp. difference : approx. 0 ˚ F(0 ° C) Current : less than 80% of rated current Temp. difference : approx. 14 ° F(8 ° C) Current : less than 80% of rated curre ...

  • LG Electronics LA120HPO - page 63

    Ser vice Manual 63 T roubleshooting Guide Electr onic P ar ts (9k model) Pr oduct does not operate at all. (* Refer to Electr onic Control De vice drawing and Sc hematic diagram.) Turn off Main Power Turn on Main Power Does "beeping" sound is made from the Indoor Unit? Primarily, the operating condition of Micom is OK. Check the voltage o ...

  • LG Electronics LA120HPO - page 64

    64 Room Air Conditioner T roubleshooting Guide The pr oduct is not operate with the remote controller . Turn on Main Power While the compressor has been stopped, the compressor does not operate owing to the delaying function for 3 minutes after stopped. Caused by other parts except the remote controller Cause by the remote controller When the mark( ...

  • LG Electronics LA120HPO - page 65

    Ser vice Manual 65 T roubleshooting Guide Compressor/Outdoor F an are unable to drive. Turn on Main Power Operate "Cooling Mode( )" by setting the desired temperature of the remote controller is less than one of the indoor temperature by 2 ° F at least. When in Fan Mode, Compressor/Outdoor Fan is stopped. Check the sensor for indoor temp ...

  • LG Electronics LA120HPO - page 66

    66 Room Air Conditioner T roubleshooting Guide When indoor F an does not operate . Check connecting condition of the CN-MOTOR CON- NECTOR Does the voltage of terminal of CN-DC/DC CONNECTOR in Indoor unit corresponds to the values in the table of page 72 Do the voltage of terminal of CN-DC/DC CONNECTOR in Outdoor unit corresponds to the values in th ...

  • LG Electronics LA120HPO - page 67

    Ser vice Manual 67 T roubleshooting Guide When V ertical Louver does not operate . • Confirm that the Vertical Louver is normally geared with the shaft of Stepping Motor. • If the regular torque is detected when rotating the Vertical Louver with hands Normal • Check the connecting condition of CN-UP/DOWN Connector • Check the soldering cond ...

  • LG Electronics LA120HPO - page 68

    68 Room Air Conditioner T roubleshooting Guide • The operation indicator of Indoor unit blinks five times. • The red indicator of Outdoor unit blinks five times. Check the connecting wires between Indoor and Outdoor unit for the connecting error and the contacting condition. Check the installation condition of outdoor unit. Check for the commun ...

  • LG Electronics LA120HPO - page 69

    Ser vice Manual 69 T roubleshooting Guide The phenomena in case of connecting err or INDOOR UNIT Connector Type Condition Open and connecting error Open Open Open Open Short between terminals ( and ) of ROOM-TH. Short between terminals ( and ) of PIPE-TH. Short between terminals • The same as the phenomenon of Outdoor Unit. • The up/down vane d ...

  • LG Electronics LA120HPO - page 70

    70 Room Air Conditioner T roubleshooting Guide OUTDOOR UNIT Connector Type Condition OPEN • PWB pattern is damaged when applying the power. Connecting reversely Connecting reversely OPEN OPEN OPEN OPEN Connecting error ( ) Connecting error ( ) Connecting error ( ) Connecting error ( ) Connecting error ( ) Connecting error ( ) • All functions st ...

  • LG Electronics LA120HPO - page 71

    Ser vice Manual 71 V oltage of Connectors accor ding to Indoor Fan Speed 1 2 3 4 1 3 4 1 2 3 4 5 INDOOR FAN MOTOR INDOOR PWB ASSY Connecting wires between Indoor and Outdoor Indoor Connecting Terminal Outdoor Connecting Terminal Input Power TAB-N CN-MOTOR CN-DC/DC RY-COMP-A 3 4 RY-COMP-B BL BK BR RD 4 3 2 1 CN-DC/DC BL BK BR RD + - S-Hi Hi Med Low ...

  • LG Electronics LA120HPO - page 72

    72 Room Air Conditioner Exploded View Exploded Vie w 352150 35211B 354210 135515 131410 146811-1 135316 145200-2 145200-4 145200-1 W49800 268711-1 152302 268711-4 135500-2 145200 146811-2 135500-1 266090 268711-3 249951 159830 330870 267110 349600 346810 359012 352380 147581 146811-1 135080 567480-1 INLET AIR + EVA MIDDLE Indoor Unit NOTE) * Please ...

  • LG Electronics LA120HPO - page 73

    Ser vice Manual 73 Exploded View 550140 554160 567502 552113 437211 435301 447910 W6640 559010 346811 549610 554031 430410 552203-1 552203-2 437212 435511 649950 W0CZZ 567480-4 268711-6 552202 552116 566000 567480-6 SUCTION 2. Outdoor Unit NOTE) * Please ensure GCSC since the replacement parts may be changed demending upon the buyer's request. ...

  • LG Electronics LA120HPO - page 74

    74 Room Air Conditioner Replacement P ar ts List Replacement P ar ts List P ar ts List(Indoor) NOTE) * Please ensure GCSC since the replacement parts may be changed demending upon the buyer's request. Please check the correct parts in View RPL(Replacement Part List)on GCSC. (GCSC Website http://biz.Lgservice.com) DESCRIPTION LOCATION No. REMAR ...

  • LG Electronics LA120HPO - page 75

    Ser vice Manual 75 Replacement P ar ts List P ar ts List(Outdoor) NOTE) * Please ensure GCSC since the replacement parts may be changed demending upon the buyer's request. Please check the correct parts in View RPL(Replacement Part List)on GCSC. (GCSC Website http://biz.Lgservice.com) DESCRIPTION LOCATION No. REMARKS PART No. LAU091CNP LAU091H ...

  • LG Electronics LA120HPO - page 76

    P/No.: 3828A20926C December, 2006 Printed in Korea ...

Manufacturer LG Electronics Category Air Conditioner

Documents that we receive from a manufacturer of a LG Electronics LA120HPO can be divided into several groups. They are, among others:
- LG Electronics technical drawings
- LA120HPO manuals
- LG Electronics product data sheets
- information booklets
- or energy labels LG Electronics LA120HPO
All of them are important, but the most important information from the point of view of use of the device are in the user manual LG Electronics LA120HPO.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals LG Electronics LA120HPO, service manual, brief instructions and user manuals LG Electronics LA120HPO. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product LG Electronics LA120HPO.

A complete manual for the device LG Electronics LA120HPO, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use LG Electronics LA120HPO by users. Manuals are usually written by a technical writer, but in a language understandable to all users of LG Electronics LA120HPO.

A complete LG Electronics manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual LG Electronics LA120HPO - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the LG Electronics LA120HPO, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the LG Electronics LA120HPO, that we can find in the current document
3. Tips how to use the basic functions of the device LG Electronics LA120HPO - which should help us in our first steps of using LG Electronics LA120HPO
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with LG Electronics LA120HPO
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of LG Electronics LA120HPO in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning LG Electronics LA120HPO?

Use the form below

If you did not solve your problem by using a manual LG Electronics LA120HPO, ask a question using the form below. If a user had a similar problem with LG Electronics LA120HPO it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)