English dropdown-ico

Manual United States Stove VFZC32N

32 pages 0.48 mb
Download

Go to site of 32

Summary
  • United States Stove VFZC32N - page 1

    C O M P A N Y U N I T E D S T A T E S S T O V E C S S U Models VFZC32N, VFZC32L V ent-Free Zero-Clearance Gas Fireplace United States Stove Company 851301 3/98 WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury, or loss of life. ~Do not store or use gasoline or ...

  • United States Stove VFZC32N - page 2

    2 TABLE OF CONTENTS IMPORTANT: Read this owner's manual carefully and completely before trying to assemble, operate, or service this fireplace. Improper use of this fireplace can cause serious injury or death from burns, fire, explosion, electrical shock, and carbon poi- soning. WARNINGS/SAFETY INFORMATION Install and use fireplace with care. ...

  • United States Stove VFZC32N - page 3

    WARNING: Any change to this heater or its controls can be dangerous. 1. This heater shall not be installed in a bedroom or bathroom. 2. Never install the fireplace * in a recreational vehicle * where curtains, furniture, clothing, or other flammable objects are less than 36 inches from the front, top, or side of the fireplace * in high traffic area ...

  • United States Stove VFZC32N - page 4

    4 WARNINGS/SAFETY INFORMATION CONTINUED 17. CARBON MONOXIDE POISONING: Early signs of carbon monoxide poisoning are similar to the flu with headaches, dizziness and/or nausea. If you have these signs, obtain fresh air immediately. Have the heater serviced as it may not be operating properly. 18. This vent-free gas fireplace is intended to be smokel ...

  • United States Stove VFZC32N - page 5

    5 VFZC32 SPECIFICATIONS, CONTINUED... FIREBOX TOP VIEW FIREBOX FRONT VIEW FIREBOX SIDE VIEW ...

  • United States Stove VFZC32N - page 6

    6 PRODUCT FEATURES AIR FOR COMBUSTION AND VENTILATION This fireplace shall not be installed in a confined space unless provisions are provided for adequate combustion and ventilation air. Read the following instructions to insure proper fresh air for this and other fuel-burning appliances in your home. WARNING Today's homes are built more ener ...

  • United States Stove VFZC32N - page 7

    7 AIR FOR COMBUSTION AND VENTILATION CONTINUED Providing adequate ventilation The following is excerpts from National Fuel Gas Code. NFPA 54/ANSI Z223.1, Section 5.3, Air for Combustion and Ventilation. All spaces in homes fall into one of the three following ventilation classifications: 1. Unusually Tight Construction; 2. Unconfined Space; 3. Conf ...

  • United States Stove VFZC32N - page 8

    8 AIR FOR COMBUSTION AND VENTILATION CONTINUED Determining if You Have a Confined or Unconfined Space Use this worksheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install the firebox plus any adjoining rooms with doorless passageways or ventilation grills between the rooms. 1. Determine the ...

  • United States Stove VFZC32N - page 9

    9 AIR FOR COMBUSTION AND VENTILATION CONTINUED B. Vent room directly to the outdoors. See Ventilation Air from Outdoors , page 10. C. Install a lower BTU/Hr firebox, if lower BTU/Hr size makes room unconfined. If the actual BTU/Hr used is less than the maximum BTU/Hr the space can support, the space is an unconfined space. You will need no addition ...

  • United States Stove VFZC32N - page 10

    10 AIR FOR COMBUSTION AND VENTILATION CONTINUED Ventilation Air From Outdoors Provide extra fresh air by using ventilation grills or ducts. You must provide two permanent openings: one within 12" of the ceiling and one within 12" of the floor. Connect these items directly to the outdoors or spaces open to the outdoors. These spaces includ ...

  • United States Stove VFZC32N - page 11

    11 INSTALLATION CONTINUED 42" NOTE: CLEARANCES ARE THE SAME IF USING OPTIONAL CABINET MANTELS OR BUILT-IN INSTALLATION. Figure 3 - Minimum Clearance to Wall and Ceiling Mantel Clearances for Built-in Installation If placing custom mantel above built-in fireplace, you must meet minimum clearance between mantel shelf and top of fireplace opening ...

  • United States Stove VFZC32N - page 12

    12 INSTALLATION CONTINUED Installing the Fireplace Screen. 1. Insert each rod through the rings located at the top of the screen. NOTE: Before placing the last ring over the rod, slide the tinnerman clip (included in the parts bag) onto the rod and then slide the last ring over the rod. ( See Figure 5 ) 2. Insert the right screen and rod into the h ...

  • United States Stove VFZC32N - page 13

    13 INSTALLATION CONTINUED 1. Before installing the firebrick panels you must first remove the brick brackets. A 5/16" nut driver will be required. ( See Figure 7a & b, below for location ) 2. Carefully remove the firebrick panels from their box. 3. Decide which side of the firebox you want the gas line to enter and knock out the appropriat ...

  • United States Stove VFZC32N - page 14

    GAS CONNECTION CAUTION Use new black iron or steel pipe only. Internally tinned copper tubing can be used in some areas when permitted by local codes. Only use pipe of 1/2" or greater diameter to allow full gas volume to heater. Excessive pressure loss will occur if the pipe is too small. A manual shutoff valve, union and plugged 1/8" NPT ...

  • United States Stove VFZC32N - page 15

    Control Valve Control Bracket (Rightside view facing heater) Test Pressure Input Test Pressure Output GAS CONNECTION, CONTINUED... GAS PRESSURE CHECK 15 The gas inlet connection is 3/8" NPT, made at the rear of the main control. This unit comes with an 18" gas flex pipe attached to the control valve at the factory. Run gas line into fireb ...

  • United States Stove VFZC32N - page 16

    MANTEL INSTALLATION This fireplace may be installed using the cabinet mantel with hearth base accessory against a wall in your home. You must use one of the Satin Black or Polished BrassTrim Kits available when installing your fireplace with the optional mantel kit. ( See Accessories on page 28 & 29 ). NOTE: The Trim Kits provide a finished app ...

  • United States Stove VFZC32N - page 17

    MANTEL INSTALLATION CONTINUED Figure 12 - Installing Firebox on Hearth Base 7. Place the Cabinet Mantel Legs on Hearth Base and slide each side firmly up against the unit ( See Figure 13 ). NOTE: The Cabinet Mantel Legs and Hearth Base should be against the wall. 8. Lower the header into the slots at the top of each leg, using four 1-1/4" scre ...

  • United States Stove VFZC32N - page 18

    Figure 15 - Rough Opening for Installing in Wall MANTEL INSTALLATION CONTINUED 9. Lower Mantel top onto legs and header to com- plete installation of mantel. Built-in Fireplace Installation. Height Front Width Depth Model # Actual Framing Actual Framing Actual Framing VFZC32 35" 35-1/4" 35-3/8" 35-1/2" 17-3/8" 18" Buil ...

  • United States Stove VFZC32N - page 19

    BUILT-IN INSTALLATION CONTINUED If installing in a corner, use the dimensions shown in Figure 16 below for the rough opening. The height is 35", which is the same as the wall opening in Figure 15, page 18. 2. Install gas piping to fireplace. NOTE: This unit give (2) options on where the gas line can be ran into the fireplace. Knock outs are pr ...

  • United States Stove VFZC32N - page 20

    LOG ASSEMBLY LOG POSITIONING This unit is supplied with a set of four ceramic fiber logs. Do not handle these logs with your bare hands! Always wear gloves to prevent skin irritation from ceramic fibers. After handling logs, wash your hands gently with soap and water to remove any traces of fibers. PROPER INSTALLATION SEQUENCE: 1. Install the rear ...

  • United States Stove VFZC32N - page 21

    OPERATING INSTRUCTIONS Avoid any drafts that alter the burner flame patterns. Do not allow fans to blow directly into the heater. Do not place a blower inside burn area of fireplace. Ceiling fans may create drafts that alter burner flame patterns. Sooting and improper burning will occur. This vent-free gas heater is intended to be smokeless. If log ...

  • United States Stove VFZC32N - page 22

    1. Open access door. 2. Set front burner to Min. and turn off the rear burner by depressing knob and rotating clockwise until stop. 3. Unplug all electric power (optional blower) if service is to be performed. 4. Push in gas control knob slightly and turn clockwise to "OFF". Do not force. 5. Close access door. 6 . Push in the control (kno ...

  • United States Stove VFZC32N - page 23

    OPERATING INSTRUCTIONS, CONTINUED MATCH LIGHTING INSTRUCTIONS If the pilot will not light using the piezo ignitor, you can light the pilot with a match. First, locate the pilot. The pilot is located between the two burner tubes on the right end (facing the unit), inside the firebox. To light pilot with a match, move the gas control (knob 1, pg. 22) ...

  • United States Stove VFZC32N - page 24

    CLEANING / SERVICING, CONTINUED Periodic Cleaning • Do not use cleaning fluid to clean logs or any part of heater. • Logs - Brush with soft bristle brush or vacuum with brush attachment. • Vacuum loose particles and dust from the front and rear burner, control, and piezo. • Inspect burner's and air intake hole. Remove lint or particles ...

  • United States Stove VFZC32N - page 25

    PARTS DIAGRAM AND PARTS LIST 25 KEY DESCRIPTION PART# QTY. 1 CABINET BOTTOM 24651 1 2 FIREBOX BACK 24652 1 3 FIREBOX LEFT SIDE 24653 1 4 FIREBOX RIGHT SIDE 24654 1 5 FIREBOX BOTTOM 24655 1 6 FIREBOX TOP 24656 1 7 CABINET BACK 24657 1 8 CABINET LEFT SIDE 24658 1 9 CABINET RIGHT SIDE 24659 1 10 INNER TOP 24660 1 * INSULATION 24661 1 1 1 CABINET TOP 2 ...

  • United States Stove VFZC32N - page 26

    5 16 15 6 8 9 2 3 7 4 10 11 17 1 19 18 A B C D 20 13 14 12 GENERATOR ASSEMBLY PARTS DIAGRAM 26 ...

  • United States Stove VFZC32N - page 27

    KEY PART # DESCRIPTION QTY. 1 24610 BURNER PLATE 1 2 24611 CONTROL BRACKET 1 3 81193 CONTROL VALVE (NATURAL) 1 81194 CONTROL VALVE (L.P.) 1 4 83251 10-24 x 1 SL ROD 2 5 83244 10-24 KEP NUT 2 • 83343 #10 X 1/2 HX HD SCREW 10 6 89831 BURNER/CONTROL FITTING 1 7 89834 1/4" TUBE, BURNER 1 8 89838 1/4 CC X 3/8-27 FITTING 1 9 89839 1/4 COMPRESSION ...

  • United States Stove VFZC32N - page 28

    Wiring Diagram For Optional VF32B Blower Kit BLOWER BLACK BLACK BLACK WHITE BLACK WHITE BLACK GREEN WHITE RHEOSTAT & JUNCTION BOX COVER 2X4 JUNCTION BOX TO POWER SUPPLY You may install the VF32B Blower Kit in the VFZC32 Vent-free Gas Fireplace. Each Blower Kit includes the following: 1- 120 CFM Blower 1 - Blower Box 1- Manual fan control switch ...

  • United States Stove VFZC32N - page 29

    OPTIONAL ACCESSORIES 29 You may purchase these fireplace accessories from your local dealer. If they can not supply these accessories, call United States Stove Company's Sales Department at 1-423-837-2100 for information. You can also write to the address listed on the back page of this manual. CABINET MANTEL Model VFGO32M - Golden Oak Cabinet ...

  • United States Stove VFZC32N - page 30

    OPTIONAL ACCESSORIES 30 Drawings are for illustration purposes only. Actual product may very in appearance. ALUMINUM TRIM KITS Model VF32PB - Polished Brass Trim Kit Model VF32SB - Satin Black Trim Kit The Trim Kits must be used when installing firebox with Cabinet Mantel or Face Mantel. BRASS HOOD Model VF32BH for use with VFZC36 Firebox. LOUVERED ...

  • United States Stove VFZC32N - page 31

    31 HOW TO ORDER REPAIR PARTS This Manual will help you obtain efficient, dependable service from your Vent-Free Zero-Clearance Gas Fireplace, and enable you to order repair parts. Keep this manual in a safe place for future reference. When writing, always give the full model number which is on the nameplate attached to the fireplace. When ordering ...

  • United States Stove VFZC32N - page 32

    32 C O M P A N Y U N I T E D S T A T E S S T O V E C S S U Keeping America Warm Since 1869 United States Stove Company 227 Industrial Park Road P.O.Box 151 South Pittsburg, TN 37380 (423) 837-2100 Save this manual for future reference. VFZC32 Owner's Manual ...

Manufacturer United States Stove Category Indoor Fireplace

Documents that we receive from a manufacturer of a United States Stove VFZC32N can be divided into several groups. They are, among others:
- United States Stove technical drawings
- VFZC32N manuals
- United States Stove product data sheets
- information booklets
- or energy labels United States Stove VFZC32N
All of them are important, but the most important information from the point of view of use of the device are in the user manual United States Stove VFZC32N.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals United States Stove VFZC32N, service manual, brief instructions and user manuals United States Stove VFZC32N. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product United States Stove VFZC32N.

Similar manuals

A complete manual for the device United States Stove VFZC32N, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use United States Stove VFZC32N by users. Manuals are usually written by a technical writer, but in a language understandable to all users of United States Stove VFZC32N.

A complete United States Stove manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual United States Stove VFZC32N - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the United States Stove VFZC32N, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the United States Stove VFZC32N, that we can find in the current document
3. Tips how to use the basic functions of the device United States Stove VFZC32N - which should help us in our first steps of using United States Stove VFZC32N
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with United States Stove VFZC32N
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of United States Stove VFZC32N in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning United States Stove VFZC32N?

Use the form below

If you did not solve your problem by using a manual United States Stove VFZC32N, ask a question using the form below. If a user had a similar problem with United States Stove VFZC32N it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)