Manual Ariens 946101-ST622

20 pages 0.57 mb
Download

Go to site of 20

Summary
  • Ariens 946101-ST622 - page 1

    Owner/Operator Man ual Models 946101 - ST622 S tring T rimmer 04648400 10/05 Printed in USA ENGLIS H FRANÇAI S ESP AÑO L T ransfer model & serial number label from product registration here. Coller l’autocollant du modèle et du numéro de série dans cet encadré. Transferir aquí la et iqueta del modelo y número de serie del regist ro de ...

  • Ariens 946101-ST622 - page 2

    GB - 2 Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Assembly . . . . . . . . . . . . . . . . . . . . . . . . 7 Controls a nd Fe a t ure s . . . . . . . . . . . . . 8 Operati on . . . . . . . . . . . . . . . . . . . . . . . . 9 Mainten a nce . . . . . . . . . . . . . . . . . . . . 1 1 Service a nd Adju stment s . . . . . . . . . . ...

  • Ariens 946101-ST622 - page 3

    GB - 3 • Do not operate the unit unless all controls function as described in this manual. Before attemp ting to operate your unit: 1. Make sure all a ssembly has been properly completed. 2. Understand all Safety Precautions provided in the m anuals. 3. Review control functions and operation of the unit. 4. Review recommended lubrications, mainte ...

  • Ariens 946101-ST622 - page 4

    GB - 4 SAFETY DECALS AND LOCATIONS AL WA YS replace missing or damaged Safety Decals. Refer to figure below for Safety Decal locations. 1. DANGER! TO A VOID SERIOUS INJUR Y O R DEA TH SAFETY RULES If unit is t o be used by someone other than original purchaser; loaned, r ented or sold, AL WA Y S provide this manual and any needed safety training be ...

  • Ariens 946101-ST622 - page 5

    GB - 5 Do not operate t rimmer in wet gras s. AL WA YS be sure of your footing. Keep a firm hold on handlebar . W alk, NEVER run. Whenever operator rel eases control on handlebar , trimmer head must stop. Chec k this feature frequently . If feature f ails to operate, disconnect spark plug wire and adjus t or have it repaired bef ore using unit. Onl ...

  • Ariens 946101-ST622 - page 6

    GB - 6 This product is equipped with an internal combustion engine. DO NOT use on or near any unimproved, forest or brush covered land unless the exhaust system is equipped with a spark arrestor meeting applicable local, state or federal laws. A spark arrestor, if used, must be maintained in effective working order by the operator . S ee your Arien ...

  • Ariens 946101-ST622 - page 7

    GB - 7 TOOLS REQU IRED • Box knife to c ut carton TO REMOVE UNIT FROM CARTON 1. Cut of f top of box. 2. Remove packing mat erial. 3. Remove literature pack, safety glass es and bottle of oil from box. 4. Cut out back of b ox and pull the un it out. 5. Remove protective packaging materials from trimming head and around unit. ASSEMBLY Hand leba r A ...

  • Ariens 946101-ST622 - page 8

    GB - 8 1. T rimmer Head 2. T rimmer Line 3. Upper Handlebar 4. Lower Handlebar 5. Control Bail 6. Throttle Control Lever 7. Recoil S t arter Handle 8. Handlebar Wing Knob 9. Oil Dipstick and Cap 10. Fuel T ank and Cap 1 1. Debris Sc reen 12. Air Cleaner 13. Primer Bulb 14. Swivel Head Lock 15. T rimmer Shield 16. T r ailing Shiel d CONTROLS AND FEA ...

  • Ariens 946101-ST622 - page 9

    GB - 9 CONTROLS AND FEATURES See Controls an d Features on page 8. T rimmer Head / T rimm er Lines The trimmer hea d holds the trimmer line a nd provides trimming height adjust ment. When mounted in the trimmer , the t rimmer lines extend about 8 in. (20.3 cm) from the cutter disk. Control Bail • Squeeze the trimmer control bail against the handl ...

  • Ariens 946101-ST622 - page 10

    GB - 10 T O ST ART AND S HUT OFF ENGIN E Pre-St art 1. Check engine oil level. See Engine Manual. 2. Check fuel level. S tarting the Engine 1. Push primer bu lb 2 or 3 tim es for a cold engine. 2. Set throttle control to Fas t. 3. Grasp starter handle and pull rope out slowly until it pulls harder . This is t he compression stroke. Let rope rewind ...

  • Ariens 946101-ST622 - page 11

    GB - 1 1 SER VICE PO SITION 1. Remove the gas cap and place a piece of plastic (a plastic gar bage bag works w ell) over the tank opening. Reinst all the cap. This keeps gasoline from spilling out the tank. 2. Set the unit swivel in the center position. 3. Loosen the two wing nut s on the lower handlebar . 4. T ip the unit up ont o its back to rest ...

  • Ariens 946101-ST622 - page 12

    GB - 12 CHECK SP A RK PLUG See Engine Manual for specif ic information on checking, cleaning, and changing the spark plug. CHANGE ENGINE OIL Change the engine oil after the firs t 2 hours of use, then every 25 hours or ev ery season, whichever comes first. Oil should be changed when engine is warm. 1. Disconnect spark plug wire. 2. Clean area aroun ...

  • Ariens 946101-ST622 - page 13

    GB - 13 CUTTING HEIGHT ADJUSTMENT The standard cutting height is ad justable f rom 1-3/16" to 4-3/8" (3 to 1 1.1 cm). T o raise the cutting height, place more spacers (up t o 4) below the cutter disk. S pacers not used under the cutter disk m ust be assembled abov e the cutter disk. For example, if you place two spacers under the cutter d ...

  • Ariens 946101-ST622 - page 14

    GB - 14 CONTROL BAIL T RAVEL ADJUSTMENT Control Bail must disengage trimmer head as control is released. T here should be a slight amount of slack in the control cable wire when bail is fully released. If the trimmer head does not disengage completely when the control bail is released, increase the amount of slack in the control cable wire as follo ...

  • Ariens 946101-ST622 - page 15

    GB - 15 T o remove the old belt: 1. S top the engine and wait for all moving parts to stop. Disconnect t he spark plug wire and place it securely away from the spark plug. 2. Place unit in service position (see Maintenance section) . 3. Remove the six (6) hex w asher head screws and t he trimmer shield. 4. Remove the four (4) hex washer head screws ...

  • Ariens 946101-ST622 - page 16

    GB - 16 TROUBLESHOOTING PROBLEM PROBABLE CAUSE CORRECTION Engine wi ll not st art or runs poorly 1. S park plug wire disconnected. 2. Engine not primed 3. Fuel tank empty . 4. Throttle control lever not in correct position. 5. Engine is flooded. 6. Defective or incorrectly gapped spark plug. 7. S tale or contaminated gasoline. 8. Engine cooling sys ...

  • Ariens 946101-ST622 - page 17

    GB - 17 If the trimmer is to be stored for more than 30 days, follow these steps to prep are your unit. 1. Run the engine until it stops from running out of gasoline. See E ngine Manual for specific instructi ons on preparing t he engine for storage. 2. Clean all dirt and debris from the trimmer . Refer to Maintenance for cleaning instructions. 3. ...

  • Ariens 946101-ST622 - page 18

    Ariens Com pany • 655 W. Ryan St, P .O. Box 157 • Brillion, WI 541 10-0157• ( 920) 756-2141 • www .ariens.com AL W2-6 2905 Ariens Limited Warranti es 2-Year L imited Lawn an d Garden Consumer Wa rranty Ariens Compa ny (Ariens) warran t s to the origi nal pur chaser that Ariens and Gra vely brand con sumer product s manufa ctured by Ariens C ...

  • Ariens 946101-ST622 - page 19

    Ariens Com pany • 655 W. Ryan St, P .O. Box 157 • Brillion, WI 541 10-0157• ( 920) 756-2141 • www .ariens.com AL W2- 62905 Exceptions, L imitations, Ex clusions These warran tie s are subject to the fo llowing conditi on s, limitat ions, and exclus ion s: T o obtain warranty serv ic e, the following conditions must be met: • The p urchase ...

  • Ariens 946101-ST622 - page 20

    Ariens Company 655 West Rya n S treet P .O. Box 157 Brillion, WI 541 10-0157 920-756-2141 Fax 920-756-2407 www .ariens.com The engine exhaust from this product contains chemicals known to the State of California to cause cancer , birth defects or other reproductive harm. W ARNING ...

Manufacturer Ariens Category Trimmer

Documents that we receive from a manufacturer of a Ariens 946101-ST622 can be divided into several groups. They are, among others:
- Ariens technical drawings
- 946101-ST622 manuals
- Ariens product data sheets
- information booklets
- or energy labels Ariens 946101-ST622
All of them are important, but the most important information from the point of view of use of the device are in the user manual Ariens 946101-ST622.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Ariens 946101-ST622, service manual, brief instructions and user manuals Ariens 946101-ST622. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Ariens 946101-ST622.

Similar manuals

A complete manual for the device Ariens 946101-ST622, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Ariens 946101-ST622 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Ariens 946101-ST622.

A complete Ariens manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Ariens 946101-ST622 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Ariens 946101-ST622, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Ariens 946101-ST622, that we can find in the current document
3. Tips how to use the basic functions of the device Ariens 946101-ST622 - which should help us in our first steps of using Ariens 946101-ST622
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Ariens 946101-ST622
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Ariens 946101-ST622 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Ariens 946101-ST622?

Use the form below

If you did not solve your problem by using a manual Ariens 946101-ST622, ask a question using the form below. If a user had a similar problem with Ariens 946101-ST622 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)