Manual Alto-Shaam QC2-100

74 pages 10.63 mb
Download

Go to site of 74

Summary
  • Alto-Shaam QC2-100 - page 1

    PROCESSING FREEZER / CHILLER / REFRIGERATION SYSTEM  PHONE: 262.251.3800 • 800.558.8744 u s a / c a ...

  • Alto-Shaam QC2-100 - page 2

    Delivery ..................................... 1 Unpacking ................................... 1 Safety Procedures and Precautions ................ 2 Installation Site Installation ............................. 3 Clearance Requirements ...................... 3 Installation Requirements ..................... 3 Guide Installation for Trolley Option . ...

  • Alto-Shaam QC2-100 - page 3

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 1. deLiVery This Alto-Shaam appliance has been thoroughly tested and inspected to insure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to th ...

  • Alto-Shaam QC2-100 - page 4

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 2. note For equipment delivered for use in any location regulated by the following directive: DO NOT DISPOSE OF ELECTRICAL OR ELECTRONIC EQUIPMENT WITH OTHER MUNICIPAL WASTE. caution Used to indicate the presence ...

  • Alto-Shaam QC2-100 - page 5

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 3. CLEARANCE REQUIREMENTS 18" (457 mm ) m i n i m u m c l e a r a n c e f r o m h e a t p r o d u c i n g e q u i p m e n t . INSTALLATION REQUIREMENTS    ? ...

  • Alto-Shaam QC2-100 - page 6

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 4. INSTALLATION REQUIREMENTS The model QC2-3 is a counter mounted unit and must use legs that allow for a 4" (102mm) clearance between the cabinet and the counter. For all other models, install the appliance ...

  • Alto-Shaam QC2-100 - page 7

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 5. SITE INSTALLATION INSTALLATION QC2-100 Bottom View WATER DRAINAGE A 1" NPS drain is located under the QC2-100. Connect the drain pipe using Teflon tape to discharge through an indirect waste pipe into an ...

  • Alto-Shaam QC2-100 - page 8

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 6. SUB TITLE TITLE 5" (127mm) Electrical Connection Cord Length: 9 ' (2743mm) 55-3/4" (1416mm) 27" (686mm) ALTO SHAAM 30" (762mm) 35-1/4" (895mm) with caster option 10-1/4" (260 ...

  • Alto-Shaam QC2-100 - page 9

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 7. SUB TITLE TITLE QC2-20 57 " (1448mm) 36 " (914mm) Cord Length 9 ' (2743mm) 36 " (914mm) 42 " (1067mm) 60 " (1524mm) 36 " (914mm) PRODUCTPAN CAPACITY m a x i m u m c h i l l ...

  • Alto-Shaam QC2-100 - page 10

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 8. SUB TITLE TITLE QC2-40 ALTO SHAAM 36" (914mm) 7" (178mm) Electrical Connection Cord Length 9 ft (2743mm) 44" (1118mm) 75" (1905mm) 34" (864mm) 26-7/16" (671mm) 60-7/16" (1534 ...

  • Alto-Shaam QC2-100 - page 11

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 9. SUB TITLE TITLE QC2-100 INSTALLATIO N SITE INSTALLATION 41-1/2" (1054mm) 14" (355mm) Electrical Connection Condensate Drain 51" (1294mm) 93-5/8" (2377mm) 35-1/2" (902mm) 40" (1015 ...

  • Alto-Shaam QC2-100 - page 12

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 10. SUB TITLE TITLE QC2-100R INSTALLATIO N SITE INSTALLATION 41-1/2" (1054mm) 51" (1294mm) 83-1/4" (2114mm) 77-5/8" (1970mm) 8-1/8" (205mm) Condensate Drain ALTO SHAAM Electrical Connecti ...

  • Alto-Shaam QC2-100 - page 13

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 11. SUB TITLE TITLE MODEL > QC2-3 QC2-20 QC2-40 QC2-100 QC2-100 remote Casters, 3" (76mm) [ s e t o f 4] 5014890 — — — — Casters, 5" (127mm) [ s e t o f 4] 5014751 5014751 5014751 — — HAC ...

  • Alto-Shaam QC2-100 - page 14

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 12. SUB TITLE TITLE ELECTRICAL INSTALLATION This appliance must be branch circuit protected with proper ampacities, in accordance with the wiring diagram. The Quickchiller must be properly grounded in accordance ...

  • Alto-Shaam QC2-100 - page 15

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 13. TITLE OPERATION OPERATING INTRODUCTION The Alto-Shaam ® Quickchiller ™ is a processing refrigeration system designed to rapidly and uniformly decrease the temperature of hot foods to either a chilled or fr ...

  • Alto-Shaam QC2-100 - page 16

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 14. TITLE OPERATION CHILL PROCESSING CYCLES The Alto-Shaam Quickchiller uses high velocity cold air circulation to remove heat from prepared foods for the purpose of rapidly reducing temperatures through the dang ...

  • Alto-Shaam QC2-100 - page 17

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 15. TITLE OPERATION ADDITIONAL INFORMATION ➤ Clean the Quickchiller and probes prior to use and make certain all processing modes are operating properly before chilling or freezing foods. ➤ To maintain proper ...

  • Alto-Shaam QC2-100 - page 18

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 16. TITLE OPERATION  … To rapidly decrease the temperature of foods by internal product probe temperature or time within a range of 24°F to 36°F (-4°C to 2°C). Soft Chill is re ...

  • Alto-Shaam QC2-100 - page 19

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 17. SUB TITLE TITLE BASIC OPERATION OPERATION  Starting from the o f f position, press the power key o n . The Alto-Shaam name will illuminate and the SELECTION SCREEN will appear on the display. The compre ...

  • Alto-Shaam QC2-100 - page 20

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 18. SUB TITLE TITLE caution ADEQUATE SPACING MUST BE ALLOWED BETWEEN PANS FOR PROPER AIR CIRCULATION FOR BOTH PROCESSING AND SUBSEQUENT HOLDING. ADVANCED OPERATION OPERATION The date and time will appear in the d ...

  • Alto-Shaam QC2-100 - page 21

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 19. SUB TITLE TITLE MANUAL OPERATION  Starting from the o f f position, press the power key o n . The Alto-Shaam name will illuminate and the SELECTION SCREEN will appear on the display. The compressor will ...

  • Alto-Shaam QC2-100 - page 22

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 20. ADVANCED OPERATION — PRESET PROGRAMMING OPERATION PRESET PROGRAM OPERATION 1. Starting from the o f f position, press the power key o n . The Alto-Shaam name will illuminate and the SELECTION SCREEN will ap ...

  • Alto-Shaam QC2-100 - page 23

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 21. SUB TITLE TITLE chanGinG user settinGs Starting from the of f position, press the power key o n . The Alto-Shaam name will illuminate and the SELECTION SCREEN will appear on the display. The compressor will b ...

  • Alto-Shaam QC2-100 - page 24

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 22. 8. HACCP DOWNLOAD (O nly on units with optional HACCP Datalogger ) Insert USB data stick into data port on front of the unit. Display will indicate USB. Press the PROGRAM key and then press the down 6 arrow k ...

  • Alto-Shaam QC2-100 - page 25

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 23. ADVANCED OPERATION – USER SETTINGS OPERATION 9. PROBE VERIFICATION With the probe verification selected, press the Start key to enter the probe verification mode. The offset and the temperature will display ...

  • Alto-Shaam QC2-100 - page 26

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 24. TITLE OPERATION FOOD PROBE USE Unpacking Food Probes 1. Cut and remove the plastic ties keeping the probe cables coiled during shipment. When removing the ties, exercise caution to avoid accidentally cutting ...

  • Alto-Shaam QC2-100 - page 27

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 25. SUB TITLE TITLE OPERATION FOOD HANDLING GUIDELINES PRODUCT COVERING To maintain sanitation control when loading the Quickchiller, foods should be above 140°F (60°C) and should be tightly covered. A tight co ...

  • Alto-Shaam QC2-100 - page 28

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 26. TITLE OPERATION PRODUCT CAPACITY PER PAN: Foods for chill or freeze processing should be portioned into shallow pans to a depth not to exceed 2-inches (51mm). The individual pan capacity chart below is provid ...

  • Alto-Shaam QC2-100 - page 29

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 27. TITLE OPERATION THE FOLLOWING CHART OF PORTION SIZES AND SERVING CAPACITY PER PAN IS PROVIDED AS A GENERAL REFERENCE ONLY. PORTION SIZES and PAN CAPACITIES   ›   ...

  • Alto-Shaam QC2-100 - page 30

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 28. TITLE CARE AND CLEANING protecting stainLess steeL surfaces It is important to guard against corrosion in the care of stainless steel surfaces. Harsh, corrosive, or inappropriate chemicals can completely dest ...

  • Alto-Shaam QC2-100 - page 31

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 29. TITLE INTERIOR CLEANING Remove the optional roll-in cart (trolley) from cart equipped models. Open the Quickchiller door to warm the interior of the cabinet. 1. Remove any loose food debris with a cleaning cl ...

  • Alto-Shaam QC2-100 - page 32

    Q U I C K C H I L L E R • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 30. TITLE TROUBLESHOOTING CONTROL ERROR DISPLAYS control d i s p l a y a c t i o n r e q u i r e d Real Time Clock Bad E-60: REAL TIME CLOCK DEFAULTS LOADED, VERIFY CORRECT TIME, POWER CYCLE UNIT TO CLEAR THIS ME ...

  • Alto-Shaam QC2-100 - page 33

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 31. QC2-3 BOTTOM 1 2 3 4 5 5 6 7 8 9 10 11 12 13 14 Item Part Description Qty. 1 RE-29821 Condensing Unit Duct 1 2 PE-29819 Top Louver Channel 1 3 PE-29830 Compressor Louver 1 4 SW-29823 Pressure Swi ...

  • Alto-Shaam QC2-100 - page 34

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 32. 1 3 2 4 7 5 6 8 9 10 11 12 13 14 21 20 16 17 18 15 19 4 QC2-3 BOX VIEW Item Part Description Qty. 1 BT-29841 Holding Bracket Ref Line 1 2 PR-34299 Probe Receptacle Assembly 1 3 PR-34298 Probe, Qu ...

  • Alto-Shaam QC2-100 - page 35

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 33. QC2-3 COIL VIEW 1 2 3 4 5 6 7 8 9 10 11 12 14 15 13 16 Upon installation of drip pan, silicone pan perimeter to interior liner bottom Add plastic edge guard to drip pan 6 Item Part Description Qt ...

  • Alto-Shaam QC2-100 - page 36

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 34. QC2-3 COMPRESSOR VIEW 1 3 2 4 7 4 5 6 Item Part Description Qty. 1 RE-29861 Condensing Assembly, 1/2 MED R404A 120V 1 2 SW-29823 Pressure Switch 1 3 FI-29862 Dryer, 1/4" Filter with 2nd 1/4& ...

  • Alto-Shaam QC2-100 - page 37

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 35. QC2-3 CONTROL BOX 2 1 3 4 5 6 7 8 9 11 12 14 15 16 17 10 18 13 1 Item Part Description Qty. 1 BT-29929 Dinrail, End Stop 2 2 BA-34010 Digital Relay 2, Circuit Board 1 3 BA-34009 Digital Relay 1, ...

  • Alto-Shaam QC2-100 - page 38

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 36. QC-20 BOTTOM 2 3 4 5 6 6 7 8 1 Item Part Description Qty. 1 PN-29968 Compressor Louver 1 2 FI-29954 Filter Dryer 1 3 VA-29900 Valve, Pressure Regulator 1 4 RE-29947 Compressor, 3/4 HP LO R404A 1 ...

  • Alto-Shaam QC2-100 - page 39

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 37. QC-20 BOX VIEW 14 9 12 11 9 10 7 8 4 3 5 1 2 6 15 16 17 18 18 19 13 20 21 20 Item Part Description Qty. 1 CU-29964 Capacitor, 14MFD, 440VAC 1 2 BT-29918 Din Rail 1 3 FU-29926 Fuse. 10 Amp Time De ...

  • Alto-Shaam QC2-100 - page 40

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 38. QC-20 COIL VIEW 3 10 1 2 17 6 7 8 9 4 5 11 12 13 14 16 15 Item Part Description Qty. 1 RE-29944 Coil, QuickChiller 1 2 PR-34704 Probe Receptacle Assembly 1 3 SN-33541 Cavity Sensor 1 4 BK-24427 M ...

  • Alto-Shaam QC2-100 - page 41

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 39. 1 2 3 4 4 5 6 8 9 7 QC-20 COMPRESSOR VIEW Item Part Description Qty. 1 FI-29954 Filter Dryer 1 2 VA-29900 Solenoid Valve, Sporlan Pressure Regulator 1 3 RE-29947 Compressor 1 4 VA-29863 Solenoid ...

  • Alto-Shaam QC2-100 - page 42

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 40. 3 2 Apply Weather Stripping to Front T op Edge of Panel 4 1 5 5 6 9 7 8 Item Part Description Qty. 1 SC-29933 Bolt, M5 12 2 CC-34682 Control Board 11 3 PI-26098 Pipe, .125" Thick Acrylic Tub ...

  • Alto-Shaam QC2-100 - page 43

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 41. QC2-40 COMPRESSOR 5 6 2 1 3 4 2 7 Item Part Description Qty. 1 VA-29898 Valve, Liquid Line Solenoid 2 2 SE-29897 Solenoid Valve & Coil, Danfoss, 120V 2 3 VA-29900 Valve, Sporlan Crankcase Pre ...

  • Alto-Shaam QC2-100 - page 44

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 42. QC2-40 COMPRESSOR HOUSING 2 3 4 5 6 1 Item Part Description Qty. 1 FU-29901 Breaker, 2 Pole 20 AMP, 60Hz 1 FU-29996 Breaker, 2 Pole 30 AMP, 50Hz 1 2 PE-29902 Compressor Louver 1 3 LG-29904 6" ...

  • Alto-Shaam QC2-100 - page 45

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 43. QC2-40 COIL 2 2 1 Suction Line 1 3 Hot Gas Defrost Line Discharge Line Item Part Description Qty. 1 RE-29905 Coil Assembly, 19x20 2 2 VA-29906 Valve, Expansion 2 3 CD-29860 Wire, 11" (279mm) ...

  • Alto-Shaam QC2-100 - page 46

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 44. QC2-40 DOOR, LEFT HAND (PRIOR TO JUNE 1, 2012) 1 6 7 4 5 4 3 2 Item Part Description Qty. 1 HG-29913 Upper Hinge, Bracket, Left-Hand 1 2 HD-26967 Handle, Door 1 3 BT-29911 Lower Bracket, Horizont ...

  • Alto-Shaam QC2-100 - page 47

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 45. QC2-40 DOOR (AFTER JUNE 1, 2012) 1 3 2 1 4 1 3 2 1 4 LEFT-HAND RIGHT-HAND Item Part Description Qty. 1 HG-29992 Hinge, Adjustable 1 2 HL-29840 Food Probe Holder 3 3 GS-29914 Gasket, Door 1 4 HD-2 ...

  • Alto-Shaam QC2-100 - page 48

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 46. QC2-40 INTERIOR 5 4 1 2 3 4 6 Item Part Description Qty. 1 PR-34299 Probe, Receptacle 3 2 PR-34298 Probe, Quick Connect 3 3 PE-29916 Panel, Fan Guard, Right 1 4 SR-29915 Rack, Pan Support 2 5 PE- ...

  • Alto-Shaam QC2-100 - page 49

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 47. QC2-40 CONTROL PANEL - HINGED LEFT (PRIOR TO JUNE 1, 2012) 12 13 1 2 3 4 5 6 7 8 9 10 16 15 14 11 17 19 18 19 20 Item Part Description Qty. 1 TM-29921 Terminal Block, Pluggable, 180 Deg, 7 Positi ...

  • Alto-Shaam QC2-100 - page 50

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 48. QC2-40 CONTROL PANEL - HINGED LEFT (AFTER JUNE 1, 2012) 6 5 1 2 3 15 14 7 10 11 8 16 9 12 13 4 17 Item Part Description Qty. 1 TM-29921 Terminal Block, Pluggable, 180 Deg, 7 Position 1 2 TM-29922 ...

  • Alto-Shaam QC2-100 - page 51

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 49. QC2-40 CONTROL PANEL - HINGED RIGHT (AFTER JUNE 1, 2012) 6 5 2 3 4 14 13 7 10 11 8 1 9 12 17 15 16 Item Part Description Qty. 1 SC-29928 Bolt, 6-32x1/2, Philip Truss Head 7 2 TM-29921 Terminal Bl ...

  • Alto-Shaam QC2-100 - page 52

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 50. QC2-40 FAN 1 2 3 Item Part Description Qty. 1 FA-29853 Motor, Fan Evaporator, 60Hz 2 RE-35856 Motor, Fan Evaporator, 50Hz 2 2 FT-29908 Plastic Collar, 14-1/2" Round 2 3 FA-29907 Blade, 14&qu ...

  • Alto-Shaam QC2-100 - page 53

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 51. QC2-100 COMPRESSOR 1 2 2 3 4 5 6 7 8 Item Part Description Qty. 1 TE-29986 Tee, Copper, 3/8 x 3/8 x 3/8" ID 4 2 RE-35155 Solenoid Valve & Coil, Danfoss, 120V 2 3 TE-35153 Tee, Copper, 1/ ...

  • Alto-Shaam QC2-100 - page 54

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 52. QC2-100 COIL 1 2 3 4 5 Item Part Description Qty. 1 RE-29905 Coil Assembly, 19x20 1 2 VA-29906 Valve, Expansion 1 3 TE-35153 Tee, Copper, 1/2 x 1/2 x 3/8" ID 1 4 FA-29945 Fan, Axial Evaporat ...

  • Alto-Shaam QC2-100 - page 55

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 53. QC2-100 DOOR 1 2 3 4 5 6 Item Part Description Qty. 1 HD-26967 Handle, Door 1 2 GS-29994 Gasket, Compression 1 3 GS-29993 Gasket, Door 1 4 HG-29992 Hinge, Adjustable 3 5 SC-29991 Screw, Pan Head, ...

  • Alto-Shaam QC2-100 - page 56

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 54. QC2-100 INTERIOR, LEFT-HAND VIEW 9 10 11 12 13 1 2 3 4 8 5 6 7 Item Part Description Qty. 1 RE-29983 Condensing Unit, 3HP 208/230V 1 Phase 1 RE-35172 Condensing Unit, 3HP 208/230V 3 Phase 1 2 PN- ...

  • Alto-Shaam QC2-100 - page 57

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 55. QC2-100 INTERIOR, RIGHT-HAND VIEW 8 9 10 11 12 1 2 4 3 7 5 6 * not shown Item Part Description Qty. 1 RE-29983 Condensing Unit, 3HP 208/230V 1 Phase 1 RE-35172 Condensing Unit, 3HP 208/230V 3 Pha ...

  • Alto-Shaam QC2-100 - page 58

    parts information QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 56. QC2-100 CONTROL PANEL, UNIT HINGED LEFT 8 12 16 18 17 19 10 9 14 20 5 13 11 4 3 7 1 6 2 15 Item Part Description Qty. 1 CC-34682 Control Board 1 2 5014750 HACCP Data Logger, USB Port, option 1 3 ...

  • Alto-Shaam QC2-100 - page 59

    PARTS INFORMATION QUICKCHILLER PARTS • M N - 2 9 6 4 7 ( R E V . 0 ) • I N S T A L L A T I O N / O P E R A T I O N / S E R V I C E M A N U A L • 57. QC2-100 CONTROL PANEL, UNIT HINGED RIGHT 9 12 11 10 13 14 4 7 8 6 5 19 17 16 18 1 2 3 15 Item Part Description Qty. 1 CC-34682 Control Board 1 2 TI-35860 Strap, Transformer Tie Down 1 3 5014750 H ...

  • Alto-Shaam QC2-100 - page 60

    ...

  • Alto-Shaam QC2-100 - page 61

    ...

  • Alto-Shaam QC2-100 - page 62

    ...

  • Alto-Shaam QC2-100 - page 63

    ...

  • Alto-Shaam QC2-100 - page 64

    ...

  • Alto-Shaam QC2-100 - page 65

    ...

  • Alto-Shaam QC2-100 - page 66

    ...

  • Alto-Shaam QC2-100 - page 67

    ...

  • Alto-Shaam QC2-100 - page 68

    ...

  • Alto-Shaam QC2-100 - page 69

    ...

  • Alto-Shaam QC2-100 - page 70

    ...

  • Alto-Shaam QC2-100 - page 71

    ...

  • Alto-Shaam QC2-100 - page 72

    ...

  • Alto-Shaam QC2-100 - page 73

    ...

  • Alto-Shaam QC2-100 - page 74

    TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...

Manufacturer Alto-Shaam Category Freezer

Documents that we receive from a manufacturer of a Alto-Shaam QC2-100 can be divided into several groups. They are, among others:
- Alto-Shaam technical drawings
- QC2-100 manuals
- Alto-Shaam product data sheets
- information booklets
- or energy labels Alto-Shaam QC2-100
All of them are important, but the most important information from the point of view of use of the device are in the user manual Alto-Shaam QC2-100.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Alto-Shaam QC2-100, service manual, brief instructions and user manuals Alto-Shaam QC2-100. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Alto-Shaam QC2-100.

A complete manual for the device Alto-Shaam QC2-100, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Alto-Shaam QC2-100 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Alto-Shaam QC2-100.

A complete Alto-Shaam manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Alto-Shaam QC2-100 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Alto-Shaam QC2-100, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Alto-Shaam QC2-100, that we can find in the current document
3. Tips how to use the basic functions of the device Alto-Shaam QC2-100 - which should help us in our first steps of using Alto-Shaam QC2-100
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Alto-Shaam QC2-100
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Alto-Shaam QC2-100 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Alto-Shaam QC2-100?

Use the form below

If you did not solve your problem by using a manual Alto-Shaam QC2-100, ask a question using the form below. If a user had a similar problem with Alto-Shaam QC2-100 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)