Manual Kohler 1071003-2-B

28 pages 0.82 mb
Download

Go to site of 28

Summary
  • Kohler 1071003-2-B - page 1

    Installation Guide Aluminum Column M product numbers ar e for Mexico (i.e. K-12345 M ) Los números de pr oductos seguidos de M corresponden a México (Ej. K-12345 M ) Français, page “Français-1” Español, página “Español-1” K-1840 1071003-2-B ...

  • Kohler 1071003-2-B - page 2

    Thank Y ou For Choosing Kohler Company W e appreciate your commitment to Kohler quality . Please take a few minutes to r eview this manual before you start installation. If you encounter any installation or performance problems, please don’t hesitate to contact us. Our phone numbers and website are listed within this manual. Thanks again for choo ...

  • Kohler 1071003-2-B - page 3

    1. Construct the Stud Framing Install the drain and supply pipes according to local plumbing codes. IMPOR T ANT! Plan the shower area around the desir ed placement of the shelving unit. Ensure the placement of the shelving unit will be free of obstr uctions (such as pipes or electrical boxes). IMPOR T ANT! Before attaching the studs, ensure the stu ...

  • Kohler 1071003-2-B - page 4

    2. Prepare the Site IMPOR T ANT! Select wall material that is water resistant (such as cement board) and meets local building codes. Install wall material to the entire shower ar ea, including the stud pocket. NOTE: Keep in mind the length of the column is 60 ″ (152.4 cm) when determining the desired height. Determine the desired vertical positio ...

  • Kohler 1071003-2-B - page 5

    3. Assemble the Unit Install Shelves Insert a filler strip down into the left and right channel. W ith the tab of the clip pointing up, snap a clip above each filler strip. NOTE: The top filler strip will extend above the unit. Repeat this process for the r emaining strips and clips. T emporarily insert a shelf above each set of clips to verify ...

  • Kohler 1071003-2-B - page 6

    Assemble the Unit (cont.) Install T op Cap Position the flat front of the clamp towar d the front of the unit. Partially thread a scr ew a total of four rotations thr ough each clamp. Do not fully tighten until instructed to do so. 1071003-2-B 6 Kohler Co. ...

  • Kohler 1071003-2-B - page 7

    4. Complete the Site V erify Fit T emporarily insert the unit into the stud pocket. V ertically center the unit, then verify the attachment flanges overlap the wall material a minimum of 1/4 ″ (6 mm). IMPOR T ANT! If a minimum of 1/4 ″ (6 mm) overlap does not exist: Set the unit aside, remove the wall material, then repeat the option selected ...

  • Kohler 1071003-2-B - page 8

    5. Secure the Unit Apply 100% silicone sealant in the groove of the backside of the column and perimeter of the top cap, as illustrated. Starting from the bottom and working up, insert the column into the cutout. NOTE: When the screws on the caps ar e tightened, the attached clamps will flip up and the column will become flush with the wall mater ...

  • Kohler 1071003-2-B - page 9

    Guide d’installation Colonne en aluminium Outils et matériels Merci d’avoir choisi la compagnie Kohler Nous apprécions votre engagement envers la qualité Kohler . V euillez prendr e s’il vous plaît quelques minutes pour lire ce manuel avant de commencer l’installation. Ne pas hésiter à nous contacter en cas de problème d’installati ...

  • Kohler 1071003-2-B - page 10

    A vant de commencer (cont.) Kohler Co. se réserve le droit d’apporter toutes modifications sur le design des pr oduits et ceci sans préavis, tel que spécifié dans le catalogue des prix. 1071003-2-B Français-2 Kohler Co. ...

  • Kohler 1071003-2-B - page 11

    1. Construire le cadrage du montant Installer le drain et les tuyaux d’alimentation selon les codes de plomberie locaux. IMPOR T ANT ! Planifier l’espace de douche autour de l’emplacement désiré de l’unité d’étagère. S’assurer que l’emplacement d’étagère sera sans obstr uctions (telles que tuyaux ou boîtiers électriques). ...

  • Kohler 1071003-2-B - page 12

    2. Préparer le site IMPOR T ANT ! Sélectionner le matériau du mur étant hydrorésistant (tel que ciment) et conforme aux codes locaux de construction. Installer le matériau du mur à l’espace entier de douche, incluant la poche de montant. REMARQUE : Garder en tête la longueur de la colonne de 60 ″ (152,4 cm) lors de la détermination de ...

  • Kohler 1071003-2-B - page 13

    3. Assembler l’unité Installer les tablettes Insérer une bande de r emplissage dans les cannaux gauche et droit. A vec la languette du clip pointant vers le haut, engager un clip au-dessus de chaque languette de remplissage. REMARQUE : La languette de remplissage supérieur e s’étendra au-delà de l’unité. Répéter cette procédur e pour ...

  • Kohler 1071003-2-B - page 14

    Assembler l’unité (cont.) A VER TISSEMENT : Risque d’endommagement du produit. Ne pas trop serrer les vis. Une fois le joint en caoutchouc dans le couvercle supérieur compr essé, la résistance de serrage augmentera. En alternant les vis, serrer complètement les vis pour sécuriser le couver cle supérieur à la colonne. Installer le couver ...

  • Kohler 1071003-2-B - page 15

    4. Compléter le site Vérifier l’ajustement Insérer temporair ement l’unité dans la poche de montant. Centrer verticalement l’unité, puis vérifier que les brides d’attache chevauchent le matériau du mur à un minimum de 1/4 ″ (6 mm). IMPOR T ANT ! Si un minimum de chevauchement de 1/4 ″ (6 mm) n’existe pas: Mettr e l’unité ...

  • Kohler 1071003-2-B - page 16

    5. Sécuriser l’unité Appliquer du mastic à la silicone à 100% dans la rainure à l’arrièr e de la colonne et du périmètre du couvercle supérieur , tel qu’illustré. En commencant de la base vers le haut, insérer la colonne dans la découpe. REMARQUE : Lorsque les vis sur les couvercles sont serrées, les pinces attachées se rabatter ...

  • Kohler 1071003-2-B - page 17

    Guía de instalación Columna de aluminio Herramientas y materiales Gracias por elegir los productos de Kohler Le agradecemos que haya elegido la calidad de Kohler . Dedique unos minutos para leer este manual antes de comenzar la instalación. En caso de problemas de instalación o de funcionamiento, no dude en contactarnos. Este manual contiene nu ...

  • Kohler 1071003-2-B - page 18

    Antes de comenzar (cont.) Kohler Co. se reserva el der echo de modificar el diseño de los productos sin pr evio aviso, tal como se especifica en la lista de precios. 1071003-2-B Español-2 Kohler Co. ...

  • Kohler 1071003-2-B - page 19

    1. Construya la estructura de postes de madera Instale las tuberías de suministro y desagüe conforme a los códigos locales de plomería. ¡IMPOR T ANTE! Planee el área de la ducha según el lugar deseado para la unidad de estantes. Asegure que el lugar de instalación de la unidad de estantes esté libre de obstr ucciones (como tubos y cajas el ...

  • Kohler 1071003-2-B - page 20

    2. Prepare el sitio ¡IMPOR T ANTE! Seleccione un material de la pared que sea resistente al agua (tal como paneles de cemento) que cumpla con los códigos locales de construcción. Instale el material de la pared a toda el ár ea de la ducha, incluyendo el encajonado de postes de madera. NOT A: T enga presente que la longitud de la columna es 60 ? ...

  • Kohler 1071003-2-B - page 21

    3. Ensamble la unidad Instale los estantes Inserte una tira de relleno en el canal izquier do y derecho. Con la lengüeta del clip hacia arriba, encaje un clip sobre cada tira de r elleno. NOT A: La tira de relleno sobresaldrá arriba de la unidad. Repita este procedimiento con las otras tiras de r elleno y los clips. Inserte provisionalmente un es ...

  • Kohler 1071003-2-B - page 22

    Ensamble la unidad (cont.) ADVER TENCIA: Riesgo de daños al producto. No apriete demasiado los tornillos. Una vez que el sello de goma de la tapa superior se comprima, aumentará la resistencia de apr etar . Alternando entre los tornillos, apriete completamente los tornillos para fijar la tapa superior a la columna. Instale la tapa superior Coloq ...

  • Kohler 1071003-2-B - page 23

    4. T ermine el sitio V erifique que quede bien Inserte provisionalmente la unidad en el encajonado de postes de madera. Centre verticalmente la unidad, luego verifique que los r ebordes de fijación se sobr epongan 1/4 ″ (6 mm) en el material de la pared. ¡IMPOR T ANTE! Si no existe el mínimo de sobrepuesto de 1/4 ″ (6 mm): Coloque la unid ...

  • Kohler 1071003-2-B - page 24

    5. Fije la unidad Aplique sellador 100% de silicona en la ranura en el lado posterior de la columna y el perímetro de la tapa superior , como se ilustra. Comenzando en la parte inferior y trabajando hacia arriba, inserte la columna en la abertura. NOT A: Cuando los tornillos de las tapas estén apretados, las grapas instaladas se voltearán hacia ...

  • Kohler 1071003-2-B - page 25

    1071003-2- B ...

  • Kohler 1071003-2-B - page 26

    1071003-2- B ...

  • Kohler 1071003-2-B - page 27

    1071003-2- B ...

  • Kohler 1071003-2-B - page 28

    USA: 1-800-4-KOHLER Canada: 1-800-964-5590 México: 001-877-680-1310 kohler .com ©2007 Kohler Co. 1071003-2-B ...

Manufacturer Kohler Category Plumbing Product

Documents that we receive from a manufacturer of a Kohler 1071003-2-B can be divided into several groups. They are, among others:
- Kohler technical drawings
- 1071003-2-B manuals
- Kohler product data sheets
- information booklets
- or energy labels Kohler 1071003-2-B
All of them are important, but the most important information from the point of view of use of the device are in the user manual Kohler 1071003-2-B.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Kohler 1071003-2-B, service manual, brief instructions and user manuals Kohler 1071003-2-B. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Kohler 1071003-2-B.

Similar manuals

A complete manual for the device Kohler 1071003-2-B, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Kohler 1071003-2-B by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Kohler 1071003-2-B.

A complete Kohler manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Kohler 1071003-2-B - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Kohler 1071003-2-B, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Kohler 1071003-2-B, that we can find in the current document
3. Tips how to use the basic functions of the device Kohler 1071003-2-B - which should help us in our first steps of using Kohler 1071003-2-B
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Kohler 1071003-2-B
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Kohler 1071003-2-B in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Kohler 1071003-2-B?

Use the form below

If you did not solve your problem by using a manual Kohler 1071003-2-B, ask a question using the form below. If a user had a similar problem with Kohler 1071003-2-B it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)