English dropdown-ico

Manual Hearth and Home Technologies 823-0290

32 pages 2.94 mb
Download

Go to site of 32

Summary
  • Hearth and Home Technologies 823-0290 - page 1

    SA VE THESE INSTRUCTIONS www .quadrare.com This manual contains instructions for Installation, Operation & Maintenance. Please read this entire manual before you install and use your new room heater . Failure to follow instructions may result in property damage, bodily injury , or even death. Isle Royale Non-Catalytic, T op-load, W ood Heate ...

  • Hearth and Home Technologies 823-0290 - page 2

    R Page 2 September 1, 2008 Isle Royale W ood Stove 250-5763C and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradi - tion of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durabil - ity , and performance. This commitment begins with our research of the m ...

  • Hearth and Home Technologies 823-0290 - page 3

    Page 3 Isle Royale W ood Stove R September 1, 2008 250-5763C Serial Number Label Location ................................. 2 Pre-Use Checklist ..................................................... 3 Listings & Safety Notices ........................................ 4 Dimensions ............................................................... 5 ...

  • Hearth and Home Technologies 823-0290 - page 4

    R Page 4 September 1, 2008 Isle Royale W ood Stove 250-5763C LISTINGS and SAFETY NOTICES W ARNING ! DO NOT A TTEMPT TO OPERA TE THIS WOODSTOVE WITHOUT READING AND UNDERST ANDING THESE OPERA TING I NS T R UC T I O NS T H OR O U GH L Y . FAI L U R E T O O P E RATE T H IS APPLIANCE PROPERL Y MA Y CAUSE A HOUSE FIRE. W ARNI NG ! TH E OU TSID E SU RF AC ...

  • Hearth and Home Technologies 823-0290 - page 5

    Page 5 Isle Royale W ood Stove R September 1, 2008 250-5763C DIMENSIONS FRONT VIEW SIDE VIEW 29" (737mm) 28-3/4" (730mm) 30" (762mm) C L 8-1/4" (210mm) 16-1/2" (419mm) 24-5/8" (625mm) 26-7/16" (570mm) 30" (762mm) 22-3/4" (578mm) 16-3/4" (425mm) VENT SPECIFICA TIONS: Single W all: Six inch (6") ...

  • Hearth and Home Technologies 823-0290 - page 6

    R Page 6 September 1, 2008 Isle Royale W ood Stove 250-5763C B A C D CLEARANCES T O COMBUSTIBLES (UL and ULC) G H Ceiling E E F F MINIMUM CLEARANCES TO COMBUSTIBLE MA TERIALS In Inches & (Millimeters) NOTE: "A" ,"C" and "F" Dimensions are to the inside diameter of the flue collar . FOR TOP VENT INST ALLA TIONS: SIN ...

  • Hearth and Home Technologies 823-0290 - page 7

    Page 7 Isle Royale W ood Stove R September 1, 2008 250-5763C FLOOR PROTECTION The oor must be non-combustible material, extending beneath heater and to the front, sides and rear as indicated. The oor must be non-combustible or otherwise adequately protected from radiant heat given off by the unit and from sparks and falling embers. A layer of ...

  • Hearth and Home Technologies 823-0290 - page 8

    R Page 8 September 1, 2008 Isle Royale W ood Stove 250-5763C Calculating Alternate Floor Protection Material Thermal Conductivity: k value The k value indicates the amount of heat (in BTU’ s) that will ow in 1 hour through 1 square foot of a uniform material 1 inch thick for each degree (F) of temperature difference from one side of the materi ...

  • Hearth and Home Technologies 823-0290 - page 9

    Page 9 Isle Royale W ood Stove R September 1, 2008 250-5763C REVERSIBLE FLUE COLLAR The ue collar is reversible for either a top or rear venting installation. The unit is shipped with the ue collar in the top vent position. CONVERTING COLLAR FOR REAR VENT INST ALLA TION 1. Remove 5 Phillips head screws from the rear shield, lift shield up and ...

  • Hearth and Home Technologies 823-0290 - page 10

    R Page 10 September 1, 2008 Isle Royale W ood Stove 250-5763C T o be sure that your stove burns properly , the chimney draft (static pressure) should be approximately -.04” water column (W .C.) during a low burn and -.10” W .C. during a high burn, measured 6 inches (152mm) above the top of the stove after one hour of operation at each burn sett ...

  • Hearth and Home Technologies 823-0290 - page 11

    Page 1 1 Isle Royale W ood Stove R September 1, 2008 250-5763C Thimble Assembly: 12" (305mm) of brick separation between clay liner and combustibles. Fireclay liner 5/8" (16mm) Minimum or Equivalent. Sill support Header Wood Stud 2" (51mm) Clearance from chimney wall Fireclay liner 5/8" (16mm) Minimum or Equivalent. FLUE SYSTEMS ...

  • Hearth and Home Technologies 823-0290 - page 12

    R Page 12 September 1, 2008 Isle Royale W ood Stove 250-5763C SOLID P ACK CHIMNEY WITH MET AL SUPPORTS AS A THIMBLE Figure 12A Center of Hole W all Center Line Opening Center Line C L 26-7/16" (570mm) Add the 26-7/16 inches (671mm), center-line measurement to the depth measurement of your oor protector . Mark this combined mea - surement at ...

  • Hearth and Home Technologies 823-0290 - page 13

    Page 13 Isle Royale W ood Stove R September 1, 2008 250-5763C First, make the frame for the thimble, ensuring it is no smaller than 14 inches (356mm) square to maintain a 2 inch (51mm) air space around the chimney section. Attach the wall spacer to the chimney side of the frame. Then insert the frame into the opening, toe nai ling it to the wal l s ...

  • Hearth and Home Technologies 823-0290 - page 14

    R Page 14 September 1, 2008 Isle Royale W ood Stove 250-5763C CONNECTION T O A MASONR Y FIREPLACE There are several kits available to connect the stove to a masonry replace. Look for a listed kit. The kit is an adapter which is installed at the location of the replace damper . The existi ng dampe r may have to be remov ed to allow installati ...

  • Hearth and Home Technologies 823-0290 - page 15

    Page 15 Isle Royale W ood Stove R September 1, 2008 250-5763C When a metal prefabricated chimney is used, the manufac - turer ’s installation instructions must be followed precisely . It will be necessary to install the ceiling support package or wall pass through, “T” section package, restops (when needed), insulation shield, roof ashi ...

  • Hearth and Home Technologies 823-0290 - page 16

    R Page 16 September 1, 2008 Isle Royale W ood Stove 250-5763C Spark Arestor Cap Roof Flashing Storm Collar Joist Shield/Firestop Listed Chimney Connector Floor Protector Outside Air Kit Connector Outside Air Floor V ent 1 . An outsid e air inlet must be prov ided for combust ion and must remain clear of leaves, debris, ice and/or snow . It must be ...

  • Hearth and Home Technologies 823-0290 - page 17

    Page 17 Isle Royale W ood Stove R September 1, 2008 250-5763C OUTSIDE AIR TERMINA TION CAP (contains rodent screen) FLEX FLANGE 1 . Remove all materials from packing box. 2. Mount the ex ange (with pipe tting extending out), over the intake air opening at the rear of stove using the four mounting screws supplied with kit. 3. Cut a 4 inch ( ...

  • Hearth and Home Technologies 823-0290 - page 18

    R Page 18 September 1, 2008 Isle Royale W ood Stove 250-5763C BURNING PROCESS In recent years there has been an increasing concern about air quality . Much of the blame for poor air quality has been placed on the burning of wood for home heating. In order to improve the situation, we at Quadra-Fire have developed cleaner-burning wood stoves that su ...

  • Hearth and Home Technologies 823-0290 - page 19

    Page 19 Isle Royale W ood Stove R September 1, 2008 250-5763C FINAL ST AGE T he nal stage of burning is the charcoal stage. This occurs when the ammable gases have been mostly burned and only charcoal remains. This is a naturally clean portion of the burn. The coals burn with hot blue ames. It is very important to reload your stove while e ...

  • Hearth and Home Technologies 823-0290 - page 20

    R Page 20 September 1, 2008 Isle Royale W ood Stove 250-5763C W ARNING! AL W A YS OPERA TE THIS APPLI- ANCE WITH THE DOOR CLOSED AND LA TCHED EXCEPT DURING ST ART -UP AND RE-FUELING OR WHEN USING THE FIRESCREEN. NOTE: See page 21 for operation considerations with a blower installed. OPERA TING THE TOP LOADING OPTION NOTE : This stove is provided wi ...

  • Hearth and Home Technologies 823-0290 - page 21

    Page 21 Isle Royale W ood Stove R September 1, 2008 250-5763C W ARNING! DO NOT LEA VE THE FIRE UNA TTENDED WHEN THE DOOR IS UNLA TCHED OR WHEN USING THE FIRESCREEN. UNST ABLE FIREWOOD COULD F ALL OUT OF THE FIREBOX CREA TING A FIRE HAZARD TO YOUR HOME. OPERA TING INSTRUCTIONS (Cont’d) OP ACITY This helps to determine how cleanly your stove is bur ...

  • Hearth and Home Technologies 823-0290 - page 22

    R Page 22 September 1, 2008 Isle Royale W ood Stove 250-5763C OPERA TING INSTRUCTIONS (Cont’d) WOOD SELECTION AND STORAGE Burn only dry seasoned wood! This will not only minimize creosote formation, but also provide the most efcient heat output. Even dry wood contains at least 15% moisture by weight and should be burned hot enough to keep the ...

  • Hearth and Home Technologies 823-0290 - page 23

    Page 23 Isle Royale W ood Stove R September 1, 2008 250-5763C CHIMNEY CLEANING 1. Remove all ash from the rebox and extinguish all hot embers before disposal. Allow the stove to cool com - pletely . 2. Close the door tightly and proceed with sweeping the chimney . 3. Sweep the collected ashes into the ash removal box, and empty . Clean out the r ...

  • Hearth and Home Technologies 823-0290 - page 24

    R Page 24 September 1, 2008 Isle Royale W ood Stove 250-5763C N OTE: Remove all labels from glass prior to lighting  GLASS CARE 1. Ensure that the re is out and the appliance is cool to the touch. 2. Protect a table or counter top with padding or towels. 3. Remove door with broken glass from the appliance b ...

  • Hearth and Home Technologies 823-0290 - page 25

    Page 25 Isle Royale W ood Stove R September 1, 2008 250-5763C DOOR & GASKET Pe riod ica lly che ck the do or gas ket for pr oper se al. As the gasket compresses or “seats” during use, it may become necessary to adjust or tighten the door latch either by removing spacer washers, shown below (at least one washer must be left in place) or , by ...

  • Hearth and Home Technologies 823-0290 - page 26

    R Page 26 September 1, 2008 Isle Royale W ood Stove 250-5763C Service & Maintenance Log Date of Service Performed By Description of Service ...

  • Hearth and Home Technologies 823-0290 - page 27

    Page 27 Isle Royale W ood Stove R September 1, 2008 250-5763C 12 8 2 10 7 6 1 1 3 4 5 13 1 9 14 Exploded V iews 18 19 20 16 15 17 * Part number list on following page. ...

  • Hearth and Home Technologies 823-0290 - page 28

    R Page 28 September 1, 2008 Isle Royale W ood Stove 250-5763C Andiron Brackets, Pair 832-3610 Andirons with Brackets 844-8980 Ash Removal System Handle Assembly 472-5060 Ash Box Hinge 434-0310 Ash Lip Must specify color . 29125 Ash Pan 434-0330 Ash Removal Door 434-0300 1 1 Ash Removal Grate 834-4100 Bafe Assembly SRV434-5010 9 Bafe Back Plat ...

  • Hearth and Home Technologies 823-0290 - page 29

    Page 29 Isle Royale W ood Stove R September 1, 2008 250-5763C Item # Part Description Alphabetical Order SKU IMPORT ANT : THIS IS DA TED INFORMA TION. The most current information is located on the Quadra-Fire web site at   . When ordering, supply serial and model numbers to ensure correct part. Se ...

  • Hearth and Home Technologies 823-0290 - page 30

    R Page 30 September 1, 2008 Isle Royale W ood Stove 250-5763C Hearth & Home T echnologies LIMITED W ARRANTY Hearth & Home T echnologies (“HHT”) and its respective brands extends the following warranty for HHT gas, wood, pellet and electric appliances purchased from an authorized HHT dealer and installed in the United States of America o ...

  • Hearth and Home Technologies 823-0290 - page 31

    Page 31 Isle Royale W ood Stove R September 1, 2008 250-5763C  Noise resulting from minor expansion, contraction, or movement of certain parts is normal and complaints related to this noise are not covered by this warranty .  HHT’s obligation under this warranty does not extend to damages resulting from: (1) installation, operation or ...

  • Hearth and Home Technologies 823-0290 - page 32

    R September 1, 2008 Page 32 • Do NOT discard this manual. • Important operating and maintenance instructions included. • Read, understand and follow these instruci- tons for safe installation and operation. • Leave this manual with party responsible for use and operation. CAUTION This product may be covered by one or more of the following p ...

Manufacturer Hearth and Home Technologies Category Indoor Fireplace

Documents that we receive from a manufacturer of a Hearth and Home Technologies 823-0290 can be divided into several groups. They are, among others:
- Hearth and Home Technologies technical drawings
- 823-0290 manuals
- Hearth and Home Technologies product data sheets
- information booklets
- or energy labels Hearth and Home Technologies 823-0290
All of them are important, but the most important information from the point of view of use of the device are in the user manual Hearth and Home Technologies 823-0290.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Hearth and Home Technologies 823-0290, service manual, brief instructions and user manuals Hearth and Home Technologies 823-0290. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Hearth and Home Technologies 823-0290.

Similar manuals

A complete manual for the device Hearth and Home Technologies 823-0290, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Hearth and Home Technologies 823-0290 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Hearth and Home Technologies 823-0290.

A complete Hearth and Home Technologies manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Hearth and Home Technologies 823-0290 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Hearth and Home Technologies 823-0290, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Hearth and Home Technologies 823-0290, that we can find in the current document
3. Tips how to use the basic functions of the device Hearth and Home Technologies 823-0290 - which should help us in our first steps of using Hearth and Home Technologies 823-0290
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Hearth and Home Technologies 823-0290
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Hearth and Home Technologies 823-0290 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Hearth and Home Technologies 823-0290?

Use the form below

If you did not solve your problem by using a manual Hearth and Home Technologies 823-0290, ask a question using the form below. If a user had a similar problem with Hearth and Home Technologies 823-0290 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)