Manual Hearth and Home Technologies FB-IN-S

44 pages 2.47 mb
Download

Go to site of 44

Summary
  • Hearth and Home Technologies FB-IN-S - page 1

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 1 Model(s): FB-GRAND-S FB-IN-S • Do not store or use gasoline or other fl am- mable vapors and liquids in the vicinity of this or any other appliance. • What to do if you smell gas - Do not try to light any appliance - Do not touch any electrical switch. Do not use any phone ...

  • Hearth and Home Technologies FB-IN-S - page 2

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 2 Congratulations Listing Label Information/Location Model Name: ___________________________________________ Date purchased/installed: __________________ Serial Number: __________________________________________ Location on appliance: ____________________ Dealership purchased fro ...

  • Hearth and Home Technologies FB-IN-S - page 3

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certi fi cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 B. BTU Speci fi cations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 C. High Altitude Installations . . . . . . . . . . . ...

  • Hearth and Home Technologies FB-IN-S - page 4

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 4 Note : T o assure top performance, safety and ef fi ciency , inserts must be installed with an approved fl ue liner as per CAN/CGA B-149 or National Fuel Gas Code ANSI Z223 and these instructions. Not e: This installation must c onform wi th local c odes. In the absenc e of l ...

  • Hearth and Home Technologies FB-IN-S - page 5

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 5 Heat & Glo gas inserts are designed for recessed installa- tions into solid fuel masonry or factory built non-combustible fi replaces that have been installed in accordance with the National, Provincial, State and local building codes. Prior to installing the gas insert: ? ...

  • Hearth and Home Technologies FB-IN-S - page 6

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 6 D. Inspect Firebox Surface cracking or crazing of fi rebrick material is normal and expected. The following types of cracks are acceptable and do not require replacement of the unit or the fi rebox: • Cracks that do not propagate entirely thru the material. • Light fractu ...

  • Hearth and Home Technologies FB-IN-S - page 7

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 7 3 3 F ireplace Size Requirements Figure 3.1 Fireplace Opening NOTE: For actual appliance dimensions refer to Section 15. B 2 in. 50.8 mm A C TOP VIEW D FRONT VIEW MINIMUM FIREPLACE SIZE Location FB-GRAND-S FB-IN-S Inches Millimeters Inches Millimeters A Front Width 35 889 30-1/ ...

  • Hearth and Home Technologies FB-IN-S - page 8

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 8 B. Clearances Figure 3.2 Clearances to Mantels or other Combustibles above Appliance Fire Risk. • Locate and install appliance to all clearance speci fi cations in manual. Fire Risk. Odor Risk. • Clearance to combustible material under the insert is 1/4 inch (0.6 cm). • ...

  • Hearth and Home Technologies FB-IN-S - page 9

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 9 Fire Risk. Asphyxiation Risk. • T erminations MUST meet minimum clearances. • Exhaust gases are hot. • Nearby vents may draw fumes into house. A. V ent T ermination Minimum Clearances Figure 4.1 speci fi es minimum vent heights for various pitched roofs. Roof Pitch H (Mi ...

  • Hearth and Home Technologies FB-IN-S - page 10

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 10 CAUTION ALL vent speci fi cations MUST be followed. • This product is tested and listed to these speci fi cations. • Appliance performance will suffer if speci fi cations are not followed. Figure 5.1 C. Measuring Standards V ertical measurements listed in the vent diagr ...

  • Hearth and Home Technologies FB-IN-S - page 11

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 11 6 6 Installation Preparation Fire Risk. A hearth or hearth extension (if present) must comply with either of the following: • The solid fuel burning fi replace manufacturer’s speci fi cation. • Local building codes required by authority having jurisdiction. • NFPA 21 ...

  • Hearth and Home Technologies FB-IN-S - page 12

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 12 A. V enting Components 7 7 Installing V ent P ipe and Appliance The vertical vent termination system installed on this model includes: • One 3-foot section stainless steel fl exible pipe (included with insert). • One length of 3-inch fl exible vent pipe for combustion ai ...

  • Hearth and Home Technologies FB-IN-S - page 13

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 13 Figure 7.2 CUT AND BEND FLASHING AS NEEDED TO FIT CHIMNEY SEALANT ADHESIVE • T rim chimney top plate to minimize excess overhang or bend over fl ue tile (see Figure 7.2). • Place 3/8 inch bead of 300º F silicone on fl ue tile top. C. Placing, Securing and Leveling the A ...

  • Hearth and Home Technologies FB-IN-S - page 14

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 14 D. Installing Adaptor and T ermination Cap For installation of termination cap see minimum vent heights for various pitched roofs (see Figure 7.2) . T o install adaptor see Figure 7.3. Roof Pitch H (Min.) Ft. Flat to 6/12.................... 1.0* Over 6/12 to 7/12 ........1.25 ...

  • Hearth and Home Technologies FB-IN-S - page 15

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 15 • Ensure that gas line does not come in contact with outer wrap of appliance. Follow local codes. • Incoming gas line should be piped into the valve compartment and connected to the 1/2 inch connection on the manual shutoff valve. • Check all fi ttings and connections o ...

  • Hearth and Home Technologies FB-IN-S - page 16

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 16 Fire hazard. Do NOT change the valve settings. • This valve has been preset at the factory . • Changing valve settings may result in fi re hazard or bodily injury . HIGH AL TITUDE INST ALLA TIONS U.L. Listed gas appliances are tested and approved without requiring changes ...

  • Hearth and Home Technologies FB-IN-S - page 17

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 17 A. Wiring the Appliance 9 9 Elect rical Infor mation Note : This appliance must be electrically wired and grounded in accordance with local codes or , in the absence of local codes, with National Electric Code ANSI/NFP A 70-latest edition or the Canadian Electric Code, CSA C22 ...

  • Hearth and Home Technologies FB-IN-S - page 18

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 18 B. Junction Box Installation Figure 9.2 Junction box installation JUNCTION BOX SIDEW ALL FEED PLUG THROUGH HOLE INSERT STRAIN RELIEF AROUND CORD IN THIS END FROM OUTSIDE OF UNIT SCREW PROVIDED Optional Accessories Connecting the electrical junction box is required if using a b ...

  • Hearth and Home Technologies FB-IN-S - page 19

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 19 Figure 9.4 Fan Wiring Diagram NOTE: IF ANY OF THE ORIGINAL WIRE AS SUPPLIED WITH THE APPLIANCE MUST BE REPLACED, IT MUST BE REPLACED WITH TYPE 105 0 C RA TED WIRE. JUNCTION BOX V ARIABLE SPEED CONTROL TEMPERA TURE SENSOR SWITCH WHT GRN BLK BLK 1 10-120 V AC BLOWER BLOWER RECEP ...

  • Hearth and Home Technologies FB-IN-S - page 20

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 20 A. Mantel Projections Figure 10.1 shows the minimum vertical and corresponding maximum horizontal dimensions of appliance mantels or other combustible projections above the top front edge of the appliance, not the surround. See Figure 10.2 for required clearances when using Ha ...

  • Hearth and Home Technologies FB-IN-S - page 21

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 21 Figure 1 1.1 Placement of Embers EMBER MA TERIAL (TOP SURF ACE, AND FRONT) BURNER P AN AIR SHUTTER 1 1 11 Appliance Setup A. Remove Shipping Materials Remove shipping materials from inside or underneath the fi rebox. B. Clean the Appliance Clean/vacuum any sawdust that may ha ...

  • Hearth and Home Technologies FB-IN-S - page 22

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 22 Log Set Assembly: LOGS-CFXGB E. Positioning the Logs This model uses locating tabs to positively locate the logs with respect to the grate assembly . Please refer to grate assembly . LOG NUMBER 1 (SR V768-701): Place log #1 onto the grate. Push log back until it rests against ...

  • Hearth and Home Technologies FB-IN-S - page 23

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 23 LOG NUMBER 3 (SR V768-705): Position log #3 onto grate such that tab E fi ts into slot on bottom surface of log. Push down until log is sitting fl at on grate. LOG NUMBER 4 (SR V582-705): Place log #4 across both fl at spots on log #1 and log #3, with the “Y” in log #4 ...

  • Hearth and Home Technologies FB-IN-S - page 24

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 24 LOG PLACEMENT INSTRUCTIONS Carefully remove the logs from the packaging. CAUTION: Logs are fragile! 773-936B 10/07 GRA TE ASSEMBL Y This model uses locating tabs to positively locate the logs with respect to the grate assembly . Please refer to grate assembly . LOG #1 (SR V773 ...

  • Hearth and Home Technologies FB-IN-S - page 25

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 25 LOG #2 (SRV773-702): Position Log #2 onto grate such that tab C fi ts into the slot on bottom surface of log. LOG #3 (SR V768-704): Position log #3 onto grate such that the tab D fi ts into the slots on bottom surface of log and the right back side of log is fl ush against ...

  • Hearth and Home Technologies FB-IN-S - page 26

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 26 Figure 1 1.16 Glass Assembly F . Glass Assembly Removing Glass Assembly There are two glass latches on the bottom of glass assembly . • T o release glass assembly , pull latch forward and allow to retract away from glass assembly . • Remove glass assembly after both latche ...

  • Hearth and Home Technologies FB-IN-S - page 27

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 27 Fire Risk. Explosion Risk. Gas may build up while lighting pilot. • Remove glass assembly before lighting pilot. • Replace glass assembly after lighting pilot. A. Before Lighting Appliance This appliance has a Standing Pilot Ignition. Before operating this appliance have a ...

  • Hearth and Home Technologies FB-IN-S - page 28

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 28 B. Lighting Appliance Standing Pilot Ignition 1. T urn off all electric power to the appliance if service is to be performed. 2. Open control access panel. 3. Move switch to “OFF” position. 4. Push in gas control knob slightly and turn clock- wise to OFF”. Do not force. ...

  • Hearth and Home Technologies FB-IN-S - page 29

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 29 C. Check Pilot Flame Appearance Pilot fl ame must contact the thermocouple and thermopile for reliable appliance operation. • Pilot fl ame should be as shown in Figure 12.1. D. After Appliance is Lit Initial Break-in Procedure When you light the appliance, you may notice t ...

  • Hearth and Home Technologies FB-IN-S - page 30

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 30 E. Frequently Asked Questions Fire Risk. High T emperatures. Keep combustible household items away from appliance. Do NOT obstruct combustion and ventilation air . • Do NOT place combustible items on top of or in front of appliance. • Keep furniture, draperies away from ap ...

  • Hearth and Home Technologies FB-IN-S - page 31

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 31 A. Standing Pilot Ignition System 1 3 13 T roubleshooting With proper installation, operation, and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a quali fi ed service person in ...

  • Hearth and Home Technologies FB-IN-S - page 32

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 32 T roubleshooting (continued) Symptom Possible Cause Corrective Action 3. Continued c. Defective valve. T urn the valve knob to the ON position. Place the ON/OFF switch in the ON position. Check the millivolt meter a the thermopile terminals. The millivolt meter should read gre ...

  • Hearth and Home Technologies FB-IN-S - page 33

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 33 1 4 14 Maintaining and Ser vicing Appliance Although the frequency of appliance servicing and maintenance will depend on use and the type of installation, a quali fi ed service technician should perform an appliance checkup at the beginning of each heating season. Annual insp ...

  • Hearth and Home Technologies FB-IN-S - page 34

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 34 Inspect Maintenance T asks Doors, Surrounds and Fronts 1. Assess condition of screen and replace as necessary . Recommend addition of screen if one is not present. 2. Inspect for scratches, dents or other damage and repair as necessary . 3. V erify no obstructions to air fl o ...

  • Hearth and Home Technologies FB-IN-S - page 35

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 35 Figure 15.1 Appliance Dimensions D F E H G ELECTRICAL ACCESS (IF EQUIPPED) GAS INLET C A B 2-1/16 in. 52 mm 1-9/16 in. 40 mm 3-9/16 in. 91 mm 1-1/16 in. 28 mm 2-1/2 in. 64 mm 4 in. 102 mm 13-3/4 in. 350 mm 3-1/8 in. 80 mm 6-5/8 in. 169 mm Tw o ø 2-13/16 in. 71 mm 9-9/16 in. 1 ...

  • Hearth and Home Technologies FB-IN-S - page 36

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 36 B. V ent Kits Components Direct V ent Flex Liner Kits (see Figure 15.2) LINK-DV -30B or (LINK-DV -30): Masonry 3 inch fl ex liner kit. Expands to 30 feet. Includes: two liners, termination cap, fl ashing, and link adapter . LINK-DV4-30B or (LINK-DV4-30): Masonry 3 inch fl e ...

  • Hearth and Home Technologies FB-IN-S - page 37

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 37 C. Service Parts Service Parts Diagram FB-GRAND-S Beginning Manufacturing Date: Oct. 2007 Ending Manufacturing Date: ______ Part number list on following page. Log Set Assembly 1 2 3 4 5 6 7 10 11 8 9 ...

  • Hearth and Home Technologies FB-IN-S - page 38

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 38 Service Parts List FB-GRAND-S IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot I ...

  • Hearth and Home Technologies FB-IN-S - page 39

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 39 Service Parts Service Parts Diagram FB-IN-S Beginning Manufacturing Date: Oct. 2007 Ending Manufacturing Date: ______ Part number list on following page. Log Set Assembly 1 2 3 4 5 6 7 10 11 8 9 ...

  • Hearth and Home Technologies FB-IN-S - page 40

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 40 Service Parts List FB-IN-S IMPORT ANT THIS IS DA TED INFORMA TION: When Requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM D ...

  • Hearth and Home Technologies FB-IN-S - page 41

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 41 IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM DESCRIPTION COMMENTS P ART ...

  • Hearth and Home Technologies FB-IN-S - page 42

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 42 D. Limited Lifetime W arranty Hearth & Home T echnologies LIMITED W ARRANTY Hearth & Home T echnologies (“HHT”) and its respective brands extends the following warranty for HHT gas, wood, pellet and electric appliances purchased from an authorized HHT dealer and in ...

  • Hearth and Home Technologies FB-IN-S - page 43

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 43 D. Limited Lifetime W arranty (continued) • This limited warranty does not extend to or include surface fi nish on the appliance or terminations, door gasketing, glass gasketing, glass discoloration, fi rebrick, pellet logs, kaowool or other ceramic insulating materials. R ...

  • Hearth and Home Technologies FB-IN-S - page 44

    Heat & Glo • FB-IN-S, FB-GRAND-S • 783-910 Rev . G • 1 1/08 44 Heat & Glo, a brand of Hearth & Home T echnologies Inc. 7571 215th St., Lakeville, MN 55044 www .heatnglo.com E. Contact Information Please contact your Heat & Glo dealer with any questions or concerns. For the location of your nearest Heat & Glo dealer , pleas ...

Manufacturer Hearth and Home Technologies Category Indoor Fireplace

Documents that we receive from a manufacturer of a Hearth and Home Technologies FB-IN-S can be divided into several groups. They are, among others:
- Hearth and Home Technologies technical drawings
- FB-IN-S manuals
- Hearth and Home Technologies product data sheets
- information booklets
- or energy labels Hearth and Home Technologies FB-IN-S
All of them are important, but the most important information from the point of view of use of the device are in the user manual Hearth and Home Technologies FB-IN-S.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Hearth and Home Technologies FB-IN-S, service manual, brief instructions and user manuals Hearth and Home Technologies FB-IN-S. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Hearth and Home Technologies FB-IN-S.

A complete manual for the device Hearth and Home Technologies FB-IN-S, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Hearth and Home Technologies FB-IN-S by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Hearth and Home Technologies FB-IN-S.

A complete Hearth and Home Technologies manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Hearth and Home Technologies FB-IN-S - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Hearth and Home Technologies FB-IN-S, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Hearth and Home Technologies FB-IN-S, that we can find in the current document
3. Tips how to use the basic functions of the device Hearth and Home Technologies FB-IN-S - which should help us in our first steps of using Hearth and Home Technologies FB-IN-S
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Hearth and Home Technologies FB-IN-S
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Hearth and Home Technologies FB-IN-S in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Hearth and Home Technologies FB-IN-S?

Use the form below

If you did not solve your problem by using a manual Hearth and Home Technologies FB-IN-S, ask a question using the form below. If a user had a similar problem with Hearth and Home Technologies FB-IN-S it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)