Bedienungsanleitung Smith Cast Iron Boilers 19A SERIES

12 Seiten 0.26 mb
Download

Zur Seite of 12

Summary
  • Smith Cast Iron Boilers 19A SERIES - page 1

    19IOM-5 WESTCAST, INC. 260 NORTH ELM STREET WESTFIELD, MA 01085 TEL. (413) 562-9631 FAX (413) 562-3799 INST ALLER READ THESE INSTR UCTIONS CAREFULL Y . THEY WILL SA VE TIME IN ASSEMBLING BOILER 19A SERIES BOILER INST ALLA TION INSTR UCTIONS STEAM OR W A TER HEA TING PRESSURIZED FOR FIRING OIL, GAS OR COMBINA TION GAS/OIL DESIGNED AND TESTED ACCORDI ...

  • Smith Cast Iron Boilers 19A SERIES - page 2

    PAGE 2 19A SERIES BOILER INST ALLA TION INSTRUCTIONS — 3640 Bur ner Mounting Plate, P o werflame - 9 1 / 8 " Opening 13 60023 Bur ner Mounting Plate Rope, 1 / 4 " 14 60434 Bur ner Mounting Plate Insulating Block 14 60430 Bur ner Mounting Plate Insulating Block (Beck ett Burner) 15 60331 Upper P ort Hydronic Seal 16 60332 Lower P or t Hy ...

  • Smith Cast Iron Boilers 19A SERIES - page 3

    3. CODES AND REGULATIONS All work in connection with the boiler, burner and controls must be performed in strict accordance with requirements of state and local authorities having jurisdiction over boiler installations. FIGURE 1 In the absence of such local requirements, the following should govern: A.S.M.E. Section IV - “ Heating Boilers" A ...

  • Smith Cast Iron Boilers 19A SERIES - page 4

    CAUTION Due to the fact that the sections are top heavy, it is absolutely necessary that the back section be supported in such a manner as to prevent its falling and causing potential serious bodily injury while preparing to add the next section. One such way would be to insert a piece of 3" x 36" piping in the lower port. NOTE Some secti ...

  • Smith Cast Iron Boilers 19A SERIES - page 5

    2. Water Boilers – The assembled boiler shall be subjected to a hydrostatic test pressure not less than 1-1/2 times the maximum allowable working pressure. 3. The required test shall not exceed the test pressure by more than 10 PSI. Excessive torque on draw rods may damage castings. Do not exceed the torque shown in TABLE 3. In a cold environment ...

  • Smith Cast Iron Boilers 19A SERIES - page 6

    TABLE 5 Feed water makeup requirements. NOTE These recommendations are considered normal for compact buildings on the basis of 80% receiver use. Where buildings are spread out, additional receiver capacity may be necessary because of the extended time required for condensation to return to the receiver. 9. WATER PIPING See FIGURE 5 for acceptable w ...

  • Smith Cast Iron Boilers 19A SERIES - page 7

    FIGURE 6 — TANKLESS PIPING FIGURE 7 — DUAL TANKLESS PIPING 12. BURNER MOUNTING PLATE & TARGET WALL The new target wall used on 3-6 section boilers must be positioned with the flat side tight against the rear casting and with the bottom side resting on the floor of the combustion chamber. No glues or fasteners are used to secure the target w ...

  • Smith Cast Iron Boilers 19A SERIES - page 8

    19A SERIES BOILER INST ALLA TION INSTRUCTIONS PAGE 8 15. CONTROL LOCATIONS NOTE Jacket front panel should be in place before controls on front of front section are installed. Refer to FIGURE 11 showing locations recommended for steam and water boiler limit and operating controls. Note the requirement for an operating temperature control whenever a ...

  • Smith Cast Iron Boilers 19A SERIES - page 9

    19A SERIES BOILER INST ALLA TION INSTRUCTIONS 19. OWNERS INSTRUCTIONS A . For best performance of the boiler, the following suggestions should be performed by a qualified boiler room technician, through a regular program of maintenance and adjustment to obtain the following. 1. Oil burner combustion: 12 to 12 1/2 + % CO2, zero smoke, smooth lightof ...

  • Smith Cast Iron Boilers 19A SERIES - page 10

    19A SERIES BOILER INST ALLA TION INSTRUCTIONS FIGURE 11 PAGE 10 “A” - 1" TAP, PRESSURE CONTROLS “B” - 1 1/4" TAP, STEAM SAFETY VALVE “C” - 1" TAP, OPTIONAL LWCO “D” - 3/4" TAP “A” “B” VENT CONNECTION 3/4" TAP STD. 3" “A” 4" TAP CLEANOUTS 3" RETURN TAP NORMAL STEAM WATER LINE OPTION ...

  • Smith Cast Iron Boilers 19A SERIES - page 11

    19A SERIES BOILER INST ALLA TION INSTR UCTIONS vision problems loss of muscle control weakness dizziness headaches nausea W ARNING shortness of breath unclear thinking unconsciousness Any appliance that burns natural gas, propane gas, fuel oil, wood or coal is capable of producing carbon monoxide (CO). Carbon Monoxide (CO) is a gas which is odorles ...

  • Smith Cast Iron Boilers 19A SERIES - page 12

    WESTCAST, INC. 260 NORTH ELM STREET WESTFIELD, MA 01085 TEL. (413) 562-9631 FAX (413) 562-3799 ...

Produzent Smith Cast Iron Boilers Kategorie Boiler

Dokumente, die wir vom Produzenten des Geräts Smith Cast Iron Boilers 19A SERIES erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Smith Cast Iron Boilers
- Bedienungsanleitungen 19A SERIES
- Produktkarten Smith Cast Iron Boilers
- Informationsbroschüren
- oder Energieetiketten Smith Cast Iron Boilers 19A SERIES
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Smith Cast Iron Boilers 19A SERIES.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Smith Cast Iron Boilers 19A SERIES, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Smith Cast Iron Boilers 19A SERIES. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Smith Cast Iron Boilers 19A SERIES ansehen.

Die komplette Bedienungsanleitung des Geräts Smith Cast Iron Boilers 19A SERIES, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Smith Cast Iron Boilers 19A SERIES hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Smith Cast Iron Boilers 19A SERIES verständlich ist.

Eine gänzliche Bedienungsanleitung von Smith Cast Iron Boilers sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Smith Cast Iron Boilers 19A SERIES bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Smith Cast Iron Boilers 19A SERIES befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Smith Cast Iron Boilers 19A SERIES, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Smith Cast Iron Boilers 19A SERIES - die uns die ersten Schritte während der Nutzung von Smith Cast Iron Boilers 19A SERIES erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Smith Cast Iron Boilers 19A SERIES hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Smith Cast Iron Boilers 19A SERIES im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Smith Cast Iron Boilers 19A SERIES?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Smith Cast Iron Boilers 19A SERIES nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Smith Cast Iron Boilers 19A SERIES hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)