-
Nilfisk-ALTO SPS-28 E - page 1
Form No. 70100B 4/99 CLARKE TECHNOLOGY Printed in the U.S. A. READ THIS BOOK This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your ALTO machine could result in injury to you or to other personnel; damage to the machi ...
-
Nilfisk-ALTO SPS-28 E - page 2
Page 2 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Table of Contents Operator Safety Instructions ................................................................................... 3 Operator Safety Instructions Battery Powered Machine .......................................... 4 Introduction & Machine Specifications .. ...
-
Nilfisk-ALTO SPS-28 E - page 3
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 3 OPERATOR SAFETY INSTRUCTIONS DANGER means: Severe bodily injury or death can occur to you or other personnel if the DAN- GER statements found on your machine or in your Owner's Manual are ignored or are not adhered to. Read and observe all DANGER statements found in you ...
-
Nilfisk-ALTO SPS-28 E - page 4
Page 4 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual CAUTION: Connect or disconnect the battery plug only when the charger supply cord is disconnected or arcing and burning may result. CAUTION: D o not expose to rain. Replace defective cords immediately. If the charger is dropped or other- wise damaged, inspect it thoroughly. ...
-
Nilfisk-ALTO SPS-28 E - page 5
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 5 INTRODUCTION The Model SPS-28 will effectively and efficiently sweep your floors at minimum cost, provided you operate this machine with reasonable care and maintain it in accordance with the intructions contained in this operator's manual. SPECIFICA TIONS Gasoline Engi ...
-
Nilfisk-ALTO SPS-28 E - page 6
Page 6 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual How to Prepare The Machine for Operation Model 28G (Gasoline Powered) NOTE: Do not attempt to operate the CLARKE Model SPS-28 before reading the instructions in this manual. WARNING: T o prevent injury , always wear protec- tive clothing. Do not wear loose cloth- ing. Before ...
-
Nilfisk-ALTO SPS-28 E - page 7
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 7 How to Prepare The Machine for Operation 1. Before starting the SPS-28B lift the battery box cover and make sure the battery cables are connected. 2. Place all controls in "NEUTRAL". 3. Turn OFF/ON switch to "ON" position. (Switch is located on left side, ...
-
Nilfisk-ALTO SPS-28 E - page 8
Page 8 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual HOW TO OPERATE THE MACHINE NOTE: Do not attempt to operate the CLARKE Model SPS-28 before reading the instructions in this manual. WARNING: To prevent injury , always wear protec- tive clothing. Do not wear loose cloth- ing. WARNING: Do not check the engine oil level when th ...
-
Nilfisk-ALTO SPS-28 E - page 9
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 9 HOW TO OPERATE THE MACHINE (cont) How to Operate the Side Broom (Optional): 1. Engage the side broom in "SWEEP" position by grasping the head assembly, pulling forward and rotating downward until the pin in the arm assembly is against the stop on the locating colla ...
-
Nilfisk-ALTO SPS-28 E - page 10
Page 10 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual HOW TO OPERATE THE MACHINE (cont) How to Empty Debris Hopper: WARNING: T o prevent injury , always stop the en- gine or motor before you empty the hoppers or clean the filter. 1. Grasp the hopper by the handle provided and lift out until clear of frame. 2. Dump debris in ap ...
-
Nilfisk-ALTO SPS-28 E - page 11
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 11 SPS-28 Space Sweeper (INCL UDES 28G & 28B) Section II Parts and Service Manual (70100B) ...
-
Nilfisk-ALTO SPS-28 E - page 12
Page 12 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual SERVICE AND MAINTENANCE WARNING: Maintenance and repairs must be done by authorized personnel only. Keep Adjustments according to specifications. WARNING: T o prevent injury always stop the en- gine or motor before doing any mainte- nance or repairs to this machine. Sepa- r ...
-
Nilfisk-ALTO SPS-28 E - page 13
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 13 Drive Belts WARNING: T o prevent injury always stop the engine or motor before doing any maintenance or repairs to this ma- chine. The drive belts are automatically tensioned by a spring- loaded idler wheel. (See Fig. 9) 1. Remove the idler pulley tension spring. 2. Slip th ...
-
Nilfisk-ALTO SPS-28 E - page 14
Page 14 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Installation of New Main Brush (cont) Remove the three screws and washers and the bristle strip retained by them. Install the new strip and assemble the retaining screws and washers. Be sure to install the "V" of each strip in the same relation to the core as its ...
-
Nilfisk-ALTO SPS-28 E - page 15
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 15 Cap acitor T est If a commercial capacitor checker is not available, the following test may be made: 1. Briefly short the capacitor terminals together with a screwdriver . 2. Disconnect a wire from either capacitor terminal. 3. Adjust an ohmmeter to a high value such as RX1 ...
-
Nilfisk-ALTO SPS-28 E - page 16
Page 16 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual CLARKE TECHNOLOGY Model SPS-28 Main Frame, Brush Assembly and Drive System Drawing 1/99 87 86 95 28 42 77 75 76 74 4 5 6 24 25 26 71 96 70 3 96 4 78 22 36 67 37 22 88 49 32 33 62 69 49 60 25 57 56 55 52 54 53 90 34 52 51 82 65 49 82 84 83 82 73 4 4 5 6 25 26 70 31 24 69 68 ...
-
Nilfisk-ALTO SPS-28 E - page 17
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 17 CLARKE TECHNOLOGY Model SPS-28 Main Frame, Brush Assembly and Drive System Parts Lists 1/99 Ref # Part No. Description Qty 1 790322 Arm, Lower Clutch, R.H. 1 2 925543 Pin, 1 / 8 x 1¼ Roll 3 3 920349 Nut, ¼-20 3 4 920160 Nut 5 / 16 - 18 Hx Jam 6 5 980652 Washer 5 / 16 Lock ...
-
Nilfisk-ALTO SPS-28 E - page 18
Page 18 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual CLARKE TECHNOLOGY Model SPS-28 Engine, Dust Control & Handle Assembly Drawing 4/99 34 11 31 41 42 26 11 27 39 37 38 37 36 35 34 33 32 31 30 29 28 43 45 44 43 84 89 86 87 88 85 83 26 13 95 14 16 26 90 18 19 21 20 83 34 1 77 34 7 82 34 6 5 4 96 55 3 17 91 83 92 8 9 94 25 ...
-
Nilfisk-ALTO SPS-28 E - page 19
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 19 CLARKE TECHNOLOGY Model SPS-28 Engine, Dust Control & Handle Assembly 4/99 Ref # Part No. Description Qty 1 60072A F ra me , Main 1 2 u 792920 Engine, 5 H.P . Briggs and Stratton 1 3 285161 Label, Gasoline 1 4 722824 Elbo w , ¼ x 45° Street Brass 1 5 755721 Nipple, ¼ ...
-
Nilfisk-ALTO SPS-28 E - page 20
Page 20 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual CLARKE TECHNOLOGY Model SPS-28 Hopper and Optional Sidebroom Assembly Drawing 1/99 49 34 BOTTOM TO P 27 28 51 52 50 53 54 55 52 OPTIONAL SIDE BROOM ASSEMBL Y 62 43 43 44 45 46 41 48 13 40 39 38 37 57 58 61 32 33 33 32 35 36 29 30 31 20 42 14 64 65 26 47 7 6 5 2 4 25 6 7 3 8 ...
-
Nilfisk-ALTO SPS-28 E - page 21
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 21 CLARKE TECHNOLOGY Model SPS-28 Hopper and Optional Sidebroom Assembly Parts List 1/99 Ref # Part No. Description Qty 1 60075A Hopper 1 2 798529 Support, Hopper T op 1 3 930090 Rivet, 5 / 32 Dia. 8 4 725197 Label, Clarke 1 5 793921 Handle, Hopper 1 6 798203 Spacer , Carrying ...
-
Nilfisk-ALTO SPS-28 E - page 22
Page 22 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual CLARKE TECHNOLOGY Model SPS-28 Battery P owered Model Drawing 1/99 7 5 14 14 13 11 12 16 11 12 16 18 17 46 26 45 44 55 37 36 24 3 49 43 12 11 19 19 21 36 20 6 27 26 50 24 22 54 25 2 53 23 51 1 28 29 30 31 32 33 34 35 40 42 36 41 39 38 47 48 36 37 41 52 23 30 30 4 ...
-
Nilfisk-ALTO SPS-28 E - page 23
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 23 CLARKE TECHNOLOGY Model SPS-28 Battery P owered Model Drawing 1/99 Ref # Part No. Description Qty 1 60071A Co v er Assembly , Battery Access 1 2 962003 Screw , 6 / 32 x 3 / 8 Rd. Hd. 4 3 930093 R iv et, 1 / 8 x 1 / 4 - 5 / 16 Po p 4 4 871376 Battery , 95 Amp Hr . (W et) 2 8 ...
-
Nilfisk-ALTO SPS-28 E - page 24
Page 24 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual CLARKE TECHNOLOGY Model SPS-28 Wiring Diagram & Electrical Schematic 1/99 ...
-
Nilfisk-ALTO SPS-28 E - page 25
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 25 CLARKE TECHNOLOGY Model SPS-28 Wiring Diagram 1/99 Ref # Part No. Description Qty 1 871376 Batter y , 95 amp Hr . (W et) 2 871377 Battery , 95 amp Hr . (Dr y) 2 2 41207A Cable, Battery 1 3 911470 Connector 1 4 951006 Wire Assembly 1 5 855607 Hour Meter (Optional) 1 6 911440 ...
-
Nilfisk-ALTO SPS-28 E - page 26
Page 26 CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual NOTE S ...
-
Nilfisk-ALTO SPS-28 E - page 27
CLARKE TECHNOLOGY Model SPS-28 Space Sweeper Operator's Manual Page 27 AL T O ® PRODUCT SUPPORT BRANCHES PRODUCTION F A CILITIES AL T O Danmark A/S, Aalborg Blytaekkervej 2 DK-9000 Aalborg +45 72 18 21 00 AL T O Danmar k A/S, Hadsund Industrikvar teret DK-9560 Hadsund +45 72 18 21 00 SALES SUBSIDIARIES AL T O Canada Ltd., Rexdale Ontario 24 C ...
-
Nilfisk-ALTO SPS-28 E - page 28
CLARKE TECHNOLOGY LIMITED U.S. W ARRANTY This Clarke Industrial/Commercial Product is warranted to be free from defects in materials and workmanship under normal use and service for a period of one year from the date of purchase, when operated and maintained in accordance with Clarke's Maintenance and Operations instructions. This warranty is ...
Haben Sie eine Frage bezüglich Nilfisk-ALTO SPS-28 E?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Nilfisk-ALTO SPS-28 E nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Nilfisk-ALTO SPS-28 E hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.