-
Ford SK5W7J-19A361-AA - page 1
1/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 W ARNING! REMOTE ST ART SYSTEMS ARE ONL Y APPLICABLE TO VEHICLES WITH AUTOMA TIC TRANSMISSION! BOTH ORIGINAL KEYS ARE REQUIRED FOR ALL REMOTE ST ART SYSTEMS ON VEHICLES EQUIPPED WITH SECURILOCK! EXPERT FITMENT REQUIRED Subject to Change Without Notice INST ALLA TION AND T ...
-
Ford SK5W7J-19A361-AA - page 2
2/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 T ABLE OF CONTENTS READ ME FIRST ........................................................................................................... 3 KIT CONTENTS ................................................................................................................... ...
-
Ford SK5W7J-19A361-AA - page 3
3/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 READ ME FIRST For convenience this document uses short names when referring to a particular system or kit. The list below identifies the short names used herein: Remote S tart System with Deluxe V ehicle Security and Keyless Entry —> RKE/VSS/RMST Remote S tart System ...
-
Ford SK5W7J-19A361-AA - page 4
4/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 A E I O B F J P C G K D H L KIT CONTENTS WARNING: / AVERTISSEMENT This vehicle is equipped with a remote controlled engine starter. To reduce the risk of serious Injury or death, switch engine starter system into service mode and disconnect the vehicle battery before perf ...
-
Ford SK5W7J-19A361-AA - page 5
5/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 S W AA T X BB U Y CC V Z P ARTS BAG CONTENTS DD 5A 15A 750 OHM 1800 OHM 1X 1X 2X 6X 2X 5X 10X 1X 2X 7X 1X PC-12 - 4X PC-32 - 7X NOTE: Part bag contents are not available as service items ...
-
Ford SK5W7J-19A361-AA - page 6
6/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 2W7Z-19G364-AA Remote St art System w/Deluxe V ehicle Security and Keyless Entry Kit (RKE/VSS/RMST) REF DESCRIPTION QTY A PC-32 MODULE ASSEMBL Y 1 B RKE/VSS/RMST DNA ASSEMBL Y (2W7J-19G367-BA) 1 C 4 BUTTON POWERCODE TRANSMITTER W/REMOTE ST ART ICONS 2 I 24-W A Y WIRING HA ...
-
Ford SK5W7J-19A361-AA - page 7
7/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 2W7Z-19G364-CA Remote St art System Kit (RMST) REF DESCRIPTION QTY A PC-32 MODULE ASSEMBL Y 1 B RMST DNA ASSEMBL Y (2W7J-19G367-CA) 1 F 2 BUTTON POWERCODE TRANSMITTER W/REMOTE ST ART ICON 2 I 24-W A Y WIRING HARNESS (BASE) 1 K 10-W A Y WIRING HARNESS (CAR ST ART FUNCTIONS ...
-
Ford SK5W7J-19A361-AA - page 8
8/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 2W7Z-19A361-CA V ehicle Security and Keyless Entry Kit (RKE/VSS) REF DESCRIPTION QTY A PC-12 MODULE ASSEMBL Y 1 B RKE/VSS DNA ASSEMBL Y (2W7J-19A498-CA) 1 C 2 BUTTON POWERCODE TRANSMITTER W/LOCK, UNLOCK ICONS 2 I 24-W A Y WIRING HARNESS (BASE) 1 L ST A TUS INDICA T OR ASS ...
-
Ford SK5W7J-19A361-AA - page 9
9/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 MODULE PREP ARA TION Place the supplied fuses into the power distribution block on the control module. Refer to the fuse placement drawing for the specific vehicle that you are working on. Fuse placement drawings are located in vehicle specific wiring sections. In this di ...
-
Ford SK5W7J-19A361-AA - page 10
10/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 MODULE PREP ARA TION (Cont’t) T ape the harness sections together , making sure to cover all of the unused wires. 4 5 Unused wires S teering column harness Driver kick panel harness Referring to the vehicle specific wiring section for the system being installed, gather ...
-
Ford SK5W7J-19A361-AA - page 11
11/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 VEHICLE PREP ARA TION All models except LS, T -Bird, Escort, Econoline and Super-Duty Pick-ups, remove the steering column shroud to allow access to the P A TS transceiver antenna ring around the ignition switch lock cylinder . A. T o allow access to the necessary vehicl ...
-
Ford SK5W7J-19A361-AA - page 12
12/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 DIPOLE ANTENNA MOUNTING 2 1 The optimum operating range for this system is dependant upon proper selection of the mounting location for the Dipole antenna. • Never mount the antenna behind (or on) any metal film or metal film window tint on the windshield. • Never mo ...
-
Ford SK5W7J-19A361-AA - page 13
13/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 ST A TUS LED Identify a suitable mounting location for the status LED. Make sure that there is at least 3/4” clearance behind the selected mounting location. 1 Drill a 9/32” mounting hole. If necessary , remove the selected trim panel 2 3 4 Insert status LED into dri ...
-
Ford SK5W7J-19A361-AA - page 14
14/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 SECURILOCK INTERF ACE KITS - 1L2Z-19G365-AB & 1S4Z-19G365-AB Route the loop end of Securilock interface antenna ( B ) up along steering column to the area around the P A TS transceiver antenna coil. Then using the supplied small tie wraps, secure the antenna harness ...
-
Ford SK5W7J-19A361-AA - page 15
15/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 SECURILOCK INTERF ACE KITS - 1L2Z-19G365-AB & 1S4Z-19G365-AB (Con’t) Carefully unwrap four (4) inches of the twisted red wire away from the Securilock P A TS antenna loop ( B ). 4 5 6 B A . Use a tie wrap ( Y ) to complete the bottom of the antenna loop as shown. M ...
-
Ford SK5W7J-19A361-AA - page 16
16/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 SECURILOCK INTERF ACE KITS - 1L2Z-19G365-AB & 1S4Z-19G365-AB (Con’t) V ehicle wiring harness X A A. Using the unwrapped red lead wire make an additional wrap around the Securilock P A TS antenna loop as close as possible to the stripe (red or Black) on the Securilo ...
-
Ford SK5W7J-19A361-AA - page 17
17/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 SECURILOCK INTERF ACE KIT - 1L3Z-19G365-AB Route the loop end of P A TS interface antenna ( B ) lead up along steering column to area around transceiver antenna coil. Slip antenna loop ( B ) over P A TS transceiver . 2 3 1 A B C B V ehicle wiring harness X A SECURILOCK K ...
-
Ford SK5W7J-19A361-AA - page 18
18/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Locate a suitable mounting location that away from hot and/or moving vehicle/engine components. SIREN INST ALLA TION Mount siren using screws provided (BB). Apply rustproofing compound (Super Seal #F3AZ-19515-SA) to drilled holes and mounting screws. Locate a vehicle gro ...
-
Ford SK5W7J-19A361-AA - page 19
19/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 2x Locate an easy to access area near the drivers side hood hinge. Mount the hood safety switch using the supplied sheet metal screws (BB) so that the switch will be biased downward when the hood is closed. Route the wire carefully avoiding any moving part s or excessive ...
-
Ford SK5W7J-19A361-AA - page 20
20/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 MOUNTING THE CONTROL MODULE 1 3 T o Securilock module T rim and tape off WHITE RF Antenna A. Using the supplied long tie wraps (X), mount the control module to underdash wiring harnesses and/ or dash mounting brackets. Module mounting locations are provided on the last p ...
-
Ford SK5W7J-19A361-AA - page 21
21/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 SYSTEM WIRING CONNECTIONS 1 A. Finish routing the systems wiring harnesses to their destination points and secure all system wiring using the supplied tie wraps (Y). B. Make the wiring connections as shown. V ehicle specific wiring diagrams begin on page 42. Make sure to ...
-
Ford SK5W7J-19A361-AA - page 22
22/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 T ransmitter programming: A . Open the driver ’ s door (press and hold in brake pedal on Remote S tart only system); NOTE: On vehicles with negative polarity door ajar switch input circuits (Refer to the vehicle specific programming section), the door is closed during ...
-
Ford SK5W7J-19A361-AA - page 23
23/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 T o change the setting of an option (VSS system): A. Press the door trim “Lock” switch to advance to the desired option (refer to the programming charts on the following pages for the specific system that you are programming; The horn will chirp a number of times to ...
-
Ford SK5W7J-19A361-AA - page 24
24/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Securilock (P A TS) Interface Programming and Remote Start Operation T est (two programmed P A TS ignition keys are required for this step) NOTE: This step does not apply to Econoline, SuperDuty Pick-ups and Escort A . Sitting in the driver seat, be prepared to press the ...
-
Ford SK5W7J-19A361-AA - page 25
25/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 System Programming Instructions - Security/Convenience Function T est Convenience Functions All Door Lock / All Door Unlock Driver door unlock (if installed) Parking light flash Trunk or hatch release Illuminated entry Ignition triggered lock/unlock (if enabled) Illumina ...
-
Ford SK5W7J-19A361-AA - page 26
26/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 SECURILOCK INTERF ACE AND RELA Y APPLICA TION CHART Note: Application information is also located in the vehicle specific wiring section Model Year / Model Rela y Re q uirements 2002 Securilock Interface Kit Headlight Rear Defroster Driver Door Unlock Other Crown Victori ...
-
Ford SK5W7J-19A361-AA - page 27
27/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 SECURILOCK INTERF ACE AND RELA Y APPLICA TION CHART Note: Application information is also located in the vehicle specific wiring section Model Year / Model Rela y Re q uirements 2004 Securilock Interface Kit Headlight Rear Defroster Driver Door Unlock Other Aviator 1L2Z- ...
-
Ford SK5W7J-19A361-AA - page 28
28/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 SECURILOCK INTERF ACE AND RELA Y APPLICA TION CHART Model Year / Model Rela y Re q uirements 2006 Securilock Interface Kit Headlight Rear Defroster Driver Door Unlock Other Crown Victoria/Grand Marquis 1L2Z-19G365-AB 1 Econoline Not Equipped 1 Escape 1S4Z-19G365-AB F-250 ...
-
Ford SK5W7J-19A361-AA - page 29
29/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Option Bank 1 – 4 chirp s 1 – Lite-touch adjustment 2 – Full shock adjustment 3 – Optional alarm disable Disables security functionality . ............................................................................................... ..................... Off 4 ...
-
Ford SK5W7J-19A361-AA - page 30
30/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Option Bank 4 – 7 chirp s 1 – Headlight Output Time (used only when option #5 below is in the LED Off position)* LED On – 20 seconds, LED Off – .5 seconds ..................................................................................... ...... On (20 sec.) 2 ...
-
Ford SK5W7J-19A361-AA - page 31
31/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Option Bank 1 – 4 chirp s 1 – Passive starter Interrupt S tarter interrupt activates 1 minutes after key off event. ..................................................................... ....... Off 2 – Passive door locks All doors lock automatically 1 minutes after ...
-
Ford SK5W7J-19A361-AA - page 32
32/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Option Bank 4 – 7 chirp s 1 –Headlight Output Time (used only when option #5 below is in the LED Off position)* LED On – 20 seconds, LED Off – .5 seconds ..................................................................................... ...... On (20 sec.) 2 ? ...
-
Ford SK5W7J-19A361-AA - page 33
33/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 RMST OPTION CHART Factory setting Factory setting Option Bank 1 – 4 chirp s 1 – Selectable chirp s Enables arming/disarming confirmation chirps (uses horn). ...................................................................... On 2 – Horn used for alarm Horn sound ...
-
Ford SK5W7J-19A361-AA - page 34
34/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Deluxe RKE/VSS OPTION CHART Factory setting Factory setting Factory setting Option Bank 1 – 4 chirp s 1 – Lite-touch adjustment 2 – Full shock adjustment 3 – Optional alarm disable Disables security functionality . ................................................ ...
-
Ford SK5W7J-19A361-AA - page 35
35/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 RKE/VSS & VSS OPTION CHART Factory setting Factory setting Factory setting Option Bank 1 – 4 chirp s 1 – Lite-touch adjustment 2 – Full shock adjustment 3 – Optional alarm disable Disables security functionality . ............................................. ...
-
Ford SK5W7J-19A361-AA - page 36
36/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 RKE OPTION CHART Factory setting Factory setting Factory setting Option Bank 1 – 4 chirp s 1 – Lite-touch adjustment 2 – Full shock adjustment 3 – Optional alarm disable Disables security functionality . ........................................................... ...
-
Ford SK5W7J-19A361-AA - page 37
37/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Option Bank 1 – 4 chirp s 1 – Lite-touch adjustment 2 – Full shock adjustment 3 – Optional alarm disable Disables security functionality . ............................................................................................... ..................... Off 4 ...
-
Ford SK5W7J-19A361-AA - page 38
38/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 5 1 2 3 4 6 7 8 9 10 11 12 13 14 15 16 9 10 11 12 1 2 3 4 5 6 7 8 13 14 15 16 17 18 19 20 21 22 23 24 2 3 5 1 4 6 7 8 9 1 0 WIRE END VIEWS A MAIN HARNESS B CAR ST AR T B EXTENDED FUNCTION WIRING HARNESS LEGEND Main Harness (24-way) T erminal Wire Color Function A-1 WHITE ...
-
Ford SK5W7J-19A361-AA - page 39
39/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Circuit T esting - Identifying Circuit Polarity 1 DC V olts Digital V olt Meter (DVM) set to “DC V olts”. Negative lead (Black) connected to a chassis ground. Positive lead (Red) connected to circuit under test. Observe reading from meter . 2 Actuate the circuit unde ...
-
Ford SK5W7J-19A361-AA - page 40
40/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 1 Inline wire splice procedure Wire Connection Procedures Wire From Powercode Harness Cut T arget Wire In V ehicle Heat Shrint T ubing Wih Hot Melt Wax NOTE: TO INSURE PROPER INST ALLA TION, USE THE FOLLOWING GUIDELINES: APPL Y FLOCK T APE T O SHARP OR JAGGED AREAS DURIN ...
-
Ford SK5W7J-19A361-AA - page 41
41/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 2 Ended Wire Splice Procedure Wire Connection Procedures NOTE: TO INSURE PROPER INST ALLA TION, USE THE FOLLOWING GUIDELINES: APPL Y FLOCK T APE T O SHARP OR JAGGED AREAS DURING INST ALLA TION OF WIRE HARNESS APPL Y FLOCK T APE TO WIRENESS IN AREAS WHERE SQUEAK AND RA TT ...
-
Ford SK5W7J-19A361-AA - page 42
42/42 SK5W7J-19A361-AA © Copyright Ford 2005 2W7Z-16A901-AA Rev Date- 8/29/05 Color Function A-5 BLACK Ground A-20 GREEN/VIOLET Door Ajar Switch Input A-3 BLACK/WHITE Dome Light Output A-2 BLUE Door Lock Output A-14 GREEN Door Unlock Output A-12 L T .GREEN Unlock Switch Sense Input A-11 WHITE/BLUE Ar m Input C-4 L T GREEN/BLACK Factory alarm disar ...
Haben Sie eine Frage bezüglich Ford SK5W7J-19A361-AA?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Ford SK5W7J-19A361-AA nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Ford SK5W7J-19A361-AA hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.