Bedienungsanleitung Avalon Stoves 21 DV Fireplace

50 Seiten 2.55 mb
Download

Zur Seite of 50

Summary
  • Avalon Stoves 21 DV Fireplace - page 1

    21 D V F i r ep l ace Featuring the Burner Tested and Listed by OMNI-Test Laboratories, Inc. Beaverton, Oregon Report # 028-S-53-5 ANSI Z21.88 • Built-In Direct Vent Fireplace • Natural Gas or Propane • Residential or Mobile Home WARNING: If the information in these instructions is not followed exactly, a fire or explosion may result causing ...

  • Avalon Stoves 21 DV Fireplace - page 2

    2 Introduction © Travis Industries 4040830 100-01143 Introduction We welcome you as a new owner of a 21 DV gas fireplace. In purchasing this fireplace you have joined the growing ranks of concerned individuals whose selection of an energy system reflects both a concern for the environment and aesthetics. It is one of the finest home heaters the wo ...

  • Avalon Stoves 21 DV Fireplace - page 3

    Table of Contents 3 © Travis Industries 4040830 100-01143 Introduction and Important Information Introduction ......................................................2 Safety Precautions Safety Precautions ............................................4 Features & Specifications Features ..........................................................6 ...

  • Avalon Stoves 21 DV Fireplace - page 4

    4 Safety Precautions © Travis Industries 4040830 100-01143 IF YOU SMELL GAS: D o not light any appliance E xtinguish any open flame D o not touch any electrical switch or plug or unplug anything O pen windows and vacate building C all gas supplier from neighbor's house, if not reached, call fire department This unit must be installed b y a qu ...

  • Avalon Stoves 21 DV Fireplace - page 5

    Safety Precautions 5 © Travis Industries 4040830 100-01143 Do not place clothin g or other flammable items on or near the heater. Because this heater can be controlled by a thermostat there is a possibility of the heater turning on and igniting any items placed on or near it. Li g ht the heater usin g the built- in piezo igniter. Do not use matche ...

  • Avalon Stoves 21 DV Fireplace - page 6

    6 Features and Specifications © Travis Industries 4040830 100-01143 Features • Works During Power Outages (millivolt system) • High Efficiency • Optional Thermostat or Remote Control • Realistic "Wood Fire" Look • Quiet Blower for Effective Heat Distribution • Convenient Operating Controls • Variable-Rate Heat Output • Lo ...

  • Avalon Stoves 21 DV Fireplace - page 7

    Installation (for qualified installers only) 7 © Travis Industries 4040830 100-01143 Installation Warnings • Failure to follow all of the requirements may result in property damage, bodily injury, or even death. • This heater must be installed by a qualified installer who has gone through a training program for the installation of direct vent ...

  • Avalon Stoves 21 DV Fireplace - page 8

    8 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Installation Overview • All requirements below must be met. See the section "Termination Requirements" Drywall Non-combustible facing (see the section "Facing Requirements") Gas Line (left side or beneath) See the section "Mantel Require ...

  • Avalon Stoves 21 DV Fireplace - page 9

    Installation (for qualified installers only) 9 © Travis Industries 4040830 100-01143 Fireplace Placement Requirements Minimum Framing Dimensions The fireplace requires a 1/2" space between the fireplace and the framing members (or other materials) along the sides and back of the fireplace. The stand-offs (and nailing brackets) may contact the ...

  • Avalon Stoves 21 DV Fireplace - page 10

    10 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Nailing Brackets For installations using 1 ” facing (1/2 ” drywall with 3/8 ” tile, 7/8 ” tile, etc.) fold the shorter tab out 90 ° . For installations using 1/2 ” facing (1/2 ” drywall or other facing) fold the larger tab out 90 ° . Fireplace Drywa ...

  • Avalon Stoves 21 DV Fireplace - page 11

    Installation (for qualified installers only) 11 © Travis Industries 4040830 100-01143 Corner Installations A typical 45° installation uses the minimum framing dimensions shown in the illustration to the right (NOTE: all clearances still apply). The recommended dimensions shown to the right allow additional space, easing gas line and electrical co ...

  • Avalon Stoves 21 DV Fireplace - page 12

    12 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Gas Line Requirements MASSACHUSETTS INSTALLATIONS - WARNING: THIS PRODUCT MUST BE INSTALLED BY A LICENSED PLUYMBER OR GAS FITTER WHEN INSTALLED WITHIN THE COMMONWEALTH OF MASSACHUSETTS. OTHER MASSACHUSETTS CODE REQUIREMENTS: • Flexible connector must not be lon ...

  • Avalon Stoves 21 DV Fireplace - page 13

    Installation (for qualified installers only) 13 © Travis Industries 4040830 100-01143 Optional Gas Line Location Remove the two screws near the gas inlet (save these screws). Phillips Screwdriver 5/16" Wrench Remove the cover plate on the bottom of the fireplace (save these nuts). Secure the gas inlet assembly using the screws removed in step ...

  • Avalon Stoves 21 DV Fireplace - page 14

    14 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Electrical Line Connection a b Insert the sheathed cable from the power source through this cable clamp. Once the wires are attached, tighten the clamp to secure the cable. Replace the cover removed in step "a". Attach the common (white), ground (expose ...

  • Avalon Stoves 21 DV Fireplace - page 15

    Installation (for qualified installers only) 15 © Travis Industries 4040830 100-01143 Vent Requirements • The gas appliance and vent system must be vented directly to the outside of the building, and never be attached to a chimney serving a separate solid fuel or gas-burning appliance. Each direct vent gas appliance must use it's own separa ...

  • Avalon Stoves 21 DV Fireplace - page 16

    16 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Vent Installation • Slide the vent sections together and turn 1/4 turn until the sections lock in place. • Screws are not required to secure the vent. However, three screws may be used to secure vent sections together if desired. • High temperature sealant ...

  • Avalon Stoves 21 DV Fireplace - page 17

    Installation (for qualified installers only) 17 © Travis Industries 4040830 100-01143 Approved Vent Configurations Restrictor Position • A vent restrictor is built into the appliance to adjust the flow rate of exhaust gases. This ensures proper combustion for all vent configurations. Depending upon the vent configuration, you may be required to ...

  • Avalon Stoves 21 DV Fireplace - page 18

    18 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Vent Configurations with Vertical Termination • The termination must fall within the shaded area shown in the chart. Use the indicated restrictor position. • A maximum of 3 elbows may be used. • 8" or 6-5/8" diameter vent may be used. 5 feet 10 fe ...

  • Avalon Stoves 21 DV Fireplace - page 19

    Installation (for qualified installers only) 19 © Travis Industries 4040830 100-01143 Vent Configurations with Horizontal Terminations • Use a single 90° elbow (NOTE: an additional 45° elbow may be used on the horizontal run). • If using 6-5/8" diameter vent, a minimum 12" vertical rise is required. • The termination must fall wi ...

  • Avalon Stoves 21 DV Fireplace - page 20

    20 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Termination Requirements NOTE : Measure all clearances from the nearest edge of the exhaust hood. A Minimum 9" clearance from any door or window B Minimum 12" above any grade, veranda, porch, deck or balcony C Minimum 3-3/8" from outside corner wal ...

  • Avalon Stoves 21 DV Fireplace - page 21

    Installation (for qualified installers only) 21 © Travis Industries 4040830 100-01143 Hearth Requirements NOTE : Looking Glass and Wilmington Faces require a raised fireplace - see "Dimensions" for details. Do not build a hearth or other item above the baseplate (this area must remain clear for the access door). If installed in front of ...

  • Avalon Stoves 21 DV Fireplace - page 22

    22 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Facing Requirements NOTE: The combustible area above the facing must not protrude more than 3/4" from the facing. If it does, it is considered a mantel and must meet the mantel requirements listed in this manual. Face Dimensions Face Height Width Bottom of F ...

  • Avalon Stoves 21 DV Fireplace - page 23

    Installation (for qualified installers only) 23 © Travis Industries 4040830 100-01143 Facing - Fireplace Details 3/8" 1/8" Face Fireplace 1" Wall Trim (1/16" thick) Wall Trim Gasket Facing - Side View Facing - Top View White Tape Gasket (attached to fireplace) Face Fireplace 1/2" Nailing Bracket 1/2" ...

  • Avalon Stoves 21 DV Fireplace - page 24

    24 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Facing Detail – Drywall Facing NOTE The facing tucks under the notch at the front of the fireplace (3/8 ” above the base of the fireplace). Recommended Order of Installation We recommend installing the facing (drywall, tile) under the notch at the front of th ...

  • Avalon Stoves 21 DV Fireplace - page 25

    Installation (for qualified installers only) 25 © Travis Industries 4040830 100-01143 Facing Detail – Tile Facing Tile NOTE : Make sure to use the correct nailing bracket for this type of facing (see “ Nailing Bracket ” for details). For this example the facing is 7/8" thick (3/8" tile plus 1/2" drywall). The framing is positi ...

  • Avalon Stoves 21 DV Fireplace - page 26

    26 Installation (for qualified installers only) © Travis Industries 4040830 100-01143 Facing Detail –Facing Over 1” Thick (Brick) WARNING : Any facing that extends in front of the faceplate on the sides or top must be non- combustible. NOTE : A 3/8” gap is required above the face for face installation. Top View NOTE : Make sure to leave a 1/ ...

  • Avalon Stoves 21 DV Fireplace - page 27

    Installation (for qualified installers only) 27 © Travis Industries 4040830 100-01143 Mantel Requirements • The combustible area above the facing must not protrude more than 3/4" from the facing. If it does, it is considered a mantel and must meet the mantel requirements listed below. • Use the table below to determine the maximum mantel ...

  • Avalon Stoves 21 DV Fireplace - page 28

    28 Finalizing the Installation © Travis Industries 4040830 100-01143 Glass Frame Removal and Installation Warning: The appliance must be completely cool before removing the glass. Warning: Do not strike or slam the glass. Open the four latches holding the glass frame in place (start with the two below the glass) - follow the directions shown to th ...

  • Avalon Stoves 21 DV Fireplace - page 29

    Finalizing the Installation 29 © Travis Industries 4040830 100-01143 Glass Frame Removal and Installation (continued) The spring pin can come loose from the latch assembly. This occurs when it is turned 1/4 turn when it is disengaged. Follow the directions below to re-install the spring pin if it becomes loose. To re-install the spring pin, first ...

  • Avalon Stoves 21 DV Fireplace - page 30

    30 Finalizing the Installation © Travis Industries 4040830 100-01143 Log Set Installation STEP A – Rear Log Installation The rear log rests against the back and left side of the firebox walls. Push on the bottom of the log to insure it sits upright. M ake sure the "cut o ut" on the bottom of t he log installs over t he pilot assembly. ...

  • Avalon Stoves 21 DV Fireplace - page 31

    Finalizing the Installation 31 © Travis Industries 4040830 100-01143 STEP B – Twig, Vertical Log, and Ember Installation Place the twig so the pin on the rear log inserts into the hole on the twig. Place the upright log as shown. When installed the top is parallel with the burner and there is a gap under the right "leg". Preparing the ...

  • Avalon Stoves 21 DV Fireplace - page 32

    32 Finalizing the Installation © Travis Industries 4040830 100-01143 Steps for Finalizing the Installation 1. Remove the glass (see page 28). NOTE: If using propane (LP) convert the appliance prior to installing the logs. 2. We recommend you purge the gas line at this time (with the glass removed). This allows gas to be detected once it enters the ...

  • Avalon Stoves 21 DV Fireplace - page 33

    Finalizing the Installation 33 © Travis Industries 4040830 100-01143 FINE TUNING THE EMBER-FYRE™ BURNER Each installation is affected by altitude, vent configuration, and fuel quality. Because of this, the restrictor and air shutter may need to be fine tuned to each installation. Follow the hints below to fine- tune the burner for optimum perfor ...

  • Avalon Stoves 21 DV Fireplace - page 34

    34 Finalizing the Installation © Travis Industries 4040830 100-01143 8. Replace the glass. 9. Attach the face following the directions below (see the directions included with the face for full details). Face Installation and Removal The face has hooks that hold it in place. Make sure the face locks in place when installing. Tilt the face back and ...

  • Avalon Stoves 21 DV Fireplace - page 35

    Operation 3 5 © Travis Industries 4040830 100-01143 Before You Begin • Read this entire manual before you use your new fireplace (especially the section "Safety Precautions" on pages 4 & 5). Failure to follow the instructions may result in property damage, bodily injury, or even death. Location of Controls Swing the control cover d ...

  • Avalon Stoves 21 DV Fireplace - page 36

    3 6 Operation © Travis Industries 4040830 100-01143 Starting The Pilot Flame The pilot flame is required to ignite the main burners (it also plays a safety role). It should be left on once lit. It will stay lit unless the gas control valve is turned to "OFF". However, the pilot will go out if the gas is shut off, the propane tank runs ou ...

  • Avalon Stoves 21 DV Fireplace - page 37

    Operation 3 7 © Travis Industries 4040830 100-01143 Starting the Fireplace for the First Time • Burn the heater at a high setting with the blower off for an extended period (up to 48 hours). This will cure the painted surfaces. Fumes from the paint curing and oil burning off the steel will occur. This is normal. We recommend opening a window to ...

  • Avalon Stoves 21 DV Fireplace - page 38

    3 8 Operation © Travis Industries 4040830 100-01143 Adjusting the Blower Speed The blower helps transfer heat from the heater into the room. It will not turn on until the heater is up to temperature (approximately 10 minutes after starting). See the illustration below for instructions on adjusting the blower speed. OFF Turn the dial all the way co ...

  • Avalon Stoves 21 DV Fireplace - page 39

    Maintenance 39 © Travis Industries 4040830 100-01143 Maintaining Your Fireplace's Appearance Fingerprints or other marks left on the optional gold surface may become etched in place if they are not wiped clean prior to turning the fireplace on. Clean the gold with denatured alcohol and a soft cloth (with the fireplace cool). Other cleaners ma ...

  • Avalon Stoves 21 DV Fireplace - page 40

    40 Maintenance © Travis Industries 4040830 100-01143 Troubleshooting Table Problem: Possible Cause: Don't Call for Service Until You: Pilot Will Not Light A gas shut off valve is turned off The gas control knob isn't turned to "PILOT" The valve control knob isn't pushed in The igniter wasn't pressed repeatedly No Prop ...

  • Avalon Stoves 21 DV Fireplace - page 41

    Maintenance 41 © Travis Industries 4040830 100-01143 How this Fireplace Works This fireplace was designed with safety as the primary concern. Many of the components inside this fireplace are for safety purposes. Therefore, only certified gas service technicians should service this fireplace. What Turns the Main Burners On and Off This fireplace us ...

  • Avalon Stoves 21 DV Fireplace - page 42

    42 Maintenance © Travis Industries 4040830 100-01143 Wiring Diagram 120 Volt Wiring Millivolt Wiring (for gas control valve) Orange White Piezo Igniter Thermopile Red Thermocouple Copper Co-Axial Wire Red Optional Remote Control Spark Electrode Pilot Hood On/Off Switch Brown Optional Thermostat 7 4 10 9 1 3 Optional Blower Green Hot (black) Common ...

  • Avalon Stoves 21 DV Fireplace - page 43

    Safety Label 43 © Travis Industries 4040830 100-01143 Listing Label The safety (listing) label is attached to the operating tag (chained to the fireplace near the gas control valve). A copy is shown below Bed & Breakfast Vented Gas Fireplace Heater Report No. 028-S-53-5 Certified for USA T ested to: ANSI Z21.88b-2001 “V ented Gas Fireplace H ...

  • Avalon Stoves 21 DV Fireplace - page 44

    4 4 Warranty © Travis Industries 4040830 100-01143 To register your TRAVIS INDUSTRIES, INC. 7 Year Warranty, complete the enclosed Warranty card and mail it within ten (10) days of the appliance purchase date to: TRAVIS INDUSTRIES, INC., 4800 Harbour Pointe Blvd. SW, Mukilteo, WA 98275. TRAVIS INDUSTRIES, INC. warrants this gas appliance (applianc ...

  • Avalon Stoves 21 DV Fireplace - page 45

    Optional Equipment (for qualified installers only) 45 © Travis Industries 4040830 100-01143 LP Conversion Instructions Install the conversion kit prior to installing the gas line to ensure proper gas use. 1 Remove the glass (see page 28). Remove the logs and coals (if installed - page 30) 2 Remove the burner (see illustration below). The mixing tu ...

  • Avalon Stoves 21 DV Fireplace - page 46

    46 Optional Equipment (for qualified installers only) © Travis Industries 4040830 100-01143 3 Follow the directions below to replace the orifice. a Slide the air shutter all the way to the left. Burner Orifice Manifold 1/2" Wrench Use a 1/2 ” open end wrench to unscrew the burner orifice. NOTE: Screw the LP orifice in so the orifice shoulde ...

  • Avalon Stoves 21 DV Fireplace - page 47

    Optional Equipment (for qualified installers only) 47 © Travis Industries 4040830 100-01143 5 Install the logs and embers. 6 Replace glass and face. 7 Remove the regulator from the front of the gas control valve. Replace with the propane regulator, using the new gasket and screws included with the regulator. NOTE: Leak test this area after the hea ...

  • Avalon Stoves 21 DV Fireplace - page 48

    48 Optional Equipment (for qualified installers only) © Travis Industries 4040830 100-01143 Firebox Liner WARNING Turn off gas to the appliance and make sure it has fully cooled prior to conducting service. NOTE : The firebox liner is fragile – take care to prevent damage. NOTE: The firebox liner leaves a slight white residue when touched – ma ...

  • Avalon Stoves 21 DV Fireplace - page 49

    Optional Equipment (for qualified installers only) 49 © Travis Industries 4040830 100-01143 3 Install the liner following the directions below. (a) Tilt the liner forward and at a slight angle as you insert it into the firebox. Place the bottom left corner into the firebox first. (b) As you insert the liner, make sure the liner goes behind the pil ...

  • Avalon Stoves 21 DV Fireplace - page 50

    50 Index © Travis Industries 4040830 100-01143 Air Shutter Adjustment ........................................3 2 Blower Operation .................................................3 8 Cap (Termination) Requirements ...........................2 0 Clearances ........................................................9 Condensation on Glass (see "S ...

Produzent Avalon Stoves Kategorie Indoor Fireplace

Dokumente, die wir vom Produzenten des Geräts Avalon Stoves 21 DV Fireplace erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Avalon Stoves
- Bedienungsanleitungen 21 DV Fireplace
- Produktkarten Avalon Stoves
- Informationsbroschüren
- oder Energieetiketten Avalon Stoves 21 DV Fireplace
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Avalon Stoves 21 DV Fireplace.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Avalon Stoves 21 DV Fireplace, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Avalon Stoves 21 DV Fireplace. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Avalon Stoves 21 DV Fireplace ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Avalon Stoves 21 DV Fireplace, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Avalon Stoves 21 DV Fireplace hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Avalon Stoves 21 DV Fireplace verständlich ist.

Eine gänzliche Bedienungsanleitung von Avalon Stoves sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Avalon Stoves 21 DV Fireplace bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Avalon Stoves 21 DV Fireplace befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Avalon Stoves 21 DV Fireplace, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Avalon Stoves 21 DV Fireplace - die uns die ersten Schritte während der Nutzung von Avalon Stoves 21 DV Fireplace erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Avalon Stoves 21 DV Fireplace hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Avalon Stoves 21 DV Fireplace im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Avalon Stoves 21 DV Fireplace?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Avalon Stoves 21 DV Fireplace nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Avalon Stoves 21 DV Fireplace hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)