Bedienungsanleitung Saab 9-3 M03-

16 Seiten 1.03 mb
Download

Zur Seite of 16

Summary
  • Saab 9-3 M03- - page 1

    Saab 9-3 M03- 900 Installation instructions SCdefault MONTERINGSANVISNING · INSTALLATION INSTRUCTIONS MONTAGEANLEITUNG · INSTRUCTIONS DE MONTAGE SITdefault Saab 9-3 M03- Engine/cabin he ater Accessories Part No. Group Date Instruction Part No. Replaces 12 787 161 9:87-42 Jun 02 12 788 928 ...

  • Saab 9-3 M03- - page 2

    2 12 788 928 Saab 9-3 M03- Heater mounting kit 1 Petrol heat er 2 Holder 3 Exhaust system 4B o l t M 6 x 1 0 0 5 Nut M8 (x3) 6 Nut M6 (x2) 7 Coolant hoses/pipes 8B o l t 9 Hose clip (x3) 10 Fuel Pump 1 1 Cable tie (x20 ) 12 Protective cover , petrol pum p 13 Bracket, fuel pump 14 Vi bration damper 15 Clamp 16 Nut M6 (x2) 17 Screw (x2) 18 Joint hose ...

  • Saab 9-3 M03- - page 3

    12 788 928 3 Saab 9-3 M03- Fuel line kit 1 Fuel line (pump-hea ter) 2 Fuel line (t ank to pump) F920A012 1 2 ...

  • Saab 9-3 M03- - page 4

    4 12 788 928 Saab 9-3 M03- Electrical connection kit Wiring harness F920A013 ...

  • Saab 9-3 M03- - page 5

    12 788 928 5 Saab 9-3 M03- Important WA R N I N G Work on the heater involve s dismantling t he vehi- cle fuel system and emptyin g the fuel tan k. When carrying out the work the following points should therefore be obser ved: · Provide good ventilation! Use appro ved extrac- tors for removing fuel fume s if they are availa- ble. · Use protective ...

  • Saab 9-3 M03- - page 6

    6 12 788 928 Saab 9-3 M03- Preparations Reduction of fuel pressur e 1 Let the engine idle. 2 Remove fuse No. 2 (fuel pump) from th e electri- cal centre located in fron t of the battery in the engine comp artment. 3 When the engine has stoppe d the ignition key must be turned to the OFF position. 4 Refit the fuse. Emptying the fuel t ank The fuel t ...

  • Saab 9-3 M03- - page 7

    12 788 928 7 Saab 9-3 M03- 1 Disconnect the negative batter y cable. 2 Remove the cap fro m the expansion tank. 3 Raise the car . 4 Remove the b olts from the forward se ction of the exhaust system. 5 Remove the exhaust system. 6 Place a recept acle under the engine, op en the drain plug on the bo ttom of the coolant pump and drain the coolant. F92 ...

  • Saab 9-3 M03- - page 8

    8 12 788 928 Saab 9-3 M03- 7 Unplug the connector at the fron t of the fuel t ank and detach the wiring harness from its moun ting. 8 Place a pillar jack un der the fuel t ank and undo the tank mountin g straps. 9 Separ ate the fuel lines using tool 83 95 261 and plug the fuel line t ank connections in order to prevent fuel spill. 10 Remove the fil ...

  • Saab 9-3 M03- - page 9

    12 788 928 9 Saab 9-3 M03- 22 Unplug the connector fr om the air mass se nsor , separate the intake hose and remove the air fil- ter cover . Remove the hose from the air filter cover (if such a hose is fitted). 23 Remove from the turbo int ake pipe the sma ll hose to the control valve (APC valve) and the hose to the carbon filte r vent-valve. Remov ...

  • Saab 9-3 M03- - page 10

    10 12 788 928 Saab 9-3 M03- 27 Fit the hose clip s (including the old clip) o nto the new coolant ho ses. Connect the hose /pipe assembly between the thermost at housing con- nection and the heat exchanger connection nearest to the exp ansion t ank. Do not screw the assembly to the bulkhead. 28 Connect the othe r coolant hose to the heat exchanger ...

  • Saab 9-3 M03- - page 11

    12 788 928 11 Saab 9-3 M03- 38 Remove th e wiper arms using pu ller 85 80 144. Remove also the bonnet seal and the cover over the bulkhead sp ace. F920A018 38 38 38 38 38 38 38 38 38 38 38 38 ...

  • Saab 9-3 M03- - page 12

    12 12 788 928 Saab 9-3 M03- 39 Locate the "Pre Acc" outlet between the eng ine bay main fuse box and the front wing and remove any adhesi ve tap e or dummy connector . 40 Plug the wiring harness from the inst allation set into the connector on the heater and ro ute it through the bulkhead space to the "Pre Acc" outlet adjacent t ...

  • Saab 9-3 M03- - page 13

    12 788 928 13 Saab 9-3 M03- 45 Raise the car . 46 Pull down the fuel pump wiring harness. 47 Thread the fuel pu mp fuel line up between the heater and the lo ngitudinal frame memb er . 48 Connect the fuel l ine to the heater . 49 Fit the fuel pump fuel line into the clips on the underside of the vehicle floor . The fuel line should be locate d in t ...

  • Saab 9-3 M03- - page 14

    14 12 788 928 Saab 9-3 M03- 51 Position the fuel pump bracket up against the vehicle floor , on the righ t-hand side in fron t of the fuel tank, and drill holes using a 3.5 mm drill. 52 Deburr the holes and remove loose swarf and paint p articles. Clean with T eroson Cleaner FL and apply S tandox 1K primer . Apply a finishing coat. 53 Fit the fuel ...

  • Saab 9-3 M03- - page 15

    12 788 928 15 Saab 9-3 M03- 58 Manoeuvre the heater exhaust pi pe up towards the heater and fit the end of the pi pe onto the exhaust port of the heater . Fasten the exhaust pipe to the floor of the vehicle with th e two nuts. Tight ening torque 5 Nm (3.5 lbf ft) 59 Fit the vehicle exhaust system. Tight ening torque 22 Nm (16.5 lbf ft) 60 Lower the ...

  • Saab 9-3 M03- - page 16

    16 12 788 928 Saab 9-3 M03- 61 Fit the heat shield to the turbo compressor (two screws and a catch). 62 Fit the turbo int ake pipe and th en connect to the pipe the small hose from th e control valve (APC valve) and the hose fro m the carbon filter vent valve. 63 Fit the air filter co ver and plug the connector into the air mass sensor . Att ach th ...

Produzent Saab Kategorie Air Conditioner

Dokumente, die wir vom Produzenten des Geräts Saab 9-3 M03- erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Saab
- Bedienungsanleitungen 9-3 M03-
- Produktkarten Saab
- Informationsbroschüren
- oder Energieetiketten Saab 9-3 M03-
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Saab 9-3 M03-.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Saab 9-3 M03-, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Saab 9-3 M03-. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Saab 9-3 M03- ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Saab 9-3 M03-, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Saab 9-3 M03- hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Saab 9-3 M03- verständlich ist.

Eine gänzliche Bedienungsanleitung von Saab sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Saab 9-3 M03- bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Saab 9-3 M03- befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Saab 9-3 M03-, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Saab 9-3 M03- - die uns die ersten Schritte während der Nutzung von Saab 9-3 M03- erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Saab 9-3 M03- hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Saab 9-3 M03- im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Saab 9-3 M03-?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Saab 9-3 M03- nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Saab 9-3 M03- hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)