-
England's Stove Works 55SHPAH - page 1
PELLET AUXILIARY HEATER INSTALLATION & OPERATION MANUAL 25 ‐ PAH/55 ‐ SHPAH/55 ‐ TRPAH REV. 12/2011 CAUTION Please read this entire manual before ...
-
England's Stove Works 55SHPAH - page 2
Page | 2 WARNING : Use of outside combustion air is mandatory with this unit. Do not operate with the hopper open; lid must be shut and tightly latched during operation. Retain for your files Model Numbe ...
-
England's Stove Works 55SHPAH - page 3
Page | 3 TABLE OF CONTENTS Introduction Introduction ................................. 4 Specifications Heating Specifications .................. 5 Dimensions ................................... 5 EPA Compliance ........................... 5 Installation ...
-
England's Stove Works 55SHPAH - page 4
Page | 4 INTRODUCTION Thank you for purchasing this fine product from England’s Stove Works! England’s Stove Works was started, and is still owned by, a family that believes strongly in a “Do It Yourself” s ...
-
England's Stove Works 55SHPAH - page 5
Page | 5 SPECIFICATIONS Heating Specifications Heat Output Range** ............................................ 11,000 BTU/hr – 25,000 BTU/hr Approximate Pellet Burn Rate** ............................................... 1.6 lb/hr – 4.0 lb/hr ...
-
England's Stove Works 55SHPAH - page 6
Page | 6 INSTALLATION Installation Over view When choosing a loca tion for your new stove, there are a multitude of factors that should be taken into account before beginning the installation. 1. Traffic Patterns – To ? ...
-
England's Stove Works 55SHPAH - page 7
Page | 7 INSTALLATION Clearances to Combustibles Unit to Side Wall Unit to Rear Wall Unit to Corner Unit Top to Ceiling Min. Ceiling Height Min. Alcove Width Max. Alcove Depth A ? ...
-
England's Stove Works 55SHPAH - page 8
Page | 8 INSTALLATION Venting Introduction This pellet stove operates on a negative draft system, which pulls combustion air through the burn pot and pushes the exhaust air through the vent pipe and out of the buil ...
-
England's Stove Works 55SHPAH - page 9
Page | 9 INSTALLATION Additional Venting Information Do not mix and match components from different pipe manufacturers when assembling your venting system (i.e. Do NOT use venting pipe from one manufacturer and a thimble ? ...
-
England's Stove Works 55SHPAH - page 10
Page | 10 INSTALLATION Approved Venting Method 1 : Through the Wall Generally the simplest installation method, venting through the wall using our AC ‐ 3000 kit (or similar venting system) is also the preferred venting ? ...
-
England's Stove Works 55SHPAH - page 11
Page | 11 INSTALLATION Approved Venting Method 2 : Through the Ceiling Venting through the ceiling/roof may be the only feasible venting option in some cases and is a factory recommended installation. When installing ? ...
-
England's Stove Works 55SHPAH - page 12
Page | 12 INSTALLATION Approved Venting Method 3 : Exis ting Chimn ey System Using an existing masonry or factory built chimney for venting is the only other acceptable method for venting this pellet unit. Use Type ...
-
England's Stove Works 55SHPAH - page 13
Page | 13 INSTALLATION Mobile Home Installation The England’s Stove Works, Inc. outside air kit MUST be used for installation of this unit in a mobile home. Please see the “Outside Air” section on page 14 ...
-
England's Stove Works 55SHPAH - page 14
Page | 14 OUTSIDE AIR HOOK ‐ UP The use of outside combustion air is mandatory on this pellet stove. The outside air connection pipe protrudes from the lower rear center of the stove; use the included outside ...
-
England's Stove Works 55SHPAH - page 15
Page | 15 FLOOR PROTECTION This pellet stove requires a non ‐ combustible floor protector if the stove is to be installed on a combustible floor. If the floor the stove is to be installed on is already non ...
-
England's Stove Works 55SHPAH - page 16
Page | 16 DAILY OPERATION Getting Started Check to see that the hopper is clean and free from foreign materials. Be sure to connect this unit to a working outlet; we recommend using a surge protector to ...
-
England's Stove Works 55SHPAH - page 17
Page | 17 Shortly after pressing the “On” button, the letters “ S U ” will appear in the heat range and blower speed windows of the control board. This indicates the stove has entered the start ‐ up sequen ...
-
England's Stove Works 55SHPAH - page 18
Page | 18 CONTROL BOARD SETTINGS The control board on this stove allows the user to adjust the heat output and convection blower speed, turn the unit on and off, and test components for function (more on diagnostic ...
-
England's Stove Works 55SHPAH - page 19
Page | 19 ERROR CODES Error codes, or “E ‐ Codes,” are alphanumeric codes that will appear in the Heat Range and Blower Speed windows of the Control Board if the unit experiences an abnormal condition. Error codes ...
-
England's Stove Works 55SHPAH - page 20
Page | 20 POWER FAILURE If the power to the unit is interrupted for approximately three minutes or less, the unit will resume operation when power is restored according to the following table: Unit’s State Before ...
-
England's Stove Works 55SHPAH - page 21
Page | 21 THERMOSTAT OPERATION Thermostat Installation 1. Unplug the unit and remove the back panel of the stove. 2. Locate the thermostat connect block, labeled J18, on the rear of the control board, near the bottom (See ...
-
England's Stove Works 55SHPAH - page 22
Page | 22 THERMOSTAT OPERATION Thermostat Operation Details The 25 ‐ PAH|55 ‐ SHPAH|55 ‐ TRPAH was designed to operate equally well in both manual and thermostat mode. While using the control board for heating control gives t ...
-
England's Stove Works 55SHPAH - page 23
Page | 23 DAILY MAINTENANCE Important Notes As with any maintenance concerning this unit, be sure the unit is “OFF” and has completed the Shut ‐ Down cycle BEFORE beginning. Be aware that metal parts in the f ...
-
England's Stove Works 55SHPAH - page 24
Page | 24 Use a long handled screwdriver or putty knife to remove any deposits left in the burnpot, being careful to remove them from the burnpot and not allow them to filter down into the cradle area. E ...
-
England's Stove Works 55SHPAH - page 25
Page | 25 MONTHLY MAINTENANCE Important Notes As with any maintenance concerning this unit, be sure the unit is “OFF,” has completed the Shut ‐ Down cycle, and is completely cool BEFORE beginning. Be aware that m ...
-
England's Stove Works 55SHPAH - page 26
Page | 26 Using a utility type vacuum cleaner, , vacuum the fly ash out of the exhaust chamber. A short piece of hose can be attached to the end of the utility vacuum line and can be useful in re ...
-
England's Stove Works 55SHPAH - page 27
Page | 27 YEARLY MAINTENANCE Important Notes As with any maintenance concerning this unit, be sure the unit is “OFF,” has completed the Shut ‐ Down cycle, and is completely cool BEFORE beginning. Be aware that ? ...
-
England's Stove Works 55SHPAH - page 28
Page | 28 YEARLY MAINTENANCE Exhaust Blower Cleaning Although the exhaust blower and blower housing were designed to minimize ash build ‐ up, some fly ‐ ash will still accumulate there throughout the burning season. The amount ...
-
England's Stove Works 55SHPAH - page 29
Page | 29 YEARLY MAINTENANCE Convection Blower Cleaning As always, be certain the stove is cool and unplugged before servicing any components within the unit. Since the convection blower does not handle any by ‐ products ...
-
England's Stove Works 55SHPAH - page 30
Page | 30 Trouble ‐ Shooting Guide WARNING: To avoid ELECTRICAL SHOCK always disconnect the unit from the power source BEFORE attempting any repair. If this guide does not correct the problem, call your lo cal dealer o ...
-
England's Stove Works 55SHPAH - page 31
Page | 31 Unit Shuts Down in 15 ‐ 20 minutes with an "E ‐ 2" code on contr ol board . 1. Loose thermal sensor. 1. Check both sides of thermal sensor connection (exhaust blower and control board). 2. Contro ...
-
England's Stove Works 55SHPAH - page 32
Page | 32 REPLACING COMPONENTS Auger Motor 1. Before beginning any component replacement, be certain the unit is unplugged and thoroughly cooled down. Also, make sure the hopper is empty before attempting to remove or repla ...
-
England's Stove Works 55SHPAH - page 33
Page | 33 REPLACING COMPONENTS Convection Blower 1. Before beginning any component replacement, be cert ain the unit is unplugged and thoroughly cooled down. 2. Remove the back exhaust outlet cover plate and back panel from the ...
-
England's Stove Works 55SHPAH - page 34
Page | 34 REPLACING COMPONENTS Vacuum Sensor 1. Before beginning any component replacement, be cert ain the unit is unplugged and thoroughly cooled down. 2. Remove the exhaust outlet cover plate and rear panel of unit. 3. L ...
-
England's Stove Works 55SHPAH - page 35
Page | 35 REPLACING COMPONENTS Gaskets 1. Door o This unit comes with a 5 / 8 ” rope gasket around the door that should be replac ed at least every two years. To replace the door gasket (Part # AC ‐ DGKNC), ...
-
England's Stove Works 55SHPAH - page 36
Page | 36 REPLACING COMPONENTS Glass This unit has a one ceramic glass panel (Part No. AC ‐ G17) in the viewing door; self adhesive window gasket is included with replacement windows purchased directly from England’s Stove ...
-
England's Stove Works 55SHPAH - page 37
Page | 37 REPLACING COMPONENTS Control Board The Control Board (Part # PAH ‐ CB09) is a digital read ‐ out board. This board offers a wide variety of settings to operate the unit. The right side panel should be ? ...
-
England's Stove Works 55SHPAH - page 38
Page | 38 WIRING DIAGRAM Caution – Shock Hazard Press the “Off” button and let the appliance completely cool BEFORE unplugging the appliance and beginning any maintenance or component replacement. Risk of shock if ? ...
-
England's Stove Works 55SHPAH - page 39
Page | 39 ILLUSTRATED PARTS DIAGRAM Auger Motor Assembly Door Assembly 1 2 3 4 5 6 7 8 ? ...
-
England's Stove Works 55SHPAH - page 40
Page | 40 REPLACEMENT PARTS LIST Part Number Part Description Diagram # Gaskets PU ‐ HLG Hopper Lid Gasket 1 AC ‐ DGKNC 5/8” Door Gasket 2 AC ‐ GGK Window Gasket Kit 3 PU ‐ CBG Exhaust Blower Gasket 4 AC ? ...
-
England's Stove Works 55SHPAH - page 41
Page | 41 You may write your unit’s Manufacture Date and Serial Number in the blank spaces on this sample tag, for futu re reference. This sample tag also shows the safety info. such as UL te sting standard, etc. for your local officials, o ...
-
England's Stove Works 55SHPAH - page 42
Page | 42 LIMITED FIVE (5) YEAR WARRANTY From the date of purchase to the original owner The manufacturer extends the following warrantie s: Five Year Period: 1. Carbon steel and welded sea ms in the firebox are co ...
-
England's Stove Works 55SHPAH - page 43
Page | 43 Procedure Purchaser must give notice of claim of defect within the warranty period and pay transportation to and from a service center designated by the manufacturer. The dealer from which the unit was ...
-
England's Stove Works 55SHPAH - page 44
Page | 44 ...
-
England's Stove Works 55SHPAH - page 45
Page | 45 WARRANTY REGISTRATION for England’s Stove Works® Purchaser Information I. Purchased By (Name) _________________________________________ II. Address ____________________________________________________ III. City_______________________State________Zip Code ______ ...
-
England's Stove Works 55SHPAH - page 46
Page | 46 Important Notice This registration informatio n MUST be on file for this warranty to be valid. Please mail this information within thirty (30) days from the original date of purchase. Use any of these thre ...
Haben Sie eine Frage bezüglich England's Stove Works 55SHPAH?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit England's Stove Works 55SHPAH nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit England's Stove Works 55SHPAH hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.