Bedienungsanleitung Omega Engineering FP-6000

32 Seiten 0.49 mb
Download

Zur Seite of 32

Summary
  • Omega Engineering FP-6000 - page 1

    www .omega.com e-mail: info@omega.com U ser ’ s Guide Shop online at FP-6000 Series Flow Sensors ...

  • Omega Engineering FP-6000 - page 2

    It is the policy of OMEGA to comply with all worldwide safety and EMC/EMI regulations that apply. OMEGA is constantly pursuing certification of its products to the European New Approach Directives. OMEGA will add the CE mark to every appropriate device upon certification. The information contained in this document is believed to be correct, but OME ...

  • Omega Engineering FP-6000 - page 3

    T able of Contents Chapter Page 1 Introduction 1 1.1 Description 1 1.2 Theory of Operation 1 2 Installation and Wiring 2 2.1 Location of Fitting 2 2.2 Sensor Position 2 2.3 Sensor Wiring 3 3 Installation 4 3.1 Hardware, Standard Sensor 4 3.2 Hardware, Hot-Tap Sensor 4 3.3 Standard Fitting Installation 4 3.4 Hot-Tap Fitting Installation 5 3.5 Calcul ...

  • Omega Engineering FP-6000 - page 4

    . ...

  • Omega Engineering FP-6000 - page 5

    Impor tant Safety Information! CAUTION: (Standard version) Never remove the flow sensor from a pressurized pipe. Always wear safety face protection during sensor installation/removal. (Hot-Tap version) Follow the recommended installation/removal instructions in this manual. Always wear safety face protection during sensor installation/removal. Maxi ...

  • Omega Engineering FP-6000 - page 6

    Unpacking and Inspection Your flow sensor package includes the following items: OMEGA FP-6000 Series Adjustable Brass Flow Sensor 6 inch ruler (Standard sensor version only) 10 inch brass alignment rod Warranty Record For your protection, record your sensor's purchase information for future reference. The serial number is located on the metal ...

  • Omega Engineering FP-6000 - page 7

    Chapter 1 Introduction This manual contains description, specifications and instruction for the installation, removal, and operation of the OMEGA FP-6000 Series Adjustable Brass Flow Sensor. Please read the manual thoroughly. If you require further assistance, please contact your OMEGA dealer. 1.1 Description The FP-6000 Series is an insertion flow ...

  • Omega Engineering FP-6000 - page 8

    The linearity and accuracy of the FP-6000 Series sensor depend on predictable flow conditions in the pipe and proper location of the fitting. As with any insertion flow sensor, the pipe must be full and generally free of air pockets. 2.1 Location of Fitting The sensor must be located in a free-flowing straight run of pipe. OMEGA recommends a minimu ...

  • Omega Engineering FP-6000 - page 9

    3 (max. 30 ° ) will help to avoid these problem areas, but use caution. Excessive angles will cause bearing drag at lower flow rates. On a vertical pipe run locate the sensor where the flow is upward. If downward flow is necessary the system must be designed to prevent air/water vapor pockets from developing in the pipe which will affect the perfo ...

  • Omega Engineering FP-6000 - page 10

    The following items are required to properly install the OMEGA FP-6000 Series Adjustable Brass flow sensor. 3.1 Hardware, Standard Sensor • female pipe fitting (weld-on or saddle) 1 1 / 2 in. NPT or ISO 7/1-Rc 1- 1/2 •1 1 / 4 in. (32 mm) diameter drill • Pipe thread sealant • Tape measure 3.2 Hardware, Hot-T ap Sensor The Hot-Tap sensor req ...

  • Omega Engineering FP-6000 - page 11

    5 4. Remove brass sensor nut from sensor. 5. Thread brass sensor nut into pipe fitting. 3.4 Hot-T ap Fitting Installation 1. Install the pipe fitting on the outside diameter of the pipe according to the manufacturer's instruc- tions. Failure to follow these instructions may result in bodily injury and/or product failure. 2. Install the pipe ni ...

  • Omega Engineering FP-6000 - page 12

    6 4. Open the isolation valve and insert the drill through the valve and cut the sensor clearance hole. After the hole is cut, withdraw the drill from the isolation valve and close the valve. Remove the drilling machine per manufacturer's instructions. 5. Install brass sensor nut/bleed valve into the top of the isolation valve. Make sure the b ...

  • Omega Engineering FP-6000 - page 13

    7 Standard Sensor H = 5.95 - pipe wall thickness - (0.10 X I.D.) Example: 3.0 inch schedule 80 wrought steel; Wall thickness= 0.3 in. Inside diameter = 2.9 in. H = 5.95 - 0.3 - (0.10 X 2.9) H = 5.36 in. Hot-Tap Sensor H = 15.00 - pipe wall thickness - (0.10 X I.D.) Example: 10 inch schedule 40 wrought steel; Wall thickness= 0.365 in. Inside diamete ...

  • Omega Engineering FP-6000 - page 14

    8 Once the correct dimensions are calculated and recorded, the sensor can be installed in the fitting. The Standard and Hot-Tap versions require substantially different procedures. 3.6 Standard Installation 1. Thread one hex nut onto each of the three threaded rods included in package. Install threaded rod with a lock-washer onto the brass sensor n ...

  • Omega Engineering FP-6000 - page 15

    9 4. Place the alignment rod in the hole on the sensor flange. Align the flange so rod is parallel to the process pipe. 5. Thread upper hex nuts with lock-washers until they contact the sensor flange and tighten. Check for proper "H" dimension and readjust if necessary. 5.95 in. (151 mm) " H " pipe I.D. process pipe FLOW 1-1/2 i ...

  • Omega Engineering FP-6000 - page 16

    10 3.7 Hot-T ap Installation 1. Thread one hex nut onto each of the three threaded rods included in package. Install threaded rod with a lock-washer onto the brass sensor nut. Secure rods in place by tightening each hex nut against the brass sensor nut. 2. Thread one jam nut and lower hex nut onto each stud so the top surface of each nut is 13.75 i ...

  • Omega Engineering FP-6000 - page 17

    alignment rod sensor flange process pipe (top view) The flow sensor alignment rod MUST be parallel to the process pipe as shown. direction of flow sensor flange 18 inch threaded rods 13.75 in. process pipe (side view) direction of flow alignment rod Upper hex nuts (3/16 x 1/4-20) 1/4 in. lock washers Brass sensor nut Bleed valve lower hex nut and j ...

  • Omega Engineering FP-6000 - page 18

    12 Using the Hot-Tap Installation Tool The Hot-Tap installation tool helps to lower the sensor into place against the pressure in the pipe. 1. Thread protector plate hex nuts onto each of the three threaded rods. Adjust each hex to a height of approximately 1 in. (25 mm) from the top of each rod. Remove the black plastic cable grom- met in top of s ...

  • Omega Engineering FP-6000 - page 19

    13 3. Align the sensor cable with the swivel mount cable port to prevent cable pinching. Use a 3/8 inch wrench or socket to turn the installation tool shaft clockwise until it is seated in the hole at the top of the sensor flange. 4. Wearing safety face protection, slowly open the isolation valve to the full open position. Loosen the lower hex and ...

  • Omega Engineering FP-6000 - page 20

    14 4.1 Standard Sensor Removal To remove the Standard FP-6000 Series sensor from a depressurized empty pipe, simply remove the cap nuts and upper hex nuts located above the sensor flange. Pull up on sensor flange with twisting motion. 4.2 Hot-T ap Sensor Removal To remove the Hot-Tap sensor safely from a pressurized active pipe, the entire installa ...

  • Omega Engineering FP-6000 - page 21

    15 5. Wearing safety face protection, turn the installation tool shaft counterclockwise to withdraw sensor until the sensor flange contacts the upper hex nuts. 6. Raise one lower hex and jam nut to bottom of sensor flange. 7. Close valve, remove bearing plate and tool. To remove the sensor 8. Wearing safety face protection, cover the bleed valve wi ...

  • Omega Engineering FP-6000 - page 22

    5.1 Maintenance All versions of the FP-6000 series sensor require little or no maintenance, with the exception of an occasional sensor/paddlewheel cleaning. 5.2 Replacement Par ts (Standard version) 1. Standard sensor assembly FP-6000, -6001 2. Rotor kit (bearings, shaft, retainers, and rotor included), see table below ♦ • FP52509-1 kit with st ...

  • Omega Engineering FP-6000 - page 23

    17 5.3 Rotor Replacement Procedure 1. With a small pair of needle-nose pliers, firmly grip the center of the rotor pin (axle) and with a twisting motion, bend the rotor pin into an "S" shape. This should pull the ends of the pin out of the shaft retainers and free the rotor assembly. 2. Remove shaft retainer from each side by gently tappi ...

  • Omega Engineering FP-6000 - page 24

    5.644 in. 5.589 in. 5.500 in. 5.427 in. 5.369 in. 5.310 in. 5.187 in. 5.064 in. 4.830 in. 4.583 in. 4.350 in. 4.200 in. 3.950 in. 3.700 in. 3.475 in. * 3.000 in. 18 NPS SCH 40 SCH 80 STD XS 5.600 in. 5.538 in. 5.442 in. 5.360 in. 5.296 in. 5.230 in. 5.094 in. 4.942 in. 4.688 in. 4.475 in. 4.275 in. 4.150 in. 3.950 in. 3.750 in. 3.550 in. 3.350 in. ...

  • Omega Engineering FP-6000 - page 25

    19 14.694 in. 14.639 in. 14.550 in. 14.477 in. 14.419 in. 14.360 in. 14.237 in. 14.144 in. 13.880 in. 13.633 in. 13.400 in. 13.250 in. 13.000 in. 12.750 in. 12.525 in. * 12.050 in. NPS SCH 40 SCH 80 STD XS 14.650 in. 14.588 in. 14.492 in. 14.410 in. 14.346 in. 14.280 in. 14.144 in. 13.992 in. 13.738 in. 13.525 in. 13.325 in. 13.200 in. 13.000 in. 1 ...

  • Omega Engineering FP-6000 - page 26

    K-factors Stainless Steel SCH 5S STAINLESS STEEL PIPE PER ANSI B36.19 K-FACTOR K-FACTOR A-FACTOR A-FACTOR PIPE PULSES/ PULSES/ U .S . SIZE U.S. GAL LITER GPM/HZ LPM/HZ 1 1/2 104.200 27.5297 0.5758 2.1795 2 67.160 17.7437 0.8934 3.3815 2 1/2 46.060 12.1691 1.3026 4.9305 3 29.790 7.8705 2.0141 7.6234 3 1/2 22.060 5.8283 2.7199 10.295 4 16.890 4.4624 ...

  • Omega Engineering FP-6000 - page 27

    K-factors Wr ought Steel 21 STD WROUGHT STEEL PIPE PER ANSI B36.10 K-FACTOR K-FACTOR A-FACTOR A-FACTOR PIPE PULSES/ PULSES/ U.S. SIZE U.S. GAL LITER GPM/HZ LPM/HZ 1 1/2 122.000 32.2325 0.4918 1.8615 2 78.690 20.7900 0.7625 2.8860 2 1/2 55.630 14.6975 1.0786 4.0823 3 35.530 9.3871 1.6887 6.3918 3 1/2 26.070 6.8877 2.3015 08.711 4 19.840 5.2417 3.024 ...

  • Omega Engineering FP-6000 - page 28

    22 K-factors Plastic Pipe To convert K from to multiply K by U.S. gallons cubic feet 7.479 U.S. gallons cubic inches 0.00433 U.S. gallons cubic meters 263.85 U.S. gallons pounds of water 0.120 U.S. gallons acre feet 325853 U.S. gallons liters 0.264 U.S. gallons Imperial gallons 1.201 To convert K from to multiply K by liters cubic meters 1000 liter ...

  • Omega Engineering FP-6000 - page 29

    23 Specifications General Data Flow velocity range: 1.6 to 20 ft/s 0.5 to 6 m/s Linearity: ± 1% of full range Repeatability: ± 0.5% of full range Pipe sizes: Standard version: 1.5 to 24 in. (38 to 610 mm) Hot-Tap version: 1.5 to 36 in. (38 to 914 mm) Cable length: 25 ft (7.6 m), can extend up to 200 ft (61 m) without amplification Materials Senso ...

  • Omega Engineering FP-6000 - page 30

    operating pressure: 225 psi (15 bar) Maximum operating temperature: 212 ° F (100 ° C) Caution: The FP-6002 and FP-6003 Series Hot- Tap system's overall specifications and limitations depend on the lowest maximum rating of the components associated with the system. For example, a ball valve, a component of the system, is rated at a maximum 10 ...

  • Omega Engineering FP-6000 - page 31

    W ARRANTY /DISCLAIMER OMEGA ENGINEERING, INC. warrants this unit to be free of defects in materials and workmanship for a period of 13 months from date of purchase. OME GA ’ s W A RR ANT Y adds an additional one (1) month grace period to the normal one (1) year product warranty to cover handling and shipping time. This ensures that OMEGA ’ s cu ...

  • Omega Engineering FP-6000 - page 32

    6-2517.090-OM/(D-8/02) M-2973/0802 Where Do I Find Ever ything I Need for Process Measurement and Control? OMEGA…Of Course! Shop online at www.omega.com TEMPERA TURE   Thermocouple, RTD & Thermistor Probes, Connectors, Panels & Assemblies   Wire: Thermocouple, RTD & Thermistor   Calibrators & Ice Point References ...

Produzent Omega Engineering Kategorie Stud Sensor

Dokumente, die wir vom Produzenten des Geräts Omega Engineering FP-6000 erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Omega Engineering
- Bedienungsanleitungen FP-6000
- Produktkarten Omega Engineering
- Informationsbroschüren
- oder Energieetiketten Omega Engineering FP-6000
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Omega Engineering FP-6000.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Omega Engineering FP-6000, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Omega Engineering FP-6000. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Omega Engineering FP-6000 ansehen.

Die komplette Bedienungsanleitung des Geräts Omega Engineering FP-6000, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Omega Engineering FP-6000 hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Omega Engineering FP-6000 verständlich ist.

Eine gänzliche Bedienungsanleitung von Omega Engineering sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Omega Engineering FP-6000 bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Omega Engineering FP-6000 befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Omega Engineering FP-6000, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Omega Engineering FP-6000 - die uns die ersten Schritte während der Nutzung von Omega Engineering FP-6000 erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Omega Engineering FP-6000 hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Omega Engineering FP-6000 im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Omega Engineering FP-6000?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Omega Engineering FP-6000 nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Omega Engineering FP-6000 hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)