Bedienungsanleitung Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment

32 Seiten 1.53 mb
Download

Zur Seite of 32

Summary
  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 1

    Hydr ostatic Zer o-T urn Commer cial Riding Mo wer Professional Turf Equipment OPERATOR’S AND SERVICE MANUAL 60” Fabricated Deck W/ R.O.P .S. ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 2

    2 T ABLE OF CONTENTS F oreword . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 General Saf ety Operations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 A.Danger . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 3

    3 FOR W ARD The T ank Hydrostatic Zero-T ur n Commercial Riding Mower pro vides superb maneuv erability , mid-mount cutting capability f or profession al landscapers, commercial la wn ser vice compa - nies, prof essional turf managers and golf course superintendents. The machine incorporates many safety f eatures that should be studied b y all oper ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 4

    4 GENERAL SAFETY OPERA TIONS A. D ANGER 1. Do not operate mach ine in confined areas where e xhaust gases can accumulate. 2. Do not oper ate machine without mo wer chute deflector in place and operationa l. 3. Do not carry passengers. B. W ARNING 1. Do not oper ate machines under the influence of alco hol or dru gs. 2. Do not operate mach i nes wit ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 5

    5 11. When looking for oil leak s , n e ver run your hand o ver h ydraulic hoses , lines or fittings . Ne ver tighten or ad just hydra ulic hoses, lines or fitti ngs while the sy stem is under pressure. If high-pressure oil penetr ates the skin, the oil must be remo ved with in a fe w hours by a doc - tor fa mil iar with this f or m of injur y or s ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 6

    6 blade bolts a re tight before restar ting the engine . 13. Ne ver lea ve the mo wer unattended without: turning off the blade clutch s witch; placing the left and right steering lev ers in the neutral opened-out position; mo ving the throttle to slow; setting the parking brake; shutting off the engine and taking the k ey from the ignition sw it c ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 7

    7 SAFETY DECALS AND LABELS K E E P HA ND S a n d F E E T AW AY DA NG E R TO R E DU CE THE RI S K O F I N J U RY , DO NO T OP E R A T E M O W E R UN L E S S DI S CHARG E CHUT E CO V ER O R GRAS S C ATCH ER I S I N I TS PRO PER PL A CE. WARNING SHIELD MISSING DO NOT OPERATE Do not put hands or feet under or into mower when engine is running. ROTATING ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 8

    8 SPECIFICA TIONS GENERAL INFO . Controls: Engine ignition and star t s witch; th rottle; choke; left and right steering lev ers; electric blade cl utch s witch; parking brake; mower dec k lift P arking Brake: Mechanical linkage brak e handle to inter nal drum brakes Seat: Adjustable seat and armrests . 5" Adjustment (f ore-aft) Frame: 2" ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 9

    9 OPERA TING INSTR UCTIONS A.General 1. When Mowing: a. K eep adults , children, and pets aw ay fr om the area to be m o wed. b . Wh en operating this mower , in the forward direction, do not allo w the steer ing le vers to retur n to Neutral on th eir own. Alwa ys maintain a firm grip on the le vers , operate them smoothly and a voi d any sudden m ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 10

    10 b . Av oid tur ning do wnhill if possible, if not use e xtra care and go slo wly . c. A void turning when going downhi ll, traction is at a minimum going do wnhill. d. Do not oper ate with discharge side of the mow er towa rd streets, b uildings, p lay - grounds , parking lots, othe r machines, ani - mals, an d other people. e. Av oid operation ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 11

    11 4. Electric Blade Clutch Switc h: (See Figure 1.) Located on the right side of the mo wer beside the ignition s witch. This is an “on/off ” push pull s witch that controls the electric bl ade clutch which supplies power to the cut - ting bl ades through the PT O. Th e switch m ust be tur ned off to star t the engi ne and should be tur ned of ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 12

    12 C.Initial Adjustments 1. Check the flu id levels and tires: Note: These checks should be made daily , befo re star ting the engine. a. Fuel: Using a good grade of unleaded, regular gasoline (f or a gasoline engine), fill the fuel tank (beside t he engine on the left or ri ght side of the mower). When the fuel reaches one inch from the top of the ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 13

    13 f . Raise t he mowing deck to the transpor t position usin g the transpor t lev er . g. Use the transp or t lev er to lower the mow - ing dec k to the cutting position and repeat step “b . ” abov e to mak e sure that the desired cutting height has been attained . If the dimensions ar e not correct, repeat steps “c. ” through “f . ” a ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 14

    14 3. Mov e both lap bars out of the neu tral/ star t position to th e neutral position (tow ard center of machine). Slo wly , mov e both lap bars to ward the front of the machine until the machin e begins to mov e f orward — release the lap ba rs and the machine should sto p. The more that the lap bar s are mov ed towa rd the front of the ma chi ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 15

    15 Note: Do not hold the key in the “Start” position for more than 10 seconds o r y ou may damage the star ter . If th e engine do es not start in this time, wait abou t 30 seconds and try again. i. Gasoline Engine: Once the engine s tar ts, push the ch ok e on halfwa y and as the engine warms, push the chok e off all the way . 4. Operating the ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 16

    16 MAINTENANCE AND SER VICE W ARNING: Disconnect the spark pl ug wires or r emo ve the key fr om the ignition to prevent the engine from accidentally starting before performing any maintenance on th is mower . A. Mower Dec k 1. Removing the Mo wer Deck: a. Apply the par king brake . Remove ignition ke y and both spark plug caps. b . Lower th e cutt ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 17

    17 a. Set the parking brak e. b . Clean any debris fr om the blades. K eep bl ades shar p and free of b uild up at all times. c. Sharpen bl ades ev enly at the original 30° angle to maintain balanced cut ting blades . Do not sharpen the underside of the bl ades. Use a electric blade sharpener , a conv entional electric grinder or a hand file to sh ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 18

    18 1. Adding Hydraulic Oil (use SAE14W 40 ) a. Place the Mower on a le v el surface and engage the pa rking brake. b. Stop the engine and remo ve the key fro m the ignition switch. c. Clean the area around the Hydr aulic Oil fill neck. d. Remove the h ydraulic fill cap and check the le vel. The correct lev el is a 1/4” below the oil tank fill nec ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 19

    19 c. Store the batter y with a full charge . A dis - charged batter y will fr eeze (ref er to the table belo w). d. Recharge battery when e v er the specific gra vity value is less than 1.225 3. Battery Remov al Wa r n i n g : When removing the cables from the batter y follo w these steps to avoid a short between the wrench and the frame. a. Remov ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 20

    20 occurs. Engage the BBC (PT O Clutch) a couple of times , and re-chec k the air-gap . If it is not b etween the specs l isted on page 24, repeat the ad justment procedure. b. P arking Brake Switch: Sit in the opera - tor’ s seat. With both steering lev ers opened-out in the neutral position and the bl ade clutch swit ch “off ”, release the ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 21

    21 2. Leaking T ires: When a flat tire occurs , repair or replace immed iately . The nor mal pro cedure is to remov e t he wheel and replace it with a spare. T ake the leaking tire to a maintenance area and repair . If a tire is getting soft, park the mow er on the nearest le vel, pa ved area. If the leaking ti re is on a tr action wheel, put bloc ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 22

    22 pin from the cle vis pin and pulling the cle v is pin from the brak e clevis . Loosen the he x nut and turn the brak e clevis in a cloc kwise direction one full turn looking do wn the brak e rod. This will tighten th e brake about .040 inch. Tighten the he x nut and reassemb le the brake cle vi s to the brak e shaf t assembly . Normally , both b ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 23

    23 tion the mower mov es — to the front or the rear . T o make the a djustment, place the steer - ing le vers in the ope ned-out neutral position and set the parking brak e, shutoff the engine , take the ke y from the ignition s witch and piv ot the seat f orward. If the mower creep s to the right, you will adjust the linkage on the left side of ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 24

    24 MAINTENANCE SCHEDULE A. Daily Chec ks 1. Before starting engine: a. Ch ec k the fuel lev e l.** b . Check the engine oil le vel.** c. Check the h y draulic oil le vel. d. Check the hydraulic hoses f or leaks, abra - sion, kinks, twists, or a flatte ned condition. e. Ch ec k the tires an d tire pressure. Dri v e Tires : 8-10 psi. F ront Caster Wh ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 25

    25 . OIL CHAR T Apply a f ew drops of en gine oil or use a spra y lubricant. Apply the oil to both sides of pivot points . Wipe off any e xcess. Star t engine and operate mo wer briefly to insure that oil spreads ev enly . Number of Oil P oints Description DA I L Y 4 4 2 2 2 2 1 2 WEEKL Y 1 2 2 2 1 1 1 4 2 2 Deck Suspension Pivots Height Adjustment ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 26

    26 P erformance Adjustments A. High Speed T racking Adjustment If mow er tracks to one side wi th both lap bars in fully f orward position: 1. Chec k air pressure in all four tires: a. Pressure should be within specif ied ranges and balanc ed side-to-side. b . Rear tires 8-10 psi. reco mmended (20 psi MAX.) c. F ront tires 20-25 psi. recommen ded ( ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 27

    27 g. V er ify proper th rottle adjustment b y check - ing RPM readings as outlined abo ve . C. Deck Corner Ball Wheel Roller Settings 1. Matching the set heights of the ball rollers on the f our cor ners of the mo wer deck to the desired cut height will pre vent edg e scalping and minimize an y side-to-side variance in cut height. 2. There are thr ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 28

    28 F . Deck le veling Procedure 1. P ar k the mower on a flat pav ed surface , engage the park ing brak e, shut off the engine, remove the ke y from the i gnition s witch, discon nect the spark plu g wires and using the transpor t lev er , low er the mowing deck into the 4" height of cut position. (The 4" hei ght of cut position is recom ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 29

    29 WIRING DIA GRAM GD: 02000591 ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 30

    30 MAINTENANCE RECORD DA TE WORK PERFORMED DA TE WORK PERFORMED ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 31

    31 ...

  • Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - page 32

    MANUF A CTURER’S LIMITED W ARRANTY - TURF EQUIPMENT This warranty is specific to the product manual to which it is attac hed. For a complet e list of products and warr anties contact your author ized Cub Cadet Commercial deal er . Prop er maintenance of the purchased Cub Cadet Co mme rcial equipment is the o wner’ s responsibility . Fo ll o w t ...

Produzent Cub Cadet Kategorie Lawn Mower

Dokumente, die wir vom Produzenten des Geräts Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Cub Cadet
- Bedienungsanleitungen Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment
- Produktkarten Cub Cadet
- Informationsbroschüren
- oder Energieetiketten Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment verständlich ist.

Eine gänzliche Bedienungsanleitung von Cub Cadet sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment - die uns die ersten Schritte während der Nutzung von Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Cub Cadet Hydrostatic Zero-Turn Commercial Riding Mower Professional Turf Equipment hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)