Bedienungsanleitung Weil-McLain 78

32 Seiten 2.05 mb
Download

Zur Seite of 32

Summary
  • Weil-McLain 78 - page 1

    This manual must only be used by a qualified heating installer/service technician . Failure to comply could result in severe personal injury , death or substantial property damage. Part No. 550-141-705/0600 78 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Boiler Manual • Installation • Start-Up • Maintenance • Parts Installer: L ...

  • Weil-McLain 78 - page 2

    Part No. 550-141-705 W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Contents 1. Before Installing Boiler .............................................................. page 3 2. Set Packaged Boiler or Block Assembly in Place ................ page 5 3. Assemble Block ........................................................... ...

  • Weil-McLain 78 - page 3

    • Installation • Start-Up • M aintenance • Pa r t s Befor e Installing Boiler 1a Installation must comply with: • State, provincial and local plumbing, heating and electrical codes. • Regulations of serving utilities. • National codes where applicable. Before selecting boiler location: • Check for nearby connections to: – fuel sup ...

  • Weil-McLain 78 - page 4

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Befor e Installing Boiler 1b Provide clearances for servicing around boiler: • Back, for breeching - 30 inches. • Left side, for cleaning and tankless heater removal - 34 inches • Allow sufficient space on remaining sides for cleaning, servicing and burner installation. Se ...

  • Weil-McLain 78 - page 5

    • Installation • Start-Up • M aintenance • Pa r t s Set Packaged Boiler or Block Assembly in Place 2a For packaged boiler: 1. Remove top jacket panel. Set aside until after boiler is piped. 2. Remove lag screws (2 in front, 2 in rear) from shipping rails. 3. Remove boiler from skid. Cables are already attached to block assembly . See Liftin ...

  • Weil-McLain 78 - page 6

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Assemble Block 3a Sections are top heavy . Unbolted sections may fall if not supported, resulting in severe personal injury or death. Install back refractory blanket: 1. Lay back section on floor with ports face up. 2 Apply water glass as an adhesive to blanket. 3. Press blanket ...

  • Weil-McLain 78 - page 7

    ...

  • Weil-McLain 78 - page 8

    Prepare remaining sections: 1. Follow “Prepare intermediate section” for remaining intermediate and front sections: a. Remove any grit from threads inside tapped holes with clean rag. Do not use petroleum-based cleaning or sealing compounds in boiler system. Severe damage to system components can result, causing substantial property damage. b. ...

  • Weil-McLain 78 - page 9

    ...

  • Weil-McLain 78 - page 10

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Assemble Block 3e Prepare flue collector hood assembly: Make sure gaskets are intact, not torn or otherwise damaged. These conditions can cause possible flue gas leakage and carbon monoxide emissions, resulting in severe personal injury or death. 1. Stand one collector hood modu ...

  • Weil-McLain 78 - page 11

    • Installation • Start-Up • M aintenance • Pa r t s Assemble Block 3f Install flue collector hood assembly: 1. Place hood on top of sections with open end of hood tightly against flue collar . Make sure flue collar gasket is in place, not broken, bent or folded. 2. Install 5/16" x 2" carriage bolts, flat washers and regular nuts o ...

  • Weil-McLain 78 - page 12

    ...

  • Weil-McLain 78 - page 13

    General water piping information: • System water supply and return piping should be installed and piping connections attached to boiler before erecting jacket or installing controls. • Do not pipe in through supply and out through return. This creates reverse water flow through boiler that must not be used. • When three-way valves are used fo ...

  • Weil-McLain 78 - page 14

    ...

  • Weil-McLain 78 - page 15

    • Installation • Start-Up • M aintenance • Pa r t s Connect Steam Boiler Piping 6a General steam piping information: • Hartford Loop piping arrangement and wet return are required for steam boilers. • Maintain 24-inch minimum from waterline to bottom of header (56-1/4" from bottom o f section). • When using condensate receiver, f ...

  • Weil-McLain 78 - page 16

    ...

  • Weil-McLain 78 - page 17

    ...

  • Weil-McLain 78 - page 18

    ...

  • Weil-McLain 78 - page 19

    ...

  • Weil-McLain 78 - page 20

    ...

  • Weil-McLain 78 - page 21

    ...

  • Weil-McLain 78 - page 22

    ...

  • Weil-McLain 78 - page 23

    ...

  • Weil-McLain 78 - page 24

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Install Bur ner 12a Wiring and Fuel Piping 13a T o install burner: 1. Unpack burner . 2. Place gasket around air tube and against burner mounting flange. If sealing rope is used, apply 1/8" continuous bead of rope adhesive around burner mounting flange and apply sealing rop ...

  • Weil-McLain 78 - page 25

    • Installation • Start-Up • M aintenance • Pa r t s Make Final Adjustments 14a T o fill water boilers: 1. Close manual air vents and drain cocks. 2. Fill to correct system pressure. Correct pressure will vary with each installation. 3. Starting on lowest floor , open air vents one at a time until water squirts out. Close vent. Repeat with r ...

  • Weil-McLain 78 - page 26

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Make Final Adjustments 14b Skim steam boilers: Clean all newly install steam boilers to remove oil. Failure to properly clean can result in violent water level fluctuations, water passing into steam mains, or high maintenance costs on strainers, traps and vents. Skim boiler only ...

  • Weil-McLain 78 - page 27

    • Installation • Start-Up • M aintenance • Pa r t s Data and Dimensions 15a Data Dimensions Supply T appings Return T appings Quantity Quantity And Size* And Size* Boiler Model W ater Steam W ater Steam A B D E H W L 378 2 - 4" 2 - 4" 2 - 3" 2 - 3" 13-1/8 -- 8 42-1/2 13-1/2 20-3/8 21-1/2 478 2 - 4" 2 - 4" 2 - 3 ...

  • Weil-McLain 78 - page 28

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Data and Dimensions 15b Part No. 550-141-705 28 Front Back Side Intermediate Minimum for heater removal 3" NPT return W=Boiler section length 4" NPT supply outlets 3" NPT return W ater line ...

  • Weil-McLain 78 - page 29

    • Installation • Start-Up • M aintenance • Pa r t s Part No. 550-141-705 29 Parts 16a B A C O N E G F D J K L P Q K M P I H ...

  • Weil-McLain 78 - page 30

    W eil-McLain 78 Boiler For Gas, Light Oil, Gas/Light Oil Fired Burners Parts 16b Figure No. Description W-M Sales Ref. No. A Front Section (7813) 1 1B329 B Intermediate Section Regular (7815) 1 1B330 Intermediate Section Supply - Steam (7814) 1 1B331 C Intermediate Section T ankless (7816) 1 1B332 D Back Section (7818) 1 1B333 Section Assembly Kit ...

  • Weil-McLain 78 - page 31

    • Installation • Start-Up • M aintenance • Pa r t s Ratings 17a Part No. 550-141-705 31 ◆ I=B=R Burner ✝ ✝ Boiler Water Capacity Net I=B=R Ratings ❏ Content Gals. Packaged ✝ ■ * * Positive Boiler * * Gross Net Stack Presure I=B=R Weight Light ❍ ■ I=B=R ■■ Firebox Gas In V ent Steam Less Oil Gas Output Steam Steam W ater ...

  • Weil-McLain 78 - page 32

    Part No. 550-141-705/0600 32 ...

Produzent Weil-McLain Kategorie Burner

Dokumente, die wir vom Produzenten des Geräts Weil-McLain 78 erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Weil-McLain
- Bedienungsanleitungen 78
- Produktkarten Weil-McLain
- Informationsbroschüren
- oder Energieetiketten Weil-McLain 78
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Weil-McLain 78.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Weil-McLain 78, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Weil-McLain 78. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Weil-McLain 78 ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Weil-McLain 78, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Weil-McLain 78 hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Weil-McLain 78 verständlich ist.

Eine gänzliche Bedienungsanleitung von Weil-McLain sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Weil-McLain 78 bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Weil-McLain 78 befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Weil-McLain 78, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Weil-McLain 78 - die uns die ersten Schritte während der Nutzung von Weil-McLain 78 erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Weil-McLain 78 hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Weil-McLain 78 im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Weil-McLain 78?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Weil-McLain 78 nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Weil-McLain 78 hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)