Deutsch dropdown-ico

Bedienungsanleitung Frymaster MPF50S Series

30 Seiten 1.48 mb
Download

Zur Seite of 30

Summary
  • Frymaster MPF50S Series - page 1

    Frymaster, a member of the Co mmercial Food Eq uipment Service Ass ociation, recomm ends using CFESA Certified Tec hnicians. 24-Hour Service Hotline 1-800-551-8633 MAR 2008 *8196301* MPF50S Series Portable Filtration System Operating, Service & Parts Manual ...

  • Frymaster MPF50S Series - page 2

    Please read all sections of this manual and retain for future reference. Installation, maintenance, and repairs shoul d be performed by your Frymaster Dean Factory Authorized Service Agency. WARNING Safe and satisfactory operation of y our equipment depends on its proper installation. Installation MUST conform to local codes, or in th e absence of ...

  • Frymaster MPF50S Series - page 3

    NOTICE: If this filter unit is cleaned with water, disconnect the unit from power source before cleaning and thoroughly dry the filter unit before reconnecting to electrical power source. DANGER The crumb tray (if equipped) in portable filter sy stems must be emptied into a fireproof container at the end of frying operati ons each day. Some food pa ...

  • Frymaster MPF50S Series - page 4

    MPF50S Series Portable Filtration Systems Operation, Service & Parts Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 2. IMPORTANT INFORMATION 2-1 3. FILTER PREPARATION 3-1 4. OPERATING/FILTER INSTRUCTIONS 4-1 5. CLEANING AND MAINTENANCE 5-1 6. TROUBLESHOOTING/SERVI CE PROCEDURES 6-1 7. PARTS LIST 7-1 ...

  • Frymaster MPF50S Series - page 5

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-1 1.1 Parts Ordering Place parts orders directly with your local Frym as ter/Dean Factory Authorized Service Center. A list of FASCs was included with th e filter when shipped from the factory. If you do not have access to this list, please contact the Frymaster/Dean service depart ...

  • Frymaster MPF50S Series - page 6

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-2 1.3 After Purchase In order to improve service, fill out the followi ng chart with the nearest Frymaster Authorized Service Technician and FASC in your area. Authorized Service Technician/FASC Address Telephone/Fax Filter Model Number Filter Serial Number 1.4 Safety Information B ...

  • Frymaster MPF50S Series - page 7

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-3 1.5 Service Personnel 1.5.1 Definitions A. Qualified and/or Authorized Operating Pers onnel 1. Qualified/authorized operating pe rsonnel are those who have car efully read the information in this manual and have familiarized them selves with the equipment f unctions, or have had ...

  • Frymaster MPF50S Series - page 8

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 General MPF50S portable filters can be used with a va riety of Frymaster fryers, as well as other manufacturers’ equipment. Oil capacity is appr oximately 50 pounds. Unit specifications are listed below. Model Unit Height (inches) Unit Width (inches) Unit Length (i ...

  • Frymaster MPF50S Series - page 9

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-2 2.1 General (cont.) Oil or shortening is gravity-draine d from the fryer into the filter ("S" Models), or pumped from the frypot into the filter pan, and then filtered through filter p aper. Filter powder, which enhances the filtering process, is distributed ov ...

  • Frymaster MPF50S Series - page 10

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-3 2.3 Pre-Installation NOTE: Failure to use qualified service personnel will void the Fry master warranty. A. Standards : Use of this filter unit mu st be in accordance with all app licable state and local codes. DANGER This portable filter is equipped with a three-prong ( ...

  • Frymaster MPF50S Series - page 11

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 3: FILTER PREPARATION 3-1 3.1 Assembling The Filter System On initial installation and before each use, rem ove all loose parts from the filter, wash all access ories in hot, soapy water and dry thoroughly. DO NOT WASH INTERIOR OF FILTER PAN WITH DETERGENT OR WATER! Wipe debris and residue from th e ...

  • Frymaster MPF50S Series - page 12

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 3: FILTER PREPARATION 3-2 3.1 Assembling The Filter System 1. Ensure the filter pan is clean a nd free of all food and breading pa rticles that could prevent the filter paper from sealing against the bottom of the pan. 2. Place the filter paper support sc reen between the raised dimp les in th e bot ...

  • Frymaster MPF50S Series - page 13

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4-1 4.1 Filter Operation WARNING Use care when draining and filtering oil to avoid the possibility of a serious burn. 1. Sprinkle 8 ounces (1 cup) of filter po wder over the filter paper, distr ibuting the powder as evenly as possible. If filtering a second frypot ...

  • Frymaster MPF50S Series - page 14

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4-2 4.1 Filter Operation (cont.) 5. Ensure the oil is at operating temper ature, 350°F. Turn the fryer off. WARNING The filter pan maximum capacity is 50 lb s. DO NOT OVERFI LL THE FILTER PAN. 6. Place filter pan directly under fryer drain valve an d drain oil in ...

  • Frymaster MPF50S Series - page 15

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5-1 5.1 General Cleaning operations fall into three general categories : • Wiping unit clean after e ach filter session; • Cleaning, changing filter paper and prepari ng the unit for the next day’s business. • Weekly cleaning to remove oil deposits and other parti ...

  • Frymaster MPF50S Series - page 16

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5-2 5.3 Daily— Close Of Business At the close of a working day, filter the oil in all f r yers. When the last f ryer is filtered, follow these steps: 1. Ensure the flexible hose and pump lines ar e clear by running the f ilter pump for an additional 15–30 seconds afte ...

  • Frymaster MPF50S Series - page 17

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-1 6.1 Operating Problems Plugged lines and plugged filter paper account for ove r 90 percent of filtrati on system m alfunctions. A general troubleshooting chart, included in this chapter, provides instructions in diagnosing common malfunctions. Contact a fa c ...

  • Frymaster MPF50S Series - page 18

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-2 6.2 General Troubleshooting (cont.) ...

  • Frymaster MPF50S Series - page 19

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-3 6.3 Wiring Diagrams 6.3.1 MPF50SS 115 2P 17P HEATER 1P 12P 11P 14P 15P 16P 4P 3P SWITCH FILTER LIGHT HEATER LIGHT FILTE R CONTROL SW ITCH PUMP M OTOR MOTOR PUMP GREEN WH I T E BLACK CORDSET GREEN WH I T E BLACK EXTERNAL CORD 115V OPTION 230V OPTION 6.3.2 MPF ...

  • Frymaster MPF50S Series - page 20

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-4 6.4 Service Procedures 6.4.1 Replace Lights/Switches WARNING Disconnect power cord from elect rical power before servicing. 1. Disconnect power cord from power supply. 2. Remove four screws securing the switch panel to the control panel. 3. Lift the panel ou ...

  • Frymaster MPF50S Series - page 21

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-5 6.4.2 Replace Heater Strip 1. Disconnect power cord from power supply. 2. Perform Step 2, Section 6.4.3.1, Replace Motor. 3. Remove screws securing outer panels and cord-holding bracket. Remove bracket and the panels. 4. Turn the unit on its side and remove ...

  • Frymaster MPF50S Series - page 22

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-6 6.4.2 Replace Heater Strip (cont.) 7. 115VAC Filters: Disconnect the black wire from the heater indica tor light on the switch panel (left, black arrow), and the white wire from the receptacle (white, white arrow). 230VAC Filters: Disconnect the red wire con ...

  • Frymaster MPF50S Series - page 23

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-7 6.4.3 Replace Motor/Pump 1. Disconnect power cord from power supply. 2. Perform Step 2, Section 6.4.1. Remove two screws securing the handle brackets to the control panel (arrows). Do not remove the remaining handle-bracket screws. Remove remaining screws se ...

  • Frymaster MPF50S Series - page 24

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-8 6.4.3.1 Replace Motor 4. Remove four bolts securing the pump to the motor. Leave the plumbing connected to the pump. Use care not to damage the flex supply lines connected to the pump. Remove the pump gasket for reassembly. 5. Remove six screws securing the ...

  • Frymaster MPF50S Series - page 25

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-9 6.4.3.2 Replace Pump 1. Disconnect power cord from power supply. 2. Perform Steps 2 and 3, Section 6.4.3.1, Replace Motor. 3. Remove foil insulation tape and heater strip from pump and flex lines. Remove the heater strip from the pump and disconnect flexline ...

  • Frymaster MPF50S Series - page 26

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-10 6.4.3.3 Replace Wand Hose 1. Disconnect power cord from power supply. 2. Remove cord-holder bracket and outer panels (see Step 3, Section 6.4.2 for reference). 3. Unscrew the hose fitting with an open-end wrench from the elbow on the pump. 4. Install the ne ...

  • Frymaster MPF50S Series - page 27

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 7: PARTS LIST 7-1 7.1 MPF50S Parts List ...

  • Frymaster MPF50S Series - page 28

    MPF50S SERIES PORTABLE FILTRATION SYST EMS CHAPTER 7: PARTS LIST 7-2 Item Part # Description 1 823-6231 Pan, Filter 2 806- 5223SP Base Assembly (Includes items 3 & 4) 900-9542 Bracket, Motor-Mount – All MPF50S 900-1748 Brace, End- Filter Base 900-8585 Brace, Rear Cross- Filter Base 3 810-2805 Caster, 2"- Swivel (Without Brake ) 4 810-280 ...

  • Frymaster MPF50S Series - page 29

    MPF50S SERIES PORTABLE FILTRATION SYST EMS CHAPTER 7: PARTS LIST 7-3 24 912-2616 Bracket, Handle- Right 25 911-2616 Bracket, Handle- Left * 826-1380 Screw, ¼-20 x ½" Slotted Head (For Handle Bra cket) (Qty. of 5) 26 910-9169 Handle, Portable Filter * 826-1389 Bolt, ¼-20 x ¾" Hex Head (Qty. of 10) * 810-0219 Spacer, Handle Bolt * 809-0 ...

  • Frymaster MPF50S Series - page 30

    Frymaster, L.L.C., 8700 Line Av enue, PO Box 51 000, Shreveport, Louisiana 71135-1000 Shipping Address: 8700 Line Av enue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318- 219-71 40 FAX (Tech Support) 1-318-219-7135 PRINTED IN THE UNITED STATES SERVICE HOTLINE 1-800-551-8633 819-6301 MA R 2 00 8 ...

Produzent Frymaster Kategorie Water Dispenser

Dokumente, die wir vom Produzenten des Geräts Frymaster MPF50S Series erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Frymaster
- Bedienungsanleitungen MPF50S Series
- Produktkarten Frymaster
- Informationsbroschüren
- oder Energieetiketten Frymaster MPF50S Series
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Frymaster MPF50S Series.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Frymaster MPF50S Series, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Frymaster MPF50S Series. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Frymaster MPF50S Series ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Frymaster MPF50S Series, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Frymaster MPF50S Series hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Frymaster MPF50S Series verständlich ist.

Eine gänzliche Bedienungsanleitung von Frymaster sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Frymaster MPF50S Series bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Frymaster MPF50S Series befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Frymaster MPF50S Series, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Frymaster MPF50S Series - die uns die ersten Schritte während der Nutzung von Frymaster MPF50S Series erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Frymaster MPF50S Series hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Frymaster MPF50S Series im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Frymaster MPF50S Series?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Frymaster MPF50S Series nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Frymaster MPF50S Series hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Captcha
Neues Bild

Kommentare (0)