Bedienungsanleitung Asian Resources Int'l Limited MHG-T2

17 Seiten 1.01 mb
Download

Zur Seite of 17

Summary
  • Asian Resources Int'l Limited MHG-T2 - page 1

    Use and Care Instructions for your new T2 Turgo Micro-hydroelectric Generator Models: MHG-T2 Asian Phoenix Resources Ltd., Canada PowerPal ™ T2 Turgo 1 ...

  • Asian Resources Int'l Limited MHG-T2 - page 2

    READ THIS FIRST This manual contains important informati on concerning your new PowerPal T2 Turgo micro-hydroelectric generator. It covers Model MHG-T2. You should read this manual carefully before installing PowerPal or allow a trained technician from your local PowerPal Service Center to install it for you. Your PowerPal generator is designed to ...

  • Asian Resources Int'l Limited MHG-T2 - page 3

    POWERPAL COMPONENTS Inside your PowerPal box you will find: • 1 x generator-turbine assembly • 1 x penstock adaptor flange , internal diameter 110mm • 1 x rubber gasket • 4 x M10 foundation nuts and bolts • 1 x control panel including electronic load controller • 1 x ballast load • 1 x Guarantee Card • 1 x this instruction manual. P ...

  • Asian Resources Int'l Limited MHG-T2 - page 4

    Turbine stand lt Forebay G F E D C B A A. Forebay, or water tank B. Atmospheric vent C. Penstock, or intake pipe D. Spear valve E. Turbine PowerPal ™ T2 Turgo 4 ...

  • Asian Resources Int'l Limited MHG-T2 - page 5

    SELECTING A SITE PowerPal is designed for use in a wide range of locations. There are two cr itical factors that influence power output – head and flow. Head is th e vertical distance between the turbine and the water source (for ebay), m easured in meters. Flow is the amount of water that passes through the turbine at any inst ant, measured in l ...

  • Asian Resources Int'l Limited MHG-T2 - page 6

    Measuring Flow The best way to measure the water flow is to tak e a piece of pipe the same diameter as the penstock, insert it in the stream or da m where the flow is expected to com e from, and measure the flow from there. In the diagram below, a short length of pipe (less than 1 meter) is buried into the side of a small ‘dam’ using mud or imp ...

  • Asian Resources Int'l Limited MHG-T2 - page 7

    When installing the penstock, try to keep it as straight as pos sible and avoid sharp turns or angles. To do this, part of the hillslope may need exc avating while in other places the penstock may need supporting with poles etc. S teeper terrain has advan- tages over more gentle terrain as cost is reduc ed by the use of a shorter penstock. C A B Th ...

  • Asian Resources Int'l Limited MHG-T2 - page 8

    SYSTEM INSTALLATION Mechanical Aspects After locating a suitable site and completing the civil works, your PowerPal is ready for installation. To do this: 1. Bolt the turbine to a turbin e stand or base which allo ws at least 300mm clearance between the turbine and the ground. This clearance is required to prevent splashback that will disrupt turbi ...

  • Asian Resources Int'l Limited MHG-T2 - page 9

    220VAC house suppl y Ballast load Electronic Load Controller - ELC Main network or house distribution boar d hydro turbine A B C To connect the electrical compone nts, please follow these steps: The electrics should be installed by persons competent in mains voltage wiring. This system operates on a switc hed neutral basis. Neutral and phase connec ...

  • Asian Resources Int'l Limited MHG-T2 - page 10

    4. Connect the user load cables L1 and L2 between the control box and the house. 5. Connect the ballast load (C ) to the control box and user load cable. The ballast load is rated 10-15% (maximum ) higher than the rated power output of the generator e.g. 2.2kW for model MHG-T2. As such, it will becom e hot, up to 100 ° C. To prevent injury and the ...

  • Asian Resources Int'l Limited MHG-T2 - page 11

    5. Operate like this for 15 minutes while observing any unusual noise, excessive temperature or other problems and if OK then switch on the power to the user. Up till now the ballast lo ad has been receiving all the power and should be hot, but once switching on the user load the powe r to the balla st load will fall. 6. The voltage should remain s ...

  • Asian Resources Int'l Limited MHG-T2 - page 12

    Changing the Bearings and Seal Apart from greasing the bearing, there are on ly two tasks that m ust be completed at regular intervals. These are the changing of the lower generator bearing & turbine bearing and the lower bearing seal every two years. See the section on Technical Specifications at the end of this m anual for part numbers. These ...

  • Asian Resources Int'l Limited MHG-T2 - page 13

    E F C D A B TROUBLESHOOTING If any problems are encountered, check this section before contacting your Service Center. 1. Head and flow conditions appear to be OK, but PowerPal will not work. It is likely that the system has been installed in correctly. Check this by f ollowing the steps once more. PowerPal ™ T2 Turgo 13 ...

  • Asian Resources Int'l Limited MHG-T2 - page 14

    2. PowerPal has provided el ectricity for a while and suddenly the electricity stops. If this instruction manual is not followed and power consumption is too high, or if there is a short circuit in an appliance th e circuit breake r in the electronic load controller will trip. This will stop the elec tric current. If this o ccurs, check for possibl ...

  • Asian Resources Int'l Limited MHG-T2 - page 15

    a) Start the generator and ad just the spear valve to obtai n 220-240 volts, 0 amps at the panel. [Do not turn the circuit breaker on]. b) Adjust the potentiometer on the circuit board very slowly to the left. When you detect a small decrease in voltage, stop. Turn on the circuit breaker and increase water to increase power to the unit. Increase po ...

  • Asian Resources Int'l Limited MHG-T2 - page 16

    APPENDIX A – FOREBAY DESI GN The instructions given on page 7 of this manual to design the forebay are adequate for most cases. The most important aspects of forebay design are: 1) To allow a continual flow of water to the penstock so tha t the turbine keeps functioning. 2) To have sufficient safeguards to prevent sand, vegetation and other debri ...

  • Asian Resources Int'l Limited MHG-T2 - page 17

    POWERPAL T2 TURGO MODELS T-2 Model (1.5kW) (single nozzle) Output (watts) H (head, in metres) 14 15 16 17 18 19 20 Q (flowrate, in l/sec) 18.5 17. 3 16.2 15.2 14.4 13.6 12.9 1250 18.5 17.3 16.3 15.4 14.6 13.9 1361 18.5 17.4 16.5 15.6 14.8 1452 18.5 17.5 16.6 15.7 1543 18.5 17.5 16.6 1633 18.5 17.6 1724 18 1750 T-2 Model (2.0kW Med H) (single nozzle ...

Produzent Asian Resources Int'l Limi Kategorie Portable Generator

Dokumente, die wir vom Produzenten des Geräts Asian Resources Int'l Limited MHG-T2 erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Asian Resources Int'l Limi
- Bedienungsanleitungen ted MHG-T2
- Produktkarten Asian Resources Int'l Limi
- Informationsbroschüren
- oder Energieetiketten Asian Resources Int'l Limited MHG-T2
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Asian Resources Int'l Limited MHG-T2.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Asian Resources Int'l Limited MHG-T2, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Asian Resources Int'l Limited MHG-T2. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Asian Resources Int'l Limited MHG-T2 ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Asian Resources Int'l Limited MHG-T2, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Asian Resources Int'l Limited MHG-T2 hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Asian Resources Int'l Limited MHG-T2 verständlich ist.

Eine gänzliche Bedienungsanleitung von Asian Resources Int'l Limi sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Asian Resources Int'l Limited MHG-T2 bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Asian Resources Int'l Limited MHG-T2 befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Asian Resources Int'l Limited MHG-T2, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Asian Resources Int'l Limited MHG-T2 - die uns die ersten Schritte während der Nutzung von Asian Resources Int'l Limited MHG-T2 erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Asian Resources Int'l Limited MHG-T2 hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Asian Resources Int'l Limited MHG-T2 im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Asian Resources Int'l Limited MHG-T2?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Asian Resources Int'l Limited MHG-T2 nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Asian Resources Int'l Limited MHG-T2 hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)