Bedienungsanleitung LG Electronics 3828A30087S

33 Seiten 4.77 mb
Download

Zur Seite of 33

Summary
  • LG Electronics 3828A30087S - page 1

    ENGLISH LG Room Air Conditioner INSTALLATION MANUAL LG http://www.lgservice.com IMPORTANT • Please read this instruction manual completely before installing the product. • When the power cord is damaged, replacement should be performed by authorized personnel only. • Installation work must be performed in accordance with the national wiring s ...

  • LG Electronics 3828A30087S - page 2

    2 Room Air Conditioner Room Air Conditioner Installation Manual T ABLE OF CONTENTS Safety Precautions ......................... 3 Introduction .....................................9 Symbols Ued in This Manual ......9 Features .......................................9 Installation ..................................... 10 Installation P ar ts ........ ...

  • LG Electronics 3828A30087S - page 3

    Installation Manual 3 ENGLISH Safety Precautions T o pre vent the injury of the user or other people and proper ty damage, the follo wing instructions must be f ollowed. ■ Incorrect operation due to ignoring instruction will cause har m or damage. The seriousness is classified by the f ollowing indications. ■ The meanings of the symbols used in ...

  • LG Electronics 3828A30087S - page 4

    4 Room Air Conditioner Safety Precautions ■ Operation Be cautious when unpacking and installing the product. • Shape edges could cause injury . Be especially careful of the sharp edges. For installation, always contact the dealer or an A uthorized Service Center . • There is r isk of fire, electric shock, explosion, or injury . Do not install ...

  • LG Electronics 3828A30087S - page 5

    Installation Manual 5 ENGLISH Safety Precautions Do not place a heater or other appliances near the power cable. • There is risk of fire, failure of the product, and/or electric shock. Do not let the air conditioner run for a long time when the humidity is very high and a door or a window is left open. • Moisture may condense and w et or damage ...

  • LG Electronics 3828A30087S - page 6

    6 Room Air Conditioner Saf ety Precautions ■ Installation Alwa ys check f or gas(refrig erant) leakage after installation or repair of product. • Low refrigerant le vels ma y cause product failure . Install the drain hose to ensure that water is drained awa y properl y . • A bad connection may cause w ater leakage. Keep level e ven when insta ...

  • LG Electronics 3828A30087S - page 7

    Safety Precautions Installation Manual 7 ENGLISH ■ Operation Do not install the product where the noise or hot air from the outdoor unit could damage the neighborhoods. • It may cause a prob lem for your neighbors. Use two or more people to lift and transport the air conditioner • A void personal injury . Do not install the product where it w ...

  • LG Electronics 3828A30087S - page 8

    8 Room Air Conditioner Saf ety Precautions ■ Disuse Alwa ys insert the filter securely . Clean the filter every two weeks or more often if necessary . • A dir ty filter reduces the efficiency of the air conditioner and could cause product malfunction or damage. Do not drink the water drained from the unit. • It is not sanitary and could cause ...

  • LG Electronics 3828A30087S - page 9

    Installation Manual 9 ENGLISH Introduction This symbol alerts you to the risk of electric shock. This symbol alerts you to hazards that ma y cause harm to the air conditioner . This symbol indicates special notes. NOTICE Intr oduction Symbols Used In This Manual Features Air Intake Vents Air Outlet Vents Connecting Wires Piping Drain Hose Base Plat ...

  • LG Electronics 3828A30087S - page 10

    10 Room Air Conditioner Installation Type "A" screw and plastic anchor Type "B" screw Remote Control Holder Installation plate Figure Figure Name Screw driver Electric Drill Measuring Tape, Knife Hole Core Drill Spanner Torque wrench Ohmmeter Hexagonal wrench Ammeter Gas Leak Detector Thermometer, Level Flaring Tool Set Name Ins ...

  • LG Electronics 3828A30087S - page 11

    Installation parts you should purchase. Vinyl tape (Wide) • Apply after carrying out a drainage test. • To carry out the drainage test, remove the air filters and pour water into the heat exchanger. Saddle Forced Operation Button Gas side piping (Optional Parts) Liquid side piping (Optional Parts) Additional drain pipe Vinyl tape (Narrow) Drain ...

  • LG Electronics 3828A30087S - page 12

    Installation 1. Check the quality label on the indoor and outdoor unit. 2. Make cer tain that the refrigerant is R-410A. THIS PRODUCT CONT AINS R-410A REFRIGERANT 1) Diff erent compressor oil - R-410A(P olyol ester) / R-22(Mineral). - Do not mix the e xisting mineral oil. - Do not apply used pipe, tools and gauges co vered with the e xisting minera ...

  • LG Electronics 3828A30087S - page 13

    Installation Manual 13 ENGLISH Installation Outdoor unit 1. If an awning is built o ver the unit to pre vent direct sunlight or rain e xposure, make sure that heat radiation from the condenser is not restricted. 2. Ensure that the space around the back and sides is more than 30cm(11.8in). The front of the unit should hav e more than 70cm(27.6in) of ...

  • LG Electronics 3828A30087S - page 14

    12k Ø 12.7mm(1/2") Ø 6.35mm(1/4") 7.5(25) 7.5(25) 15(49) 20(0.22) 14 Room Air Conditioner Installation Piping Length And Elev ation • Capacity is based on standard length and maximum allo wance length is on the basis of reliability . • Oil trap should be installed e ver y 5~7meters (16.4~23.0ft). Pipe Size Capacity (Btu/h) Suction E ...

  • LG Electronics 3828A30087S - page 15

    Installation Manual 15 ENGLISH Installation The wall y ou select should be strong and solid enough to pre vent vibr ation 1. Mount the installation plate on the wall with type "A" screws . If mounting the unit on a concrete wall, use anchor bolts . • Mount the installation plate horizontally b y aligning the centerline using a lev el. 2 ...

  • LG Electronics 3828A30087S - page 16

    16 Room Air Conditioner Installation Flaring W ork Cut the pipes and the cable. 1. Use the piping kit accessor y or the pipes purchased locally . 2. Measure the distance between the indoor and the outdoor unit. 3. Cut the pipes a little longer than measured distance. 4. Cut the cable 1.5m(59.1in) longer than the pipe length. Burrs remo val 1. Compl ...

  • LG Electronics 3828A30087S - page 17

    Installation Manual 17 ENGLISH Installation Indoor 1. Prepare the indoor unit's piping and drain hose for installation through the w all. 2. Remove the plastic tubing retainer(see the illustration b y) and pull the tubing and drain hose aw ay from chassis . 3. Replace only the plastic tubing holder 1, not the holder 2 in the original position. ...

  • LG Electronics 3828A30087S - page 18

    18 Room Air Conditioner Installation Wrap the insulation material around the connecting portion. • Overlap the connection pipe insulation material and the indoor unit pipe insulation material. Bind them together with vinyl tape so that there is no gap . Route the indoor tubing and the drain hose to the required piping hole position. Plastic bands ...

  • LG Electronics 3828A30087S - page 19

    Installation Manual 19 ENGLISH Installation Insert the connecting cable into the indoor unit. • Don't connect the cable to the indoor unit. • Make a small loop with the cab le for easy connection later . T ape the drain hose and the connecting cable . • Connecting cable Connecting the pipings to the indoor unit and the drain hose to drai ...

  • LG Electronics 3828A30087S - page 20

    20 Room Air Conditioner Installation Reroute the pipings and the drain hose across the bac k of the chassis. Reroute the pipings and the drain hose across the bac k of the chassis. Drain hose Vinyl tape(narrow) Pipe Wrap with vinyl tape(wide) • Bundle the piping and drain hose together by wrapping them with cloth tape ov er the range within which ...

  • LG Electronics 3828A30087S - page 21

    Installation Manual 21 ENGLISH Installation Installation Inf or mation. For left piping. Follo w the instruction below . Correct case • Press on the upper side of clamp and unf old the tubing to downward slowly . Incorrect case • F ollowing bending type from right to left may cause damage to the tubing. ...

  • LG Electronics 3828A30087S - page 22

    22 Room Air Conditioner Installation Put a couple drops of refrigerant oil on the face of the flare before assembling taking care not to add any contaminants. Align the center of the pipings and sufficiently tighten the flare nut by hand. • The drain hose can be connected at two different positions. Use the most convenient position and, if necess ...

  • LG Electronics 3828A30087S - page 23

    Installation Manual 23 ENGLISH Installation Connecting the Piping Connection Of The Cable 1 Indoor Unit Outdoor Unit 2 3 4 1 2 3 4 5 6 G To branch circuit Ground P ower supply a L1 * L2 Connecting cable(Low v oltage) b T erminal (4P) T erminal (6P) Outdoor unit Wiring Diagram T erminal block Over 5mm (0.2") Cov er control Conduit panel Connect ...

  • LG Electronics 3828A30087S - page 24

    24 Room Air Conditioner Installation After the confirmation of the above conditions , prepare the wiring as follows: 1) Never fail to have an individual po wer circuit specifically f or the air conditioner . As f or the method of wiring, be guided by the circuit dia gram posted on the inside of control cover . 2) The screw which fasten the wiring i ...

  • LG Electronics 3828A30087S - page 25

    Installation Manual 25 ENGLISH Installation Chec king The Drainage • P our a glass of water on the drain pan. • Ensure the water flows through the drain hose of the indoor unit without an y leakage and goes out the drain exit. Drain piping • The drain hose should point downw ard for easy dr ain flow . • A void these situations . Drain pan D ...

  • LG Electronics 3828A30087S - page 26

    26 Room Air Conditioner Installation Forming The Piping Form the piping by wrapping the connecting portion of the indoor unit with insulation material and secure it with two kinds of vin yl tapes. • If you w ant to connect an additional drain hose , the end of the drain outlet should be routed abo ve the ground. Secure the drain hose appropriatel ...

  • LG Electronics 3828A30087S - page 27

    Installation Manual 27 ENGLISH Air Purging Air purging With V acuum Pump Lo Hi Indoor unit Outdoor unit Manifold valve Charge hose Nitrogen gas cylinder(in vertical standing position) Pressure gauge Air and moisture remaining in the refrigerant system ha ve undesira ble eff ects as indicated below . • Pressure in the system r ises. • Operating ...

  • LG Electronics 3828A30087S - page 28

    28 Room Air Conditioner Installation Evacuation • Connect the charge hose end described in the preceding steps to the vacuum pump to ev acuate the tubing and indoor unit. Confirm the "Lo" knob of the manifold valv e is open. Then, run the vacuum pump . The operation time f or ev acuation varies with tubing length and capacity of the pum ...

  • LG Electronics 3828A30087S - page 29

    Installation Manual 29 ENGLISH Installation Charging ■ Each outdoor unit is factory charged (nameplate charge) for the e vaporator as well as a 7.5m(25ft) line set. Any time a line set is used either shor ter or longer then the nominal 7.5m(25ft) line set length the refrigerant charge has to be adjusted. ■ Whether the line set is made shor ter ...

  • LG Electronics 3828A30087S - page 30

    30 Room Air Conditioner T est Running Outside ambient TEMP . The pressure of the gas side ser vice valve 95 ° F(35 ° C) 8.5~9.5kg/cm 2 G(120~135 P .S.I.G.) Settlement of outdoor unit ■ Anchor the outdoor unit with a bolt and nut( ø 10mm(0.39in) tightly and horizontally on a concrete or rigid mount. ■ When installing on the wall, roof or roof ...

  • LG Electronics 3828A30087S - page 31

    Installation guide at the seaside Installation Manual 31 ENGLISH Installation guide at the seaside 1. Air conditioners should not be installed in areas where corrosive gases, such as acid or alkaline gas, are produced. 2. Do not install the product where it could be exposed to sea wind (salty wind) directly. It can result corrosion on the product. ...

  • LG Electronics 3828A30087S - page 32

    32 Room Air Conditioner ...

  • LG Electronics 3828A30087S - page 33

    P/No .: 3828A30087S ...

Produzent LG Electronics Kategorie Air Conditioner

Dokumente, die wir vom Produzenten des Geräts LG Electronics 3828A30087S erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen LG Electronics
- Bedienungsanleitungen 3828A30087S
- Produktkarten LG Electronics
- Informationsbroschüren
- oder Energieetiketten LG Electronics 3828A30087S
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung LG Electronics 3828A30087S.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen LG Electronics 3828A30087S, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen LG Electronics 3828A30087S. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts LG Electronics 3828A30087S ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts LG Electronics 3828A30087S, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von LG Electronics 3828A30087S hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von LG Electronics 3828A30087S verständlich ist.

Eine gänzliche Bedienungsanleitung von LG Electronics sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von LG Electronics 3828A30087S bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von LG Electronics 3828A30087S befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich LG Electronics 3828A30087S, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts LG Electronics 3828A30087S - die uns die ersten Schritte während der Nutzung von LG Electronics 3828A30087S erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit LG Electronics 3828A30087S hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von LG Electronics 3828A30087S im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich LG Electronics 3828A30087S?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit LG Electronics 3828A30087S nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit LG Electronics 3828A30087S hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)