-
Generac Power Systems Guardian Elite 005259-0 - page 1
ST ANDBY GENERA T OR O WNER'S MANU AL This manual should remain with the unit. A ne w standar d of reliability Serial Number 2.4L 35kW Model: 005259-0 — CAUTION — ONL Y QU ALIFIED ELECTRICIANS OR CONTRA CT ORS SHOULD A TTEMPT INST ALLA TION! Cover040 Re v . 0 02/06 Part No. 0G0238 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 2
Standby Generator Sets T able of Contents SECTION P AGE SAFETY RULES ................................................ 1-1 INTRODUCTION ..................................................... 1-3 Read this Manual Thoroughly ................................... 1-3 Operation and Maintenance ...................................... 1-3 How to Obtain Servic ...
-
Generac Power Systems Guardian Elite 005259-0 - page 3
Study these SAFETY RULES carefully before install- ing, operating or servicing this equipment. Become familiar with this Owner’s Manual and with the unit. The generator can operate safely , efficiently and reli- ably only if it is properly installed, operated and maintained. Many accidents are caused by failing to follow simple and fundamental ru ...
-
Generac Power Systems Guardian Elite 005259-0 - page 4
• Before performing any maintenance on the gen- erator , disconnect its battery cables to prevent accidental start -up. Disconnect the cable from the battery post indicated by a NEGA TIVE, NEG or (–) first. Reconnect that cable last. • Never use the generator or any of its parts as a step. Stepping on the unit can stress and break parts, and ...
-
Generac Power Systems Guardian Elite 005259-0 - page 5
1-3 I NTRODUCTION Thank you for purchasing this model of the standby generator set product line. Every effort was expended to make sure that the information and instructions in this manual were both accurate and current at the time the manual was written. However , the manufacturer reserves the right to change, alter or otherwise improve this produ ...
-
Generac Power Systems Guardian Elite 005259-0 - page 6
I DENTI F ICA TION R EC ORD D A T A LA BE L Every generator set has a DA T A LABEL that contains important information pertinent to the generator . The data label, which can be found attached to the gen- erator’s lower connection box, lists the unit ’s serial number and its rated voltage, amps, wattage capacity , phase, frequency , rpm, power f ...
-
Generac Power Systems Guardian Elite 005259-0 - page 7
E QUIPM ENT DE SCRI PTION This equipment is a revolving field, alternating cur - rent generator set. It is powered by a gaseous fueled engine operating at 1800 rpm for 4-pole direct drive units, 3600 rpm for 2-pole direct drive units and 2300 - 3000 rpm for quiet drive gear units. See the Specifications section for exact numbers. The unit comes com ...
-
Generac Power Systems Guardian Elite 005259-0 - page 8
ENGI N E P RO TE CTIVE DEVICE S The standby generator may be required to operate for long periods of time without an operator on hand to monitor such engine conditions as coolant tempera- ture, oil pressure or rpm. F or that reason, the engine has several devices designed to protect it against potentially damaging conditions by automatically shutti ...
-
Generac Power Systems Guardian Elite 005259-0 - page 9
F U EL SYST EM FUE L RE QUIRE MEN T S The standby generator may be equipped with one of the following fuel systems: • Natural gas fuel system • Propane vapor (PV) fuel system The Manual Drawing Listing that is affixed to the unit includes the “Identification Code,” which may be used to identify the type of fuel system installed on the unit. ...
-
Generac Power Systems Guardian Elite 005259-0 - page 10
SP ECIF ICA TIONS GEN ERA T OR T ype ............................................................................. Synchronous Rotor Insulation ................................................................... Class H Stator Insulation .................................................................. Class H T otal Har monic Distor tion ........ ...
-
Generac Power Systems Guardian Elite 005259-0 - page 11
COLD WEA THER KIT F or cold climates, optional cold weather kit (part number 0F6148) is recommended. The kit includes: • Battery W armer • 4” Junction Box with hardware • 6 qt. pack 5W -30 synthetic oil (engine) R EC ON F IGU R I NG TH E F U EL SY STEM NOTE: All models are configured for natural gas or LP vapor from the factory . T o reconf ...
-
Generac Power Systems Guardian Elite 005259-0 - page 12
GEN ER A T OR A C LEAD C ONN ECTIONS See “V oltage Codes”. This generator may be rated at any one of three voltages, either single -phase or three -phase. The electrical wires in the unit ’s AC con- nection (lower) panel should be installed according to the number of leads and the voltage/phase required for the application. If there are any q ...
-
Generac Power Systems Guardian Elite 005259-0 - page 13
I NST ALL A TION Refer to the separate “Installation Guide QT Product Line” supplied with the unit. P R EP ARA TION B EFOR E S T ART -UP The instructions in this section assume that the standby generator has been properly installed, ser - viced, tested, adjusted and otherwise prepared for use by a competent, qualified installation contractor . ...
-
Generac Power Systems Guardian Elite 005259-0 - page 14
S T ART -U P CH ECKLIS T Before working on the generator , ensure the fol- lowing: • The AUTO/OFF/MANU AL switch is in the OFF position. • The 120V AC supply to the battery charger is switched OFF . P REP AR A TION FOR S T ART -U P • Ensure that the 120V AC circuit breaker to the bat - tery charger is open. • Remove the fuse from the th ...
-
Generac Power Systems Guardian Elite 005259-0 - page 15
GEN ER A T OR C ONTROL AND OP ER A TION Refer to the appropriate control panel operator’s manual for this unit. OP ER A TI NG U N IT WITH MAN U AL TR ANSF ER SWIT CH If the generator was installed in conjunction with a transfer switch capable of manual operation only , the following procedure applies. A manually operated transfer switch is one th ...
-
Generac Power Systems Guardian Elite 005259-0 - page 16
MAI NTENANCE P ER FOR M ED B Y AUTHOR IZED SERVICE F A CILITI ES Before working on the generator , ensure the fol- lowing: • The AUTO/OFF/MANU AL switch is in the OFF position. • The 15A fuse has been removed from the con- trol box. • The 120V AC supply to the battery charger is switched OFF . EVER Y TH R EE MONTHS 1. Check battery condit ...
-
Generac Power Systems Guardian Elite 005259-0 - page 17
Figure 10.1 - Oil Dipstick and Oil Fill Cap Oil Fill Cap Oil Dipstick B A TTE R Y FL UID Check battery electrolyte fluid based on the Maintenance Schedule. Fluid should cover separa- tors in all battery cells. If fluid level is low , add dis - tilled water to cover tops of separators. DO NOT USE T AP W A TER IN BA TTERY . ENGI NE COOL ANT Check coo ...
-
Generac Power Systems Guardian Elite 005259-0 - page 18
CHANGI NG ENGIN E OI L Refer to maintenance performed by authorized service facilities for engine oil and filter change frequencies. Drain the oil while the engine is still warm from run- ning . This means warm up the engine, shut it down and drain immediately as follows: 1. Remove OIL DRAIN HOSE from its retaining clip. 2. Loosen and remove OIL DR ...
-
Generac Power Systems Guardian Elite 005259-0 - page 19
M ISCELLAN EOUS MAINTENANCE CLEAN ING TH E GEN ER A T OR Keep the generator as clean and as dry as possible. Dirt and moisture that accumulates on internal gen- erator windings have an adverse effect on insulation resistance. P eriodically clean generator exterior surfaces. A soft brush may be used to loosen caked on dirt. Use a vacuum system or dr ...
-
Generac Power Systems Guardian Elite 005259-0 - page 20
SERVICE S CH EDU LE 30 KW - 1 50 KW S T ANDBY GA S ENGI N E DR IVEN GEN ER A T OR SET S The following is a recommended maintenance schedule for standby gas engine driven generator sets from 30kW to 150 kW in size. The established intervals in the schedule are the maximum recommended when the unit is used in an average service application. They will ...
-
Generac Power Systems Guardian Elite 005259-0 - page 21
Maintenance Level 1 Level 2 Level 3 Level 4 Level5 T asks Recom- T ask Required T ask Required T ask T ask Required T ask mended Comp. to be done Comp. to be done Comp. Required Comp. to be done Comp. to be done (Date- 3 months/ (Date- Semi- (Date- to be done (Date- Bi- (Date- monthly/ Initials) Break -in Initials) annually/ Initials) Annually/ Ini ...
-
Generac Power Systems Guardian Elite 005259-0 - page 22
Maintenance Level 1 Level 2 Level 3 Level 4 Level5 T asks Recom- T ask Required T ask Required T ask T ask Required T ask mended Comp. to be done Comp. to be done Comp. Required Comp. to be done Comp. to be done (Date- 3 months/ (Date- Semi- (Date- to be done (Date- Bi- (Date- monthly/ Initials) Break -in Initials) annually/ Initials) Annually/ Ini ...
-
Generac Power Systems Guardian Elite 005259-0 - page 23
Maintenance Level 1 Level 2 Level 3 Level 4 Level5 T asks Recom- T ask Required T ask Required T ask T ask Required T ask mended Comp. to be done Comp. to be done Comp. Required Comp. to be done Comp. to be done (Date- 3 months/ (Date- Semi- (Date- to be done (Date- Bi- (Date- monthly/ Initials) Break -in Initials) annually/ Initials) Annually/ Ini ...
-
Generac Power Systems Guardian Elite 005259-0 - page 24
TROU B LESHOO TING GU IDE P ROB LEM CAUSE C OR R ECTION Engine won’t crank. 1. 15 amp fuse blown. 1. Replace fuse. 2. Loose or corroded or defectiv e 2. Tighten, clean or replace batter y cables. batter y cables as necessary . 3. Defectiv e star ter contactor . 3. Replace contactor.* 4. Defectiv e star ter motor . 4. Replace star ter motor .* 5. ...
-
Generac Power Systems Guardian Elite 005259-0 - page 25
Standby Generator Sets Notes ...
-
Generac Power Systems Guardian Elite 005259-0 - page 26
Standby Generator Sets Notes ...
-
Generac Power Systems Guardian Elite 005259-0 - page 27
Standby Generator Sets Notes ...
-
Generac Power Systems Guardian Elite 005259-0 - page 28
...
-
Generac Power Systems Guardian Elite 005259-0 - page 29
1 0F3137 1 PAN CB CONN BOX 2 0F3188 1 STAND RH CONTR OL 3 0F31 89 1 S TAN D L H CON TRO L 4 0 23484N 1 BUSHING SNAP SB-2.5-31 (3) 5 0F6366 B 1 / 2 XFMR D UA L 12 0V/ 16V (F OR 120 /240V & 277 /480V U NITS) 0F6366A 1 XFMR DUAL 104 V/1 6V (FOR 120/208 V UNITS) (3) 6 043180 2 / 4 WA SHER FLAT M4 (3) 7 022264 2 / 4 WA SHER LOCK #8-M4 (3) 8 0C3990 2 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 30
...
-
Generac Power Systems Guardian Elite 005259-0 - page 31
5) UL CIR CU IT BRE AKER (Q J-2P) A 0F8137 1 COVER QJ 2P FRM CB B 06546 9 1 DECAL, DANGE R HIGH VOLT AG E C 0 E7994 - CB 0225A 24 0V 2P S QJ22 D 0F8136 1 COVER QJ 2P CB DISH E 036 261 4 RIVET POP .125 X .275 SS F 022473 2 WASHER FLAT 1/4 -M6 ZINC G 022097 2 WASHER LOCK M6 -1/4 H 022127 2 NUT HEX 1/4-20 STEEL J 0F8139 1 INSU L CB 2P QJ K 0C2454 7 SC ...
-
Generac Power Systems Guardian Elite 005259-0 - page 32
...
-
Generac Power Systems Guardian Elite 005259-0 - page 33
1 0 G005 6 1 RTR -2390--35 KD1 CP L 0G115 5 1 RTR -2390--35 KD1 CPL (G2 ) 0F967 7 1 RTR -2390--45 KD1 CP L 0G095 9 1 RTR -2390--45 KD1 CPL (G2 ) 2 0 G005 7 1 STR- 2390 --35AD1 CPL 0F96 64 1 STR 39 0 45 K 2P 1P H DI RECT 0G005 8 1 STR -2390 --35K D1 CPL 0G01 84 1 STR 39 0 45 KW 2P 3P H 4 80V 0G005 9 1 STR -2390 --35 GD 1 CPL 0G01 83 1 STR 39 0 45 KW ...
-
Generac Power Systems Guardian Elite 005259-0 - page 34
...
-
Generac Power Systems Guardian Elite 005259-0 - page 35
COM P O NE NTS I N C LU DE D IN 0F 969 6E 1 0F1823A 1 ENCL HSB CO NT ROL PANE L 2 0F3078 1 COVER CO NTR OL PANE L 3 0F2606 1 HING E C ONT INUO US H-PA NEL 4 036261 6 RIVET POP .125 X .275 SS 5 043 181 4 SCREW PHM M3-0 .5 X 10MM 6 052777 7 W ASHE R FL AT M3 7 0F8710B 1 ASSY PCB CPL 2 CTRLR 3600 RP M 8 0 F12 62 4 HOLD ER, F USE WI CKMANN 178. 615 0 9 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 36
...
-
Generac Power Systems Guardian Elite 005259-0 - page 37
1 0F95 17 1 WEL DM E NT FR AM E 2.4 L C2 2 052860 4 NU T FLANG ED HEX M12 - 1 .75 3 0522 51 5 DAMPE NE R VIBR ATIO N 4 0 BLUE 4 052 257 5 SPA CER . 49 X .62 X 1.87 PWD R/ZNC 5 0522 52 5 DAMPE NE R VIBR ATIO N 6 0522 59 5 WASHE R FL AT M 12 7 0528 91 5 SCREW HH C M 12-1. 75 X 8 0 G8. 8 8 053 6210410 1 ASSY W IRE 14 .00" 9 0429 09 1 SCREW HH C M ...
-
Generac Power Systems Guardian Elite 005259-0 - page 38
...
-
Generac Power Systems Guardian Elite 005259-0 - page 39
1 0F34 08B 1 BAT TERY TR AY C1 CPL 2 0F3411 1 S TRAP BA TT ERY RET AI NM E NT 3 0255 07 REF WAS HE R SH AKEP ROOF EX T 7/16 S TL 4 0522 12 REF S CREW HHC M 10- 1.25 X 25 G8. 8 5 0465 26 REF WAS HER LO CK M1 0 6 0221 31 REF WAS HE R FL AT 3/ 8-M 10 Z IN C 7 05033 1A REF BAT TERY PO ST COVE R RED + 8 0503 31 REF BAT TERY POS T CO VE R BL ACK - 9 0388 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 40
...
-
Generac Power Systems Guardian Elite 005259-0 - page 41
1 0G0158 1 ENGIN E 2.4L G1 2 0221 31 3 WASHER FL AT 3/ 8-M10 Z IN C 3 0F9585 1 EXHAUST ADAP TER 2.4L M AC H 4 0465 25 3 NUT HEX M10- 1.25 G8 YE L CH R 5 0522 12 1 (REF) S CREW HHC M 10- 1.25 X 25 G8.8 6 0E9868A 1 (REF) ALTERNATOR DC W/OUT PULLEY 7 0F3 216B 1 ( REF) PULL EY 11 7 OD DC ALT ERN ATO R 8 0G011 5 1 (REF) BRACKET TENSIONER 9 0A8622029 6 ( ...
-
Generac Power Systems Guardian Elite 005259-0 - page 42
...
-
Generac Power Systems Guardian Elite 005259-0 - page 43
1 0F9529 1 WEL D MENT RADIATOR SUPPORT 2. 4L 2 0F2608 1 R AD IATOR 598 X 568 X 49 CPL RH 3 0F52 63 1 V - BELT 31/6 4" X 57-3/8" 40 4 6 5 2 6 5 W A S H E R L O C K M 1 0 5 0599 81 4 SCRE W H HC M 10- 1. 5 X 30 G 10. 9 6 0222 2 2 2 SCRE W H H C 5/ 16- 24 X 1- 1/ 2 G5 7 0F50 5 0 1 SHIELD RAD IATOR C5 8 042568 8 SCREW HH C M6-1.0 X 2 0 G8.8 9 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 44
...
-
Generac Power Systems Guardian Elite 005259-0 - page 45
1 0E6586 1 GASKET B OSCH 32 & 40 2 0E0519 A 1 ADAPTER CARBUR ETOR W/PVC CONN 3 0C81 27 1 E LEME NT A IR CL EA NER 4 0526 19 4 SCREW HH C M 5-0. 8 X 20 G 8. 8 5 022 127 1 NU T HEX 1/4 -20 ST EEL 6 0629 74 1 STUD TH 1/4- 20 X 4- 1/ 2 G2 ZNC 7 0G0190 1 PLATE, AI R CLE A NE R TOP 2. 4L 8 037561 1 NU T WING 1/4-20 NYL K 9 0220 97 1 W ASHE R LO CK M6 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 46
...
-
Generac Power Systems Guardian Elite 005259-0 - page 47
1 0269 1 5 2 NIPPLE CLO SE 3/ 4 X 1. 37 5 2 075580 1 FLANGE FUEL I NLET 3 0F6390B 1 R EGULA TOR ASSY 2.4 L 4 0392 5 3 2 SCREW HHC M 8- 1. 2 5 X 20 G8. 8 5 0221 45 2 WASHE R FLAT 5/ 16-M 8 Z IN C 6 0 22 12 9 2 W A SH ER L OC K M8 -5 /1 6 7 0457 71 2 NUT HEX M 8-1.2 5 G 8 CLEA R Z INC 8 0G0180 1 (REF) GASKET- THROTTLE B ODY 9 0E8286 1 STREET EL 45D 1 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 48
...
-
Generac Power Systems Guardian Elite 005259-0 - page 49
1 0G0045 (XX) 1 REAR WRAP C2 CPL 2 0C2454 54 S CRE W T HF M6-1 X 16 N WA Z/JS 3 0F 58 49 ( XX) 2 DO O R C 2 4 087233 2 RIVET POP .1875 X .450 SS 5 0E3257 4 S CRE W T H-FRM M6 W /CAP S HKP RF W 6 0F5852 (XX) 2 DISC HA RGE DU CT LH & RH SIDE C2 7 0F 9833 (XX) 2 FRO NT CORNER S C2 8 0F5851 (XX) 1 DISC HA RGE CENT E R DU CT C2 9 049813 2 NUT HEX M6 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 50
...
-
Generac Power Systems Guardian Elite 005259-0 - page 51
1 0F97 94 1 MUFFLER 7" X 9" X 18-1/ 2" 2" IN/OUT 2 0G 0 1 13 1 E X H AU S T ELB OW 2 1/ 4 O D 2 1/ 2 O D 3 0F99 37 1 BRACKE T MUF FLER 4 0F28 30 1 MUFFLER BRACKE T STIF FENE R 5 0F29 62 1 MUFFLER STRAP 6 080762 2 BOLT U 3/8 -16 X 2.62 7 0E0170A 1 EXHAUST BLANKET 988 MM (C2) 8 0C2454 4 SCREW THF M6 -1 X 1 6 N WA Z/JS 9 0F9736 1 P ...
-
Generac Power Systems Guardian Elite 005259-0 - page 52
...
-
Generac Power Systems Guardian Elite 005259-0 - page 53
...
-
Generac Power Systems Guardian Elite 005259-0 - page 54
...
-
Generac Power Systems Guardian Elite 005259-0 - page 55
...
-
Generac Power Systems Guardian Elite 005259-0 - page 56
...
-
Generac Power Systems Guardian Elite 005259-0 - page 57
...
-
Generac Power Systems Guardian Elite 005259-0 - page 58
...
-
Generac Power Systems Guardian Elite 005259-0 - page 59
...
-
Generac Power Systems Guardian Elite 005259-0 - page 60
...
-
Generac Power Systems Guardian Elite 005259-0 - page 61
...
-
Generac Power Systems Guardian Elite 005259-0 - page 62
...
-
Generac Power Systems Guardian Elite 005259-0 - page 63
1.) C2 UN ITS A 0F98 32 1 S HIELD CO NN B OX C 2 0F98 32G GS0 R 1 SHIE LD CO NTRO L S TA ND C 2 B 0C24 5 4 3 S CR EW THF M6- 1 X 16 N WA Z/ JS 2.) C3 UN ITS A 0F 98 32B 1 SHIE LD CONT RO L S TA ND C 3 0F98 32K GS 0R 1 SHIE LD CO NTRO L S TA ND C 3 B 0C245 4 3 SCR EW THF M6- 1 X 16 N WA Z/ JS 3.) C4 UN ITS A 0F 98 32A 1 SHIE LD CONT RO L S TA ND C 4 ...
-
Generac Power Systems Guardian Elite 005259-0 - page 64
Standby Generator Sets W arranty Printed in U.S.A. GENERA C PO WER SYSTEMS ST ANDARD LIMITED W ARRANTY FOR HOME ST ANDBY/LIGHT COMMERCIAL PRODUCT 45kW AND BELO W For a period of two (2) y ears from the date of sale, or start-up by A uthorized/Cer tified Generac P ow er Systems Dealer , or branch thereof , Generac P ow er Systems, Inc. will, at its ...
Haben Sie eine Frage bezüglich Generac Power Systems Guardian Elite 005259-0?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Generac Power Systems Guardian Elite 005259-0 nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Generac Power Systems Guardian Elite 005259-0 hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.