-
Stow PSH - page 1
POR TO-SCREED MODEL PSH © COPYRIGHT 2004, MUL TIQUIP INC . OPERA TION AND P AR TS MANUAL Re vision #1 (01/20/04)US MODEL # SERIAL # P/N 36442 STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT A DIVISION OF MUL TIQUIP INC . POST OFFICE BO X 6254 CARSON, CA 907 ...
-
Stow PSH - page 2
...
-
Stow PSH - page 3
HERE'S HOW TO GET HELP PLEASE HA VE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING P AR TS DEP AR TMENT 800-427-1244 or 310-537-3700 F AX: 800-672-7877 or 310-637-3284 SER VICE DEP AR TMENT 800-421-1244 F AX: 310- 537-4259 TECHNICAL ASSIST ANCE 800-478-1244 F AX: 310- 631-5032 W ARRANTY DEP AR TMENT 888-661-4279, or 310-661-4279 F AX: 310- 5 ...
-
Stow PSH - page 4
P A GE 4 — ST O W PORT O-SCREED — OPERA TION & P AR TS MANU AL — REV . #1 (01/20/04) POR T O-SCREED PSH— T ABLE OF CONTENTS Help and T echnical Assistance .................................. 3 T able of Contents/Introduction .................................. 4 P ar ts Order ing Procedures U .K. & Europe ................ 5 P ar ts Or ...
-
Stow PSH - page 5
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 5 PORT O-SCREED PSH— SPECIFICA TIONS (PSH) NOTE: 1 . Sound pressure is a weighted measure. It is measured at the operator's ear position while the walk-behind PSH is operating at full throttle on concrete in a manner most often experienced in “ normal ” ci ...
-
Stow PSH - page 6
P A GE 6 — ST O W PORT O-SCREED — OPERA TION & P AR TS MANU AL — REV . #1 (01/20/04) PORT O-SCREED PSH— SPECIFICA TIONS (ENGINE) s n o i t a c i f i c e p S e n i g n E . 2 e l b a T e n i g n E l e d o M 2 X Q 1 K 0 2 1 X G A D N O H e p y T r e d n i l y C e l g n i S , e v l a v d a e h r e v O , e k o r t s - 4 e k o r t S X e r o B ...
-
Stow PSH - page 7
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 7 POR T O-SCREED PSH— SAFETY MESSA GE ALERT SYMBOLS Safety precautions should be followed at all times when operating this equipment. F ailure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others. FOR Y ...
-
Stow PSH - page 8
P A GE 8 — ST O W PORT O-SCREED — OPERA TION & P AR TS MANU AL — REV . #1 (01/20/04) Respiratory Hazard AL W A YS wear appro ved respiratory protection. AL W A YS wear appro ved e ye and hearing protection. Sight and Hearing hazard Equipment Damage Messages Other important messages are provided throughout this manual to help pre vent dama ...
-
Stow PSH - page 9
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 9 F ailure to follo w instructions in this manual ma y lead to ser ious injur y or e v en death! This equipment is to be operated by tr ained and qualified personnel only! This equipment is f or industrial use only . ■ AL W A YS use extreme caution when w o rking w ...
-
Stow PSH - page 10
P A GE 10 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) ■ NEVER Run engine without air filter . Sev ere engine damage ma y occur . Ser vice air filter frequently to pre vent carb uretor malfunction. ■ A V OID wearing jewelry or loose fitting clothing that ma y snag on the controls or moving parts as this c ...
-
Stow PSH - page 11
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 11 POR T O-SCREED PSH— OPERA TION AND SAFETY DECALS OPERA TION AND SAFETY DECALS The PORT O-SCREED walk-behind PSH is equipped with a number of oper ation and saf ety decals. These decals are provided f or operator safety and maintenance information. Should an y o ...
-
Stow PSH - page 12
P A GE 12 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) The ST O W MODEL PSH PORT O-SCREED is designed f or vibration screeding concrete . Vibration screeding with the ST O W P or to-screed is the ideal wa y to str ike-off and vibrate concrete sidewalks, floors, patios, and even bridge decks. The PSH P or to-S ...
-
Stow PSH - page 13
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 13 Figure 5. Controls and Components Figures 5 shows the location of the basic controls or components, f or the POR T O-SCREED PSH . Listed below is a brief explanation of each control or component 1. Throttle Control Lever – Controls the speed of the engine. Move ...
-
Stow PSH - page 14
P A GE 14 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) Figure 6. Engine Controls and Components INITIAL SER VICING The engine (Figure 6) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturer's engine manual f or instr uctions & details of operation ...
-
Stow PSH - page 15
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 15 Fuel Check Motor fuels are highly flammable and can be dangerous if mishandled. DO NOT smoke while refueling. DO NOT attempt to refuel the PSH if the engine is hot! or running . D ANGER 1 . Remove the gasoline cap located on top of fuel tank. 2 . Visually inspect ...
-
Stow PSH - page 16
P A GE 16 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) 3 . Place the choke lever (Figure 11) in the " CLOSED " position if starting a cold engine. POR T O-SCREED PSH — INITIAL ST ART -UP This section is intended to assist the operator with the initial start-up of the PSH. It is extremely important ...
-
Stow PSH - page 17
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 17 Figure 15. Throttle Le ver (Run P osition) POR T O-SCREED PSH — INITIAL ST ART -UP Figure 14. Starter Grip 2 . After the engine cools , turn the engine start/stop switch to the “ OFF ” position (Figure 16). Figure 16. Engine ON/OFF Switch (OFF Position) 3 . ...
-
Stow PSH - page 18
P A GE 18 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) OPERA TION POR T O-SCREED PSH — OPERA TION DO NO T alter .this setting since damage to the eccentric bearings can result and both the engine and machine warranty will be automatically V OIDED . 4. Start the engine as previously described. Refer to the E ...
-
Stow PSH - page 19
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 19 See the engine manual supplied with your machine for appropriate engine maintenance schedule and troubleshooting guide for problems. MAINTENANCE SCHEDULE Daily (8-10 Hours) 1. Check the oil le v el in the engine crankcase; fill as necessar y . 2 . Check V -belt. W ...
-
Stow PSH - page 20
P A GE 20 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) PORT O-SCREED PSH — TROUBLESHOO TING (ENGINE) ) E N I G N E ( G N I T O O H S E L B U O R T . 4 E L B A T M O T P M Y SE S U A C E L B I S S O PN O I T U L O S o n t u b , e l b a l i a v a s i l e u f " , t r a t s o t t l u c i f f i D . " g ...
-
Stow PSH - page 21
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 21 SUGGESTED SP ARE P AR TS POR T O-SCREED PSH 1 T O 3 UNITS WITH HOND A GX120K1QX2 ENGINE 1 to 3 Units Qt y . ..... P/N ........................ Description 1 ........... 30033-401 ............ CABLE, THRO TTLE ASM 4 ........... 22094-006 ............ O-RING (F ASTE ...
-
Stow PSH - page 22
P A GE 22 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) POR T O-SCREED PSH — NAMEPLA TE AND DECALS NAMEPLA TE AND DECALS D DECAL SHEET INTL STDS ISO P/N 1 1246 C B A P/N 36099 (ISO Blue) P/N 25263-001 P/N 20109-001 P/N 131 18 CONT ACT SERVICE DEP ARTMENT P O W D E R C O T E D A 4 LUBRICATION C D B A “HOT? ...
-
Stow PSH - page 23
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 23 POR T O-SCREED PSH — NAMEPLA TE AND DECALS NAMEPLA TE AND DECALS NO . P AR T NO . P AR T NAME QTY . REMARKS 1 21302 DECAL: GU ARD W ARNING .................................. 1 ....... SAFETY ITEM 2 20525 SMALL DECAL: W ARNING, CA PROP 65 ........................ ...
-
Stow PSH - page 24
P A GE 24 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) POR T O-SCREED PSH — ASSEMBL Y ASSEMBL Y 2 3 31 36 37 1 4 5 5 5 25 26 6 6 32 8 8 9 27 28 7 7 10 13 11 16 17 18 19 29 24 20 33 19 19 20 34 30 22 21 14 15 35 15 23 12 ...
-
Stow PSH - page 25
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 25 ASSEMBL Y NO . P AR T NO . P AR T NAME QTY . REMARKS 1 21387 ENGINE, 4 HP . HOND A GX120K1QX2 1 2 12704-304 CLUTCH 1 3 18241-301 B E L T G UAR D ...................................................... 1 ......... SAFETY ITEM 4 0655 SCREW , HHC 5/16 - 18 X 3/4" ...
-
Stow PSH - page 26
P A GE 26 — ST O W PORT O-SCREED — OPERA TION & P ARTS MANU AL — REV . #1 (01/20/04) Effective: July 15, 2003 TERMS AND CONDITIONS OF SALE — P AR TS T erms and Conditions of Sale STOW Construction Equipment ST OW CONSTR UCTION EQUIPMENT POST OFFICE BO X 6254 CARSON, CALIFORNIA 90749 310-661-4242 • 877-BUY -STO W F AX: 310-604-9237 E-M ...
-
Stow PSH - page 27
STOW PORTO-SCREED — OPERATION & PARTS MANUAL — REV. #1 (01/20/04) — PAGE 27 NO TE P A GE ...
-
Stow PSH - page 28
OPERA TION AND P AR TS MANUAL STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT A DIVISION OF MUL TIQUIP INC . POST OFFICE BO X 6254 CARSON, CA 90749 310-537-3700 • 888-252-STOW [888-252-7869] F AX: 310-537-1986 • F AX: 800-556-1986 E-MAIL: stow@multiquip. ...
Haben Sie eine Frage bezüglich Stow PSH?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Stow PSH nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Stow PSH hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.