Deutsch dropdown-ico

Bedienungsanleitung Baldor DG3E

30 Seiten 0.48 mb
Download

Zur Seite of 30

Summary
  • Baldor DG3E - page 1

    Diesel POW’R Products Generator DG3E and DG6E Installation & Operating Manual 5/05 MN2414 ...

  • Baldor DG3E - page 2

    W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Engine exhaust from this product contains chemicals known to the state of California to cause cancer , birth defects and other reproductive harm. W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Battery posts, terminals and related accessories are known to the state of California to cause cancer , birth de ...

  • Baldor DG3E - page 3

    T able of Contents T able of Contents i MN2414 Section 1 Product Safety Information 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Safety Notice 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Baldor DG3E - page 4

    ii T able of Contents MN2414 ...

  • Baldor DG3E - page 5

    Section 1 Product Safety Information Product Safety Information 1-1 MN2414 Safety Notice Be sure that you are completely familiar with the safe operation of this equipment. This equipment may be connected to other machines that have rotating parts or parts that are controlled by this equipment. Improper use can cause serious or fatal injury . Alway ...

  • Baldor DG3E - page 6

    1-2 Product Safety Information MN2414 Precaution Statements Used In This Manual There are three classifications of precautionary statements used in this manual. The most critical is a W ARNING statement, then the Caution statement and the least critical is the Note statement. The usage of each statement is as follows: W ARNING: Indicates a potentia ...

  • Baldor DG3E - page 7

    Product Safety Information 1-3 MN2414 Operation W arning Statements Continued W ARNING: Be sure that you understand how to stop the engine quickly in case of an emergency situation. Become familiar with the controls and safety systems provided with this generator set. W ARNING: Always wear safety glasses with side shields and hearing protection whe ...

  • Baldor DG3E - page 8

    1-4 Product Safety Information MN2414 W arning Statements Continued Burn W ARNING: Parts of this generator are extremely hot during and after operation. T o prevent severe burns, do not touch any part of the generator until you have first determined if the part is hot. Wear protective clothing and after use allow sufficient time for parts to cool b ...

  • Baldor DG3E - page 9

    Product Safety Information 1-5 MN2414 W arning Statements Continued Maintenance W ARNING: Before servicing the generator set, be sure to disconnect the battery terminals to prevent accidental engine rotation or starting. W ARNING: Before cleaning, inspecting, repairing, refueling or performing any maintenance to the generator set, always be sure th ...

  • Baldor DG3E - page 10

    1-6 Product Safety Information MN2414 Caution Statements Caution: The brass connecting tab on some 120V AC duplex receptacles have been removed. Each receptacle is powered by a separate generator winding. When replacing a receptacle, inspect the brass tab that normally links both receptacles. If it is removed, be sure to remove the brass tab from t ...

  • Baldor DG3E - page 11

    Section 2 General Information General Information 2-1 MN2414 Thank you for purchasing your Baldor Generator Set. This manual contains information you need to safely and efficiently install and operate your generator set. During the preparation of this manual every effort was made to ensure the accuracy of its contents. This manual describes only ve ...

  • Baldor DG3E - page 12

    2-2 General Information MN2414 ...

  • Baldor DG3E - page 13

    Section 3 Receiving & Installation Receiving & Installation 3-1 MN2414 Receiving & Inspection When you receive your generator , there are several things you should do immediately . 1. Observe the condition of the shipping container and report any damage immediately to the commercial carrier that delivered your system. 2. V erify that th ...

  • Baldor DG3E - page 14

    3-2 Receiving & Installation MN2414 Physical Location The mounting location of the system is important. It should be installed in an area that is protected from direct harmful gases or liquids, dust, metallic particles, shock and vibration. It can only be installed in an outdoor location so the exhaust fumes are vented to the atmosphere. This s ...

  • Baldor DG3E - page 15

    Receiving & Installation 3-3 MN2414 Electrical Connections Continued T able 3-1 Single Phase Power Receptacle Description Model Electrical Connection Information (Receptacle Provided at Panel) Straight 120V AC (20Amp) T wist Lock 120V AC (30Amp) T wist Lock 120/240V AC (30Amp) T wist Lock 120/240V AC (50Amp) Rated Watts/ (Full load Amps 120/240 ...

  • Baldor DG3E - page 16

    3-4 Receiving & Installation MN2414 Frame Ground Connection Continued Figure 3-3 Frame Ground Connection Earth Ground Frame Stud W asher Ground Wire Lug Nut W asher Engine Oil Refer to the engine manual that was provided with your generator . Determine the correct type of engine oil and the amount specified by the engine manufacturer . Add the ...

  • Baldor DG3E - page 17

    Receiving & Installation 3-5 MN2414 Battery Connections Continued Note: OHV units that have an electronic governor must have a battery installed before the Genset can be started (even with the pull starter). If no battery is present or the battery is discharged, the electronic governor will not operate and the generator set will not run. Proced ...

  • Baldor DG3E - page 18

    3-6 Receiving & Installation MN2414 Optional Wheel Kit PDG2 − 2 Wheel Dolly Kit; and PDG4 − 4 Wheel Dolly Kit An optional 2 or 4 wheel dolly kit is available for these portable generators. If you have purchased one of these kits, refer to MN2409 for the installation instructions. Recommended Engine Oil and Battery T ype Series DG MODEL SUMM ...

  • Baldor DG3E - page 19

    Section 4 Operation Operation 4-1 MN2414 Operator Control Panel Each operator panel is slightly different, depending on features of the generator you purchased. The Operator Control Panel of Figure 4-1 is shown because it has most of the available features. This will be used to explain how the controls operate. Figure 4-1 Operator Control Panel Sta ...

  • Baldor DG3E - page 20

    4-2 Operation MN2414 Pre − Start Checks Before the engine is started, several things must first be checked. 1. Place the generator set in an open, dry , well ventilated and reasonably level location. 2. If grounding is required for your application, check to make sure your unit is grounded properly (see Section3). 3. Check the engine’s oil leve ...

  • Baldor DG3E - page 21

    Section 5 T roubleshooting and Maintenance T roubleshooting and Maintenance 5-1 MN2414 Maintenance This manual contains only very minimal engine maintenance instructions. Refer to the engine manufacturer ’s owner ’s manual for specific engine maintenance instructions for your generator set. Any maintenance instructions or recommendations in the ...

  • Baldor DG3E - page 22

    5-2 T roubleshooting and Maintenance MN2414 Problems and Solutions Some of the more common problems are listed in T able 5-1. This information is intended to be a check or verification that simple causes can be located and fixed. It is not an exhaustive “how to” for all types of problems. Procedures that require in depth knowledge or skills (li ...

  • Baldor DG3E - page 23

    Appendix A DG Series Premier K Series A-1 MN2414 Information in this Appendix applies to the following Baldor Generators: DG3E and DG6E. Caution: The brass connecting tab on some 120V AC duplex receptacles have been removed. Each receptacle is powered by a separate generator winding. When replacing a receptacle, inspect the brass tab that normally ...

  • Baldor DG3E - page 24

    A-2 Premier K Series MN2414 Replacement Parts Replacement parts assembly views for the Generator set are shown in Figure A-3 and A-4. Parts information is provided in T able A-1. Parts information for the engine is provided in the engine manual that was provided with your generator set. Please refer to the engine manual for replacement parts inform ...

  • Baldor DG3E - page 25

    Premier K Series A-3 MN2414 T able A-1 Generator Set Parts List Continued Ref No. Part No. Description DG3E DG6E Not Shown EH0316A00 Control Box (Operator Panel) X Not Shown EH0332A00 Control Panel Cover (Operator Panel) X Not Shown EH0434A00L2B Control Box (Operator Panel) X Not Shown EH0435A00L2B Control Panel Cover (Operator Panel) X 13 WD3201A0 ...

  • Baldor DG3E - page 26

    A-4 Premier K Series MN2414 Figure A-5 DG3E Wiring Diagram ...

  • Baldor DG3E - page 27

    Premier K Series A-5 MN2414 Figure A-6 DG3E Wiring Diagram with Low Oil & Remote Start ...

  • Baldor DG3E - page 28

    A-6 Premier K Series MN2414 Figure A-7 DG6E Wiring Diagram ...

  • Baldor DG3E - page 29

    Baldor District Offices UNITED ST ATES ARIZONA PHOENIX 421 1 S 43RD PLACE PHOENIX, AZ 85040 PHONE: 602−470−0407 F AX: 602−470−0464 CALIFORNIA LOS ANGELES 6480 FLOTILLA COMMERCE, CA 90040 PHONE: 323−724−6771 F AX: 323−721−5859 HA YWARD 21056 FORBES STREET HA YWARD, CA 94545 PHONE: 510−785−9900 F AX: 510−785−9910 COLORADO DENV ...

  • Baldor DG3E - page 30

    © Baldor Electric Company MN2414 P r i n t e di nU S A 5/05 W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Engine exhaust from this product contains chemicals known to the state of California to cause cancer , birth defects and other reproductive harm. W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Battery posts, terminals and related accessories ar ...

Produzent Baldor Kategorie Portable Generator

Dokumente, die wir vom Produzenten des Geräts Baldor DG3E erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Baldor
- Bedienungsanleitungen DG3E
- Produktkarten Baldor
- Informationsbroschüren
- oder Energieetiketten Baldor DG3E
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Baldor DG3E.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Baldor DG3E, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Baldor DG3E. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Baldor DG3E ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Baldor DG3E, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Baldor DG3E hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Baldor DG3E verständlich ist.

Eine gänzliche Bedienungsanleitung von Baldor sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Baldor DG3E bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Baldor DG3E befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Baldor DG3E, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Baldor DG3E - die uns die ersten Schritte während der Nutzung von Baldor DG3E erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Baldor DG3E hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Baldor DG3E im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Baldor DG3E?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Baldor DG3E nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Baldor DG3E hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Captcha
Neues Bild

Kommentare (0)