-
United States Stove 1200Q - page 1
1 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• Model 1200Q SOLID FUEL W ARM AIR FURNA CE Owners Manual C O M P A N Y U N I T E D S T A T E S S T O V E C S S U WARNOCK HERSEY R *FOR P ARALLEL INST ALLA TION WITH AN EXISTING FORCED AIR, GAS OR OIL FIRED FURNA CE (U .S. ONL Y) *FOR INST ALLA TION AS A CENTRAL FURNA CE DO NO T USE THIS FURNA CE IN A M ...
-
United States Stove 1200Q - page 2
2 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• T OOLS AND MA TERIALS NEEDED TOOLS Pencil 6 Foot Folding Rule or Tape Tin Snips Drill, Hand or Electric Drill Bit (For Sheet Metal Screws) 1/8" Dia. Screw Driver (Blade-Type) Gloves Sabre Saw 5/16" Nut Driver or 5/16" Socket with Rachet MATERIALS 6" Pipe, 6" Elbow, Collar and ...
-
United States Stove 1200Q - page 3
3 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• CA UTION: Your Furnace has the following labels. Read and obey all labels. REFER TO MARKINGS ON THE APPLIANCE FOR ADDITIONAL INFORMATION. CAUTION! INSPECT FLUE PIPES, FLUE PIPE JOINTS AND FLUE PIPE SEALS REGULARL Y T O ENSURE THA T SMOKE AND FLUE GASES ARE NO T DRA WN INT O , AND CIRCULA TED BY , THE ...
-
United States Stove 1200Q - page 4
4 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• Read these rules and the instructions carefully. Failure to follow them will cause a hazard that could result in death, serious bodily injury, and/or property damage. Check your local codes. This installation must comply with their rulings. Do not install this furnace in a mobile home or trailer. Alwa ...
-
United States Stove 1200Q - page 5
5 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• Your Supplemental Furnace is designed to be a supplemental or central heating source for your home. This solid fuel furnace may be installed in conjunction with a properly operating central fur- nace that is listed or certified in accordance with nationally recognized safety standards and equipped wit ...
-
United States Stove 1200Q - page 6
6 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• MODEL 1200Q DIMENSIONS FIG. 1 ...
-
United States Stove 1200Q - page 7
7 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• 1. 2. 3. 4. FIG. 3 The furnace should be located in the same room as the central system and as close as possible, but no closer than 9". There should be no wall between the furnace and the warm air outlet duct that is connected directly to the warm air outlet plenum of the central furnace. See Fi ...
-
United States Stove 1200Q - page 8
8 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• LISTED FACTORY BUILT CHIMNEY Carefully follow chimney manufacturer's instructions. Use only a Listed Residential Type or Building Heating Appliance Chimney. If your chimney starts at the ceiling (Fig. 5), you will need enough 6" pipe to reach the ceiling. The top of the chimney must be at le ...
-
United States Stove 1200Q - page 9
9 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• RULES FOR CONNECT OR PIPE INST ALLA TION FIG. 6 The crimped end of the chimney connector fits inside the furnace flue collar. Install additional chimney connector and elbow with the CRIMPED END TOWARD THE FURNACE. This will allow any con- densation in the flue to run back into the furnace. Use 6" ...
-
United States Stove 1200Q - page 10
10 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• ASSEMBL Y OF FURNA CE Your furnace requires the following items to be assembled or installed by the service person: Feed Door Handle Feed Door Latch Ash Door Handle Ash Door Latch Blower and Blower Control Electrical Connections Remove all parts from inside the furnace and inspect for damage, includi ...
-
United States Stove 1200Q - page 11
11 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• BLO WER & COMPONENT ASSEMBL Y - FIG. 11 JUNCTION BOX MOUNTING BRACKET 1. Attach the Honeywell Limit Control to the bracket as shown below, using (2) of the #12 x 3/4" Tek Screws provided in the parts bag. 2. Attach the 2x4 Junction Box to the bracket. Use (2) of the #12 x 3/4" Tek Screw ...
-
United States Stove 1200Q - page 12
12 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• MODEL 1200Q WIRING DIAGRAM - FIG. 12 LIMIT CONTROL BLACK WHITE WHITE BLACK WHITE BLACK GREEN 2 x 4 JUNCTION BOX BLOWER TO HOUSE SUPPL Y NOTE: GROUND HOUSE SUPPLY TO INSIDE OF JUNCTION BOX. ...
-
United States Stove 1200Q - page 13
13 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• Installation Please see all methods of Installation in Appendix at the rear of this booklet. This is a furnace, not a free standing stove. You must direct heated air from 12" outlet away from the furnace, or it will not function properly. 1. This installation must be done by a qualified heating ...
-
United States Stove 1200Q - page 14
14 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• POWER FAILURE INSTRUCTIONS: Operation after loss of power Remove filter if provided. Do not expect to keep home at normal temperatures. Do not load fuel abov e bottom of feed door . Set Fuel door and Ash door spin draft maxim um closed per the factory installed stops. 1 2 3 4 (U.S. ONLY) FIG. 13 ...
-
United States Stove 1200Q - page 15
15 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• CENTRAL INST ALLA TION (U.S. & CANAD A) ADD-ON INST ALLA TION (U .S. ONL Y) ...
-
United States Stove 1200Q - page 16
16 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• AL TERNA TIVE P ARALLEL INST ALLA TION WIRING DIA GRAM - FIG. 15 TO GAS/OIL/ELECTRIC TRANSFORMER HOTBLAST COMBINATION CONTROL LIMIT FAN JUMPER IN H H POWER SUPPLY GAS/OIL/ELECTRIC POWER SUPPLY JUNCTION BOX CENTRAL FURNACE BLOWER MOTOR WOOD FURNACE BLOWER MOTOR CAUTION! DO NOT CONNECT PLENUM FAN CONTR ...
-
United States Stove 1200Q - page 17
17 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• Your Hotblast Furnace is for burning wood only. WOOD BURNING: (1)use Hardwood, 18" to 26", split and air dried (seasoned) for six months. (2) set thermostat to "HIGH" before opening feed door. (3) add wood to a convenient level. CAUTION NEVER USE GASOLINE, GASOLINE-TYPE LANTERN FU ...
-
United States Stove 1200Q - page 18
18 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• Do not expect a furnace to draw. It is the chimney that creates the draft. Smoke spillage into the house or exces- sive build-up of water or creosote in the chimney is not functioning properly. Correct the problem before using furnace. Possible causes are: The connector pipe may be pushed into the ch ...
-
United States Stove 1200Q - page 19
19 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• MODEL 1200Q - P AR TS ...
-
United States Stove 1200Q - page 20
20 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• MODEL 1200Q - PARTS LIST KEY PART# DESCRIPTION QTY. 1 69121 FIREBOX WELDMENT 1 2 24576 BAFFLE 1 3 40288 GRATE 4 4 89066 FIRE BRICK 1 8 5 23800 SMOKE CURTAIN 1 6 23787 SMOKE DOOR CLIP 2 7 83445 1/4-20 X 1-1/4 BOLT 2 N/S 8325 0 1/4-20 KEP NUT 2 8 24594 FEED DOOR 1 9 23859 DRAFT CAP 3 1 0 C2 0599 1/2-13 ...
-
United States Stove 1200Q - page 21
21 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• APPENDIX INST ALLA TION A NOTE: ANTI-BACKDRAFT FLAPPERS OR BAFFLE ARE REQUIRED FOR THIS INSTALLATION. ...
-
United States Stove 1200Q - page 22
22 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• APPENDIX INST ALLA TION B NOTE: ANTI-BACKDRAFT FLAPPERS OR BAFFLE ARE REQUIRED FOR THIS INSTALLATION. ...
-
United States Stove 1200Q - page 23
23 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• APPENDIX INST ALLA TION C NOTE: ANTI-BACKDRAFT FLAPPERS OR BAFFLE ARE REQUIRED FOR THIS INSTALLATION. ...
-
United States Stove 1200Q - page 24
24 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• APPENDIX INSTALLATION D (U.S. ONLY) INSTALLATION E (U. S. ONLY) ...
-
United States Stove 1200Q - page 25
25 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• APPENDIX INSTALLATION F INSTALLATION G ...
-
United States Stove 1200Q - page 26
26 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• NOTES ...
-
United States Stove 1200Q - page 27
27 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• List of Problems Possible Cause Solutions 1. Smoking when feed door is open. 2. Furnace does not heat. 3. Blower does not run. 4. No air from registers - fan running. 5. Air from registers is not hot. 6. Blower runs too long. 7. Blower does not run long enough. 8. Smoke and/or odor from registers whe ...
-
United States Stove 1200Q - page 28
28 •DRAWINGS FOR ILLUSTRATION PURPOSES ONLY• THIS MANU AL WILL HELP Y OU OBT AIN EFFICIENT , DEPEND- ABLE SER VICE FROM Y OUR HO TBLAST FURNA CE, AND EN- ABLE Y OU T O ORDER REP AIR P AR TS CORRECTL Y . KEEP THIS MANU AL IN A SAFE PLA CE FOR FUTURE REFER- ENCE. WHEN WRITING, AL W A YS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLA TE A TT A ...
¿Tienes una pregunta acerca de United States Stove 1200Q?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con United States Stove 1200Q, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con United States Stove 1200Q probablemente compartirá una forma de solucionarlo.