-
Heartland Wood Stove - page 1
The Artisan Inst allation and Operating Instructions 01/07 EINS 515000 SAFETY NOTICE: If this stove is not properly installed, a house fire may result, for your safety , follow the installation directions, cont act local building or fire officials about restrictions and installation inspection requirement s in your area. IMPORT ANT : Check around o ...
-
Heartland Wood Stove - page 2
2 FOR YOUR SAFETY DO NOT ST ORE OR USE GASOLINE OR OTHER FLAMMABLE V APOURS OR LIQUIDS IN THE VICINITY OF THIS ST OVE. S tove Location - If the stove must be located near a window , avoid using long curt ains which could blow over the stove top, causing a fire hazard. Any openings in the wall behind the stove or in the floor under the stove must be ...
-
Heartland Wood Stove - page 3
Artisan CONSUMER W ARRANTY ENTIRE PRODUCT –LIMITED ONE YEAR W ARRANTY HEARTLAND warrant s the replacement or repair of all p arts of the Artisan which prove to be defective in material or workmanship. Painted porcelain enamel finish or plated surfaces have a 90 day warranty from the date of original purchase. Such part s will be replaced or repai ...
-
Heartland Wood Stove - page 4
4 T ABLE OF CONTENTS 1) Welcome ..................................................................................................................... ...... Pg 5 2) Installation ............................................................................................................... .......... Pg 6 3) Inst allation Requirements .............. ...
-
Heartland Wood Stove - page 5
Getting Acquainted The Artisan stove is a time proven heating and cooking appliance. T ake your time to acquaint yourself with the principles on which your new stove operates as a heater and a cooking stove. Familiarizing yourself with the primary principles of the air intake controls, the oven damper , the flame path for the fire and the relations ...
-
Heartland Wood Stove - page 6
Place the stove in the intended position and lift out the hotplate, checking that the joint between the underside of the hob and the top of the stove is intact. Any joints which have opened should be made good with the fire cement provided. Replace the hotplate making sure that it is seated evenly on the soft rope and that it is approximately 0.1? ...
-
Heartland Wood Stove - page 7
ARTISAN REQUIREMENTS How-to Step s Note: Information herein is for recommendation purposes only . All clearances are subject to local, Provincial or S tate building and fire codes. Clearances may change without notice. Always consult with local building inspector . Improperly installed and/or maintained stove may result in a house fire. Clearances ...
-
Heartland Wood Stove - page 8
Clearances to Combustibles Single W all Chimney Connector All measurement s must be done before st arting the inst allation. Dimensions All drawings are for reference only , showing approximate dimensions for rough-in purposes. In some installations, two or more clearances to combustible walls may contradict each other . The clearances with the gre ...
-
Heartland Wood Stove - page 9
Clearances to Combustibles Listed Double W all Chimney Connector All measurement s must be done before st arting the inst allation. Dimensions All drawings are for reference only , showing approximate dimensions for rough-in purposes. In some installations, two or more clearances to combustible walls may contradict each other . The clearance with t ...
-
Heartland Wood Stove - page 10
The chimney connector is a single-wall pipe or a listed and approved double-wall pipe that connects the stove to the chimney . Approved clearances change according to what type of chimney connector you use. Consult the clearances section of this manual for the proper clearances. The stove’ s flue collar accepts only 6” chimney connector . Follo ...
-
Heartland Wood Stove - page 11
Chimney and draf t The chimney is the most important element of a successful stove operation. The chimney ‘drives’ the system by producing the draft that draws in combustion air and exhausts smoke and gases to out doors. When installing a new stove or upgrading an existing one, give as much attention to the chimney as you do to the appliance th ...
-
Heartland Wood Stove - page 12
General W ARNING: HOT SURF ACES, use the tool supplied to operate this appliance. When raising the dome lids, it is recommended that the heatproof glove supplied with the stove, is used. Air for combustion within the firebox is obt ained by the primary air int ake on the ashpit door . The rate of burning is determined by the manually operated spinw ...
-
Heartland Wood Stove - page 13
Door Operation OVEN DOOR OPERA TION - T o open the doors. T wist the handle slightly to lift up the door catch from the locking spindle and pull the door open. (See Fig. 8) T o close the doors. Gently push the door shut until the door catch makes contact with the locking spindle. FIREDOOR OPERA TION CAUTION: THESE DOORS ARE EXTREMEL Y HOT DURING OP ...
-
Heartland Wood Stove - page 14
Refuelling The firebox should be filled to the recommended level at the middle of the firebox door opening. When correctly fuelled, the stove will maintain the maximum rated output for a minimum of 2 hours, including intermittent cooking. Once re-fuelling has been completed, close the firebox door immediately and open only for re-fuelling charges. ...
-
Heartland Wood Stove - page 15
Break-In Fire SMOKE/SMELL EMITTED DURING INITIAL USAGE. Some part s of the stove have been coated with a light covering of protective oil. During initial operation of the stove, this may cause smoke/smell to be emitted and is normal and not a fault with the appliance, it is therefore advisable to open doors and or windows to allow for ventilation. ...
-
Heartland Wood Stove - page 16
Flueway Cleaning W ARNING: HOT SURF ACES, use the tool supplied to operate this appliance. It is recommended to use the heatproof glove supplied when raising the dome lids to use the hotplate. Following a prolonged shutdown of the appliance, perhaps af ter the summer break, ensure the flueway is free from obstruction prior to re-lighting. Prolonged ...
-
Heartland Wood Stove - page 17
Sp ares List Part Number Description No Rep’d 1/16182 T Bottomgrate bars top 6 1/16182 B Bottomgrate bars bottom 5 RS4F301 170 RH rear firebrick 1 RS4F301 171 Rear firebrick 2 RS4F301 172 LH rear firebrick 1 RS4F301 173 LH front firebrick 1 RS4F301 175 Front firebrick 1 RS4F301 176 Rear angle firebrick 1 RS4F301200 RH front firebrick 1 JP AD30122 ...
-
Heartland Wood Stove - page 18
Overfiring - Caution! Overfiring of your woodburning appliance represent s a serious fire hazard T o prevent overfiring: 1. If the air intake has little ef fect on dampering the fire, excessive chimney draft is the probable cause (especially on chimneys in excess of 20’). Normal chimney draft is approximately 0.05” W .C.. NOTE: Open damper befo ...
-
Heartland Wood Stove - page 19
Chimneys and Draf t The performance of your woodburning system depends more on the chimney than on any other single component. The chimney ‘drives’ the system by producing the draft that draws in combustion air and exhausts smoke and gases to outdoors. Give as much attention to the chimney as you do to the appliance that it serves. How Chimneys ...
-
Heartland Wood Stove - page 20
Masonry chimneys should be checked for deterioration including damaged bricks, crumbling and missing mortar , cracks in the drip cap at the top of the chimney , and loose flashings at the roof line. The liner should be checked for cracks and mis-alignment. It must be at least 6” in size. An existing factory-built chimney needs a careful inspectio ...
-
Heartland Wood Stove - page 21
The Artisan Cooking Instructions 1050 Fountain S t N. Cambridge, Ontario, Canada N3H-4R7 Business (519) 650-5775 Fax (519) 650-3773 T oll Free Phone: 1-877-650-5775 T oll Free Fax: 1-800-327-5609 The temperature registered by the oven door thermometer may not necessarily correspond with the reading taken with a thermometer inside the oven A TTENTIO ...
-
Heartland Wood Stove - page 22
Learning how to most effectively control the oven temperature takes some time and experience. As a general rule, the stove should be at the charcoal stage of the combustion process before the oven is ready for cooking. The temperatures established on both the cooking surface and in the oven are determined by three primary things: 1. The amount of d ...
-
Heartland Wood Stove - page 23
T op Oven Cooking The oven door thermometer registers the temperature at the door only . Oven temperatures vary from top to bottom and side to side. The only accurate check on oven temperature is an oven thermometer alongside food being roasted or baked. Once the stove has about 4” of red hot coals in the firebox, it will become stable. The entir ...
-
Heartland Wood Stove - page 24
Add on kit s that are available for the Heartland Artisan: Fresh Air Kit If your home is tight and well insulated, the stove may be “st arved” for combustible air , then this kit is what you need! Artisan Fresh Air Kit - #RN0001 If you have any questions or you need replacement p art s, cont act your dealer or call us direct at 519-650-5775. Ou ...
¿Tienes una pregunta acerca de Heartland Wood Stove?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Heartland Wood Stove, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Heartland Wood Stove probablemente compartirá una forma de solucionarlo.