-
Vanguard FBST - page 1
® Sav e this manual for future reference. For more information, visit www .desatech.com UNVENTED (VENT -FREE) LogMate ® UNIVERSAL FIREBO X OWNER’S OPERA TION AND INST ALLA TION MANU AL MODEL FBST 36" See-Thru Heat-Circulating Firebox FOR YOUR SAFETY — Do not store or use gasoline or any other ammable v ...
-
Vanguard FBST - page 2
www .desatech.com 1051 16-01D 2 W ARNING: Improper installation, adjustment, altera - tion,service ormaintenancecan causeinjury orprop - erty damage. Refer to this manual for correct installation and operational procedures. For assistance or addi- tional information consult a? ...
-
Vanguard FBST - page 3
www .desatech.com 1051 16-01D 3 SAFETY INFORMA TION IM PO RT ANT : R ea d t hi s o wn er’ s ma nu al c ar ef u ll ya nd c om pl et e ly b e f o r e t r y i n g t o as se m b l e , op er a t e or se rv ic eth is r ebo x. Imp ro pe r us e of th is re bo x ca nc au se ...
-
Vanguard FBST - page 4
www .desatech.com 1051 16-01D 4 12. Do not use th e reb ox if it has bee n unde r wat er due to the sho ck haz ard th at cou ld res ult wi th the blo wer acce ssar y ( if i nsta lled ) i n pl ace. 1 3 . Provide adequate clearances around air openings. LOCAL CODES Install and use rebox with care. Follow all local codes. In the absence of local ...
-
Vanguard FBST - page 5
www .desatech.com 1051 16-01D 5 LOCA TING FIREBO X PLANNING Plan where you will install the rebox. This will sav e time and mone y later whe n you instal l the re - box. Before installation, consider the following: 1. Where the rebox will be located. Allow for wall and ceiling clearances (see Installation Clearances , page 8). 2. Everythin ...
-
Vanguard FBST - page 6
www .desatech.com 1051 16-01D 6 Unusually tight construction is dened as con - struction where: a. walls and ceilings exposed to the outside atmospher e have a continuous water vapor retarder with a rating of one perm (6 x 10 - 1 1 kg per pa-sec-m 2 ) or less with openings gasketed or sealed and b. weather stripping has been added on open- able ...
-
Vanguard FBST - page 7
www .desatech.com 1051 16-01D 7 The space in the above example is a conned space because the actual Btu/Hr used is more than the maximum Btu/Hr the space can support. Y ou must provid e additional fresh air. Y our option s are as follows: A. Rework work sheet, adding the space of an adjoining room. If the extra space provides an unconned spac ...
-
Vanguard FBST - page 8
www .desatech.com 1051 16-01D 8 INST ALLA TION NOTICE: This rebox in com - bination with unvented log sets are intended for use as supplemental heat. Use along with your primary heating system. Do not install them as your primary heat source. If you have a central ...
-
Vanguard FBST - page 9
www .desatech.com 1051 16-01D 9 Figure 5 - Minimum Clearance - Front V iew 42" Min. 0" to Wood Floor 8" Min. 0" Min. Clearance to Upper Frame/Wallboard Ceiling 4" Min. from the Perpendicular Side Wall to the Edge of Facial 1/2" Min. Clearance to Combustibles 44 1 / 4 " 24" Figure 6 - Minimum Clearance - T op ...
-
Vanguard FBST - page 10
www .desatech.com 1051 16-01D 10 INST ALLA TION Continued 44 1 / 4 " Min. 40 1 / 4 " Min. 36" Min. to Facing Wall 22 3 / 4 " Min. Facing Wall Wallboard Wallboard Gas Line Facing Wall (Base line) Note: Gas line may also be on opposite side. Figure 8 - Framing for Built-In Firebox Installation 1 1 / 2 " Max. 3/8" Max. 4& ...
-
Vanguard FBST - page 11
www .desatech.com 1051 16-01D 1 1 INST ALLING GAS LINE W ARNING: A qualied ser - vic e perso n must con nect heate r to gas supply . Follow all local codes. IMPORT ANT : See Connecting to Gas Supply in your log set owner ’ s manual for details on gas hookup. Y ou may run the gas line from either side of the reb ...
-
Vanguard FBST - page 12
www .desatech.com 1051 16-01D 12 If a sediment trap is not incorporated as a part of the gas utiliz atio n equ ipme nt, one shall be inst alle d as close to the inlet of the equipment as practical at the time of installation, as per ANS Z223.1/NFP A 54 . See Figure 14. Prepare incoming black iron gas line with T eon tape or pipe joint compound ( ...
-
Vanguard FBST - page 13
www .desatech.com 1051 16-01D 13 Figure 15 - Locating Electrical Connection and Gas Connection on Either Side of Fireplace Cover Plates Electrical Connection Access Hole Gas Connection Access Hole Note: A 120V supply connection to the leads to the receptacle must be provided for use with the optional blower kit whether installed during or after ini ...
-
Vanguard FBST - page 14
www .desatech.com 1051 16-01D 14 Figure 17 - Optional Blower Wiring Diagram INST ALLA TION Continued HEA T DEFLECTIVE HOOD INST ALLA TION The factory supplied heat deective hoods must be installed inside the replace opening on both sides for the safe operation of the unit as shown in Figure 19. 1. Remove protective covering from hoods. 2. Pos ...
-
Vanguard FBST - page 15
www .desatech.com 1051 16-01D 15 OPERA TING GUIDELINES AND MAINTENANCE INSTRUCTIONS Whe n lit for the rst time , a ven t- fre e log hea te r will emit a sl ight o dor for a bout an ho ur or two . This is a normal occ urre nce which is due to the “curi ng” of the lo gs and th e “bur n-in ” of inte rna l p aint s and lubr ica nts used in t ...
-
Vanguard FBST - page 16
www .desatech.com 1051 16-01D 16 ILL USTRA TED P ARTS BREAKDOWN MODEL FBST **These items are used on both sides of fireplace. 8** 14 16** 16** 16** 7-1 7-2 2 16** 1 1** 16** 12 6 6 6 15 15 15 15 13 13 10** 5** 15 15 15 15 6 6 15 15 4 15 15 15 15 15 15 15 4 14 14 16** 16** 8** 16** 16** 7-1 9** 15 1 3 ...
-
Vanguard FBST - page 17
www .desatech.com 1051 16-01D 17 P ARTS LIST MODEL FBST This list contains replaceable parts used in your rebox. When ordering parts, follow the instructions listed under Replacement Parts on page 15 of this manual. KEY NO. P ART NO. DESCRIPTION QTY . 1 *** Firebox Assembly 1 2 *** Firebox Bottom 1 3 *** Firebox T op 1 4 23982 T op Spacer 4 5 ...
-
Vanguard FBST - page 18
www .desatech.com 1051 16-01D 18 TECHNICAL SERVICE Y ou may have further questions about installatio n, operation or troubleshooting. If so, contact DESA at 1-866-672-6040. Y ou can also visit DESA T echnical Service web site at www .desatech.com . ACCESSORIES Purcha se these rebox accessori es from your local deal er . If they can not supply th ...
-
Vanguard FBST - page 19
www .desatech.com 1051 16-01D 19 NO TES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ____________________________________ ...
-
Vanguard FBST - page 20
LIMITED WARRANTY VENT -FREE FIREBO X DESA warrants this product to be free from defects in materials and components for four (4) years from the date of rst purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. T o make a claim under this warranty the Bill of Sale ...
¿Tienes una pregunta acerca de Vanguard FBST?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Vanguard FBST, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Vanguard FBST probablemente compartirá una forma de solucionarlo.