-
Woodstock W1785 - page 1
Phone: (360) 734-3482 • Online Technical Support: tech-support@shopfox.biz COPYRIGHT © JUNE, 2007 BY WOODSTOCK INTERNATIONAL, INC. WARNING: NO PORTION OF THIS MANUAL MAY BE REPRODUCED IN ANY SHAPE OR FORM WITHOUT THE WRITTEN APPROVAL OF WOODSTOCK INTERNATIONAL, INC. #9629TS Printed in China M O D E L W 17 8 5 P A L M N A I L E R OWNER'S MAN ...
-
Woodstock W1785 - page 2
? ...
-
Woodstock W1785 - page 3
Model W1785 Palm Nailer -1- Saf e t y Inst ructi ons f or P neu ma tic T ools 1. KEEP ALL SAFETY DEVICES IN PLACE and in working order. 2. REMOVE ADJUSTING KEYS AND WRENCHES. Form habit of checking to see that keys and adjusting wrenches are removed from tool before operation. 3. KEEP WORK AREA CLEAN . Cluttered areas and benches invite accidents. ...
-
Woodstock W1785 - page 4
Model W1785 Palm Nailer -2- 10. USE PROPER AIR HOSE for the tool. Make sure your air hose is in good condition and is long enough to reach your work without stretching. 11. WEAR PROPER APPAREL. Do not wear loose clothing, gloves, neckties, rings, bracelets, or other jewelry which may get caught in moving parts. Non-slip footwear is recommended. Wea ...
-
Woodstock W1785 - page 5
Model W1785 Palm Nailer -3- 1. HAND INJURIES: Do not place your hands near the nail point of entry. A nail can deflect and tear through the surface of the workpiece, puncturing your hand or fingers. 2. COMBUSTIBLE GASES: Never connect the nailer to pressurized oxygen or other combustible gases as a power source. Only use filtered, lubricated, and r ...
-
Woodstock W1785 - page 6
Model W1785 Palm Nailer -4- No list of safety guidelines can be complete. Every shop environment is different. Always consider safety first, as it applies to your individual working conditions. Use this and other tools with caution and respect. Failure to do so could result in serious personal injury, damage to equipment or poor work results. INT R ...
-
Woodstock W1785 - page 7
Model W1785 Palm Nailer -5- The Mo del W1 785 is d esigned to b e oper ated at 70 - 100 PSI using cl ean, dr y , regu lat e d , com pressed air . D o not exceed t he 1 20 PSI max imum pressure for your mo del. Before using yo ur nailer , regulate the air press ure to find th e optimum setting within the sp ecified ope rating rang e . Start by te st ...
-
Woodstock W1785 - page 8
Model W1785 Palm Nailer -6- SETUP In ve nto r y This tool has b een caref u l ly packaged for safe tra nspor tation. If you n otice the tool has been damaged dur ing s h ip ping , p l ea se contac t you r autho rized Shop Fox dealer immediately . Unp ac king The foll ow ing is a descr iption of the main compo nents shipped with the Mod el W1 785. L ...
-
Woodstock W1785 - page 9
Model W1785 Palm Nailer -7- OP ER A TIO NS If yo u have not read th e safety instru ctions in this manual , do n ot oper ate the nai ler . Before you o perate yo ur nailer , p lace five to si x drops of the includ ed oil into the quick connect fitting w here th e nailer conne cts to the air sup ply . T o ope rate your nailer , do these steps : 1. C ...
-
Woodstock W1785 - page 10
Model W1785 Palm Nailer -8- Re pl acin g Pist ons/ O-Rings Under heav y us e , the piston or O-ring s may wear out. Repl acement is quick and easy . Contact your author ized Shop F ox dealer to obtain th e Pisto n Repair Kit (Par t N umber X 1 7851 27), or the Co mplete O-Ring Kit ( Part Numbe r X 1785 128). 5. Take hold of the ram pin and pull the ...
-
Woodstock W1785 - page 11
Model W1785 Palm Nailer -9- C LEANIN G & L UBRICA TI ON C lea ni ng Use a go od solvent to clean the n ose asse mbly of the nailer . Al ways be sure that th e nailer is dr y before using it again. Do not allow d ust , chips , s and , etc. into the air conn ectors or into the body of t he nailer; this may result in leaks and damage to the nai le ...
-
Woodstock W1785 - page 12
Model W1785 Palm Nailer -10- P ARTS BREAK DO WN & P ARTS LI ST ...
-
Woodstock W1785 - page 13
Model W1785 Palm Nailer -11- TR OUB LE SHOO TI NG Symptom Possible Cause Possible Solution Air leaking at trig ger valve area. 1. O-rings in trigger valve housing are damaged. 1. O-rings must be replaced & operation of safety nose must be checked. Air leaking bet ween hou sing and hos e 1. Loose screws in housing. 2. Damaged O-ring. 3. Loose ai ...
-
Woodstock W1785 - page 14
Woodsto ck International , Inc. warrants all Sho p Fox machiner y to b e free of defect s from wor kmanship and mater ials for a pe riod of t wo years from the date of or iginal purchas e by the o riginal owner . This warranty doe s not apply to defect s due directly or indirectly to misuse , abu se , negligence or accident s , l ack of ma intenan ...
-
Woodstock W1785 - page 15
CUT ALONG DOTTED LINE Name ___________________________________________________________________________________ Street __________________________________________________________________________________ City _________________________ State ___________________________ Zip ________________________ Phone # ______________________ Email __________________ ...
-
Woodstock W1785 - page 16
TAPE ALONG EDGES--PLEASE DO NOT STAPLE FOLD ALONG DOTTED LINE WOODSTOCK INTERNATIONAL INC. P.O. BOX 2309 BELLINGHAM, WA 98227-2309 Place Stamp Here FOLD ALONG DOTTED LINE ...
¿Tienes una pregunta acerca de Woodstock W1785?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Woodstock W1785, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Woodstock W1785 probablemente compartirá una forma de solucionarlo.