-
Heat & Glo LifeStyle EVEREST - page 1
Heat & Glo • Everest • 750-900 Rev . L • 1/06 1 Model: Everest Installers Guide Underwriters Laboratories Listed In the Commonwealth of Massachusetts: • installation must be performed by a licensed plumber or gas fitter; • a CO detector shall be installed in the room where the appliance is installed. - Do not store or use gasoline or ...
-
Heat & Glo LifeStyle EVEREST - page 2
Heat & Glo • Everest • 750-900 Rev . L • 1/06 2 These units MUST use one of the vent systems described in the Installing the Fireplace section of the Installers Guide . NO OTHER vent systems or component s MA Y BE USED . This gas fireplace and vent assembly MUST be vented directly to the outside and MUST NEVER be attached to a chimney ser ...
-
Heat & Glo LifeStyle EVEREST - page 3
Heat & Glo • Everest • 750-900 Rev . L • 1/06 3 T able of Content s Safety and W arning Information . .................................... 2 Service Parts Lists . ......................................................... 4 Section 1: Approvals and Codes . ................................... 6 Appliance Certification ...................... ...
-
Heat & Glo LifeStyle EVEREST - page 4
Heat & Glo • Everest • 750-900 Rev . L • 1/06 4 Part number list on following page. 1 3 5 10 8 7 9 11 Log Set Assembly 6 2 23 13 14 15 16 17 12 Back Log (not shown) 4 19 20 21 18 22 (NG , LP) Exploded Part s Diagram Service Parts EVEREST Beginning Manufacturing Date: 8-00 Ending Manufacturing Date: ______ Î ...
-
Heat & Glo LifeStyle EVEREST - page 5
Heat & Glo • Everest • 750-900 Rev . L • 1/06 5 Service Parts List IMPORT ANT : THIS IS DA TED INFORMA TION. The most current information is located on your dealers VIP site. When ordering, supply serial and model numbers to ensure correct service parts. EVEREST ITE M IP I IG N IT ION SERIA L # P A RT NUMBER 1 Log B u rn er O rifice N G ( ...
-
Heat & Glo LifeStyle EVEREST - page 6
Heat & Glo • Everest • 750-900 Rev . L • 1/06 6 Appliance Certification The Heat & Glo fireplace model discussed in this Installers Guide have been tested to certification standards and listed by the applicable laboratories. Certification MODEL: EVEREST LABORA TOR Y : Underwriters Laboratories TYPE: Direct V ent Gas Fireplace Heater S ...
-
Heat & Glo LifeStyle EVEREST - page 7
Heat & Glo • Everest • 750-900 Rev . L • 1/06 7 2 Getting St arted Introducing the Heat & Glo Gas Fireplaces Heat & Glo direct vent gas fireplaces are designed to oper- ate with all combustion air siphoned from outside of the building and all exhaust gases expelled to the outside. The information contained in this Installers Guide ...
-
Heat & Glo LifeStyle EVEREST - page 8
Heat & Glo • Everest • 750-900 Rev . L • 1/06 8 Figure 1. Diagram of the Everest TOP ST ANDOFF S TOP VENT COLLARS TRIM D OOR RA T ING PLA TE AND LABELS GAS CONTROLS ELECT RICA L ACCESS GA S LIN E ACCESS Ø 8 (203.1) 8 (203mm ) 8-15/16 (227mm ) 20-7/8 (531mm) ELEC TRICA L ACCESS 4-1 1/16 (119mm) 2-5/16 (59 mm) 49-7/8 (1266m m) 4-1 1/16 (1 ...
-
Heat & Glo LifeStyle EVEREST - page 9
Heat & Glo • Everest • 750-900 Rev . L • 1/06 9 3 Inst alling the Fireplace Step 1. Locating the Fireplace The diagram below shows space and clearance require- ments for locating a fireplace within a room. AB CD E 35 1/2” 21 3/4” 30 1/2” 43 1/4” 61 3/16” (902mm) (552mm) (775mm) (1099mm) (1554mm) Minimum Clearances from the Firep ...
-
Heat & Glo LifeStyle EVEREST - page 10
Heat & Glo • Everest • 750-900 Rev . L • 1/06 10 V ent system termination kits V ent system components Figure 5. V ent Component s and T erminations Step 3. Inst alling the V ent System A. V ent System Approvals These models are approved to use DVP -series direct vent pipe components and terminations. Approved vent system components are l ...
-
Heat & Glo LifeStyle EVEREST - page 11
Heat & Glo • Everest • 750-900 Rev . L • 1/06 11 STRAIGHT UP VERTICAL VENTING V (FT .) 40' MAX. (12.4 M) Figure 6. Straight Up V ertical V enting V CAP ...
-
Heat & Glo LifeStyle EVEREST - page 12
Heat & Glo • Everest • 750-900 Rev . L • 1/06 12 Figure 7. V enting with One 90° Elbow NOTE: If a 90 o elbow is first attached to the unit, the maximum horizontal run is 3-feet (914mm). NOTE: For corner installations: A 6-inch (152mm) section of straight pipe may need to be attached to the fireplace before a 90 o elbow , to allow the ven ...
-
Heat & Glo LifeStyle EVEREST - page 13
Heat & Glo • Everest • 750-900 Rev . L • 1/06 13 VH + H 1 1' MIN. (305mm) 10' MAX. (3.1m) 2' MIN. (610mm) 15' MAX. (4.65m) 4' MIN. (1.22m) 20' MAX. (6.2m) V+H+H 1 = 40' MAX.(12.4m) H+H 1 = 20´ MAX. (6.2m) V+V 1 +H = 40' MAX.(12.4m) Figure 8. V enting with T wo 90° Elbows VENTING WITH TWO (2) 90° ...
-
Heat & Glo LifeStyle EVEREST - page 14
Heat & Glo • Everest • 750-900 Rev . L • 1/06 14 Figure 9. V enting with three 90° elbows VENTING WITH THREE (3) 90° ELBOWS V + V 1 H + H 1 1' MIN. (305mm) 10' MAX. (3.1m) 2' MIN. (610mm) 15' MAX. (4.65m) 4' MIN. (1.22m) 20' MAX. (6.2m) NOTE: H + H 1 = 20' MAX. (6.2m) V + V 1 + H + H 1 = 40' MAX. ...
-
Heat & Glo LifeStyle EVEREST - page 15
Heat & Glo • Everest • 750-900 Rev . L • 1/06 15 Figure 10. V ertical Baffle 1. Att ach the First V ent Component to the Starting Collars T o attach the first vent component to the st arting collars of the fireplace: • Make sure that the fireplace gasket supplied with the fireplace seals between the first component and the out- er firep ...
-
Heat & Glo LifeStyle EVEREST - page 16
Heat & Glo • Everest • 750-900 Rev . L • 1/06 16 Figure 1 1 ! Figure 12 CORRECT INCORRECT COMB US T IBLE SURF ACE HEA T SHI E LD 3“ MIN. (76MM) W ARNING: INST ALLA TION OF THIS FIRE- PLACE REQUIRES THE USE OF HEA T SHIELD 570-290 ABOVE THE FIRST 90 0 ELBOW IN THE VENTING SYSTEM. 3. Install Support Brackets Refer to Cinch Pipe and T ermi ...
-
Heat & Glo LifeStyle EVEREST - page 17
Heat & Glo • Everest • 750-900 Rev . L • 1/06 17 For V ertical Runs - One ceiling firestop is REQUIRED at the hole in each ceiling through which the vent passes. T o install firestops for vertical runs that p ass through ceilings: • Position a plumb bob directly over the center of the verti- cal vent component. • Mark the ceiling to e ...
-
Heat & Glo LifeStyle EVEREST - page 18
Heat & Glo • Everest • 750-900 Rev . L • 1/06 18 Figure 17. T rapezoid T ermination Cap 7 1 / 4" (184mm) ! ! W ARNING: VENTING TERMINALS SHALL NOT BE RECESSED INT O A W ALL OR SID- ING . VENT TERMINA TION CLEARANCES MUST BE FOLLOWED TO A VOID FIRE DANGER. SEE VENT TERMINA TION MINIMUM CLEARANCES DI- AGRAM ON FOLLOWING P AGE. C. V ent ...
-
Heat & Glo LifeStyle EVEREST - page 19
Heat & Glo • Everest • 750-900 Rev . L • 1/06 19 Î V = VENT TERMINAL X = AIR SUPPL Y INLET = AREA WHERE TERMINAL IS NOT PERMITTED Figure 18. V ent T ermination Minimum Clearances A = 12 inches ................ clearances above grade, veran- da, porch, deck or balcony B = 12 inches ................ clearances to window or door that may be ...
-
Heat & Glo LifeStyle EVEREST - page 20
Heat & Glo • Everest • 750-900 Rev . L • 1/06 20 For V ertical T erminations - T o locate the vent and install the vent sections: • Locate and mark the vent centerpoint on the underside of the roof, and drive a nail through the centerpoint. • Make the outline of the roof hole around the centerpoint nail. • The size of the roof hole ...
-
Heat & Glo LifeStyle EVEREST - page 21
Heat & Glo • Everest • 750-900 Rev . L • 1/06 21 ! Step 4. Positioning, Leveling, and Securing the Fireplace ! ! The diagram below shows how to properly position, level, and secure the fireplace. Figure 20. Proper Positioning, Leveling, and Securing of a Fireplace Figure 21. Intermittent Pilot Ignition NAILING T ABS (BOTH SIDE S) Step 5. ...
-
Heat & Glo LifeStyle EVEREST - page 22
Heat & Glo • Everest • 750-900 Rev . L • 1/06 22 Figure 22. Gas Supply Line • At the gas line access hole, use insulation to re-pack the space around the gas pipe. • Insert insulation from the outside of the fireplace and pack the insulation tightly to totally seal between the pipe and the outer casing. Step 6. The Gas Supply Line NOT ...
-
Heat & Glo LifeStyle EVEREST - page 23
Heat & Glo • Everest • 750-900 Rev . L • 1/06 23 Step 8. Wiring the Fireplace NOTE: Electrical wiring must be installed by a licensed electrician. CAUTION: DISCONNECT REMOTE CONTROLS IF YOU ARE ABSENT FOR EXTENDED TIME PERIODS. THIS WILL PREVENT ACCIDENT AL FIREPLACE OPERA TION. Intermittent Pilot Ignition (IPI) Wiring Appliance Requireme ...
-
Heat & Glo LifeStyle EVEREST - page 24
Heat & Glo • Everest • 750-900 Rev . L • 1/06 24 Step 9. Finishing The following diagram shows the minimum vertical and corresponding maximum horizontal dimensions of fireplace mantels or other combustible projections above the top front edge of the fireplace. See Figures 2 and 3 for other fireplace clearances. Only non-combustible materi ...
-
Heat & Glo LifeStyle EVEREST - page 25
Heat & Glo • Everest • 750-900 Rev . L • 1/06 25 Installing the T rim Combustible materials may be brought up to the specified clearances on the side and top front edges of the fireplace, but MUST NEVER overlap onto the front face. The joints between the finished wall and the fireplace top and sides can only be sealed with a 300° F . (14 ...
-
Heat & Glo LifeStyle EVEREST - page 26
Heat & Glo • Everest • 750-900 Rev . L • 1/06 26 Step 1 1. Before Lighting the Fireplace Before lighting the fireplace, be sure to do the following: Remove all paperwork from underneath the fireplace. Review safety warnings and cautions • Read the Safety and Warning Information section at the beginning of this Installers Guide . Double- ...
-
Heat & Glo LifeStyle EVEREST - page 27
Heat & Glo • Everest • 750-900 Rev . L • 1/06 27 4 Maint aining and Servicing Y our Fireplace Fireplace Maintenance Although the frequency of your fireplace servicing and main- tenance will depend on use and the type of installation, you should have a qualified service technician perform an appli- ance check-up at the beginning of each he ...
¿Tienes una pregunta acerca de Heat & Glo LifeStyle EVEREST?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Heat & Glo LifeStyle EVEREST, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Heat & Glo LifeStyle EVEREST probablemente compartirá una forma de solucionarlo.