-
Poulan Pro HDF550N - page 1
189773 12.17.03 TR PRINTED IN U .S.A. • Assembly • Operation • Maintenance • Service and Adjustments • Storage • Troubleshooting • Repair Parts OWNER'S MANUAL MODEL NO . HDF550N 5.5 HP 26 Inc h Tiller F or Parts and Ser vice, contact our authorized distributor: call 1-800-849-1297 F or T echnical Assistance: call 1-800-829-5886 ...
-
Poulan Pro HDF550N - page 2
2 • K eep children and pets aw ay . • Do not overload the machine capacity by attempting to till too deep at too f ast a rate. • Ne ver oper ate the machine at high speeds on slipper y surf aces. Look behind and use care when bac king. • Ne ver allow b ystanders near the unit. • Use only attachments and accessories approv ed by the manuf ...
-
Poulan Pro HDF550N - page 3
3 PR ODUCT SPECIFICA TIONS Gasoline Capacity: 3 Quar ts (2.8L) Unleaded Regular Oil (API-SF-SJ): SAE 30 (Abov e 32°F/0°C) (Capacity: 20 oz./0.6L) SAE 5w-30(Below 32°F/0°C) Spark Plug: Champion RC12YC (Gap: .030"/0.76mm) CONGRA TULA TIONS on y our purchase of a new tiller . It has been designed, en gi neered and manu f ac tured to give you ...
-
Poulan Pro HDF550N - page 4
4 ASSEMBL Y OPERA T OR’S POSITION (See Fig. 1) When right or left hand is mentioned in this manual, it means when you are in the oper ating position (standing behind tiller handles). Y our new tiller has been assemb led at the factory with exception of those par ts left unassemb led for shipping purposes. T o ensure saf e and proper operation of ...
-
Poulan Pro HDF550N - page 5
5 UNP A CK CAR T ON & INST ALL HANDLE (See Fig. 2) CA UTION: Be careful of exposed sta ples when handling or disposing of cartoning material. IMPORT ANT : WHEN UNP ACKING AND AS SEM BLING TILLER, BE CAREFUL NO T TO STRETCH OR KINK CABLE(S). • Cut cable ties securing handles. • Slowly lift handle as sem bly up , route cable(s) as sho wn and ...
-
Poulan Pro HDF550N - page 6
6 KNO W Y OUR TILLER READ THIS O WNER'S MANU AL AND SAFETY RULES BEFORE OPERA TING Y OUR TILLER. Compare the illustrations with y our tiller to familiarize y ourself with the location of various controls and adjustments. Save this manual f or future reference . REVERSE TINE CONTROL These symbols ma y appear on your Tiller or in literature supp ...
-
Poulan Pro HDF550N - page 7
7 handles _94 FOR W ARD TINE CON TROL IN “OFF ” (UP) POSITION REVERSE CONTROL e ngine_a rt_ 7 1 CHOKE CONTROL THRO TTLE CONTROL FOR W ARD TINE CON TROL IN “ON” (DO WN) POSITION TINE OPERA TION (See Fig. 5) FOR W ARD • Squeeze f orward tine control to handle. REVERSE • With f orward tine control “OFF” (up) position, pull back and hol ...
-
Poulan Pro HDF550N - page 8
8 T O TRANSPORT CA UTION: Before lifting or trans por t ing, allow tiller engine and m uffl er to cool. Disconnect spark plug wire. Drain gasoline from fuel tank. AROUND THE Y ARD • Tip depth stake f orward until it is held by the stak e spring. • Push tiller handles down, raising tines off the g round. • Push or pull tiller to desired locat ...
-
Poulan Pro HDF550N - page 9
9 e ng in e_a rt_ 7 1 BREAKING IN Y OUR TILLER Break-in your belt(s), pulle ys and tine control before y ou actually begin tilling. • Star t engine, tip tines off ground b y pressing handles down and engage tine control to star t tine rotation. Allow tines to rotate f or fi ve min utes. • Check tine operation and adjust if necessary . See “T ...
-
Poulan Pro HDF550N - page 10
10 MAINTENANCE SCHEDULE FILL IN DATES AS YOU COMPLETE REGULAR SERVICE Check Engine Oil Level Change Engine Oil Oil Pivot Points Inspect Air Screen Inspect Spark Arrester / Muffler Clean or Replace Air Cleaner Cartridge Clean Engine Cylinder Fins Replace Spark Plug BEFORE EACH USE EVERY 25 HOURS EVERY 5 HOURS EVERY 50 HOURS SERVICE DATES 2 1 - Chang ...
-
Poulan Pro HDF550N - page 11
11 FIG. 11 engine_ar t_12 FIG. 12 OIL DRAIN PLUG OIL FILLER PLUG OIL LEVEL TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE SAE VISCOSITY GRADES -20 0 30 40 80 100 -30 -20 0 20 30 40 F C 32 -10 10 60 5W-30 SAE 30 oil_visc_chart1_e MAINTENANCE AIR CLEANER SCREW CO V ER AIR CLEAN ER CAR TRIDGE FIG. 13 Disconnect spark plug wire before perf orming ...
-
Poulan Pro HDF550N - page 12
12 MAINTENANCE e ngine_a rt_ 7 1 BLO WER HOUSING AIR SCREEN CYLINDER FINS MUF FLER FIG. 14 COOLING SYSTEM (See Fig. 14) Y our engine is air cooled. F or proper engine performance and long lif e keep your engine clean. • Clean air screen frequently using a stiff-br istled - brush. • Remov e blo wer housing and clean as nec es sar y . • K eep c ...
-
Poulan Pro HDF550N - page 13
13 TILLER T O ADJUST HANDLE HEIGHT (See Fig. 15) F actor y assemb ly has provided low est handle height. Se lect handle height best suited f or your tilling conditions. Handle height will be diff erent when tiller digs into soil. • If a higher handle height is desired, loosen the f our nuts securing handle panel to engine brack ets. • Slide han ...
-
Poulan Pro HDF550N - page 14
14 TINE OPERA TION CHECK (See Fig. 19) W ARNING: Disconnect spark plug wire from spark plug to pre vent star ting while chec king tine operation. F or proper tine operation, forw ard tine control lev er must be against control body and all slack remo ved from inner wire of control cable when control is in the “OFF” (up) position. If le ver and ...
-
Poulan Pro HDF550N - page 15
15 belts_10 FIG. 22 FOR W ARD MOTION (INSIDE) V -BEL T ENGINE PULLEY REVERSE IDLER ARM REVERSE IDLER PULLEY IDLER ARM PIN FIG. 21 FOR W ARD IDLER PULLEY REVERSE IDLER PULLEY ENGINE PUL- LEY FRONT VIEW REFERENCE REVERSE (OUTSIDE) V -BEL T FOR W ARD MO TION (INSIDE) V -BEL T TRANS MIS SION PUL LEY BEL T GU ARD BOL T BEL T GUIDE REVERSE IDLER PULLEY I ...
-
Poulan Pro HDF550N - page 16
16 ST ORA GE ENGINE OIL Drain oil (with engine warm) and replace with clean oil. (See “ENGINE” in the Maintenance section of this man ual). CYLINDER(S) • Remov e spark plug. • P our 1 ounce (29 ml) of oil through spar k plug hole into cylinder . • Pull starter handle slowly se veral times to distribute oil. • Replace with new spark plug ...
-
Poulan Pro HDF550N - page 17
17 Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly . 2. See “TO ST ART ENGINE” in the Operation section. 3. Engine fl ooded. 3. Wait se veral min utes before attempting to star t. 4. Dir ty air cleaner . 4. Clean or replace air cleaner cartr idge . 5. Water in fuel. 5. Empty fuel tank and carb uretor, and ...
-
Poulan Pro HDF550N - page 18
18 1 187820X428 Brac ket Handle 2 72140512 Bolt, Carr iage 5/16-18 unc x 1-1¦2 3 9266R Grip , Handle 4 166376 Handle, L.H. 5 73680500 Locknut, Cro wn 5/16-18 6 19111116 Washer 11/32 x 11/16 x 16 Ga. 7 19121414 Washer 3/8 x 7/8 x 14 Ga. 8 74760516 Bolt, Hex Hd. 5/16-18 x 1 9 74760512 Bolt, Hex Hd 5/16-18 x 3/4 10 10040500 Washer , Lock 5/16 11 7322 ...
-
Poulan Pro HDF550N - page 19
19 KEY P ART NO . NO. DESCRIPTION 19 188502 Bolt, Belt Guard 20 12000036 Ring, Klip 21 73350600 Nut, Hex, J am 3/8-16 22 161806 Pulley , Idler 23 175377 Ar m, Idler 24 74760620 Bolt, Hex 3/8-16 x 1-1/4 25 106968X Shaft, Idler Arm 26 73350500 Nut, Hex, J am 5/16-18 27 73220400 Nut, Fin Hex 1/4-20 28 10040400 Washer LK Hvy Helical 1/4 29 109227X P ad ...
-
Poulan Pro HDF550N - page 20
20 6 7 8 13 9 10 11 22 15 3 24 5 4 7 4 5 17 16 18 18 21 17 16 2 2 1 3 24 19 19 20 20 wheel_d.stake_2 1 9194R Pin, Cle vis 2 74760520 Bolt, Hex 5/16-18 x 1-1/4 3 74760512 Bolt, Hex 5/16-18 x 3/4 4 73220500 Nut, Hex 5/16-18 5 10040500 Washer , Lock 5/16 6 73800600 Locknut, w/w asher 3/8-16 7 4921H Clip , Hair pin 8 1952J Suppor t, Depth Stak e, R.H. ...
-
Poulan Pro HDF550N - page 21
21 REP AIR P AR TS TILLER - - MODEL NUMBER HDF550N TINE ASSEMBL Y KEY P ART NO . NO. DESCRIPTION 1 156934 Tine, Outer , R.H. 2 3146R Retainer , Spr ing 3 156932 Tine, Inner , R.H. 4 156931 Tine, Inner , L.H. 5 156933 Tine, Outer , L.H. 6 4929H Pin, Cle vis KEY P ART NO . NO. DESCRIPTION 3 1 6 4 5 6 2 2 tine_ipb_3 ...
-
Poulan Pro HDF550N - page 22
22 REP AIR P AR TS TILLER - - MODEL NUMBER HDF550N TRANSMISSION KEY P ART NO . NO. DESCRIPTION 14 9173R Spacer , Split 16 19091412 Washer 9/32 x 7/8 x 12 Ga. 17 19092016 Washer 9/32 x 1-1/4 x 16 Ga. 18 10040400 Washer , Lock 1/4 19 74610412 Bolt, Hex 1/4-28 x 3/4 Gr . 5 20 - - - - - - - Engine, Briggs Model 126302 Order par ts from engine manuf ac- ...
-
Poulan Pro HDF550N - page 23
23 REP AIR P AR TS TILLER - - MODEL NUMBER HDF550N DECALS KEY P ART NO . NO. DESCRIPTION 1 157377 Decal, Logo 2 189787 Decal, Logo 3 157378 Decal, HP , Re verse 4 189936 Decal, Rev erse, Tine Control 5 141907 Decal, Hand Placement 6 176392 Decal, Eng. Tiller 7 171077 Decal, OHV . N-I/C 8 141906 Decal, W ar ning, Rotating Tines 9 157381 Decal, Hvy D ...
-
Poulan Pro HDF550N - page 24
LIMITED W ARRANTY The Manuf acturer warrants to the original consumer purchaser that this product as manuf actured is free from de- f ects in mater ials and w or k man ship . F or a per iod of two (2) y ears from date of purchase by the original consumer purchaser , we will repair or replace, at our option, without charge f or par ts or labor incur ...
¿Tienes una pregunta acerca de Poulan Pro HDF550N?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Poulan Pro HDF550N, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Poulan Pro HDF550N probablemente compartirá una forma de solucionarlo.