-
Empire Comfort Systems VFD36FB0F-1 - page 1
Page 1 23200-0-1206 INST ALLA TION INSTRUCTIONS AND OWNER'S MANUAL The Breckenridge Deluxe V ent-Free Universal Fireboxes DO NOT A TTEMPT TO MODIFY OR AL TER THE CONSTRUCTION OF THE FIREBOX OR ITS COMPO- NENTS. ANY MODIFICA TION OR AL TERA TION OF CONSTRUCTION MA Y VOID THE W ARRANTY OF THIS FIREBOX. CHILDREN AND ADUL TS SHOULD BE ALERTED TO T ...
-
Empire Comfort Systems VFD36FB0F-1 - page 2
23200-0-1206 Page 2 SECTION P AGE Important Safety Information ................................................................................................. 3 Introduction ............................................................................................................................ 3 Clearances .................................... ...
-
Empire Comfort Systems VFD36FB0F-1 - page 3
Page 3 23200-0-1206 The installation must conform with local codes or , in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.1 (latest edition) and to the National electrical Code, ANSI/NFP A70 (latest edition). NO TE: I nst al la tio n and r ep air sho ul d be done by a qua li - fied service person. The appliance should be in ...
-
Empire Comfort Systems VFD36FB0F-1 - page 4
23200-0-1206 Page 4 Clearances to combustibles Sidewall Clearances: The clearance from the inside of the firebox to perpendicular combustible side wall should not be less than 6". See Figure 1. Fir ebox Side and Bac k Clearances: The firebox outer casing side and back flanges are zero clearance to combustibles. T op Framing and Finishing: C ...
-
Empire Comfort Systems VFD36FB0F-1 - page 5
Page 5 23200-0-1206 Deluxe V ent-Free Firebox Framing Dimensions (in inches) "A" "B" "C" Model Framing Height Framing W idth Framing Depth VFD32FB 36 1/8" 35" 17" VFD36FB 38 1/8" 40" 19 3/8" VFD42FB 38 1/8" 44" 19 3/8" Attention: Add 3-3/4" to "A" Dimension wh ...
-
Empire Comfort Systems VFD36FB0F-1 - page 6
23200-0-1206 Page 6 Figure 7 Firebox Dimensions H J K I A G F B E H I A G F B E C D L M DELUXE LOUVERED DELUXE FLUSH FIREBOX INST ALLA TION INSTRUCTIONS (continued) DELUXE REFERENCE LETTER LOUVERED FLUSH VFD32 VFD36 VFD42 VFD32 VFD36 VFD42 A 35 5/8" 37 5/8" 37 5/8" 35 5/8" 37 5/8" 37 5/8" B 34 1/2" 39 1/2" 43 ...
-
Empire Comfort Systems VFD36FB0F-1 - page 7
Page 7 23200-0-1206 Locating Firebox Place firebox in framing opening. Use the four (4) framing brackets provided on the firebox to attach firebox to framing. Different hole locations can be used for finishing materials with thicknesses of 3/8", 1/2" and 3/4". Attach these materials with screws provided, two (2) per framing brack ...
-
Empire Comfort Systems VFD36FB0F-1 - page 8
23200-0-1206 Page 8 The fireb ox is desi gned to accept a 3/8- inch gas line for an appr oved vent-free gas logset. Have the line installed by a qualified service pers on in accord ance with all buil ding code s. Consul t local buil ding codes to properly size the gas supply line leading to the 3/8-inch hook-up at the unit. The state of Massachus ...
-
Empire Comfort Systems VFD36FB0F-1 - page 9
Page 9 23200-0-1206 OPTIONAL FRESH AIR KIT INST ALLA TION INSTRUCTIONS FOR DELUXE AND PREMIUM FIREBOXES 4. Next, with the vise grip attached, feed the long control rod through the small rectangular opening at the left side of the firebox face. Carefully position the rod and bracket so that the bracket can be secured to the inside opening of the ? ...
-
Empire Comfort Systems VFD36FB0F-1 - page 10
23200-0-1206 Page 10 with the hole in the front flange of the movable air door . See Figure 18. 7. Once the control rod is fed through the air door hole, gently lift the outer air door plate assembly inward and upward until the mounting holes in the plate line up with the pilot holes in the side wrap. 8. Install (4) screws to retain the Air Door a ...
-
Empire Comfort Systems VFD36FB0F-1 - page 11
Page 1 1 23200-0-1206 Completion of Air Kit installation 1. Determine the length of 4” Dia. rigid or flex duct connector (installer supplied) you will need from the firebox/fireplace to the exterior surface of the outside wall, where the air kit hood will be installed. Add a few extra inches to the length to allow for easier attachment of the ...
-
Empire Comfort Systems VFD36FB0F-1 - page 12
23200-0-1206 Page 12 OPTIONAL SINGLE SPEED BLOWER INST ALLA TION INSTRUCTIONS Attention: Install blower assembly before connecting gas inlet supply line. Wiring The appliance, when installed, must be electrically grounded in accordance with local codes or, in the absence of local codes, with the National Electrical Code, ANSI/NFP A 70 , if an exter ...
-
Empire Comfort Systems VFD36FB0F-1 - page 13
Page 13 23200-0-1206 4. Insert blower assembly into interior , bottom of firebox. Posi- tion blower assembly so that you align the notch on back of blower assembly with the center screw on firebox back, then push the blower assembly against firebox back. The blower wheel must be centered with the back wall of the firebox. The magnets on the bac ...
-
Empire Comfort Systems VFD36FB0F-1 - page 14
23200-0-1206 Page 14 Blower Motor The blower motor does not have oiling holes. Do not attempt to oil the blower motor . Blower Wheels The blower wheels will collect lint and could require periodic cleaning. If the air output decreases or the noise level increases, it indicates a dirty blower wheel. Remove fan and clean blower wheels. W arning: Unpl ...
-
Empire Comfort Systems VFD36FB0F-1 - page 15
Page 15 23200-0-1206 CAUTION: ALL WIRING SHOULD BE DONE BY A QUALIFIED ELECTRICIAN AND SHALL BE IN COMPLIANCE WITH ALL LOCA L, CITY AND ST A TE BUIL DING CODE S. BEFORE MAKING THE ELECTR ICAL CONNEC TION, MAKE SURE THA T MAIN POWER SUPPL Y IS DISCONNECTED. THE APPLIANCE, WHEN INST ALLED, MUST BE ELECTRICALL Y GROUNDED IN ACCORDANCE WITH LOCAL CODES ...
-
Empire Comfort Systems VFD36FB0F-1 - page 16
23200-0-1206 Page 16 P AR TS LIST ITEM P ART NUMBER DESCRIPTION VFD32FB0L VFD32FB2DL VFD32FB2CL VFD32FB0F VFD32FB2DF VFD32FB2CF 1 17149 17149 17149 17149 17149 17149 TOP ST ANDOFF 2 17169 17169 17169 N/A N/A N/A UPPER LOUVER 3 10554 10554 10554 10554 10554 10554 FRAMING BRACKET 4 17170 17170 17170 N/A N/A N/A LOWER LOUVER 5 17162 17162 17162 17162 ...
-
Empire Comfort Systems VFD36FB0F-1 - page 17
Page 17 23200-0-1206 Parts can be ordered through your service person or dealer . For best results, the service person or dealer should order parts through the distributor . Parts can be shipped directly to the service person/dealer . All parts listed in the Parts List have a Part Number . When ordering parts, first obtain the Model Number from th ...
-
Empire Comfort Systems VFD36FB0F-1 - page 18
23200-0-1206 Page 18 P AR TS VIEW 1 2 3 4 5 6 7 8 9 10 1 1 12 13 14 15 1 16 17 17 ...
-
Empire Comfort Systems VFD36FB0F-1 - page 19
Page 19 23200-0-1206 Accessory Description Model Numbers Fan Kit 1 2 Designed to provide forced air flow . FBB5 V ariable Speed Control Kit W all mounted variable speed control for use with FBB5 blower SCV -1 Brick Liners Deluxe Firebox VBP32SA VBP36SA VBP42SA Fresh Air Kit 1 2 8 4 7 6 5 3 Deluxe and Premium Fireboxes BV A-1 Frame Kits Standard 3- ...
-
Empire Comfort Systems VFD36FB0F-1 - page 20
23200-0-1206 Page 20 Extended 4" Hoods Extended hoods that extend out 2" farther than the standard hoods, to accommodate thicker surround materials. A vailable as optional kits in Brass, Hammered Pewter , and Stainless Steel finishes. Contact dealer for all available optional hood accessories Louvers Styles include Slat, Mission, Arch, a ...
¿Tienes una pregunta acerca de Empire Comfort Systems VFD36FB0F-1?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Empire Comfort Systems VFD36FB0F-1, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Empire Comfort Systems VFD36FB0F-1 probablemente compartirá una forma de solucionarlo.