-
Holley 05177NOS - page 1
LS-1 Kit Num ber 051 77NOS OWNER ’S MANU AL P/N A5177- SNOS ...
-
Holley 05177NOS - page 2
2 CONGRATULATIONS on p urchasing y our NOS Nitrous O xide Inject ion System! Your system is comp osed of the highest quality componen ts available. It should pro vide many miles of trouble-free perfo rmance when used correctly. If you have any questions regar ding the performance o f your system, call NOS Technical Service at 1-866-GOHOLLEY. NOTICE ...
-
Holley 05177NOS - page 3
3 Never drop or violent ly strike the bottle. Doing so m ay resu lt in an explosive bottle failure. Never change pressure settings of safet y relief valve on the nitrou s bottle valve. Increasing the safe ty relie f valve pressure setti ngs may create an explosive bottle hazard. Identif y the gas content by the NOS label on the bottle before using. ...
-
Holley 05177NOS - page 4
4 TABLE OF CONTENTS WHAT IS NITROU S OXIDE? .......................................................................................................5 Do’s and Don’ts of Nitrou s Oxide..............................................................................................5 Chapter 1 Introduction to your NOS Nitrous O xide Kit ......... .... ...
-
Holley 05177NOS - page 5
5 WHAT IS NITROUS O XIDE? NITRO US OXIDE… …Is a cryogenic gas composed of nitrogen and oxygen molecules …Is 36% oxygen by weight …Is non-flammab le by itself …Is stored as a compressed liquid …Exists in two gra des—U.S.P. and Nitrous Plus : U.S.P. is medical grade nitrous oxide; its common use is dental and veterina ry anesthesia. ...
-
Holley 05177NOS - page 6
6 1.2 Sys tem Requirements W hen used correctly, Kit Number 05177NOS will work with stock LS-1 internal engin e components. To ensure proper performance and driveline longevity, the following i s suggested: Automatic Transmis sions If the vehicle is to be exposed to severe operating co nditions, such as drags trip use, a reputable high pe rform ...
-
Holley 05177NOS - page 7
7 Figure 1 Kit Num ber 05177NOS Components Chapter 2 Kit Installation 2.1 Bottle Mounting Instructions NOTE: Disconn ect the battery ground before beginn ing installation. 2.1.1 Street V ehicles Accurate calibra tion of your NOS nitrous sys tem depends on the bottle remaini ng at a stable temperature. Mount the bott le away from hea t sources, such ...
-
Holley 05177NOS - page 8
8 Before mounting a nitrous bottle in a racin g vehicle intended for use in sanction ed events, check with the sanctioning association fo r any rules regarding this subj ect. Most associations require the bo ttle to be mounted within the confines of the safety roll cage, with t he safety pressure relief cap ven ted away from the driver’s compartm ...
-
Holley 05177NOS - page 9
9 Figure 4 Kit Num ber 05177NOS Assembl y Draw ing ...
-
Holley 05177NOS - page 10
10 Figure 4A Kit Num ber 05177NOS Installed 4. Use the assemb led bottle/bracket/blow-down tube u nit as a pattern to mark for hole drilling. Drill four 5/16” holes for the bottle bracket b olts, a 1/2” hole for the blow-down tube , and an 11/16” hole for the nitrous supply tube. 5. Mount the brack ets securely to the surface (recommended min ...
-
Holley 05177NOS - page 11
11 6. Remove all debris from the airbox before reinstallation. Figure 5 Location of Spray Nozzle Holes in Airbox Figure 6 Spray Nozzle Assembl y 2.5 Solenoi d Mounting Use the following procedure to install the nitrous solenoids. CAUTION: Do not o vertighten the vise in the following procedure, or the solenoi d will be damaged. NOTE: Apply Teflon-b ...
-
Holley 05177NOS - page 12
12 2.6 Nitrous Fe ed Line Mounting HINT: Following the fuel lines along the left side of t he vehicle and entering the engine b ay near the master cylinder works well. 1. Determine the route for your nitrous feed line to follo w. Ensure the path is clear of exhaust system, suspension , steering, wheels, elec trical lines and components, and ti res. ...
-
Holley 05177NOS - page 13
13 WARNING: Be c areful when removing the fue l rail test port fitting. The fue l rail may be pressurized. Alwa y s allow the engine to co ol before performing this operation. Fuel sprayed onto hot engine component s may start a fire. 2. Remove the cap over the fuel rail test port on the front of the driver’s side fuel rail . 3. Bleed off the fue ...
-
Holley 05177NOS - page 14
14 Figure 10 Microsw itch Mounting Locatio n—shown at idle. Figure 11 Microsw itch Mounting Locatio n—shown at W.O.T. ...
-
Holley 05177NOS - page 15
15 2.9 Preparing for Operation 1. Start the vehicle . 2. Open the nit rous bottle valve. There should be no chan ge in the engine idle speed or exhaust tone. If either change is noted, refe r to Appendix A, Troubleshooting Guide . 3. Inspect the nitrous lines and fittings for leaks. 4. ENJOY!!! Chapter 3 Tuning Suggestions Your NOS Kit Numb er 0517 ...
-
Holley 05177NOS - page 16
16 Too much ni trous flow. Reduce nit rous jetting. Inadequate fu el delivery due to: Plugged fuel filter Inspect fuel filter. Clean or replace f ilter. Crimped fuel line . Inspect fuel line. Replace c rimped line. Engine detona tes heavily when s ystem is activated. W eak fuel pump. Ins tall fuel pressure gauge, such as NOS P/N 15931 NOS in the fu ...
-
Holley 05177NOS - page 17
17 Nitrous Press ure Gauges (P/N 15910NOS) measu re from 0-1500 psi (although recomm ended level is 900-950 psi) and are essential in mon itoring the bottle. The Quick Rele ase Hinged Aluminum Bracke t (P/N 14140NOS) is available fo r 10 lb. and 15 lb. bottles. P/N 14147 NOS is available for th e carbon fiber bottle. P/ N 16030NOS P/N 15910 NOS P/N ...
-
Holley 05177NOS - page 18
18 NOS Techni cal Support Phone: 1-270- 781-9741 Toll-Phone: 1-866-GO HOLLEY Fax: 1- 270-781-9772 For online hel p, please check the Tech Service se ction of our website : www .holley.com A5177-SNOS Date: 7-2-07 ...
¿Tienes una pregunta acerca de Holley 05177NOS?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Holley 05177NOS, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Holley 05177NOS probablemente compartirá una forma de solucionarlo.