-
Generac 005818-0 - page 1
EcoGen 6kW Generator Owner's Manual L I S T E D C U S Model 005818-0 ...
-
Generac 005818-0 - page 2
Introduction .............................................. 1 Read This Manual Thoroughly ................................................1 Safety Rules ............................................. 1 Contents ...............................................................................1 Operation and Maintenance.................................. ...
-
Generac 005818-0 - page 3
1 INTRODUCTION Thank you for purchasing this compact, high per formance, air -cooled, engine-driven generator . It is designed to supply electrical power to operate an inver ter/batter y charger as a component in an off-grid power solution. This unit is factor y installed in an all-weather , metal enclosure and is intended exclusively for outdoor i ...
-
Generac 005818-0 - page 4
2 !"#$%& "'()(& !*+,-.& /01,!& 234(5#66%& 7(584(& 9:)"3669:;<& 8=(43"9:;& 84& )(4 >929:;& "'9)& (?#9=@(:"A& B(28@(& 53@96934& C9"'& "'9)& Owner&s Manual & 3:$& C9"'& "'(& #:9" ...
-
Generac 005818-0 - page 5
3 !" #$% &' () *&+ $,+ #- '. (- &+$/ )0 #$1 %, /2$. #3 4( .# 5$'" #$6 .& 7# $&*0 $#8 '# .*& +$ 9$ #+ #- '. (- &+ +:$ -) *04 -' (; #$ <&. '5 $ ) 6$ ' "# $ =# *# .& ') .$ ')$ >#$ -) **# -' #0 $ ' )$ &* $& <<. ); #0 $#& ...
-
Generac 005818-0 - page 6
n Only qualified electricians or contractors should attempt such installations, which must comply strictly with applicable codes, stan- dards and regulations. 1.1 UNP ACKING/INSPECTION !" #$%& '()*+,-(./&+*%$"'001& -(2)$+#& #3$&+4(#$(#2& "4%& 5*6*.$7 83-2& 2#*(591&.$($%*#4%& 2$#&- ...
-
Generac 005818-0 - page 7
5 1.4 THE GENERA TOR Figure 1.1 * 6kW , V -twin, GT -530 Engine (door removed) Air Filter External Oil Fill/Dipstick Control Panel Data Label Circuit Breaker Fuel Inlet (back) Fue l Regulator Composite Base Battery Compartment Oil Filter Exhaust Enclosure Engine Oil Dipstick Engine Oil Fill Figure 1.2 * Data Label Sample 1.5 SPECIFICA TIONS 1.5.1 G ...
-
Generac 005818-0 - page 8
!"#$ $ %&'($ )'*&+)','-./$ 0-1$ )'23,,'-10 .+3-/ This unit uses a LP vapor withdrawal system only . This type of system uses the vapors for med above the liquid fuel in the storage tank. Recommended fuels should have a Btu content of at least 2,520 Btus per cubic foot for LP gas. Ask the fuel supplier for ...
-
Generac 005818-0 - page 9
7 !"#$%&&'$()' *"+$',()-)'#)-.+/)#',+&&' "0$'1)' %22)/$)3'0-' 01#$- */$)34' 5' +"/&*3+"6'/0"/)%&)34' *"3)-6-0*"3'0-' /0.)-)3'#)- .+/)#' #*/('%#' )&)/$-+/%&4'2*)&4' ...
-
Generac 005818-0 - page 10
8 General Information Figure 1.4 + Installation Guidelines 18 inches Minimum Distance 36 inches 36 inches 36 inches 60 inches 60 inches Existing W all No windows or openings in the wall permitted within 5 feet from any point of the generator . To p o f G e n e r a t o r 60” Minimum 60” Recommended Minimum From Ends 18 inches Minimum Generator C ...
-
Generac 005818-0 - page 11
9 !"!#$ %& ' '()*$ )(+,-)(.(/'0 See the Specifications section for cor rect batter y size and rating. !"!!$ %& ' '()*$ -/0' &11& '-2/ Fill the batter y with the proper electrolyte fluid if necessar y and have the batter y fully charged before installing it. Before installing and connectin ...
-
Generac 005818-0 - page 12
10 ! "#! $%&#! '(#!%')*)'+! ,-.#&! $%,,*+! )$! '%&/#0! -11! 2/0! '(#!3456! 1%$#! )$! -8#0! 1&-7! '(#! 9#/: #&2'-&! ;-/'&-*!,2/#*<! -&! $,2&=)/9! 72+! -;;%&! 2'! '(#! >2''#&+!,-$'$! 2$! '(#! ;2>*#$! 2&#! ...
-
Generac 005818-0 - page 13
11 ACTIVA TION CHART CHOOSE LANGUAGE TROUBLESHOOTING !"#$%&'()*&+#,( -#*( .))/0(1*'#( 23( #453%%( 23(+*#"5*+( %&67 89&8*:( ; 5*##( <=><)( 23(#*%*42: ?@( 2A*(B5368( %&689&8*( "#(4A3#*6C( "2( 4&6( D*( 4A&68*+( %&2*5(9#"68( 2A*( E*+"2F(G*69: !"#$%&'( ) * ...
-
Generac 005818-0 - page 14
12 !"# $%&'# (&) *+,'# *%+*# ,'-.*# /01*+2&# ,3# (04-+*,51&# 6,*%# 5+**&) 7# (%+)2&)#)+*,'238# *.) '#9::# *%&# -06&)# 3.--17#*0# *%&# 2&'&)+*0) " ;"# 9'# *%&# 2&'&)+*0)# -+'&18# 3&*# *%&# <.*0=9>>=# ?+'.+1# 3 ...
-
Generac 005818-0 - page 15
13 Operation Figure 3.1 + Generator Control P anel Escape MAIN FUSE AUT O OFF MANUAL 7.5 AMP Enter !"#$% &'()*% "#+,(% -"% #&% *.,% /,$,(0*#( 1% *.,% 2')"304% '$*,( &05,% +'33% 6,/'$% 0$% '$)*0330*'#$% 0))')*0$*7% 8.,% 0))')*0$*% +'33% "(#9"*% *.,% -),(% *#% ...
-
Generac 005818-0 - page 16
14 !"#$%&$'( !)$*&+&)$, The following notes apply during cranking cycle. 1. Star ter motor will not engage within five (5) seconds of the engine shutting down. 2. The fuel output will not be energized with the star ter . 3. The star ter and magneto outputs will be energized together . 4. Once the star ter is energized the cont ...
-
Generac 005818-0 - page 17
15 High Engine T emperature (Shutdown Alarm 7 Auto Reset) A 10 second delay on star t-up and one (1) second delay before shutdown. Auto reset when the condition clears and restar t the engine if a valid star t signal is still present. This switch>s contacts (Figure 3.4) close if the temperature should exceed approximately 140° C (284° F), init ...
-
Generac 005818-0 - page 18
16 !"#$ %&'( !"#$ %&'$ ()*$ +,-#$ ./$ 0"#$ 1./02.3$ *(/#3$ *2.0#10-$ 0"#$ 45$ 1./02.3$ 1621,60$ (7(6/-0$ .8#23.(9$ :;67,2#-$ <&=$ (/9$ <&>?&$ !"6-$ +,-#$ 6-$ @62#9$ 6/$ -#26#-$ @60"$ 0"#$ A(00#2 B$ .,0*,0$ 3#(9$ 0.$ 0"#$ *(/#3&$ C+$ 0"6-$ +,-#$ #3#D )#/0$"( ...
-
Generac 005818-0 - page 19
17 4.3.3 OIL & OIL FIL TER CHANGE PROCEDURE T o change the oil, proceed as follows: 1. Star t the engine by moving the AUTO/OFF/MANU AL switch to MANUAL and r un until it is thoroughly warmed up. Then shut OFF the engine by moving the switch to the OFF position. 2. Immediately af ter the engine shuts OFF , pull the oil drain hose (Figure 4.1) f ...
-
Generac 005818-0 - page 20
18 4.6 BA T TERY MAINTENANCE !"#$ %&''#()$ *"+,-.$ %#$ /0*1#2'#.$ 1#($ '"#$ 34#(5/2#$ 42"#.,-#3$ *#26 '/+07$!"#$ 8+--+9/0:$ 1(+2#.,(#$ *"+,-.$%#$ 8+--+9#.$ 8+($ /0*1#2'/+0; <7$ =0*1#2'$ '"#$ %&''#( )$ 1+*'*$ &0.$ 2&%-#*$ 8+($ '/:"& ...
-
Generac 005818-0 - page 21
19 !"#$% &'(&#% )(#'*'$)#% +,% )-* *#)./% "-(0% ."#% 1+&-.% 2'((% ,.30% +$% 1(')#% 4+."% ."#% '((#$% 4*#$)"% '$0% .+5".#$% ."#% *-)6#*% '* 7% 8'7% $3.9% :+5".#$% ."#% 8'7% $3.% .-% ;<=% +$>(2,9% .-*?3#9% @A .#*% .+5".#$+$5% .&q ...
-
Generac 005818-0 - page 22
20 4.11.2 RETURN TO SERVICE ! "# $%&'$(# &)%# '(*&#&"# +%$ ,*-%# ./ &%$# +&"$.0%1#2$"-%%3# .+# /"44"5+6 78# 9 %$*/:# &).&# '&*4*&:# 2"5%$# *+# &'$(%3# "//# .(3# &).&# &)%# ; <!=>=??> @;A<;B#+5*&-)# *+#+%&# &&qu ...
-
Generac 005818-0 - page 23
21 Maintenance 4.12 SERVICE SCHEDULE A T TENTION : It is recommended that all service work be performed by the nearest Dealer . SYSTEM/COMPONENT PROCEDURE FREQUENCY X = Action R = Replace as Necessar y * = Notif y Dealer if Repair is Needed. Inspect Change Clean W = Weekly M = Monthly Y = Y early FUEL Fuel lines and connections* XM L UBRICA TION Oi ...
-
Generac 005818-0 - page 24
22 T roubleshooting 5.1 TROUBLESHOOTING GUIDE Problem Cause Correction !"#$#%&'%#$ ('))$ %*+$ ,-.%/0$ 10$ 2 34#$ 5)*(%0$ 10$ $ 6*- -#,+$ 4"*- +$ ,'-,3'+$,*%7'+'*%8$ -#9).,#$ :0;<$ =34#$'%$ &#%#-.+*-$ ,*%+-*)$9.%#)0 $ >0$ ?**4#8$,*- -*7#7$ *-$7#=#,+'@#$ >0$ !'&"+#%8$,)# ...
-
Generac 005818-0 - page 25
23 Appendix 6.1 MENU SYSTEM NAVIGA TION T o get to the MENU, use the "Esc" key from any page. It may need to be pressed many times before getting to the menu page. The currently selected menu is displayed as a flashing word. Navigate to the menu required by using the +/- keys. When the menu required is flashing, press the ENTER key . Depe ...
-
Generac 005818-0 - page 26
24 Appendix MAIN MENU RUN LOG ALARM LOG HISTOR Y STA TUS COMMAND ST ATE VERSIONS DISPLA Y GENERA TOR FREQUENCY ENGINE HOURS ENGINE RPM BA TTERY V OL T AGE DEBUG INPUTS OUTPUTS DISPLA YS EDIT CONTRAST LANGU AGE TIME/DA TE EXERCISE TIME/SPEED ESC Press the “ESCAPE” key to jump back up through the menu levels. + / - Use the “+/-” key to naviga ...
-
Generac 005818-0 - page 27
Generac ® Pow er Systems, Inc. 25 25 Drawing No. 0J1320-A Installation Diagram ...
-
Generac 005818-0 - page 28
26 Generac ® P ower Systems, Inc. 26 Installation Diagram Drawing No. 0J1320-A ...
-
Generac 005818-0 - page 29
Generac ® Pow er Systems, Inc. 27 27 Drawing No. 0J1320-A Installation Diagram ...
-
Generac 005818-0 - page 30
28 Generac ® P ower Systems, Inc. 28 28 ENGINE CONTROLLER VOLTAGE REGULATOR (AVR) ENGINE START BATTERY CHARGER 12 VOLT ENGINE START BATTERY ALTERNATOR BATTERY CHARGER INVERTER TWO-WIRE START BATTERY VOLTAGE SENSING AC DISTRIBUTION PANEL 120/240V DC DISTRIBUTION PANEL 12V/24V/48V BATTERY 12V/24V/48V INVERTER/CHARGER GENERATOR HOUSE HOUSE LOADS HOUS ...
-
Generac 005818-0 - page 31
29 Drawing No. 0J1323-C Oil Make-up System ...
-
Generac 005818-0 - page 32
30 Notes ...
-
Generac 005818-0 - page 33
31 Notes ...
-
Generac 005818-0 - page 34
32 FOR GENERA TORS 10KW AND BELOW !"#"$%&' "()**)+,' -+,.$+&' /%$$%,.0' *. % ."(",. 0+1$'/%$$%,.0' $)23.*' %,#' +4&)2% .)+,* The United States Environmental Protection Agency (EP A) and Generac Power Systems, Inc. (Generac) are pleased to explain the Emission Control Syste ...
-
Generac 005818-0 - page 35
33 EMISSION CONTROL SYSTEM WARRANTY !"#$$#%&'(%&)*%+' ,-$)."' /0**0&)-'1!( ,'20* *0&)-3' 4%*'.56#7".&)' 6$#&8'$"0++' $70*9:#8&#).;' .&8#&.$< 103' ' =77+#>0?#+#)-<'@A#$' 20* *0&)-'$A0++' 077+-&apos ...
-
Generac 005818-0 - page 36
Part No. 0J0984 Revision A (10/14/10) Printed in U .S.A. W arranty GENERAC POWER SYSTEMS LIMITED W ARRANTY FOR "ECO GEN AIR-COOLED A UTOMATIC ST ANDBY GENERA TORS" !"# $ %$ &' #( ") $ " *$ + ,# '' $ - ./ $ 0' %# 1$ " #$ 23 33 $ , "4 #1 5$ 6 ,( 7, '8 ' #$ 7 "9 '1 $ *( #1 ...
¿Tienes una pregunta acerca de Generac 005818-0?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Generac 005818-0, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Generac 005818-0 probablemente compartirá una forma de solucionarlo.