Español dropdown-ico

Manual de instrucciones Johnson Controls AL6B SERIES

18 de páginas 0.54 mb
Descargar

Pasar a la página of 18

Summary
  • Johnson Controls AL6B SERIES - page 1

    562156-UIM-A-0610 R-410A OUTDOOR SPLIT -SYSTEM AIR CONDITIONING MODELS: 16 SEER - CZF / AC6B / AL6B SERIES 2 TO 5 T ONS INSTALLATION MANUAL LISTED ISO 9001 Certified Quality Management System T ABLE OF CONTENTS GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 SAFETY . . . . . . . . . . . . . . . . . . . . . . ...

  • Johnson Controls AL6B SERIES - page 2

    562156-UIM-A-0610 2 Johnson Controls Unitary Products INSPECTION As soon as a unit is r eceived, it should be inspected for possible dam- age during transit. If damage is evident, th e extent of the damage should be noted on the carrier ’s delivery receipt. A sep arate request for inspection by the carrier ’ s agent sh ould be made in writing. ...

  • Johnson Controls AL6B SERIES - page 3

    562156-UIM-A-0610 Johnson Controls Unitary Produ cts 3 GROUND IN ST ALLA TION The unit may be installed at ground level on a solid b ase that will not shift or settle, causing strain on t he refrigerant lines and possible leaks. Maintain the clearances shown in Figure 1 "T ypical Installation with Required Clearances" and install the unit ...

  • Johnson Controls AL6B SERIES - page 4

    562156-UIM-A-0610 4 Johnson Controls Unitary Products The outdoor condensing unit must be connected to the indoor evapora - tor coil using field supplied refrigerant grade copper tubing that is inter- nally clean and dry . Units should be installed only with the tubing sizes for approved system combinations as specified in tabular data sheet. The c ...

  • Johnson Controls AL6B SERIES - page 5

    562156-UIM-A-0610 Johnson Controls Unitary Produ cts 5 2. Remove the cap and Schrader core from both the liquid and vapor service valve service ports at th e outdoor unit. Connect low pressure nitrogen to the liquid line service port. 3. Braze the liquid line to the liquid valve at the outdoor unit. Be sure to wrap the valve body with a wet rag. Al ...

  • Johnson Controls AL6B SERIES - page 6

    562156-UIM-A-0610 6 Johnson Controls Unitary Products FIELD CONNECTIONS POWER WIRING 1. Install the proper size weather proof disconnect switch outdoors and within sight of the unit. 2. Remove the screws at the bottom of the corner cover . Slide corner cover down and remove from unit. See Figure 5 "T ypical Field Wir- ing". 3. Run power w ...

  • Johnson Controls AL6B SERIES - page 7

    562156-UIM-A-0610 Johnson Controls Unitary Produ cts 7 CFM SELECTION BOARD SETTINGS For proper system operation the CFM Selection Board jumpers must be set properly . Refer to the T ech Guide for the recommende d air flow settings for each size condensing unit and matchu p. Set the cooling speed per the instruct ions for the air handler or furnace ...

  • Johnson Controls AL6B SERIES - page 8

    562156-UIM-A-0610 8 Johnson Controls Unitary Products For additional connection diagrams for a ll UPG equipment refer to “Low V olt age System Wiring” document available online at www . upgnet.com in the Product Catalog Section. FIGURE 10: Thermost at Wiring – Single Stage Air Conditioner (with AC control) – PSC Air Handler 6LQJOH6WDJH? ...

  • Johnson Controls AL6B SERIES - page 9

    562156-UIM-A-0610 Johnson Controls Unitary Produ cts 9 FIGURE 1 1: Thermostat Wiring – Single S tage Air Conditioner (with AC control) – VS Air Handler 09 $9 ,'02'(/ 6 -XPSHUPXVWE HVHW WR³*$6(/(&´ < )LUVW6WDJH &RPSUHVVRU : 6HFRQG6WDJH+HD W * )DQ 67+683E 7+(502 67$7 ...

  • Johnson Controls AL6B SERIES - page 10

    562156-UIM-A-0610 10 Johnson Controls Unitary Products FIGURE 12: Thermostat Wiring – Single S tage Air Conditi oner (with AC control) – Modulating F urnace </&/& 7 /& 7& </&& ,'02'(/ 6 700 <00 <0/0 -XPSHUPX ...

  • Johnson Controls AL6B SERIES - page 11

    562156-UIM-A-0610 Johnson Controls Unitary Produ cts 11 SECTION VI: SY STEM CHARGE 1. The factory charge in the outdoor unit includes enough charge for the unit, a 15 ft. line set and the smallest rated indoor coil match-up. Some indoor coil matches may r equire additional charge. See tabu- lar data sheet provided in unit literature packet for char ...

  • Johnson Controls AL6B SERIES - page 12

    562156-UIM-A-0610 12 Johnson Controls Unitary Products 3. If the coil needs to be cleaned , use clean water to wash dust, dir t, and debris from outdoor condensing coil. 4. Refer to the furnace or air handler instructions for filter a nd blower motor maintenance. 5. The indoor coil and drain pan should be inspected and clea ned reg- ularly to preve ...

  • Johnson Controls AL6B SERIES - page 13

    562156-UIM-A-0610 Johnson Controls Unitary Produ cts 13 LED DIAGN OSTIC INDICA TORS The control includes two LED’s that display diagnostic information. LED1 is red and LED2 is green. These LED’s are used to display oper- ational mode, fault information. A third LED, LED3 is used to display status information. LED3 is yellow . These LED’s are ...

  • Johnson Controls AL6B SERIES - page 14

    562156-UIM-A-0610 14 Johnson Controls Unitary Products F AUL T CODE DISPLA Y The control will display any fault cod e that is currently active using the LED’s. The control will display the fault code, pause two seconds, and display the fault again. The control will continue the fault code display until the condition that caused the f ault code no ...

  • Johnson Controls AL6B SERIES - page 15

    562156-UIM-A-0610 Johnson Controls Unitary Produ cts 15 COOLING OPERA TION First-St age Cooling Operation During first-stage cooling operation, the con trol will receive a thermostat signal at the Y1 terminal. The contr ol will energize the M compressor output terminal. This signal energi zes the coil on the compressor con- tactor causing the compr ...

  • Johnson Controls AL6B SERIES - page 16

    562156-UIM-A-0610 16 Johnson Controls Unitary Products SECTION IX: WIRING DIAGRAM FIGURE 13: Wiring Diagram (2 - 4 T on) ...

  • Johnson Controls AL6B SERIES - page 17

    562156-UIM-A-0610 Johnson Controls Unitary Produ cts 17 FIGURE 14: Wiring Diagram (5 T on) ...

  • Johnson Controls AL6B SERIES - page 18

    Subject to change without not ice. Published in U.S.A. 562156-UIM-A-0610 Copyright © 2010 by Johnson Controls, Inc. All rights reserved. Supersedes: Nothing Johnson Contro ls Unitar y Prod uc t s 5005 Y ork Driv e Norman, OK 73069 NOTES ...

Fabricante Johnson Controls Categoría Air Conditioner

Los documentos del dispositivo Johnson Controls AL6B SERIES que obtenemos del fabricante se pueden dividir en varios grupos. Entre ellos están::
- dibujos técnicos Johnson Controls
- manuales de instrucciones AL6B SERIES
- hojas de producto Johnson Controls
- folletos informativos
- o etiquetas energéticas Johnson Controls AL6B SERIES
Todos son importantes, pero lo más importante desde el punto de vista del usuario de un dispositivo lo encontraremos en el manual de instrucciones Johnson Controls AL6B SERIES.

Un conjunto de documentos determinado como manual de instrucciones se divide también en tipos más detallados, tales como: instrucciones de montaje Johnson Controls AL6B SERIES, instrucciones de servicio, instrucciones cortas o instrucciones de usuario Johnson Controls AL6B SERIES. Dependiendo de la situación debes buscar el documento que necesitas. En nuestra página puedes consultar el manual de instrucciones más popular del producto Johnson Controls AL6B SERIES.

Manuales de instrucciones parecidos

El manual de instrucciones del dispositivo Johnson Controls AL6B SERIES, ¿cómo debería ser?
El manual de instrucciones, también determinado como el manual de usuario o simplemente instrucciones, es un documento técnico que tiene como objetivo ayudar a los usuarios a utilizar Johnson Controls AL6B SERIES. Las instrucciones normalmente las realiza un escritor técnico pero en un lenguaje comprensible para todos los usuarios de Johnson Controls AL6B SERIES.

El manual de instrucciones completo de Johnson Controls debe contener unos elementos básicos. Una parte de ellos es menos importante, como por ejemplo: la portada / la página principal o las páginas de autor. Sin embargo, lo demás debe facilitarnos la información más importante desde el punto de vista del usuario.

1. Introducción y pistas sobre cómo orientarse con el manual Johnson Controls AL6B SERIES - Al principio de cada manual se deben encontrar las indicaciones acerca de la manera de usar un manual de instrucciones. Debe contener información sobre dónde encontrar el índice Johnson Controls AL6B SERIES, preguntas frecuentes o problemas más comunes – son los apartados más buscados por los usuarios de cada manual de instrucciones.
2. Índice - listados de todos los consejos acerca de Johnson Controls AL6B SERIES que encontraremos en el documento
3. Consejos de uso de las funciones básicas del dispositivo Johnson Controls AL6B SERIES - que deben facilitarnos los primeros pasos durante el uso de Johnson Controls AL6B SERIES
4. Troubleshooting - una secuencia sistematizada de acciones que nos ayudará a diagnosticar los problemas más importantes con Johnson Controls AL6B SERIES
5. FAQ - las preguntas frecuentes
6. Datos de contacto Información acerca de cómo encontrar los datos de contacto del fabricante / servicio de Johnson Controls AL6B SERIES en cada país si no somos capaces de solucionar el problema por nuestra cuenta.

¿Tienes una pregunta acerca de Johnson Controls AL6B SERIES?

Utiliza el formulario que se encuentra abajo

Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Johnson Controls AL6B SERIES, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Johnson Controls AL6B SERIES probablemente compartirá una forma de solucionarlo.

Copia el texto de la imagen

Captcha
Nueva imagen

Comentarios (0)