-
DCS DCS-DRH48N - page 1
PROFESSIONAL DEL REY HEA TER Use a nd Ca re Gu id e and Installation Instruc tions MODELS: DCS-DRH48N ...
-
DCS DCS-DRH48N - page 2
Thank you for selecting DCS Professional Del Rey Heater . Because of this appliance ’ s unique features we have dev eloped this Use and Installation Guide. It contains valuable information on how to properly operate and maintain your new applianc e for years of safe and enjoyable use . To help serve you better , please fill out and submit your Ow ...
-
DCS DCS-DRH48N - page 3
TA B L E O F CO N T ENTS 2 SAFET Y PRACTICES AND PRECA UTIONS ...................................................................................................3-4 CLEARANCES / INST ALLA TION SPECIFICA TIONS .................................................................................5-8 INST ALLA TION ......................................... ...
-
DCS DCS-DRH48N - page 4
When properly cared for , your Del Rey Heater will giv e safe, reliable service for many years. How ever , extreme care must be used since the heater produces int ense heat and can increase accident potential. When using this appliance basic saf ety prac tices must be follo wed, including the f ollowing: Read this Care and Use Guide careful ...
-
DCS DCS-DRH48N - page 5
Children should not be left alone or unattended in an area where the heater is being used . Never allow them to sit, stand or play on or around the heater at an y time. When in use, por tions of the heater get hot enough to cause sever e burns. Never let clothing , or other flammable materials come in contact with or too close to any part o ...
-
DCS DCS-DRH48N - page 6
0 0 INST ALLA TION MINIMUM CLEARANCES T O COMBUSTIBLE MA TERIAL. CLEARANCES/INST ALLA TION SPECIFICA TIONS 5 21" 7-3/4" 10-1/4" Side View FLOOR On Each Side (installer supplied) 14" 96" (MIN) (MIN) (MIN) 1/2" Conduit Drip Leg (installer supplied) Gas Shut-off (installer supplied) Gas Pipe (installer supplied) Utilize 2 ...
-
DCS DCS-DRH48N - page 7
CLEARANCES 6 30 0 INST ALLA TION MINIMUM CLEARANCES T O COMBUSTIBLE MA TERIAL. Note: Mounting channels can be hacksawed 13” for use in 30 0 installations. 10" SIDE VIEW 23" 30 0 max. 4 bolts per brack et Surface Combustible (installer supplied) FLOOR 96" 1/2" Conduit (installer supplied) Gas Shut-off Va l v e (installer suppli ...
-
DCS DCS-DRH48N - page 8
CLEARANCES 7 0 0 INST ALLA TION (MINIMUM CLEARANCES T O NON-COMBUSTIBLE MA TERIAL). FLOOR 96" Four Bolts Per Brack et SIDE VIEW Surface Non Combustible 1/2" Conduit (installer supplied) Gas Shut-off Va l v e (installer supplied) Gas Pipe (installer supplied) Utilize 2 bolts (min) per brack et. Drip Leg min. Mak e sure heater is lev el (se ...
-
DCS DCS-DRH48N - page 9
CLEARANCES 8 30 0 INST ALLA TION MINIMUM CLEARANCES T O NON-COMBUSTIBLE MA TERIAL. Utilize 2 bolts (min) per brack et. SIDE VIEW 1/2" Conduit 30 0 Four Bolts Per Side FLOOR 96" min Surface Non Combustible Gas Shut-off V alve Drip Leg Gas Pipe (installer supplied) (installer supplied) (installer supplied) 30 0 max. ...
-
DCS DCS-DRH48N - page 10
INST ALLA TION 9 INST ALLA TION: T he Del Rey Heater provides r adiant warmth *indoors (commercial applications only) or outdoors with a powerful 58,000 Btu/hr natural gas. All units are equipped with hot surface ignition and 100% shutoff valv e for safety . Del Rey Heaters to be installed in Aircr af t Hangers must be installed in accordance with ...
-
DCS DCS-DRH48N - page 11
INST ALLA TION 10 Do not locate either the gas or electrical supply line directly over the flue outlet of the heater . Electrical supply line shortage and / or control overheating may occur . The heater must be installed in a location such that it is accessible for servicing and have no restriction of air flow to the air inlet of the heat ers casin ...
-
DCS DCS-DRH48N - page 12
LEAK TESTING 11 IMPORT ANT : VENTILA TION A minimum building ventilation rat e of 4 CFM per 1,000 BTU’ s of installed heater input must be provided . This ra te of ventilation may be obtained through either gra vity or mechanical ventilation of the building. In conjunction with building ventilation system, adequate fresh air into the building mus ...
-
DCS DCS-DRH48N - page 13
LIGHTING/OPERA TION INSTRUCTIONS 12 LIGHTING INSTRUCTIONS Upon installation of the heater and completion of the gas line and electrical supply to each heater , f ollow the steps belo w for Lighting Instructions. Lighting instructions are also provided on the contr ol panel of the heater . Tu rn gas and power to “ON” .T he igniter should light w ...
-
DCS DCS-DRH48N - page 14
CAR E & C L EANING / BASIC TROUBLESHOO TING 13 CARE AND CLEANING To k eep your Del Rey Heater in maximum performance, we r ecommend the following to be perform annually . 1. With an air hose regulated t o 30 psig, blo w off any dust and dir t that has accumulated around the burner and inside the control compartment of the heater . Proper eye pr ...
-
DCS DCS-DRH48N - page 15
SERVICING 14 REMOV AL OF BURNER Tu rn off gas and electrical before attempting any service to this appliance. Heater may be serviced by f ollowing instructions below: a. Remove the f our screws on the control service panel. b. Remove the hex nut that is holding the orific e fitting to the infrared burner ’ s bracket. c. Remove the burner windscr ...
-
DCS DCS-DRH48N - page 16
GAS V AL VE REPLA CEMENT 15 Tu rn off gas supply . Tu rn off electrical supply . Disconnect gas & electrical supply . Remove unit fr om hangers. Remove scr ews securing the rear panel and remove the panel. U se a 7/8” open end wrench to hold orifice nut. Remove the existing black pipe and install it in the new v al ...
-
DCS DCS-DRH48N - page 17
GAS V AL VE REPLA CEMENT 16 Reinstall (4) screws securing valv e to case. Re-connect leads to valve . Be sure valv e switch is on (in the up position). T he transformer must be mount ed outside of unit to protect it from the heat and ensure long ser vice life. Refer to page 10. Do not install transformer inside unit. ...
-
DCS DCS-DRH48N - page 18
HEA TER P ARTS LIST 17 ITEM DESCRIPTION P ART NO. 1) W all Plate R/H 22019 2) Mounting Channel 22014 3) Body Plate R/H 22012 4) Screws 15001-26 5) Back Panel 22002 6) W all Plate L/H 22019 7) Mounting Channel 22014 8) Body Plate L/H 22012 9) Collector Box 22016 10) Mini Ingiter 16325 11) Con trol V alve 18270 12) Ignition Module Co ver 22022 13) Re ...
-
DCS DCS-DRH48N - page 19
WIRING DIA GRAM 18 120 V AC 60 Hz 120 V A C 60 Hz 24 V A C Ground MINI IGNITER NO TE: 1. PURPLE, FLAME SENSE (ELECTR ODE SENSOR) 2. GREEN, GR OUND 3. BLUE, T O V AL VE HO T (LOC A TION 1) 4. ORANGE, THERMOST A T 5. KEY 6. BLACK, L1-24 V A C 7. RED IGNITER ELECTR ODE SENSOR 969 FIG09.EPS V alve 2 1 3 4 6 2 1 7 IGNITION MODULE ...
-
DCS DCS-DRH48N - page 20
19 WIRING SCHEMA TIC BK WT YELL OW YELL OW BK BL RED PURPLE ...
-
DCS DCS-DRH48N - page 21
20 WA R R A N T Y LENGTH OF W ARRANT Y T his warranty applies to appliances used in residential and c ommercial applications. One (1) Y ear F ull par ts and Labor Cov ers the entire product. Fi ve (5) Y ear limited warranty on all stainless steel components (not including surface corrosion and discoloration). DCS WILL CO VER: All repair labor and p ...
-
DCS DCS-DRH48N - page 22
21 SERVICE HOW T O OBT AIN SERVICE: F or warranty ser vice, please contac t your local service provider or DCS Cust omer Care Center at (888) 281-5698, Monda y thru Friday , 6:00 am – 4:30 pm PST . Before y ou call, please have the f ollowing inf ormation ready : Model Number Se rial Number Date of installation A brief description ...
-
DCS DCS-DRH48N - page 23
NO TES 22 ...
-
DCS DCS-DRH48N - page 24
NO TES 23 ...
-
DCS DCS-DRH48N - page 25
NO TES 24 ...
-
DCS DCS-DRH48N - page 26
5800 Skylab Road, Huntington Beach, CA 92647 T el: 714.372.7000 • F ax: 714.372.7001 C ustomer Care C enter: (888) 281-5698 www .dcsappliances.com As produc t improvement is an ongoing pr ocess at DCS, we r eserve the right to change specifications or design without notice. P/N 10955 Rev . B Litho in USA 01/2004 ...
¿Tienes una pregunta acerca de DCS DCS-DRH48N?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con DCS DCS-DRH48N, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con DCS DCS-DRH48N probablemente compartirá una forma de solucionarlo.