Español dropdown-ico

Manual de instrucciones Baldor PG 6000

26 de páginas 0.29 mb
Descargar

Pasar a la página of 26

Summary
  • Baldor PG 6000 - page 1

    PG 6000 Generator Installation & Operating Manual 8/06 MN2418 ...

  • Baldor PG 6000 - page 2

    W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Engine exhaust from this product contains chemicals known to the state of California to cause cancer , birth defects and other reproductive harm. W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Battery posts, terminals and related accessories are known to the state of California to cause cancer , birth de ...

  • Baldor PG 6000 - page 3

    T able of Contents T able of Contents i MN2418 Section 1 Product Safety Information 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Safety Notice 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Baldor PG 6000 - page 4

    ii T able of Contents MN2418 ...

  • Baldor PG 6000 - page 5

    Section 1 Product Safety Information Product Safety Information 1-1 MN2418 Safety Notice Be sure that you are completely familiar with the safe operation of this equipment. This equipment may be connected to other machines that have rotating parts or parts that are controlled by this equipment. Improper use can cause serious or fatal injury . Alway ...

  • Baldor PG 6000 - page 6

    1-2 Product Safety Information MN2418 Precaution Statements Used In This Manual There are three classifications of precautionary statements used in this manual. The most critical is a W ARNING statement, then the Caution statement and the least critical is the Note statement. The usage of each statement is as follows: W ARNING: Indicates a potentia ...

  • Baldor PG 6000 - page 7

    Product Safety Information 1-3 MN2418 Operation W arning Statements Continued W ARNING: Be sure that you understand how to stop the engine quickly in case of an emergency situation. Become familiar with the controls and safety systems provided with this generator set. W ARNING: Always wear safety glasses with side shields and hearing protection whe ...

  • Baldor PG 6000 - page 8

    1-4 Product Safety Information MN2418 W arning Statements Continued Burn W ARNING: Parts of this generator are extremely hot during and after operation. T o prevent severe burns, do not touch any part of the generator until you have first determined if the part is hot. Wear protective clothing and after use allow sufficient time for parts to cool b ...

  • Baldor PG 6000 - page 9

    Product Safety Information 1-5 MN2418 W arning Statements Continued Maintenance W ARNING: Before servicing the generator set, be sure to disconnect the spark plug(s) to prevent accidental engine starting. W ARNING: Before cleaning, inspecting, repairing, refueling or performing any maintenance to the generator set, always be sure the engine has sto ...

  • Baldor PG 6000 - page 10

    1-6 Product Safety Information MN2418 ...

  • Baldor PG 6000 - page 11

    Section 2 General Information General Information 2-1 MN2418 Thank you for purchasing your Baldor Generator Set. This manual contains information you need to safely and efficiently install and operate your generator set. During the preparation of this manual every effort was made to ensure the accuracy of its contents. This manual describes only ve ...

  • Baldor PG 6000 - page 12

    2-2 General Information MN2418 ...

  • Baldor PG 6000 - page 13

    Section 3 Receiving & Installation Receiving & Installation 3-1 MN2418 Receiving & Inspection When you receive your generator , there are several things you should do immediately . 1. Observe the condition of the shipping container and report any damage immediately to the commercial carrier that delivered your system. 2. V erify that th ...

  • Baldor PG 6000 - page 14

    3-2 Receiving & Installation MN2418 Physical Location The mounting location of the system is important. It should be installed in an area that is protected from direct harmful gases or liquids, dust, metallic particles, shock and vibration. It can only be installed in an outdoor location so the exhaust fumes are vented to the atmosphere. This s ...

  • Baldor PG 6000 - page 15

    Receiving & Installation 3-3 MN2418 Electrical Connections All load connections are made at the panel using electrical cords with the proper mating plug for the receptacle being used. More than one receptacle can be used as long as the total load does not exceed the continuous rating of the generator . W ARNING: Never connect this generator to ...

  • Baldor PG 6000 - page 16

    3-4 Receiving & Installation MN2418 Frame Ground Connection W ARNING: Be sure the system is properly grounded before applying power . Do not apply AC power before you ensure that grounds are connected. Electrical shock can cause serious or fatal injury . NEC requires that the frame and exposed conductive surfaces (metal parts) be connected to a ...

  • Baldor PG 6000 - page 17

    Section 4 Operation Operation 4-1 MN2418 Operator Control Panel The Operator Panel is shown in Figure 4-1. Figure 4-1 Operator Panels 120V AC 20A 120V AC 20A 240V AC 22A AC Circuit Breakers W ARNING: Never connect this generator to any buildings electrical system unless a licensed electrician has installed an approved transfer switch. The National ...

  • Baldor PG 6000 - page 18

    4-2 Operation MN2418 Start − Up Procedure Recoil Start 1. Move the engine’s choke lever to the “Choke/Start” position. If the engine is warm or if the ambient air temperature is high; try starting the engine without choking it. 2. Move the Control Panel Engine “ON/OFF” switch to “ON” (if equipped). 3. Pull lightly on the recoil grip ...

  • Baldor PG 6000 - page 19

    Section 5 T roubleshooting and Maintenance T roubleshooting and Maintenance 5-1 MN2418 Maintenance This manual contains only very minimal engine maintenance instructions. Refer to the engine manufacturer ’s owner ’s manual for specific engine maintenance instructions for your generator set. Any maintenance instructions or recommendations in the ...

  • Baldor PG 6000 - page 20

    5-2 T roubleshooting and Maintenance MN2418 Problems and Solutions Some of the more common problems are listed in T able 5-1. This information is intended to be a check or verification that simple causes can be located and fixed. It is not an exhaustive “how to” for all types of problems. Procedures that require in depth knowledge or skills (li ...

  • Baldor PG 6000 - page 21

    Appendix A PG6000 Connections Powerchief R Series A-1 MN2418 Caution: The brass connecting tab on some 120V AC duplex receptacles has been removed. Each receptacle is powered by a separate generator winding. When replacing a receptacle, inspect the brass tab that normally links both receptacles. If it is removed, be sure to remove the brass tab fro ...

  • Baldor PG 6000 - page 22

    A-2 Powerchief R Series MN2418 Figure A-2 PG6000 Wiring Diagram ...

  • Baldor PG 6000 - page 23

    Appendix B Special Information for California Special Information for California B-1 MN2418 Information in this Appendix applies only to products operated in the state of California. LIMITED W ARRANTY ON EV APORA TIVE EMISSION CONTROL SYSTEMS − CALIFORNIA ONL Y The California Air Resources Board (CARB) and Baldor Generators (herein ”Baldor”) ...

  • Baldor PG 6000 - page 24

    B-2 Special Information for California MN2418 W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Engine exhaust from this product contains chemicals known to the state of California to cause cancer , birth defects and other reproductive harm. W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Battery posts, terminals and related accessories are known to the ...

  • Baldor PG 6000 - page 25

    Baldor District Offices ...

  • Baldor PG 6000 - page 26

    © Baldor Electric Company MN2418 P r i n t e di nU S A 8/06 W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Engine exhaust from this product contains chemicals known to the state of California to cause cancer , birth defects and other reproductive harm. W ARNING: CALIFORNIA PROPOSITION 65 W ARNING: Battery posts, terminals and related accessories ar ...

Fabricante Baldor Categoría Portable Generator

Los documentos del dispositivo Baldor PG 6000 que obtenemos del fabricante se pueden dividir en varios grupos. Entre ellos están::
- dibujos técnicos Baldor
- manuales de instrucciones PG 6000
- hojas de producto Baldor
- folletos informativos
- o etiquetas energéticas Baldor PG 6000
Todos son importantes, pero lo más importante desde el punto de vista del usuario de un dispositivo lo encontraremos en el manual de instrucciones Baldor PG 6000.

Un conjunto de documentos determinado como manual de instrucciones se divide también en tipos más detallados, tales como: instrucciones de montaje Baldor PG 6000, instrucciones de servicio, instrucciones cortas o instrucciones de usuario Baldor PG 6000. Dependiendo de la situación debes buscar el documento que necesitas. En nuestra página puedes consultar el manual de instrucciones más popular del producto Baldor PG 6000.

Manuales de instrucciones parecidos

El manual de instrucciones del dispositivo Baldor PG 6000, ¿cómo debería ser?
El manual de instrucciones, también determinado como el manual de usuario o simplemente instrucciones, es un documento técnico que tiene como objetivo ayudar a los usuarios a utilizar Baldor PG 6000. Las instrucciones normalmente las realiza un escritor técnico pero en un lenguaje comprensible para todos los usuarios de Baldor PG 6000.

El manual de instrucciones completo de Baldor debe contener unos elementos básicos. Una parte de ellos es menos importante, como por ejemplo: la portada / la página principal o las páginas de autor. Sin embargo, lo demás debe facilitarnos la información más importante desde el punto de vista del usuario.

1. Introducción y pistas sobre cómo orientarse con el manual Baldor PG 6000 - Al principio de cada manual se deben encontrar las indicaciones acerca de la manera de usar un manual de instrucciones. Debe contener información sobre dónde encontrar el índice Baldor PG 6000, preguntas frecuentes o problemas más comunes – son los apartados más buscados por los usuarios de cada manual de instrucciones.
2. Índice - listados de todos los consejos acerca de Baldor PG 6000 que encontraremos en el documento
3. Consejos de uso de las funciones básicas del dispositivo Baldor PG 6000 - que deben facilitarnos los primeros pasos durante el uso de Baldor PG 6000
4. Troubleshooting - una secuencia sistematizada de acciones que nos ayudará a diagnosticar los problemas más importantes con Baldor PG 6000
5. FAQ - las preguntas frecuentes
6. Datos de contacto Información acerca de cómo encontrar los datos de contacto del fabricante / servicio de Baldor PG 6000 en cada país si no somos capaces de solucionar el problema por nuestra cuenta.

¿Tienes una pregunta acerca de Baldor PG 6000?

Utiliza el formulario que se encuentra abajo

Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Baldor PG 6000, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Baldor PG 6000 probablemente compartirá una forma de solucionarlo.

Copia el texto de la imagen

Captcha
Nueva imagen

Comentarios (0)