-
Bolens MTD7122B09 - page 1
STOCK NUMBER 93-7122.0 MODEl. NUMBER MTO1122B09 FACTORY NUMBER 130..61OF098 Thank you tol' purchasing an Amel'lcan-built product. ...
-
Bolens MTD7122B09 - page 2
.3 .5 .6 10 Slope Gauge Safe Operation Practices Assembly Instructions. . Controls.. " Operation. Adjustments lubrication Maintenance Off-Season Storage. 19-23 ,.. .24.25 26-33 ..., ...29 34,35 36-39 Back Cover 12 14 15 18 Engine Operating and Maintenance Instructions. Trouble Shooting Chart. Illustrated Parts for Lawn Tractor. . Electrical Sy ...
-
Bolens MTD7122B09 - page 3
i > I ..J I W , u. c:( U') I W I ..- I c:( I a: I w I Q. 10 I ..- 10 : Z I > I « I ~ I I => 10 I > I UJ I a: I UJ I :I: ~ :s: 41 .S U') -J W .~ Q. oC 0 ~-.. ..J cn c:t W -Z :J - Y ~ I a: I w I t- I UJ I C 10 I ..- I I W I C I - I => I " I « I cn I « I I ..- I W I W I :I: I U') I U') I - I :I: I ..- W U&apo ...
-
Bolens MTD7122B09 - page 4
I I I Remove this sheet from your owner's manual and lay the hardware on the illustration for identification purposes. After assembly, keep the Slope Gauge which is on the reverse side of this sheet for future use. (Hardware pack may contain extra items which are not used on your unit.) I I INST ALLING THE SA TTERY Cable Tie rf§:!;~--- + ~~ I ...
-
Bolens MTD7122B09 - page 5
RULES FOR SAFE OPERA liON THIS SYMBOL POINTS OUT IMPORTANT SAFETY INSTRUCTIONS WHICH, IF NOT FOLLOWEO COULD ENDANGER THE PERSONAL SAFETY AND/OR PROPERlY OF YOURSELF AND OTHERS READ AND FOLLOW ALL INSTRUCTIONS IN THIS MANUAL BEFORE ATTEMPTING TO OPERATE YOUR UNIT FAILURE TO COMPl Y WITH THESE INSTRUCTIONS MAY RESULT IN PERSONAL INJURY WHEN YOU SEE S ...
-
Bolens MTD7122B09 - page 6
ASSEMBLY IMPORTANT: This unit is shipped WITHOUT GASOLINE or OIL; however, a small amount of oil may be present from the factory. Do not overfill. After assembly, service engine with gasoline and oil as instructed in the engine section of this manual. NOTE: Reference to right or left hand side of the unit is observed from the driver's seat, fa ...
-
Bolens MTD7122B09 - page 7
Caps " ~ FIGURE 1, ,f. FIGURE 2. ACTIVATING THE BATTERY Do not activate battery (fill with battery acid) until battery is actually placed in service. Be certain to read previous warnings before activating the battery. 1. Open the battery pack. Be careful not to puncture the box. It contains the battery with a long plastic tube attached, batter ...
-
Bolens MTD7122B09 - page 8
Negative I~ ,I =~~~ ..! r- --.,,- / Positive y Terminal Battery ~ Drain Tube '9 ~ -'- -- Battery - Black Box Red (Negative) (Positive) Cable Cable INSTALLING THE BATTERY (Hardware A) 1. Raise the seat bracket (on top of the fenders). 2. Make certain the positive cable (heavy red wire) extends through the retainer on the front of the ba ...
-
Bolens MTD7122B09 - page 9
Steeri ~ ~~HeX Lock Wheel ,~ Nut , ..,r" :--- Cupped Washer 3. Attach one end of steering bellow to the steering wheel as shown in figure 6, inset. 4. Position the front wheels of the tractor so they are pointing straight forward. 5. Place the steering wheel and steering bellow over the steering shaft. positioning steering wheel as desired. 6. ...
-
Bolens MTD7122B09 - page 10
CONTROLS LIGHT SWITCH Push the light switch to turn on the lights. The lights will only operate when the engine is running. See figure 9. AMMETER The ammeter registers the rate of battery charge or discharge. The ammeter will register on the discharg- ing side when starting the engine. It should register on the opposite side (charging) when the eng ...
-
Bolens MTD7122B09 - page 11
INTERLOCKS (Not Shown) Interlock safety switches are located by the clutch-brake pedal. the li"t lever, the gear shift lever and under the seat. Before the engine will start, the clutch-brake pedal must be (jepressed all the way and the lift lever must be in the disengaged position. Before the IJnit can be shifted into reverse or if the operat ...
-
Bolens MTD7122B09 - page 12
WARNING: Look to the rear before back- ing up. Move the lift lever into the DISENGAGED position to raise the deck and disengage the blades. GRASS CATCHER Stock Number 95-1136-1 (Factory No. 190-064) is available as optional equipment. A WARNING: The mower should not be operated without the entire grass catcher or chute deflector in place. NOTE: Und ...
-
Bolens MTD7122B09 - page 13
SPEED CONTROL ADJUSTMENT (See figure 12) NOTE: When operating the unit initially or after replac- ing the belt5. there will be little difference between the highest two speeds until after the belts have gone through a break-in period and have seated themselves into the pull~ys. First. adjust the speed control lever by pushing the clutch-brake pedal ...
-
Bolens MTD7122B09 - page 14
FIGURE 15. BRAKE ADJUSTMENT (See figure 16) The brake is located by the right rear whee! inside the frame. During normal operation of this machine, the brake is subject to wear and will require periodic examination and adjustment. WARNING: Do not have the engine running when you adjust the brake.To adjust the brake, remove the cotter pin. Adjust th ...
-
Bolens MTD7122B09 - page 15
STEERING SHAFT Lubricate steering shaft at least once a season with light oil. ENGINE Refer to the engine section of Iris manual for all engine maintenance instructions. CLEANING ENGINE AND BLADE HOUSING Any fuel or 011 spilled on the machine should be wiped off promptly. Grass, leaves, and other dirt must not be left to accumulate around the cooli ...
-
Bolens MTD7122B09 - page 16
Blade Mounting Torque 3/8" Dia. Bolt 375 in. Ib, min.. 450 in. Ib, max. 5/16" Dia. Bolt 150 in. Ib, min., 250 in, Ib, max, To insure safe operation of your unit, ALL nuts and bolts must be checked periodically for correct tightness. FUEL FILTER Your unit is equipped with a replaceable in-line fuel filter. Replace filter whenever contamina ...
-
Bolens MTD7122B09 - page 17
6. Remove the engine pulley belt guard by slipping it back and to the right. See figure 23. 3 Push the idler pulley toward the right side of the unit. Lift the belt over the idler pulley. See figure 21 . 4 Remo'e the belt from the variable speed pulley. 5. Remo'v.e the two bolts which hold the shift lever bracket to the frame on the left ...
-
Bolens MTD7122B09 - page 18
BATTERY REMOVAL OR INSTALlATION A WARNING: When removing the battery, follow this order of disassembly to prevent the screwdriver from shorting against the frame. COMMON CAUSES FOR BATTERY FAILURE ARE: 1. Overcharging 2. Undercharging 3. Lack of water 4. Loose holds downs and/or corroded connections 5. Excessiv~ loads 6. Battery :':trolyte sub ...
-
Bolens MTD7122B09 - page 19
FOR ENGINE MODEL 281707-0411-01 IMPORT ANT: Do not start the engine before reading the following section of this manual. A WARNING: Do not operate engine in an enclosed area. Exhaust gases contain car- bon monoxide, an odorless and deadly poison. AI'Nays remove ignition key and disconnect spark plug wire from spark plug before per- forming any ...
-
Bolens MTD7122B09 - page 20
SECTION 2 STARTING A WARNING: ALWAYS KEEP HANDS AND FEET CLEAR OF MOWER BLADE OR OTHER ROTATING PARTS. Lift )) ~ "' ~ ", -, -- '. ~~ ~ -.,' ~~:- ,~- .~ ':(~::~l~~~'~~': -'-- Throttle Clutch- Brake Pedal' /" To Start Engine 1. Depress the clutch-brake pedal and set the park- ing brake. 2. Plac ...
-
Bolens MTD7122B09 - page 21
2 Remove foam pre-cleaner. Spark Plug-Clean and reset gap at .030" every 1 00 a. Wash pre-cleaner in liquid detergent and warm hours of operation. water to remove dirt. NOTE: Do not blast clean spark plug. Spack plug b. WrElp pre-cleaner in cloth and squeeze dry. should be cleaned by scraping or wire brushing and .washing with a commercial sol ...
-
Bolens MTD7122B09 - page 22
J - ~~~:;qll~~~ ~- ~ ~ ~ °!8-C~'ok~ . Casing Clamp Screw Now open needle valve 1-1/2 turns counterclockwise and idle valve one turn. This initial adjustment will per- mit the engine to be started and warmed up approx- imately 5 minutes prior to final adjustment. Final Adjustment-Place speed control lever in FAST position. Turn needle valve in ...
-
Bolens MTD7122B09 - page 23
b. While engine is s1ill warm, drain oil from crankcase Refill with fresh oil, c. Remove spark plug, pour approximately '/2 ounce (15 cc) of engine oil into cylinder and crank slowly to distribute oil. Replace spark plug. d. Clean dirt and chaff from cylinder, cylinder head fins, blower housing, static guard and muffler areas. e. Store in a cl ...
-
Bolens MTD7122B09 - page 24
TROUBLE SHOOTING CHART FOR ELECTRIC START MODELS -REMEDY- ---:J The battery must be instatled with the negative terminal, identified at t'le terminal post by (Neg. N or -). grounded The positive terminal (Pos, P or ..) attaches to the large cable from the solenOid The small red wire from the fuse holder or cirCUit breaker IS also attached to t ...
-
Bolens MTD7122B09 - page 25
ILLUSTRATED PARTS FOR MODEL MT[)7122BO9 LAWN TRACTOR , PARTS LIST FOR MODEL MTD7122BO9 LAWN TRACTOR I REF. -+-~ PART NO. DESCRIPTION DESCRIPTION 1 ~T-Pm- ~~j NO. 710-0924 10 736-0226 11 736-0119 12 712-0267 13 714-0507 14 732-0303 17 736-0140 18 726-0235 19 736-0329 20 1712-0287 2 1 16195 3 720-0218 4 16192 5 ' 736-0192 6 711-0198 7 738-0155 I ...
-
Bolens MTD7122B09 - page 26
..r 1 1.2 ./ . 17 ~ L;, " " " :) 6 I. ~ ,~ 21. '. ~'5 ~ ~ ~~8 '" ~ 6$ 41 , 11-;-(( 15-i ~ ' 1.Q . 5 .. 6 w/ 17 /1 " ~ 36,~ '~'..~' -~ '- ~.. . ~~:;~ .,' -.~ ~.~. 31 I r'-- 35 z: . 10 3 21 ...
-
Bolens MTD7122B09 - page 27
Il.LUSTRATED PARTS FOR MODEL MTD7122BO9 LAWN TRACTOR ""':~ 5' ~t 7-- 61 ~-'y--w "'~i ~"':~~. ;--8 -..r ~ 9 j , / ;; ~ 33 / " """" 44 / ,10 ---QI 55 ' :.-~-:-~ ~ 58,' ,'26 t ~;;--o:;;;~~~>... ',.f ! I 51 ~ ~ <...y 16 a.1.8 i :5 m ' -.', ~ rZ ~ I ...
-
Bolens MTD7122B09 - page 28
...
-
Bolens MTD7122B09 - page 29
rAEFT- PART--- ~-:-i !!:.O-.:.-- --- : 1 i 731-0220 2 712-0237 3 736-0242 I 4 i 731-0805 I 51731-0954 , 6'16512 I 71741-0356 I 8 1712-0324 9117198 I 10 1738-0141 11 ;710-0152 :..-:- ClutC~VeIIOW- -.-Red--o.:c:--- 13 ~T 14 - : S r='"-- tart: -==-.., Alt.-,' ,@. 1 -'DIfTi ,.JJ;t::+-- Mag ~ .,:-, 6 --Jf:J /~~.II~~-:?:==~~ &a ...
-
Bolens MTD7122B09 - page 30
ILLUSTRATED PARTS FOR MODEL MTD7122BO9 LAWN TRACTOR ~ 114 ~ 91 . ~ -~ < : ..oJ ~ ~ , ~_-" c' -~ "'- ., -"""~ rr -~~ .:: 2 9 ,E;I ~. 8- 1 ~"--'.~: 97 !of , ...j' '1 i 'I;' '389.: '85"'~;!J~- 18 B8 ~__~~b~/"A .! 46-'~ 9 3-~ -:..::..'. ' &apo ...
-
Bolens MTD7122B09 - page 31
I RE"FT-pART- ~~_t:l~- 1 1 12 H.P. 2,710-0726 I 31725-0977 4 712-0123 5 736-0119 7i 736-0247 9 ! 750-0777 10 710-1077 PARTS LIST FOR MODEL MTD7122BO9 LAWN TRACTOR ~ , DESCRIPTION I REF" PART ! NO. NO. , c--- ~-r ' , Engine (See Breakdown)! 621 711-0768 , Hex Wash, AB-Tap Scr, 5/16" x I 63i 736-0275 .I : 75" 64[710-0428: : ...
-
Bolens MTD7122B09 - page 32
~ 1--""'" PARTS LIST FOR MODEL MTD7122BO9 LAWN TRACTOR REF I NO.'r PART NO. REF. I NO. PART NO. DESCRIPTION DE~CRIPTION.I 1 I 09735A 2 17640 3 17641 4 17710 5 14800 6 14804 7 748-0331 8 736-0231 9 736-0119 10 712-0267 11 736-0192 12 714-0144 13 736-0256 14 732-0412A 24 736-0160 25 726-0272 26 738-0526 27 710-0351 28 14802A ...
-
Bolens MTD7122B09 - page 33
Ill.USTRATED PARTS FOR MODEL MTD7122B,O9 LAWN TRACTOR 53" PARTS LIST FOR MODEL MTD7122BAO9 LAWN TRACTOR REF. PART -DESCRIPTION ~EF. PART -;;;;;;~I~~ NO. NO. .NO. NO. - ~ - 1 750-0776 Spacer .33" 1.0. x .88" 20 736-0217 I L-Wash. 3/8" I.D.-H.D. 2 710-0672 Hex Bolt 5/16-24 x 1.25" Lg. 21 736-0329 L-Wash. 1/4" 1.0.* 3 175 ...
-
Bolens MTD7122B09 - page 34
ILLUSTRA TED P ARTS FOR MODEL MTD7122BO9 LAWN TRACTOR 52d LJ I 22 232' 22 ~ ,yV 2'- -- ~ -,_.' -f rI-. 8 -- 45, e I '. "2S "26 "" ~, 17 ,~ I 28 '6 IS ""'~ ' 30 '0 I 20 ! 1 21 " tcI-18 37 '/ ~ { 23 ,~ 56 .16 ~ 3' 58 )5 SINGLE SPEED TRANSAXLE-R.H. MODEL 717-05 ...
-
Bolens MTD7122B09 - page 35
!REFT ~ REF .- I No.1 --- 1 ; 714-0129 2 ' 1 716-0115 i 3 71 0-0854 I 4,710-0809 I 5: 717-0540 i 6 1710-0642! 7 1712-0287 I 8 1717-0634 9/721-0178 10 1736-0335 PART NO. PARTS LIST FOR MODEL MTD7122BO9 LAWN TRACTOR ---, ---m ' -, ~~,,"",-~~~~ON- ---i ~J P:~.T .--r~~-- , 1 33 736-0351 1 34 ! 717-0541 .35 750-0555 36 ! 736-0329 I 3 ...
-
Bolens MTD7122B09 - page 36
...
-
Bolens MTD7122B09 - page 37
ILLUSTRATED PARTS FOR 281707-0411-01 ENGINE FOR MODEL MTD7122B09 LAWN TRACTOR ;l4K::::-: --!f ~ ,-- --" ) E , 224 ~ J09 ~ 1- ~ousin9 l~nglh-f 310 <»~L- I -~ j 544 0 ~ 803 , I ~ 37 ~) t8332 ~S '~~~I 801 NOTE: To identily Briggs & Stratton manulactured starter rnotors. measure the housing length ...
-
Bolens MTD7122B09 - page 38
PARTS LIST FOR 281707-0411-01 ENGINE FOR MODEL MTD7122BO9 LAWN TRACTOR .--,-- PART NO. DESCRIPTION DESCRIPTION -~ - 1 2 3 5 7 8 9 10 11 12 45 46 52 78 94 95 98 91920 *271996 99 101 104 108 118 121 123 125 126 127 128 130 131 132 133 134 136 137 138 141 142 147 171 186 187 188 201 209 219 26157 93043 t230896 222010 396568 394698 93357 490472 490473 ...
-
Bolens MTD7122B09 - page 39
PARTS LIST FOR 281707-0411-01 ENGINE FOR MODEL MTD7122BO9 LAWN TRACTOR (CONTINUED) ' '-' --- REF. i PART ~-- --~--~." NO. NO. -+ 634~ ~- i REF. I NO. L--- I 1308 ! 309 PART NO. -- 491490 :394806 27~353 635 1 657 662 1 663 668 ' 726 I i 310 I 311 1332 1333 , 334 94003 :395538 92284 492341 93381 337 346 353 354 356 358 363 38 ...
-
Bolens MTD7122B09 - page 40
HOW AND WHERE TO ORDER REPLACEMENT PARTS To eliminate error and to speed delivery of replacement parts, always include the following information on your order. 2. Best possible identification of the part itself (a) Part Number- (b) Part Name- (c) If necessary return the old part as sample. 3. CUSTOMERS may order all replacement parts from any parti ...
¿Tienes una pregunta acerca de Bolens MTD7122B09?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Bolens MTD7122B09, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Bolens MTD7122B09 probablemente compartirá una forma de solucionarlo.